What 385 owners told NHTSA about the 2023 Ford F-150 Supercab

driving approximately 20 miles an hour, gently applying the brake as I was approaching a stoplight when the brake suddenly engaged forcefully causing the car to jerk to a stop unexpectedly. There was a warning across the dash that said " forward collision is not available" and that disappeared. A local dealership said this was an ABS issue and reprogrammed it.

NHTSA ODI 11749360

The contact owns 2023 Ford F-150. The contact stated while driving 25 MPH, while depressing the accelerator pedal the automatic brake system engaged independently causing all four wheels to lock up. a dealer was contacted. The vehicle was taken to dealer where it was diagnosed that front camera bezel needed to be replaced. The vehicle was repaired as the front camera bezel was replaced. The contact was relating the failure NHTSA Campaign Number: 22V334000 ( FORWARD COLLISION AVOIDANCE); however, the VIN was not included in the recall. The manufacturer was notified of the failure and offered no assistance and informed him he had to pay for the cost of repair. The failure mileage was 24,000.

NHTSA ODI 11737133

While driving up to 40 mph, the emergency brake will randomly come on causing me to skid and stop suddenly. I manually have to turn back off the emergency brake to drive again. This incident has occurred in traffic multiple times. The truck has been at the dealership service center four times and they cannot replicate, diagnose, or repair the issue. The dealership states they have looked at the electrical components and replaced the battery, which did not solve the issue. There are no warnings prior to the emergency brake coming on. A collision is not about to happen that causes it to come on.

NHTSA ODI 11733375

This vehicle is equipped with Blue Cruise, a hands-free driving feature. While in hands-free drive mode (Blue Cruise), the vehicle abruptly disengaged and aggressively pulled off the highway. In icy conditions and at high speeds. This is abnormal for the system. Typically, if the Blue Cruise disengages, it gives a timed warning, about 5-10 seconds, and then will disengage. This was dangerously different. The dealership serviced the vehicle and updated the system. However, Blue C still wanders in the lane and randomly disconnects. With the Blue Cruise system turned off/disengaged and the adaptive cruise control engaged, the system also acts erratically, randomly disengaging for no reason.

NHTSA ODI 11729474

I’ve been advised by McGovern Ford in Massachusetts that I need ABS Module and an Electronic Brake Booster and it isn’t covered by any warranty. Yet it’s a safety hazard and the truck is only 2 1/2 years old. Why would those 2 items need to be replaced on a newer truck.

NHTSA ODI 11720837

⸻ Highlight Summary: My 2023 Ford F-150 (VIN: [XXX] ) has intermittent rear tail lamps, brake lights, turn signals, and backup lights failure due to water intrusion. The right side has completely failed; the left side is beginning to fail, creating a serious safety hazard at night or in low visibility. Both the dealership and Ford Customer Assistance have avoided returning calls and are denying responsibility, and this is a common problem nationwide. ⸻ Complaint – 2023 Ford F-150 Rear Lighting Failure •Vehicle: 2023 Ford F-150, VIN [XXX] , ~73,000 miles •Issue: Intermittent rear tail lamps, brake lights, turn signals, and backup lights failure due to water intrusion •Right side: completely failed; left side: starting to fail •Safety Risk: Creates serious hazard at night/low visibility, increasing risk of rear-end collisions •Dealership: D-Patrick Ford Superstore, Evansville, Indiana, E. Walnut St. •Initially could not duplicate issue •Feb 7, 2026: confirmed problem, quoted ~$3,000 for repair •Truck returned “all lights working,” but right side still not functioning •Manufacturer & Dealership Response: Ford Customer Assistance and dealership are denying responsibility and avoiding calls, leaving the defect unresolved nearly a year •Nationwide Problem: Common issue reported by many F-150 owners, indicating widespread safety defect •Request: Immediate review and corrective action for this recurring and escalating safety hazard INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11720040

I was driving and all of the dash lights came on simultaneously and I lost power braking ability while on the interstate. I was able to pull over and the truck shut off. I had to call a tow truck because it would not start back up. The AAA servicer reprogrammed the battery which turned all of the warning lights off except for the "push brake to start" warning and the truck will still not start because of this. The tech with AAA advised there is a recall related to this issue but my VIN search returns no results.

NHTSA ODI 11707462

front camera fault, service required, pre-collision avoidance not available. Lane departure warning fault, service required. This is an ongoing problem since date of purchase, 9/23/2025

NHTSA ODI 11699868

While driving down the road, the driver gauge display screen completely goes dark. All information displayed normally on the screen, such as speed, mileage, and vital information about the vehicle stops, displaying entirely. This has happened multiple times. Usually the next day, the issue is solved. Then, several months later, the issue reappears. Whenever the vehicle is taken for repair, the dealer simply cannot replicate the issue. This is a known issue that has been reported online by many people.

NHTSA ODI 11679946

The contact owns a 2023 Ford F-150. The contact stated that the vehicle received an unknown software update. The contact stated that after the software update was installed at the dealer, the contact experienced issues while activating the cruise control feature. The contact stated that previously the cruise control could be activated with a single switch. The contact stated that the cruise control and Forward Collision Avoidance switches were now located side by side. While attempting to activate the cruise control feature, the contact accidentally activated the Forward Collision Avoidance feature, and then had to take his eyes off the road to deactivate the function, almost causing several crashes. The contact reported the issue to the dealer and was informed that a new software update was upcoming. The manufacturer was notified of the issues but provided no assistance. The failure mileage was approximately 15,000.

NHTSA ODI 11677850

The contact owns a 2023 Ford F-150. The contact stated that while driving various speeds, the Forward Collision Avoidance system unintendedly activated. During the failure there were no other vehicles or large objects nearby. The "Collision Alert" message was displayed. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 38,000.

NHTSA ODI 11675092

•Resolution Requested oFull refund for $67,227.63 - Total Money Spent Down Payment Trade In Monthly Payment Aftermarket Accessories oPremium Care Warranty for Purchase of next Ford Vehicle •Issues oEngine and Electrical Issue Electronic Gauge Screen goes black while driving resulting in a safety violation Significant latency of acceleration upon starting resulting in dangerous driving conditions Issue started Mar 2024 Remote Start Not Working Issue started Mar 2024 oSafety Failure Error Messages •6 X Anti-Lock Brake Fault •18 X Tire Pressure Monitor System •9 X Restraints Indicator Lamp •28 X Pre-Collision Assist Not Available •4 X Power Train Malfunction •Attempted Repairs – the service department has stated they do not know the issue and will need to keep the car for several more weeks to determine a fix oNumber of Times 5 Times oDuration 28 Days oDates 10 APR 2024 – 1 Day 09 May 2024 – 1 Day 09 Sep 2024 – 5 Days 07 JAN 2025 – 10 Days 14 MAY – 1 Day

NHTSA ODI 11661526

Within weeks of purchasing this vehicle new from Groove Ford on Arapahoe, the dashboard would go completely black and the seat belt restraint warning, collision warning, and safety warning sensors would go off. This vehicle has been into the dealership 7 times within the past year for over 30 days and still no resolution.

NHTSA ODI 11661144

Available for inspection. The "brain" of the truck is in the stereo system. the time on the call varies, but, the call will drop the Bluetooth or wired connection with the truck, the radio will reset, and go to a broadcast radio station, from which it will stay for about 5-30 seconds while resetting, and then the call will recommence on the in-house system again. Neither party knows until I start hollering that the call has been dropped. I have checked with Apple, and there are no issues with it, and all updates have been completed. During the call with the tech people at Ford, the tech said it is a known problem.The truck has been in the shop on several occasions at Ford Villages and in Ocala, Florida, starting in February 2025. On 3/14/25, eight modules had to be updated & I was assured that it would fix the issue. After is was dropped it off, it happened again. I took it back on 3/21, and this time they said they could not duplicate the problem. Furthermore, the issue would need to be fixed, most likely by an over-the-air update.On the way home, I called my brother, and it happened not more than ten minutes out of the shop! 3/25/2025, I contacted Ford again through their customer service line and told them I wanted to start the Lemon Law buyback process. A few days later, I got a call back – denied. I am going through the lemon law process now. They offered a $4k buyback, which I soundly rejected as an insult. REGARDLESS, this truck is unsafe to operate due to the distractions that are created by the unreliability of the CarPlay system. I have ended up in a ditch, almost ran off the road by other drivers and various other close calls, all because I have had to adjust the phone to where it would work while I am driving. Most likely the CarPlay (Android-based) incompatibility with the Apple software and users are made to suffer for it Whatever it is, it must be immediately resolved. Consumers do not need to be caught in between the petty games. Still or moving.

NHTSA ODI 11658186

The contact owns a 2023 FORD F-150. The contact stated that the Pre-collision Alarm Sensor Default was displayed. The vehicle was taken to the dealer, who replaced two sensor cables. While driving at approximately 35-40 MPH, there was a sudden winding sound coming from the bearings, which could be heard underneath the hood. The vehicle was returned to the dealer, who replaced the alternator, and while repairing the vehicle, the dealer noticed that the idler pulley had failed. The idler pulley and serpentine belt were replaced. After having the vehicle repaired, the driver’s side seat cushion started deteriorating. The vehicle was taken to the dealer, who replaced the driver’s seat cushion. The contact smelled burning transmission fluid entering the cabin of the vehicle. The vehicle was taken to the dealer who diagnosed the vehicle with transmission failure. The final decision for the repair was not yet provided. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was unknown.

NHTSA ODI 11656687

On three separate occasions when I open my door, I get a “brake fault service soon” notification. I’ve done research and forums say this was a recall in the past. I’m aware my truck doesn’t have any current recalls but it has me wondering if it was ever fixed or if the repair was not good enough. I never owned the vehicle when the original recall came out so I’m not too sure what happened.

NHTSA ODI 11655214

While traveling North on [XXX] in N. Texas, congested roadway at the time, had to come to an abrupt stop because a vehicle in front of me suddenly hit their brakes. The forward collision system worked as it should, the icon popped up on the display and the vehicle started braking. One morning as I prepare to pull out of my driveway, vehicle facing North, the forward collision icon is on the dash with a diagonal line through it. I wasn't sure what that meant so I looked it up and it meant that something was blocking the sensor. Happened to be dirt from recent dust storm with rain so there was a spot that the windshield wipers cant reach therefore the sensor was blocked. Cleaned it off no more icon on the dash. Traveling West on [XXX] in West Texas, the icon appears on the dash once again with the diagonal line through it. The closest vehicle to me was around 3 quarters of a mile in front of me so there was no danger of a front collision. I noticed that as I passed under an overpass the icon disappeared but as soon a I exited the overpass the icon reappeared. Once the sun reached a certain point in the horizon when setting, the icon went off for good. This has also happened when driving in town and I am heading home form work. traveling West into the setting sun. Without a doubt if the sun is in a certain point on the horizon when setting, it will block or blind that sensor however you wish to describe it, and that safety feature will be temporarily inoperable until the sun sets lower. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11638478

When driving my truck using adaptive speed control my vehicle reacts as it should to speed limit signs until it sees any sign with the number 80 on it, e.g.- state hwy 80. As soon as it reads the number 80 the number 80mph shows on the dash speedometer and the truck immediately accelerates to 80 mph! This happens no matter what speed zone you are in, even a school zone! I contacted Ford Motor Company and they referred me to my local dealership. The Dealership RAPIDS FORD said they knew of the problem because one of their managers had the same issue with his loaner vehicle. They said they contacted Ford and the Ford tech told him he should shut off the adaptive speed control when it happens???? I don't believe this is a viable solution because you never know when it is going to happen. This will happen anytime it sees the number 80 Whether you are in a 25mph, a 55 mph, or any speed zone. this is a very DANGEROUS situation for both occupants and pedestrians. I was recently on an hour-long phone call with Ford vehicle technology assist and they insisted I find my own solution by going to my local dealerships. I know for sure this condition affects at least two, but more than likely tens of thousands of vehicles. Please look into this before somebody gets killed. I can tell that Ford is not going to. This problem showed up repeatedly because state hwy 80 was detoured through and around my town. These are highway signage not speed limit signage. They do not look alike.

NHTSA ODI 11628930

This is something I've noticed a few times, it's concerning, and I'm trying to hash out what's actually happening. After reversing at slow speed (from a parking spot for example) and then shifting into drive, I've felt what appeared to be uncommanded throttle response. The cruise control engages as if it had been set to 15mph and trying to accelerate to that speed. Being in a parking space and shifting to drive, I was at a stand still. This morning, after backing out of driveway, slowing to a near stop, and selecting drive, it felt like the truck had a significant throttle engagement which I imeddiately had to brake. The cruise control had again engaged to 15mph and was green signifying it was active and accelerating to catch up to the 15mph. This occurs immediately when shifting from reverse to drive. The only common factor I can isolate to is when backing, if I simply shift to drive after slowing to a near stop, without braking, it engages. I cannot replicate and Ford says they are not aware of any issues.

NHTSA ODI 11620938

When driving my truck using adaptive speed control. Vehicle reacts as it should to speed limit signs until it sees any sign with the number 80 on it, e.g.- state hwy. 80. As soon as it reads the number 80 it immediately accelerates to 80 mph. This happens no matter what speed zone you are in. I called Ford motor company and they referred me to my local dealership. The dealership said they were aware of the problem because one of their managers had the same issue with his vehicle. They told me that the Ford tech. told him to shut it off if that happens. I don't believe this is a viable fix because you never know when it is going to happen. This will happen anytime it sees the number 80 whether you are in a 25 mph zone, a 55 mph or any speed zone. This is a very dangerous situation for both occupants and pedestrians. I just got off an hour long phone call with Ford vehicle technology assist and they insist I find my own solution by going to local dealerships. I know for sure this condition affects at least two but more than likely thousands of vehicles. Please look in to this before somebody gets killed. I can tell Ford is not going to.

NHTSA ODI 11600865

When I use the cruise control and set it at a speed, it will maintain that set speed for a period of time and then the set speed will randomly jump up 10 to 20 miles an hour and reset the speed faster. So if I set it at 70 miles an hour. It jumps up to 80 or 85 and once even jumped up to 90 mph. The first time I told this to a Service person they told me that’s normal. The car went in and supposedly they fixed it, but it is still doing it.

NHTSA ODI 11594604

On numerous occasions all of the vehicles electronics, including screens, would shut off. Sometimes this happens while driving at highway speeds causing the vehicle to lose all power. When approaching the car to unlock there is often no power to access the vehicle, which requires manually unlocking the vehicle with the key, opening the hood, then touching metal to the battery terminal to reset the electronics. The vehicle has lost power in the middle of intersections, on the highway, and in parking lots. There are times when the car signals a fault with several of the ADAS features. When this happens it’s usually probable that once the vehicle is shut off, I won’t be able to get it started again without touching metal to the battery terminal. I have started to document the failures through video to show to the technicians just in case the OBD doesn’t match what I describe. The date I’m including is the most recent occurrence but does not reflect the many occurrences since purchasing the vehicle last spring.

NHTSA ODI 11582469

Repeated failures with my parking brake applying itself when it wants too. It’s not on a hill, it’s not just when towing my trailer, it’s not related to solar flares - this truck is dangerous. The brakes apply at speed, did it on [XXX] in LA. The whole system just applied the brakes at 55mph. I have Repeated failures with “collision warning system” and the FORD app has this notated. And at times this system applies the brakes when there is nothing in front of me! The screen (not dash) pixelates, crashes, doesn’t work properly. It will not stay connected. I rely on this navigation, the screen quits working. The passenger window goes down & up at will, like a TX employer. I cannot stop it, can’t even figure out what’s going on. My truck is not subject to recall but should be! Others have similar issues why is mine not recalled? This truck is very dangerous to drive and I don’t trust it. Problems began after we left TX around August 2023 and I was working and could not get it fixed - DEALER COULD NOT MEET FORD WARRANTY TO PROVIDE ME A CAR/TRUCK TO USE! And now I’m in North TX where Ford Dealers have horrible reputations. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11579062

Bought brand new truck in December 2023. Immediately the Air/AC/Heat would intermittingly malfunction resulting in inability to defrost windshield. This resulted in hindering the drivers visibility, automatic emergency braking, front camera visibility, and other safety features. If the AC/Heat malfunctions at a time of need for defrosting/defogging the windshield, it will put anyone in the vicinity of the moving vehicle at risk. Truck was taken into the dealership during this malfunctioning period 3 different times over 2 or 3 months. The first time a service technician diagnosed a failed module, module was replaced but did not fix the issue. The second time, the service manager and shop supervisor diagnosed a failed temp senser inside the HVAC system. Senser was reading below freezing levels, supervisor took a picture of the reading to show the electrical tech. This would cause the HVAC system to give incorrect readings to other components. After further diagnosing from the dealerships master electrical tech during the second time, tech deemed it to need an update and recalibration. Update & recalibration was completed but did not fix the issue. during the third time, the Ford Engineer, shop supervisor and master electrical tech inspected the truck and BELIEVED replacing HVAC would fix issue. It is unknown if issues were diagnosed to be failing or if it a guess. HVAC has not been replaced due to no known acknowledgement from Ford into this issue. They will replace HVAC with the exact SAME part. After discussing with other Ford owners, the same issue occurs in 2023 Ford Expedition. Multiple videos were taking over this 2–3 month timeframe, before and after multiple attempts by dealership attempting to fix the issue. Vehicle has not been inspected by police, insurance reps, or others. Warning lamps/messages displayed "Front Camera Low Visibility Clean Screen" during period of malfunctioning.

NHTSA ODI 11575726

The contact owns a 2023 Ford F-150. The contact stated while driving 75 MPH, the Forward Collision Avoidance system engaged while there was no other vehicle nearby. Additionally, the contact stated that the vehicle turned off temporarily while driving on the same day. The vehicle was taken to the dealer however, the cause of the failure could not be determined. The dealer performed several software updates: however, the failure reoccurred. The contact stated that while driving 65 MPH, the Forward Collision Avoidance system engaged while there was no vehicle nearby. The contact stated that the vehicle turned off temporarily later that day. The manufacturer was notified of the failure and a case was filed. The manufacturer advised the contact to take the vehicle back to the dealer, and to contact the NHTSA Hotline for assistance. The failure mileage was approximately 5,000.

NHTSA ODI 11565933