What 1,066 owners told NHTSA about the 2017 Ford F-150 Supercab

The contact owns a 2017 Ford F-150. The contact stated that while coming to a stop, there was an abnormal screeching sound while depressing the brake pedal. There was no warning light illuminated. The contact received notification of NHTSA Campaign Number: 25V236000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 40,000.

NHTSA ODI 11678827

The contact owns a 2017 Ford F-150. The contact received notification of an undisclosed recall. The contact stated that upon starting the vehicle on several occasions, the engine made an abnormal rattling sound. The vehicle was taken a dealer, where it was diagnosed that all four Variable Camshaft Timing (VCT) units needed to be replaced. The vehicle was repaired, but the failure reoccurred two years later. The vehicle was taken to a dealer, where it was diagnosed that all four VCT units needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 69,508.

NHTSA ODI 11678172

The drivers airbag cover is cracked. This has happened to everyone I have talked to with the same vehicle. Also is a topic on many f150 public forums. I think this should be addressed by Ford.

NHTSA ODI 11677678

The contact owns a 2017 Ford F-150. The contact stated that while starting the vehicle, the vehicle made an abnormally loud ticking sound. There was no warning light illuminated. The local dealer was contacted and informed the contact that the failure was related to the cam phasers, which the contact related to Ford Customer Satisfaction Program Number: 21N03. The dealer provided an estimate for the repair; however, the vehicle was not diagnosed or repaired. The manufacturer was contacted, and a case was filed. The failure mileage was approximately 150,000.

NHTSA ODI 11677250

The contact owns a 2017 Ford F-150. The contact stated that upon starting the vehicle, there was an abnormal loud rattling sound coming from the engine compartment. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 123,000.

NHTSA ODI 11677304

I was driving on the PA turnpike and upon hitting a pothole or bump the mount on the frame that the lower control arm bolts onto broke off. I was going under the speed limit with two small children in the car and a piece of my frame broke off after a slight bump. Every mechanic and person I speak to at ford is saying it shouldn't have happened and they can't believe it. There was no warning and I drove onto the turnpike got almost all the way home before it randomly broke. I spoke with Ford and they are unwilling to help after running my VIN. They say unless I put a complaint in and you open a recall that they will not help me. This is a 2017 truck with minimal rust it should not be breaking off a simple bump on the highway. I had a 9 year old and a 10 month old in the car and the front left of my suspension broke away from the vehicle after routine driving. Something needs to be done about the situation ford should be more concerned they have a frame break on such a new vehicle. Thank you for your time.

NHTSA ODI 11676974

Timing system failed at 73,000 miles causing engine stall loosing power brakes and control.

NHTSA ODI 11676338

On July 18, 2025, I was fueling my vehicle at COSTCO. I put my vehicle in park, exited and left the door open while I waited for my credit card to clear so I could start fueling my vehicle. I was out of the vehicle for about a minute when the vehicle started to move backwards. I was standing between the open door and the drivers seat and was startled when it began to move. I was hopping on one foot trying to get back into the vehicle. Ultimately, the open door hit a column at the station. There was damage done to my door. There was no warning that made me aware that the vehicle wasn't still in park and there was an impending issue.

NHTSA ODI 11676135

With low miles on my vehicle I’m experiencing cam phasers start becoming very loud and rattling coming from my engine compartment due to the cam phasers as I research I found that it will eventually shred up the inside of the engine and destroy it, I wouldn’t want to be going down the highway and my engine lock up do to this issue and many other people’s issues of the same exact thing this is a major safety issue that needs to be fixed for me and the multiple multiple other people that have complained also

NHTSA ODI 11676301

The contact's husband owns a 2017 Ford F-150. The contact stated that while her husband was stopped at a red light, the vehicle shut off with an "Alarm" alert message on the instrument panel. The contact's husband sought assistance and had the vehicle jumpstarted, and the vehicle restarted. The vehicle was taken to an independent mechanic where an oil change was performed, and the battery was tested, and the contact was informed that the battery was in good condition. Upon leaving the mechanic, the vehicle shut off again but another attempt to jumpstart the vehicle failed. The vehicle was towed to a dealer. The vehicle remained with the dealer for four days; however, the dealer could not duplicate the failure. The failure persisted upon return of the vehicle and the vehicle was towed to LaFontaine Ford Grand Rapids (3385 Alpine Ave NW, Grand Rapids, MI 49544); where it remained unrepaired. The manufacturer was notified of the failure and the contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 74,800.

NHTSA ODI 11675532

The contact owns a 2017 Ford F-150. The contact stated that there was a small oil leak coming from the vehicle. There were no warning lights illuminated. The contact stated that the failure was a known issue that was related to the Customer Satisfaction Program: 21N03. The vehicle was taken to the local dealer, where the oil leak was confirmed, and the dealer was informed about issues with the cam phasers. The vehicle was not repaired. The manufacturer was contacted and transferred the contact to the NHTSA Hotline. The failure mileage was approximately 60,000.

NHTSA ODI 11675555

When I turn my windshield wipers on during rain, I can't turn them back off. They WILL NOT TURN BACK OFF. I have to pull off the road and turn the truck off and then restart the truck.. Sometimes this works and sometimes this doesn't work either. THIS IS A VERY ANNOYING PROBLEM. This can be a safety issue if I am trying to deal with this and get off the road to turn the truck off. I also own a 2019 F150 and now it has started doing the EXACT same issue. I don't feel this is a problem for the owner. I feel there is a defect in these two trucks. I feel there should be a recall on this issue. I have talked to the Ford dealership about this issue. There are no warning lamps, messages or other symptoms of the problem prior to the failure. The date this first started is around April 2025 but I don't know the exact date. THANK YOU VERY MUCH:

NHTSA ODI 11675571

The contact owns a 2017 Ford F-150. The contact stated that while the vehicle was being traded in at the dealer, the contact was informed that the cam phasers needed to be replaced. The vehicle was taken to a second dealer, Upper Marlboro Ford (5701 Crain Hwy, Upper Marlboro, MD 20772), who also determined that the cam phasers needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Programs: 21N03 (Cam Phaser Replacement) and 21B10 (Powertrain Control Module Reprogram for Cam Phaser Rattle); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

NHTSA ODI 11675583

Component: 6r80 transmission lead frame Safety: Driving at 70mph on the interstate on 07/23/2025 and vehicle violently downshifted while in cruise control. Rear tires locked briefly. Driver and passenger were restrained by the seat belts or there would have been a loss of control. I was able to pull to the side of the road. Reproduced: This is the third time in a year that this has happened. Independent shop is scheduled to inspect. DTC codes P061A and P0722 are logged in the PCM. Warning Lamp: After the incident, an amber wrench icon was displayed. Still displayed after restart. Disappeared after 2nd start.

NHTSA ODI 11675766

The contact owns a 2017 Ford F-150. The contact stated that while cold-starting the vehicle, there was an abnormal rattling sound coming from the vehicle. After the vehicle had warmed up, the sound dissipated. While the contact’s mother was driving the vehicle, there was an abnormal rattling sound coming from the vehicle. The contact stated that there was a faint, unidentifiable sound in the vehicle prior to the start of the rattling sound. The contact stated that the failure was related to Customer Satisfaction Program: 21N03, related to the cam phaser. The contact, who is a mechanic, had been completing an oil change on the vehicle. The contact stated that the failure was related to the cam phasers. The contact called the local dealer, but there was no answer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 130,000.

NHTSA ODI 11675089

My 2017 Ford F-150 is experiencing an oil pan leak. F150 model is equipped with the 2.7L EcoBoost engine. This is a lack of RTV adhesion at the oil pan seal. My dealership wants over 1k to fix which I refuse to pay. This issue was created by poor engineering and craftsmanship on Fords end and the consumer should not have to pay to fix this known issue. I understand there is a fix that involves a 1-piece aluminum pan, as seen on many you tube videos. I'm requesting that Ford be held responsible for fixing this issue and not the consumer, who paid a lot of money for this truck. Any help in getting this resolved would be greatly appreciated.

NHTSA ODI 11674446

While driving with my cruise control at 75, the instrument cluster began to blink on and off like it was shorting out. Then the truck would suddenly downshift and search for a gear. It continued to do this until I could exit the highway. The truck aggressively downshifted multiple times quickly decelerating the vehicle. It was pretty scary.

NHTSA ODI 11674604

Vehicle transmission will instantly drop to gears 3 to 5 (limp mode from what I have researched) & wrench light comes on. Very dangerous on the interstate traveling at 70mph+, seems to happen more frequently on hotter days. You can park & turn off vehicle, then crank back up, & it is out of limp mode but transmission is sluggish. Initially it was happening once per week on avg, now it is a toss up on each drive I do whether it goes into limp mode or not.

NHTSA ODI 11674192

My truck dies for no reason when in park, or drive going very slowly. My vehicle is available for inspection if desired. This is very dangerous to have a running vehicle die when driving, or stopped at a red light. This has happened multiple times. I usually know when it's about to happen because my vehicle shakes, sometimes very hard, right before it happens. The dealership has stated that it will be expensive to diagnose because it happens irregularly, and they have no idea what could be causing it. No warning lamps, engine light, or any messages prior to staling. However, as stated prior, sometimes the vehicle shakes just before stalling. My vehicle is a 2017, and this just began about seven months ago. I had just had the dealership put in a new transmission and water pump . It never happened prior to that service.

NHTSA ODI 11673848

The contact owns a 2017 Ford F-150. The contact stated that while attempting to start the vehicle, the contact heard a knocking sound coming from the engine. A dealer was contacted. The vehicle was taken to the dealer, and it was determined that the cam phaser needed to be replaced. The vehicle was not repaired. The contact was relating to the failure of Customer Satisfaction Program 21N03: (GTDI Engine Cam Phaser Replacement); however, the VIN was not included in the program. The manufacturer was notified of the failure and informed the contact that the VIN was not under a recall related to the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 84,000.

NHTSA ODI 11673680

Transmission started jumping hard from park to drive , progressed dropping from higher gear to lower gears hard while driving causing the truck to lock up and skid does it at both higher speeds and lower speeds even while idling down the road .

NHTSA ODI 11672694

There is an engine rattle when starting the vehicle. I took my vehicle to Ford of Upland dealership. They said I need to replace my VCT Solenoids and water pump. This was a known issue for this year and make of vehicle and I never received any notification. Now, they want to change me $6000 to repair it. There was TECHNICAL SERVICE BULLETIN 23-2143 issued for this defect.

NHTSA ODI 11672353

The contact owns a 2017 Ford F-150. The contact stated that while operating the vehicle, the check engine light had illuminated and the vehicle had experienced rough operation. The vehicle was later towed to the local dealer who diagnosed that the cam phasers were faulty and advised that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 144,000.

NHTSA ODI 11671881

When the vehicle is started, the cam phasers rattle, and yes, it is available for inspection upon request. Ford mechanics and other mechanics have stated that if not replaced, the cam phasers will eventually fail. This puts others at risk as the auto start/stop feature shuts the engine off anytime the vehicle comes to a stop. If the cam phasers failed while stopped in the road, the vehicle would not start back up, causing a rear end collision and possible injury/death to anyone on the road. The problem exists in the 2015-2018 Ford F150 3.5L ecoboost. Ford resolved the issue in the 2019 model F150 by replacing the cam phasers with ones that are built with better quality. I am unsure if the vehicle issue has been inspected by others. There have been no warning lamps, messages, or other symptoms of the problem prior to the failure. It first appeared in my vehicle around this year.

NHTSA ODI 11671579

The contact owns a 2017 Ford F-150. The contact stated that upon starting the vehicle in the morning, there was white smoke coming from exhaust pipes. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the engine. The dealer observed a crack in the cylinder head gasket. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 99,000.

NHTSA ODI 11671715