What 50 owners told NHTSA about the 2011 Ford F-350 Super Crew

The contact owns a 2011 Ford F-350 SD. The contact stated while driving 50 MPH, the vehicle jerked and lost motive power. The contact was able to pull over to the side of the road. The check engine warning light was illuminated. The vehicle was restarted; however, the vehicle drove at a reduced speed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that metal shavings were found in the fuel filter. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.

NHTSA ODI 11643799

TRUCK HAS ABOUT 65K MILES ON IT. IT HAS HAD 2 MAJOR DIESEL ENGINE MALFUNCTIONS THAT LEFT ME STRANDED ON THE ROAD. THE FIRST TIME I BARELY MADE IT OFF THE TRAVEL LANES. THE SECOND TIME AT LEAST I WAS ABLE TO GET FULLY OFF THE ROAD. BOTH TIMES WE WERE ON THE HIGHWAY. IT ALREADY HAS HAD THE FUEL PUMP GO OUT CAUSING MAJOR PROBLEMS AND HAVING A NEW FUEL SYSTEM PUT IN. NOW SOMETHING ELSE INTERNALLY OF THE ENGINE HAS BLOWN UP AND NOW IT HAS METAL SHAVING ALL THRU THE ENGINE. THE FIRST TIME IT TOOK OVER 2 MONTHS TO GET FIXED AND THIS TIME ITS BEEN IN THE SHOP 8 WEEKS AND THE FORD EXTENDED WARRENTEE STILL HASN'T APPROVED THE REPAIRS. I'VE READ MANY ON LINE POSTS SAYING THAT THESE 2011 DIESEL ENGINES ARE EXPLODING AND FORD WON'T COVER THE REPAIRS OR MAKE GOOD.

NHTSA ODI 11170262

A FUEL INJECTOR CLAMP BROKE LEADING TO RAW FUEL POURING DOWN THE SIDE OF THE MOTOR AS WELL AS VAPORIZED FUEL SPRAYING AROUND THE TOP OF THE MOTOR. AFTER ORDERING THE REPLACEMENT CLAMP I REALIZED THEY HAVE CHANGED THE DESIGN FROM A PIECE OF CAST METAL TO STAMPED STEEL ( MUCH STRONGER). IF THE FUEL IGNITED IT COULD BE CATASTROPHIC. LUCKILY THE CLAMP BROKE IN MY DRIVE WAY AND NOT WHILE TOWING A HEAVY LOAD. THIS COULD LEAD TO THE VEHICLE SHUTTING DOWN OR WORSE CATCHING FIRE. ENCLOSE FIND PICTURES OF THE BROKEN CLAMP AND THE REDESIGNED NEW CLAMP. THERE ARE 7 MORE CLAMPS ON THIS MOTOR WAITING TO FAIL. THIS VEHICLE ONLY HAS 57,000 MILES ON IT AND HAS NEVER BEEN ABUSED.

NHTSA ODI 11144762

TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SHOOK VIOLENTLY. THE CONTACT HAD TO APPLY THE BRAKES TO SLOW DOWN THE VEHICLE AND STOP THE SHAKING. THE VEHICLE WAS DRIVEN TO THE CONTACT'S HOME. THE DEALER (O'MEARA FORD, 400 W 104TH AVE, NORTHGLENN, CO 80234) STATED THAT THERE WERE NO RECALLS FOR THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,000.

NHTSA ODI 11071768

NOTE: GRANADA TIRE BRAND(A LES SCHWAB BEND OREGON TIRE BRAND) WAS NOT IN THE DROP DOWN TO SELECT. LEFT REAR TIRE BLOWOUT DUE TO DELAMINATION WITH LESS THAN 2500 MILLE'S ON A NEW SET OF TIRES. DRIVING A 2011 F350 WEST BOUND 6 AUG 2017 ON CANADIAN HWY 16, EXCELLENT ROAD AND WEATHER, STRAIGHT SECTION WHILE TOWING 40 FT FIFTH WHEEL. HAD JUST CHECKED FOR CORRECT INFLATION. BLOW OUT OCCURRED ON A STRAIGHT CLEAR LEVEL SECTION WHILE DURING THE SPEED LIMIT IN CRUISE CONTROLL. COULD HAVE BEEN FATAL IN OTHER SITUATIONS. BOUGHT FOUR NEW COOPER TIRES TO REPLACE THE GRANADAS. FOUND THE RIGHT REAR WAS ALSO IN THE PROCESS OF DELAMINATION AND COULD HAVE BLOWN OUT SOON. SEVERE DAMAGE WAS DONE TO THE LEFT REAR WHEEL WELL ARE AND EXTERIOR TRUCK BED. WAS ABLE TO DRIVE AFTER SPARE WAS INSTALLED. TIRE BRAND GRANADA TIRE LINE TOURING L/T TIRE SIZE, P275/70R18 COMPONENT* LIGHT TRUCK TIRE BLOW OUT DOT NUMBER 5KWS RT 2711

NHTSA ODI 11015210

WHILE DRIVING THE F350, WITHOUT WARNING THE ENGINE WILL SHUT DOWN. THIS OCCURRED WHILE DRIVING ON THE INTERSTATE IN A STRAIGHT DIRECTION. HAS CONTINUED TO OCCUR OVER THE PAST MONTH (4TIMES). THE VEHICLE WILL NOT RESTART. WAIT ANYWHERE FROM 2MINUTES TO 20 MINUTES THE VEHICLE WILL RESTART. APPEARS TO BE THE ERG SYSTEM. SERIOUS SAFETY CONCERN!!!!! ACCORDING TO OTHER INDIVIDUALS ON THE INTERNET THIS IS A COMMON PROBLEM.

NHTSA ODI 11005016

TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AND STALLED INTERMITTENTLY. THE WARNING INDICATOR FOR THE EXHAUST FLUID ILLUMINATED, WHICH MEANT THE FLUID WAS LOW. THE CONTACT WAS UNABLE TO DETERMINE THE CAUSE OF THE INTERNAL FAILURE AND STALLING. THE DEALER (PARAMOUNT FORD HYUNDAI OF VALDESE 101 MALCOLM BLVD, VALDESE, NC 28690 (828) 338-9348) DIAGNOSED THAT THE ECM NEEDED TO BE REPLACED OR THE INCORRECT FUEL MAY HAVE BEEN USED. THE DEALER WAS UNABLE TO DUPLICATE AND DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 07/18/17*LJ *JS

NHTSA ODI 10992809

WE WERE TRAVELING ON US23 IN WISE VIRGINIA, DOWN A MOUNTAIN. A SIGNAL AT THE BOTTOM TURNED RED; WHEN MY HUSBAND APPLIED THE BRAKES, THE ENGINE EXPERIENCED TOTAL FAILURE. THERE WAS NO ADVANCE INDICATION FROM THE VEHICLE SAFETY SYSTEM THAT ANYTHING WAS WRONG. WITH NO ENGINE POWER, MY HUSBAND HAD NO BRAKES OR POWER STEERING TO CONTROL THE VEHICLE. DUE TO DRIVER SKILL AND LUCK, WE WERE ABLE TO BRING THE VEHICLE TO A SAFE STOP. THE VEHICLE IS NOW AT FREEDOM FORD IN WISE, AND THEIR TECHNICIAN SAYS THE FAILURE WAS DUE TO EXCESSIVE WATER IN THE FUEL, AND THE FUEL SYSTEM IS CONTAMINATED AND NEEDS TO BE COMPLETELY REPLACED. THIS INDICATES TO- VARIOUS OUTSIDE MECHANICS- THAT THE WATER AND FUEL SEPARATOR WASN'T WORKING; THUS ALLOWING THE ENGINE TO BECOME OVERWHELMED. THIS SUGGESTS FAULTY PARTS- A FAULTY SEPARATOR-WHICH SHOULD BE COVERED UNDER OUR WARRANTY. HOWEVER, FORD IS CLAIMING THAT THE FUEL SYSTEM FAILURE IS WHAT CAUSED THE COMPLETE LOSS OF POWER.

NHTSA ODI 10970786

I WAS PASSING A TRANSPORT TRUCK AND JUST AS I GOT EVEN WITH THE DOOR OF THE TRUCK MY FORD F350 SUPER DUTY MOTOR QUIT, JUST SHUT DOWN. A BUS WAS COMING IN MY LANE AS I WAS PASSING, THE TRUCK SLOWED DOWN TO LET ME BY BUT I HAD NO POWER, NO POWER BRAKES OR POWER STEERING. THE BUS SLOWED DOWN AND I BRAKED ENOUGH TO GET IN BACK OF THE TRUCK AND OVER TO THE SIDE OF THE ROAD. THE BUS WENT ON BY AND THE TRUCK CONTINUED ON HIS WAY AND I TRIED TO START MY TRUCK. IT FIRED UP AND WE DROVE TO A TRACTOR SUPPLY AND BOUGHT SOME DIESEL OIL AND WHEN WE CHECKED THE OIL TO SEE HOW MUCH IT WAS DOWN WE WERE SURPRISED TO FIND IT WAS FULL. WE DROVE 200 MILES HOME AND DIDN'T HAVE ANOTHER PROBLEM. THERE WERE NO CODES ON THE COMPUTER SCREEN IN THE TRUCK. I HAVEN'T TAKEN IT TO THE DEALER YET BUT WILL TO SEE IF THEIR EQUIPMENT WILL SHOW A REASON.

NHTSA ODI 10936822

VEHICLE WOBBLES/VIBRATES "DEATH WOBBLE" AT HIGH SPEED OR WHEN HITTING A BUMP ON FREEWAY, ONLY WAY TO STOP THE WOBBLE IS TO REDUCE VEHICLE SPEED TO UNDER 30 MPH, VEHICLE ONLY HAS 35K MILES, I HAVE HEARD OF MANY COMPLAINTS ABOUT THIS ISSUE OCCURRING AROUND 30K MILES ON FORDS, DODGE (A CLASS-ACTION LAWSUIT WAS STARTED IN 2014) & JEEP (CONGRESS HAS ALREADY REQUESTED A RECALL). I AM ASKING THAT THIS ISSUE IS LOOKED INTO FURTHER BEFORE A SERIOUS INJURY. THANK YOU *TR

NHTSA ODI 10936530

TRUCK GOES INTO A DEATH WOBBLE WHEN DRIVING 60MPH OR FASTER. USUALLY HAPPENS WHEN YOU GO OVER A BRIDGE, CATTLE GUARD OR BUMP IN THE ROAD. CAUSE THE CEHICLE TO SHAKE UNCONTROLLABLY AND YOU HAVE TO COME TO ALMOST A COMPLETE STOP. I HAVE HAD FORD WORK ON IT AND NOTHING HAS CURED THE PROBLEM. THIS ISSUE IS GOING TO CAUSE SERIOUS ACCIDENTS IF NOT TAKEN SERIOUSLY.

NHTSA ODI 10903402

TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CHECK VALVE IN THE FUEL TANK FRACTURED, WHICH CAUSE A BLOCKAGE IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 210,000.

NHTSA ODI 10887758

TL* THE CONTACT OWNS A 2011 FORD F-350 SD. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER AND STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 13V535000 (ENGINE), BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 59,800.

NHTSA ODI 10854821

DRIVING ON INTERSTATE HIGHWAY AT NIGHT. NOTED VIBRATION AS WHEN TIRES ARE NOT BALANCED. EXITED INTERSTATE AT FIRST EXIT AND CHECKED ALL TIRES. TIRE PRESSURES GOOD AND EQUAL. NO KNOTS OR DAMAGE NOTED AND ALL TIRES SAME TEMPERATURE. THOUGHT A BALANCE WEIGHT HAD COME OFF AND TIRES NEEDED TO BE REBALANCED. BEGAN DRIVING ON INTERSTATE WITH NO CHANGE IN VIBRATION. ABOUT 15 MINUTES LATER THERE WAS AN EXPLOSION AND THE TRUCK VIOLENTLY VEERED TO THE RIGHT. PULLED BACK INTO MY LANE AND THEN PULLED OVER TO RIGHT SHOULDER. RIGHT FRONT TIRE DESTROYED. CALLED AAA AND HIGHWAY PATROL. DESCRIBED INCIDENT TO TROOPER AND HE LOOKED AT THE TIRE AND SAID THE BELTS SEPARATED. SIGNIFICANT DAMAGE TO VEHICLE - BENT RIGHT FRONT BUMPER FORWARD, BLEW A 7 FOOT FACTORY RUNNING BOARD OFF OF THE VEHICLE AND DESTROYED THE RIGHT FRONT QUARTER PANEL. RIGHT FRONT TIRE CHANGED AND STAYED OVERNIGHT AT MOTEL. OBTAINED NEW TIRE REPLACEMENT NEXT MORNING. I BOUGHT THIS TRUCK TO PULL A TRAILER BUT HAVE NOT BOUGHT A TRAILER YET. LUCKILY I WAS NOT PULLING A TRAILER AND THERE WAS NOT A VEHICLE NEXT TO ME IN THE RIGHT LANE WHEN THE EXPLOSION OCCURRED. THERE WERE NO VEHICLES NEARBY OR THEY MAY HAVE HAD SOME MAJOR DEBRIS FLYING THEIR WAY. THE TIRE IS A CAPITOL H/T TIRE NOT CAPITOL PRECISION TRAC II (BUT FORM WOULD NOT ALLOW ME TO ADD THIS TIRE TO COMPLAINT)

NHTSA ODI 10781274

DRIVERS SIDE REAR (SIDE WINDOW) EXPLODED ON I95. 65 MPH. NO OTHER VEHICLES NEARBY, NO ROAD DEBRIS. WINDOW WAS IN A MILLION SMALL PIECES HELD TOGETHER BY WINDOW TINT. NO IMPACT POINT, NOT HOLE, NO SIGN OF ANYTHING HITTING (WHICH WOULD BE NEXT TO IMPOSSIBLE FROM THE SIDE WITH NO TRAFFIC AROUND). IT WAS AN EXTREMELY LOUD BANG LIKE A GUN SHOT WHEN IT OCCURRED. 2011 FORD F350. GOOGLING ONLINE INDICATES THIS IS NOT A RARE EVENT.

NHTSA ODI 10726382

I LOST STEERING IN THE TRUCK. THE STEERING WHEEL TURNED LEFT TO RIGHT AND VISE VERSA WITH A LOT OF PLAY. IT HAPPENS RANDOMLY. THE FRONT END WILL SHAKES BECAUSE OF NO STEERING MAKING THE TRUCK UNCONTROLLABLE. IT IS VERY RANDOM WHEN IT HAPPENS AND HAS HAPPENED AT INTERSTATE SPEED. THE DEALER SAYS THERE IS NOTHING WRONG AND HAVE REPLACED TIE ROD ENDS ALONG WITH BRAKES.

NHTSA ODI 10723796

UPON STARTING THE VEHICLE, I NOTICED THAT THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT HAS BEEN DIAGNOSED WITH A BAD DEF PUMP, HEATER AND SENSOR. THESE ARE FOR EMISSION CONTROL AND I HAVE BEEN TOLD THAT THESE PARTS ARE NOT A WARRANTIED ITEM. SEEMS THAT THIS SHOULD BE COVERED AS IT FOR THE SAFETY OF THE ENVIRONMENT.

NHTSA ODI 10723241

CATASTROPHIC TREAD SEPARATION (TIRE DID NOT DEFLATE) OF LEFT REAR TIRE ON PICKUP. NEARLY LOST CONTROL, BUT MAINTAINED CONTROL AND GOT TO SIDE OF ROAD. ESTIMATED $8,500 DAMAGES TO TRUCK. NO INJURIES AND NO OTHER VEHICLES INVOLVED. NO ROAD HAZARD HIT. TIRES ROTATED AS REQUIRED. IN FOR DEALER SERVICE THAT MORNING AND CORRECT INFLATION VERIFIED.

NHTSA ODI 10722876

TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY. WHILE DRIVING 60 MPH, THE ENGINE SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED SINCE THE GLOW PLUGS FRACTURED WITHIN THE ENGINE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. UPDATED 8/27/15*CN

NHTSA ODI 10720972

WHILE DRIVING AT HIGHWAY SPEED, THE VEHICLE, A 2011 FORD F-350 SUPER DUTY GAVE A WARNING TO PULL SAFELY OVER - WITH NO WARNING THE ENGINE STOPPED. THUS RENDERING THE STEERING AND THE BRAKING SIGNIFICANTLY DEGRADED. THANKFULLY, MY WIFE AND I WERE ABLE TO PULL INTO A NEARBY PARKING LOT AND WAIT FOR A TOW TO THE FORD DEALER. A CUSTOMARY USE OF THIS VEHICLE IS TO TOW A TRAILER OFTEN WITH HEAVY MACHINERY. THANKFULLY ON THIS DAY THERE WAS NO TRAILER ATTACHED. THIS SITUATION WARRANTS AN IMMEDIATE RECALL. IF I HAD BEEN TRAVELING DOWN AN INCLINE OR ON ANYTHING LESS THAN A STRAIGHT ROAD. THIS INCIDENT COULD HAVE BEEN CATASTROPHIC. *TR

NHTSA ODI 10705657

MAR.2,2015 WAS TRAVELING WEST ON HWY. 82 ABOUT 10 MILES OUT OF PRATTVILLE,AL. THIS IS A HEAVILY TRAVELED HWY. BY TRUCK AND AUTO. I WAS GIVEN THE MESSAGE STOP SAFELY NOW AND 30 SEC. LATER LOST POWER ON A MAJOR HIGHWAY GOING UP HILL. TRUCK WAS TOWED TO FORD DEALER WHERE I WAS TOLD THE TRUCK HAD A RECALL, 14E03. I WAS TOLD EGT SENSOR #2 WAS REPLACED AND THE 14E03 RECALL WAS DONE BUT THE TWO WERE NOT CONNECTED. I LEANED THIS PROBLEM WAS ADDRESSED IN A NOV.2013 RECALL FOR AMBULANCES BUT THIS WAS NOT ADDRESSED FOR THE HUNDREDS OF THOUSANDS OF PRIVATELY OWNED TRUCKS. WHY? I LEANED OF THE JAN.2015 RECALL 14E03 WHEN MY TRUCK WAS TOWED IN TO DEALER. THIS IS NOT ONLY A COSTLY BUT ALSO DANGEROUS GAME FORD IS PLAYING WITH IT'S CUSTOMERS. I WAS BLESSED! *TR

NHTSA ODI 10705436

THE ENGINE IN MY 2011 FORD F350 SUPER DUTY DIESEL SHUT DOWN WITH NO ADVANCE WARNING IN FREEWAY RUSH HOUR TRAFFIC DUE TO A EGT SENSOR. THIS HAS BEEN A PROBLEM WITH THE 6.7 ENGINE FOR SOME TIME ACCORDING TO SEVERAL DIFFERENT DIESEL FORUM SITES. THE ONLY RECALL TO DATE FROM FORD HAS BEEN ON THOSE VEHICLES EQUIPPED WITH AN AMBULANCE PACKAGE, ALTHOUGH THIS AFFECTS ALL VEHICLES WITH THE 6.7 MOTOR. *TR

NHTSA ODI 10700628

PURCHASED 8/30/2011. 1ST SERVICE CALL NOV/2011: NOTICED AT HWY SPEEDS AND/OR ACCELERATING TO PASS OR ENTER HWY TRUCK WOULD MISS/CUT OUT. SEVERAL TIMES IT DIED AS TRUCK WAS ENTERING HWY. TRUCK WAS ALSO SHIFTING HARD WHEN GOING INTO DRIVE FROM PARK. DEALER STATED THEY COULDN'T DUPLICATE PROBLEM AT INITIAL VISIT. DIAG SHOWED AN UPDATE FOR 6.7 DIESEL, THEY DID UPDATE BUT PROBLEM CONTINUES. 2ND SERVICE CALL: MAY/2012 TRANS LIGHT ON-CUTTING OUT/SLIPPING & SHIFTING HARD STILL. REPLACED TORQUE CONVERTER AND PCM & NOX SENSOR. 3RD SERVICE 2/2013: RADIATOR ASSEMBLY LEAKING-NEW RADIATOR. 4TH SERVICE4/2014:TRANS LIGHT ON, TEMP SENSOR 2 OUT-REPLACED. 5TH SERVICE 5/2014: ENG WARNING, TRUCK SHUT DOWN RUNNING ON HWY-SAID PULL OVER SAFELY. #4 EXHAUST SENSOR-REPLACED. 6TH SERVICE JAN 2014 128,942 MILES -ENG WARNING, TRUCK SHUT DOWN WOULD NOT RESTART-HAD TO TOW OFF HWY. CATASTROPHIC ENGINE FAILURE-NO COMPRESSION ON ONESIDE OF ENGINE, METAL DEBRIS IN TURBOCHARGE-TOTAL ENGINE REPLACEMENT. 7TH SERVICE JAN 2014-ON THE WAY HM FROM ENGINE REPLACEMENT ENGINE LIGHT CAME ON, NOX SENSOR OUT-REPLACED. 8TH SERVICE 2/2015 - NOX SENSOR OUT-REPLACED. 9TH SERVICE 2/2015: CADILLAC CONVERTER BAD-NEEDS REPLACED. TRUCK SERVICED ON A REGULAR BASIS, ALMOST EVERY 2 MONTHS BY FORD. *TR

NHTSA ODI 10690172

SENSOR DID NOT FIX THE STALLING PROBLEM WHICH WAS MONITORED BY FORDS BOX PUT IN THE TRUCK. I HAD TO HIT THE BUTTON FOR A SIGNAL TO BE SENT TO FORD EVERY TIME MY ENGINE LOST POWER (WENT MOMENTARILY DEAD) FINALLY FORD INSTALLED A 2013 ECM TO CORRECT THE PROBLEM, WHICH IT FIXED IT. I TRADED THE TRUCK FOR A 2014 F350 6.7L , NO PROBLEMS. *TR

NHTSA ODI 10676436

I WAS DRIVING EAST ON I-90 NEAR BOZEMAN, MT AT ABOUT 70MPH WHEN A WARNING APPEARED ON MY DASH TELLING ME TO PULL OVER TO A SAFE LOCATION IMMEDIATELY. THERE WAS AN OFF RAMP ABOUT 1/4 MILE AHEAD AND I BEGAN TO SLOW DOWN TO TAKE THE OFF RAMP WHEN THE ENGINE SHUT DOWN COMPLETELY AND LUCKILY, I WAS ABLE TO BRING IT TO A STOP BARELY ON THE OFF RAMP WITHIN ONLY A FEW FEET OF THE INTERSTATE HIGHWAY. THE ENGINE WOULD NOT START, SO I CONTACTED A TOWING SERVICE AND WAITED FOR THEIR ARRIVAL. THEY WERE NOT DUE TO ARRIVE FOR ABOUT 1.5 HOURS AND IT WAS GETTING LATE IN THE AFTERNOON. I KEPT TRYING TO START THE ENGINE EVERY 15 MINUTES OR SO, AND FINALLY AFTER ABOUT 45 MINUTES OF WAITING, THE ENGINE STARTED AND I DROVE IMMEDIATELY BACK TO BOZEMAN FORD FOR ASSISTANCE, WHERE UPON, THEY DISCOVERED THAT THE PROBLEM WAS AN EXHAUST GAS TEMPERATURE (EGT) SENSOR AND REPLACED IT. THE DEALERSHIP CHARGED ME $100.00 AND SAID THERE WAS NO NOTIFICATIONS FROM FORD ABOUT THIS PROBLEM. SINCE THEN I HAVE HEARD OF OTHERS THAT HAVE HAD THE SAME PROBLEM WITH PICKUPS OTHER THAN THE AMBULANCE PACKAGES THAT THE RECALL COVERS, AND WANTED YOU TO KNOW THAT THIS COULD BE A SERIOUS PROBLEM ON THE ROAD. IF MY WIFE AND I HAD BEEN ANOTHER 2 MILE DOWN THE ROAD, WE WOULD HAVE BEEN IN THE CURVES OF THE BOZEMAN PASS, WHICH IS NARROW AND BUSY AND USUALLY ICY THAT TIME OF YEAR. I DID TALK TO MY FORD DEALERSHIP IN BILLING, MT SOON AFTER THE INCIDENT, BUT I NEVER HEARD BACK FROM THEM. I'M HOPING THE PROBLEM DOESN'T RECUR IN THE FUTURE, BUT HEARING ABOUT IT AGAIN ON THE NEWS HAS CAUSED ME TO CONTACT YOUR OFFICE. PLEASE CONTACT ME WITH ANY INFORMATION ON THIS SUBJECT THAT YOU MAY HAVE. *TR

NHTSA ODI 10676468