What 50 owners told NHTSA about the 2011 Ford F-350 Super Crew

TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY THE CONTACT STATED THAT THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AND STALLED INTERMITTENTLY. THE WARNING INDICATOR FOR THE EXHAUST FLUID ILLUMINATED, WHICH MEANT THE FLUID WAS LOW. THE CONTACT WAS UNABLE TO DETERMINE THE CAUSE OF THE INTERNAL FAILURE AND STALLING. THE DEALER (PARAMOUNT FORD HYUNDAI OF VALDESE 101 MALCOLM BLVD, VALDESE, NC 28690 (828) 338-9348) DIAGNOSED THAT THE ECM NEEDED TO BE REPLACED OR THE INCORRECT FUEL MAY HAVE BEEN USED. THE DEALER WAS UNABLE TO DUPLICATE AND DIAGNOSE THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. UPDATED 07/18/17*LJ *JS

NHTSA ODI 10992809

PURCHASED 8/30/2011. 1ST SERVICE CALL NOV/2011: NOTICED AT HWY SPEEDS AND/OR ACCELERATING TO PASS OR ENTER HWY TRUCK WOULD MISS/CUT OUT. SEVERAL TIMES IT DIED AS TRUCK WAS ENTERING HWY. TRUCK WAS ALSO SHIFTING HARD WHEN GOING INTO DRIVE FROM PARK. DEALER STATED THEY COULDN'T DUPLICATE PROBLEM AT INITIAL VISIT. DIAG SHOWED AN UPDATE FOR 6.7 DIESEL, THEY DID UPDATE BUT PROBLEM CONTINUES. 2ND SERVICE CALL: MAY/2012 TRANS LIGHT ON-CUTTING OUT/SLIPPING & SHIFTING HARD STILL. REPLACED TORQUE CONVERTER AND PCM & NOX SENSOR. 3RD SERVICE 2/2013: RADIATOR ASSEMBLY LEAKING-NEW RADIATOR. 4TH SERVICE4/2014:TRANS LIGHT ON, TEMP SENSOR 2 OUT-REPLACED. 5TH SERVICE 5/2014: ENG WARNING, TRUCK SHUT DOWN RUNNING ON HWY-SAID PULL OVER SAFELY. #4 EXHAUST SENSOR-REPLACED. 6TH SERVICE JAN 2014 128,942 MILES -ENG WARNING, TRUCK SHUT DOWN WOULD NOT RESTART-HAD TO TOW OFF HWY. CATASTROPHIC ENGINE FAILURE-NO COMPRESSION ON ONESIDE OF ENGINE, METAL DEBRIS IN TURBOCHARGE-TOTAL ENGINE REPLACEMENT. 7TH SERVICE JAN 2014-ON THE WAY HM FROM ENGINE REPLACEMENT ENGINE LIGHT CAME ON, NOX SENSOR OUT-REPLACED. 8TH SERVICE 2/2015 - NOX SENSOR OUT-REPLACED. 9TH SERVICE 2/2015: CADILLAC CONVERTER BAD-NEEDS REPLACED. TRUCK SERVICED ON A REGULAR BASIS, ALMOST EVERY 2 MONTHS BY FORD. *TR

NHTSA ODI 10690172

TL* THE CONTACT OWNS A 2011 FORD F-350 SUPER DUTY. WHILE DRIVING 55 MPH, THE VEHICLE STALLED AND AN UNKNOWN WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING, EGT SENOR #4 CIRCUIT OPEN, EGT SENSOR WAS REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 105,451.

NHTSA ODI 10644488

IN A DAYLIGHT SAFETY ZONE REQUIRING HEADLIGHTS, I NOTICED MY DASH LIGHTS WERE NOT ON, EVEN THOUGH MY LIGHT SWITCH WAS IN THE MANUAL ON POSITION. THIS OCCURRED DURING DAYTIME WHILE TRAVELING THROUGH DENSE GROVES OF TREES THAT ALLOWED ENOUGH LIGHT TO SEE THE ROAD, BUT PRODUCED ENOUGH SHADE TO DARKEN MY INSTRUMENT PANEL. ON ENTERING A TUNNEL, MY HEADLIGHTS SHOWED TO BE ON, BUT THE INSTRUMENT PANEL LIGHTS WERE NOT ON, CAUSING THE INSTRUMENT PANEL TO BE TOTALLY BLACKED OUT, AND CREATING A POTENTIAL HAZARDOUS CONDITION. THIS OCCURRED FOR NEARLY A HALF MINUTE UNTIL THE DAYLIGHT SENSOR DETERMINED IT WAS DARK LONG ENOUGH TO ACTIVATE THE DASH LIGHTS. I BROUGHT THE PROBLEM TO THE ATTENTION OF TWO FORD DEALERS, WHO WERE UNABLE TO DUPLICATE THE PROBLEM WITH THE TRUCK IN THEIR SHOP. THE THIRD DEALER I CONTACTED WAS ABLE TO VERIFY THE PROBLEM I EXPERIENCED; SPECIFICALLY, THAT WHILE THEIR TESTS SHOWED ALL SYSTEMS CHECKED OUT OKAY, DASH LIGHTS WERE INEXPLICABLY LINKED TO THE DAYLIGHT SENSOR, REGARDLESS OF WHETHER THE HEADLIGHT SWITCH WAS PLACED IN PARK, ON, OR AUTO MODE. IF THE TRUCK WAS OUTSIDE IN THE SUN, PARK AND ON SWITCH POSITIONS DISPLAYED THE EXPECTED PARKING/HEADLIGHT/TAIL LIGHT COMBINATION, BUT NOT THE DASH LIGHTS. AUTO POSITION WORKED AS EXPECTED. ON COMPARING TRUCKS SIMILAR TO MINE, ONE WITH A COMPUTER MODULE DISPLAY AND ONE WITHOUT (AS MINE IS) THE DEALER FOUND THAT THE DISPLAY-EQUIPPED TRUCK'S DASH LIGHTS CAME ON AS EXPECTED IN DAYLIGHT WHEN THE SWITCH WAS ON, BUT THE TRUCK EQUIPPED AS MINE, WITH DO DISPLAY, FAILED AS MINE DOES. BEING STUMPED, BOTH THE DEALER AND I CONTACTED FORD FOR FURTHER INSIGHT. TO DATE, WHILE THE DEALER IS WILLING TO PURSUE THE ISSUE TO ITS SATISFACTORY CONCLUSION, FORD TELLS ME THAT IF THE DEALER CAN'T LOCATE A PROBLEM, NONE EXISTS. I ASKED FORD TO VERIFY THE PROBLEM WITH THEIR ENGINEERS AND DETERMINE WHY THE TWO MODULES DIFFER, WITH NO SUCCESS.

NHTSA ODI 10417313