What 385 owners told NHTSA about the 2023 Ford F-150 Supercab

Right rear taillight lens has water ingression. The dealer states that they cannot replace the lens under warranty because of a technical issue bulletin issued by Ford Moter company that states that condensation is normal and that it should dissipate after a short period of time. Well this has not gone away. And after some time, it will start corroding the electrical connections for the lights and cause them to stop working. The dealer is telling me that it would no be covered under warranty until there is at least a quarter of water in the bottom of the lens. By that time the electrical connections for the lights will be damaged

NHTSA ODI 11639449

I started receiving notifications that the battery on my 2023 Ford F150 was in battery save mode due to low battery. I called my dealership and set up an appointment. I took in my vehicle and they charged the battery but told us that Ford has an issue with these batteries not holding a charge. He recommended we just run our truck in the driveway for 30 min when this happens. The charge lasted 3 day's, I drive this vehicle multiple times daily and we have taken many trips in it. I have never had a vehicle that the battery will not charge properly and then to be told they know this is an issue but aren't doing anything to fix it is unacceptable.

NHTSA ODI 11638484

My Ford F150 was hit by another vehicle going at least 45 mph on the passenger which push my vehicle into another vehicle. However, the airbags was never deployed which cause injury to my right side from steering wheel.

NHTSA ODI 11637210

2019 F150 Backup camera doesn't work. Ford recalled some 2019 F150's but not mine. I've noticed they are having a huge issue with backup cameras and was also told the same by the dealership. Seems as like they should be responsible for fixing mine too. 2019 Supercab door locks freeze. Ford fixed under a recall. The recall worked for a year. Called dealer back last year Ford won't fix it again. It's obviously a manufacturer defect that wasn't fixed correctly on the recall. Seems crazy that I have to pay them to fix it again. The lock freezes open and you can't lock the door. It will open while driving.

NHTSA ODI 11625271

We have been having repeated problems with the dash freezing in place for several days needing a battery to be disconnected to reset the issue. When the issue is going on, the dash is completely frozen in place. There is no way to know how much fuel is left, how fast you are going or anything else from the cluster due to it not changing at all. When the issues were brought to the dealers attention, they were shown a video of the problem occurring. But were unable to replicate the issue and thus did nothing but notate they didn't see it happen. The vehicle is owned by the Law Enforcement agency and it is not feasible to have the officer come into the dealership when the issue is acting up. The primary safety issues we see is the possibility of the vehicle running out of gas on the highway and causing a accident. Speeding concerns since the officers have no way of knowing their speed. Maintenance concerns since even the odometer is frozen so there is no way to track when its ready for service.

NHTSA ODI 11614167

It happened several times already. My F150 Tremor randomly has extremely loud electrical sound POP through the speakers followed by the loud static, no matter I listen to radio or connect to android studio. It's super dangerous to hear this while driving.

NHTSA ODI 11611306

The contact owns a 2023 Ford F-150. The contact stated that while operating the vehicle, the check engine warning light had remained illuminated, and the speed erroneously increased and decreased while driving. The vehicle was taken to the local dealer who diagnosed that the turbo was faulty. The vehicle was not yet repaired. The contact had also experienced several electrical failures, including the rear window becoming inoperable, failing to open and close as needed. The vehicle was not yet repaired. The manufacturer was not yet notified of the failure. The failure mileage was 9,000.

NHTSA ODI 11609589

Purchased the new truck 12/21/23 within a week or two all the Adas signals and chimes continued to flash. A sensor was ordered and arrived months later and was installed. The problems never stopped. Besides the signals all flashing my blind spot in my mirrors stopped working. The dangerous issue is that while I am driving all of a sudden at any given moment my vehicle loses power and it stops accelerating. I am afraid to drive my new vehicle because I am affraid of pulling out of my driveway or driving on the highway trying to change lanes I am going to lose power and get hit by someone. This truck is not safe to drive.

NHTSA ODI 11606776

Air Conditioner will stop working after minutes of being on. This is not bearable in 95-110 degree weather.

NHTSA ODI 11602780

The AC stops blowing and cooling at an adequate speed after driving for a period of time. The safety issue is that while the blower is malfunctioning, it cannot defog/defrost the windshield.

NHTSA ODI 11590770

I was driving at about 40mph and everything shut off for about 5 seconds. It was long enough for all the gages on the instrument cluster to go to their off positions. The desolation screen went blank as did the infotainment system and all lights.

NHTSA ODI 11589552

On numerous occasions all of the vehicles electronics, including screens, would shut off. Sometimes this happens while driving at highway speeds causing the vehicle to lose all power. When approaching the car to unlock there is often no power to access the vehicle, which requires manually unlocking the vehicle with the key, opening the hood, then touching metal to the battery terminal to reset the electronics. The vehicle has lost power in the middle of intersections, on the highway, and in parking lots. There are times when the car signals a fault with several of the ADAS features. When this happens it’s usually probable that once the vehicle is shut off, I won’t be able to get it started again without touching metal to the battery terminal. I have started to document the failures through video to show to the technicians just in case the OBD doesn’t match what I describe. The date I’m including is the most recent occurrence but does not reflect the many occurrences since purchasing the vehicle last spring.

NHTSA ODI 11582469

Repeated failures with my parking brake applying itself when it wants too. It’s not on a hill, it’s not just when towing my trailer, it’s not related to solar flares - this truck is dangerous. The brakes apply at speed, did it on [XXX] in LA. The whole system just applied the brakes at 55mph. I have Repeated failures with “collision warning system” and the FORD app has this notated. And at times this system applies the brakes when there is nothing in front of me! The screen (not dash) pixelates, crashes, doesn’t work properly. It will not stay connected. I rely on this navigation, the screen quits working. The passenger window goes down & up at will, like a TX employer. I cannot stop it, can’t even figure out what’s going on. My truck is not subject to recall but should be! Others have similar issues why is mine not recalled? This truck is very dangerous to drive and I don’t trust it. Problems began after we left TX around August 2023 and I was working and could not get it fixed - DEALER COULD NOT MEET FORD WARRANTY TO PROVIDE ME A CAR/TRUCK TO USE! And now I’m in North TX where Ford Dealers have horrible reputations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11579062

Randomly the ac line will freeze over and no air flow will come out of the vents although the fans can be heard working. Issues is not a simple thing to be duplicated and have brought it to 3 ford locations and still having the issue. They won’t attempt to repair anything else that could be the issue like the compressor because of fear of ford giving a bad review to the shop and mechanic. Just this week 2/28 I took the vehicle in while issue was happening and once the line defrosted and air flow came back I was again sent away because they could not replicate. This is a huge problem as I cannot defrost or defog my windshield in cold weather.

NHTSA ODI 11574829

The a/c fails to operate in hot weather. You can hear the internal fans blowing, but no air comes out when it is hot outside, and the car idles for a few minutes. Has been in the shop twice to fix this.

NHTSA ODI 11574536

The air conditioning stopped cooling on several ocasiones, they changed the air sistema and it failed egain

NHTSA ODI 11574023

When selecting the tow menu on the display if you select trailer tpms or try to use the down button to scroll the instrument cluster will blank out and reboot while you are driving. You loose the entire cluster so you cannot see speed or anything.

NHTSA ODI 11572705

When selecting the TOWING option on the dash cluster, the dash shuts off to a black screen and restarts while driving. This prevents seeing the speed and other dash information. The truck also sends warning to phone after dash shut off that power steering, ABS, seatbelt control, and airbag control is malfunctioning. Took to dealer and they were able to reproduce the issue. The replaced dash but did not fix. They escalated the issue to Ford who said they are working on it back in October. Still no fix.

NHTSA ODI 11569980

On [XXX] as I was going in reverse the car started to accelerate out of control, I pumped the breaks and it increased speed, I then tried to power down truck and that did not work. My vehicle ended up going in ditch backwards and I hit a mailbox and ditch. Earlier in the week when I went to go from reverse to forward it felt like it was locked and then it would engage. I do not feel this is safe and will not ride the vehicle as I think there is something wrong mechanically with the truck. Police report will be uploaded in 1-2 days. My email address us [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11568123

While driving random chiming occurs intermittently. No fault recorded or seen on dash. Second issue has happened 3x since purchase, dash cluster shut down or cycled power or reset while driving. This to me is a safety issue.

NHTSA ODI 11567878

Whenever temperatures are below freezing, the TCCM engages the front IWE system and hubs to warm up for the first 2 miles of driving. However, when the system disengages, the hubs are not fully disengaging from the IWE shaft and a loud grinding noise happens. I have taken my vehicle to the Ford dealer and they gave a contradictory answer by saying that it was a “issue,” but that it was “operating normally.“ It is definitely not normal and they know it is a defective system that is damaging the drive system on a brand new vehicle with less than 800 miles on it.

NHTSA ODI 11565135

Loud buzzing noise interrupts driver focus. This happens intermittently, but has occurred while braking at busy intersections, while backing into urban parking spaces, while attempting to use the camera for safe maneuvering - or just at random times while driving. Navigation has been interrupted, preventing the ability to make safe decisions to arrive at a desired location. Voice-based services have been interrupted, prompting the need for physical interaction (which entices the driver away from hands-free operation and taking their eyes off the road). Backup camera has been disabled (blank screen) while switching to Reverse preventing detection of objects behind the vehicle. Infotainment/vehicle operations are disrupted while system randomly reboots (and often buzzes loudly). Additional issues render the audio system as annoying, buzzing during songs whether on Carplay or via USB music. The optional (and expensive) B&O Unleashed audio system has been rendered almost useless. Noise has been so disruptive as to startle me during operation of the vehicle on multiple occasions since purchasing the vehicle in July 2023. Updates have been hinted at to address this problem but have not been delivered or realized - and yes Auto Update is on and I'm manually checking for updates as well. October OTA did not address this issue (and may have made it worse - although my high hopes for this update may have just increased my annoyance at its persistence). I have reported this to my Ford dealer. Date listed below is last occurrence.

NHTSA ODI 11559080

Issue #1: Rain Sensing Wiper function is completely inoperable. Wipers must be operated manually. Issue #2: Blinker stalk becomes stuck in off and on positions. This malfunction has put myself and others at risk because the vehicle, at times, is unable to inform others on the road of the appropriate vehicle lane change. This risk has become heightened in periods of warm weather, where the stalk becomes "more stuck" than usual. The dealership has replicated the issue and attempted to resolve several times; after several months of waiting for a solution from Ford and recent near-misses on highway trips, I have decided to escalate with Ford as well as with NHTSA. The vehicle has no warning lights nor signals warning any user that an error with the blinker stalk may occur while driving. Issue #3: Left side blind side monitor false readings when there is no vehicle on driver side blind side. Dealer unable to verify. False positives desensitize driver to true positives, therefore, this is an added risk.

NHTSA ODI 11559185

Tire monitoring system malfunctions after 30ish minutes of driving. Seems the issue is interference from the on board power generator referred to by ford as “pro power onboard”. After the tire monitoring system turns on, immediately turning off the pro power generator the tire monitoring system returns to normal. After researching this issue it’s very common and has been on going through multiple years with no fix.

NHTSA ODI 11554292

The back up camera screen is constantly freezing up or the screen goes black. When this happens the driver has no control over any audio, navigation or other settings that are linked to the screen. The only way to get the screen to come back on or unlock the frozen back up screen is to turn the vehicle off and let it time out. This happens at least 3 or 4 times a week. When dealership was asked about it, was told they don’t have a fix for it and it’s a common problem.

NHTSA ODI 11553235