What 1,066 owners told NHTSA about the 2017 Ford F-150 Supercab

On July 18, 2025, I was fueling my vehicle at COSTCO. I put my vehicle in park, exited and left the door open while I waited for my credit card to clear so I could start fueling my vehicle. I was out of the vehicle for about a minute when the vehicle started to move backwards. I was standing between the open door and the drivers seat and was startled when it began to move. I was hopping on one foot trying to get back into the vehicle. Ultimately, the open door hit a column at the station. There was damage done to my door. There was no warning that made me aware that the vehicle wasn't still in park and there was an impending issue.

NHTSA ODI 11676135

The contact owns a 2017 Ford F-150. The contact stated that while driving at various speeds, the transmission was slipping and the vehicle jerked significantly, causing the contact to sustain back pain. The power train warning light and an unknown warning light were illuminated. The vehicle was taken to Geared Up Transmissions, where it was diagnosed and determined that the transmission had failed due to a transmission clutch failure. The vehicle was not repaired. The contact related the failure to an unknown recall. An unknown dealer was contacted and confirmed that the VIN was not under recall. The manufacturer was notified of the failure and transferred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 148,000.

NHTSA ODI 11649442

The wiring for the rear defrost caught fire. A week later it caused the rear glass to completely shatter. We didn't know it was the rear defrost wiring until we had the glass replaced and were able to see the wires fried. I have farm animals and routinely leave my 3 children in their carseats in the truck with it running when it's cold outside and I feed our animals. If it had caught fire with my kids in the truck I wouldn't have known and they wouldn't have been able to get out. I talked to 2 Ford dealerships, 2 different lawyers and a service rep through Ford's website. Even though this exact issue is everywhere on Ford Forums no one will do anything about it because there's no current recall. The only thing we could do to make sure this doesn't happen again is to pull the fuse for the rear defrost. This is a devastating accident waiting to happen and no one will do anything about it.

NHTSA ODI 11636104

This is a MAJOR issue with Ford F150s. I am not sure how this was never a recall. Ford issues a TSB for this but NOTHING is the TSB fixes the issue. There is a major fault in the IWE system that causes the 4x4 to engage randomly causing the truck to have major steering issues. It causes grinding, like metal on metal grinding, the steering wheel locks in place at times and I personally almost dies several times from this.The locking steering wheel caused me to crash into a ditch because I could not bring the steering wheel back to center. This has randomly happened to me several times while driving, The TSB claims the issue to be intermittent, which it is due to the fault in this IWE system. FOrd needs to literally cover and replace the entire IWE system before someone gets hurt. Please look this up, this is a very known issue that deserves to be a recall and not a TSB. Please help save lives.

NHTSA ODI 11635701

Vehicle would downshift into 1st gear even at highway speeds locking tires up, sometimes would downshift into 3rd. At one time it caused truck to slide off into ditch hitting mailbox and a culvert. Was charged $2,000 for a new lead frame and months later back at ford with transmission failure where they say I’m responsible for full cost of transmission

NHTSA ODI 11625182

When I use the brakes, the doors open and passengers fall on the roadway. Then get struck by passing vehicles. It hurts when getti ng run over. Plus it sucks when the doors open randomly in traffic.

NHTSA ODI 11565249

Hit from behind. Rage driver attempted manslaughter trying to force us into high speed traffic. Hit us a 2nd time. Driver hitting us refused to yield information; name, address, insurance, registration. Obtained via Oceanside Ca. Police incident # 2300118069. Cause- no accountability due to No Fault Insurance practices

NHTSA ODI 11560464

The contact owns a 2017 Ford F-150. The contact stated that while driving at an undisclosed speed and upon activating the rear window defroster, she observed smoke filling the interior of the vehicle. After a visual inspection of the rear window, the contact observed the rear window lower wire cover on fire. After turning the vehicle off, the fire extinguished on its own, after which the rear window shattered. Emergency services were not called. A fire report was not filed, and no injuries were reported. No warning lights were illuminated. The vehicle was towed to the dealer, who determined that the rear defroster wiring had shorted, causing the wiring to catch fire. The vehicle was repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA hotline for assistance. The failure mileage was 106,000.

NHTSA ODI 11552662

I am filing this incident with you before I take my 2017 Ford F-150 to my local Ford dealership tomorrow. My truck was parked on a church parking lot September 3, 2023 . The truck was placed and left in park. I walked away from the truck and walked into a building went upstairs. According to the church security video my pickup truck started rolling across the lot until it was stopped by flower bed timbers just short of the Church Sanctuary building. I was upstairs and happened to look out the window and saw my truck in the flower bed. It was still in park!!! Thirty minutes later and a group of small children would have been crossing that area. Already my Ford dealership is telling me because my vin shows no recall (even though other 17/18 pickups have this issue) they will not cover the diagnosis or repair. How many more trucks like mine are out there? I am frustrated. Ford may or may not be aware of this. That is why I am reaching out to you. I do not trust them. 1

NHTSA ODI 11542664

On 07-15-2023 A girl rana stop sign and hit my truck quite hard on the Drivers side just in front of the door. It was so violent that my head, shoulder, arm, and left hand shattered the drivers window in each place they hit. Pictures show all 4 definitive places where each body part hit. I incurred a fracture on my left hand, shoulder, and head pain. I had to really force the drivers door open. It bent the front end around and I had to force the passenger door open. The side airbags didn't deploy. At the time of the accident all I felt was my hand and was slightly dizzy but didn't feel like I needed medical attention. The next day I knew I needed medical attention and went to the urgent care. I am now getting unusual headaches on the left and rear side of my head. I do not normally get headaches and am rarely ever sick. I have an appointment with my doctor to get checked out on Monday. I really feel that the side airbags should have deployed. Why even have them if they done deploy.

NHTSA ODI 11535261

On April 28th, 2023 at approx. 1800 this Ford F-150 malfunctioned yet again. While traveling east on Interstate I-70 in a construction zone near Saint Clairsville, OHIO, this F-150 was set on cruise speed for the construction zone. This F-150 shifted from 8th gear down to 3rd gear. This uncommanded and unprompted change of speed injured my neck and nearly ended my family's life and the lives of others. The 18 wheeler carrying thousands of gallons of fuel behind me NEARLY clipped my rear end. As this change in speed was did not included BRAKE LIGHTS, because I did not hit my brake pedal. This F-150 is a danger to society and will certainly kill a construction worker, police officer, or any one near it. Perhaps it will take out a critical bridge or other important infrastructure????? I just hope it doesn't kill a presidential motorcade. This truck is a hazard. I am NOT in control of the truck at highway speed. I will not be accountable for the impending disaster this truck will cause. YOU ARE! This F-150 does have the 10R80 transmission, so you are aware of the danger. What are you going to do???? My son has name this truck "MURDER TRUCK", he fears riding in it. He refuses to risk his life in this F150. Please contact me NOW. [XXX]. The corvair was recalled for far less. Simply driving this....is the danger/hazard. I know you don't give a [XXX]. So [XXX] you for doing nothing. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11520781

The contact owns a 2017 Ford F-150. The contact stated while driving approximately 25 MPH and slowing for traffic at an intersection, his brakes failed as he depressed the brake pedal. The contact stated that his vehicle crashed into the rear of the vehicle in front of him. The contact stated that his air bags deployed. The contact stated no warning light was illuminated. The contact stated that the front end of his hood and grill were crushed, and that the radiator had been ruptured. The contact stated that the other vehicle had suffered damage to trunk and rear bumper. The contact stated that there were no injuries to him or the other driver. The contact said that the police were on scene and wrote a report. The contact stated that his vehicle had been towed to his residence, he was not sure if the other vehicle had been towed. The contact's vehicle had not been repaired. The manufacturer had not been informed of the failure. The contact had researched online and related the failure to NHTSA Campaign Number: 22V150000 (Service Brakes, Hydraulic). The failure mileage was unknown.

NHTSA ODI 11511036

The contact owned a 2017 Ford F-150. The contact stated that while her husband was driving an unknown RV hauling a 2017 Ford F-150 at 70 MPH, the vehicle caught fire from the front end. The contact's husband attempted to extinguish the fire but was unsuccessful. The firefighters were able to extinguish the fire. Police and fire reports were filed. The vehicle was deemed totaled. The vehicle has not been diagnosed. The manufacturer was made aware of the failure. The failure mileage was approximately 60,000.

NHTSA ODI 11507380

The Right Rear Light underneath the brake light caught fire and exploded.

NHTSA ODI 11500440

Brakes slowly stop holding while at a stop for too long; such as at a red light or waiting for a train, and takes more force from driver to stop vehicle. After inspecting the braking system I found brake fluid leaking between the brake booster and master cylinder. With a little investigating I found Ford already recalled the same part number for other F150 trucks but mine was not in that group from the same model year. The current recall needs to be expanded to cover every truck with that part number. Due to this failure i was involved in a low speed TC in a parking lot when my brakes stopped holding.

NHTSA ODI 11480579

Yesterday evening, 8/13/2022, I had my family in the F150 TRUCK. We were traveling at 77 mph (in a 70 mph zone) on toll route 576 enroute to Pittsburgh Airport. The F150 TRUCK was on cruise control (this time) when it downshifted from 10th gear to 1st gear. My neck is very sore, now. It continued to mis-shift although no service light illuminated this time. The milage during this incident was 53,809.3 (give or take a mile or two, I don't take pictures when at the wheel of F150 TRUCK) All my family was traumatized again. The truck made it to the airport. Where we picked up our foreign exchange student from Japan named Jua. The ride home, I white knuckled the steering wheel, not knowing when we would go out of control. The truck made it home without causing death to our family or innocent civilians. This is the second time this has occurred. Ford attempted to fix with valve body replacement.

NHTSA ODI 11479227

The truth caught on fire driving down the road with passengers. It started on the passenger side and engulfed the truck. Insurance is investigating it.

NHTSA ODI 11475066

The contact owns a 2017 Ford F-150. The contacts stated that his wife was driving approximately 55mph when the vehicle in front came to an abrupt stop and the contact crashed into the other vehicle, which resulted in the air bags not deploying. The contacts sought medical treatment and sustained abdominal, wrists chest injuries, while the wife sustained chest, side, back, and stomach injuries. The contact's son was sitting in the rear passenger side seat and also received chest and stomach injuries. A police report was taken, and the vehicle was towed by the city and remained in their lot. The manufacturer was not informed of the failure. The failure mileage was approximately 103,000. The VIN was not available.

NHTSA ODI 11451363

While driving my vehicle I began to notice a clicking noise in relation to my tires/speed. No sensors came on, all gauge readings were normal. I pulled over and viewed the tires to check for a flat, all seemed fine and pressure was reading normal. When I resumed driving, I came back into my lane turning slightly left and noticed that the steering wheel began to vibrate. I slowed the vehicle again and put on my hazard lights while attempting to reach a freeway exit. The vehicle began shaking as though I had a flat but again I did not. I decided to turn off an exit and when I attempted to make a left turn into a parking lot, my front passenger wheel flew completely off. My two four year olds and I were then left without control of the truck, finally grinding to a stop blocking two directions of traffic on a Highway unable to get out of harms way. It was night, cars were coming in either direction. I had to emergently remove my children from their car seats and get away from the vehicle to safety. The lug nuts/bolts were completely sheered off. The wheel flew into a field several yards away from the vehicle. If I would not have exited the freeway, I shutter to imagine what would have happened to us as other large trucks would not have been able to stop at the rate that we were forced too. Please. This vehicle/part needs an official recall!

NHTSA ODI 11450709

The contact owned a 2017 Ford F-150. The contact stated that while operating the vehicle, smoke and heat were suddenly present inside the cabin of the vehicle. After exiting the vehicle the fire department was called to the scene and extinguished the flames. During the incident, the vehicle was destroyed and towed away. The contact indicated that the flames had started behind the front seats inside the cabin of the vehicle but the cause of the fire was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 47,000. THE CONSUMER STATED THERE WAS NO POLICE OR FIRE REPORT, BUT BOTH ARRIVED AT THE SCENE. THE CONSUMER SUFFERED FROM 3RD DEGREE BURNS ON THE ARM.

NHTSA ODI 11436913

My son, Marine LCpl Ryan McCoy, was driving on I95 in Virginia back to Camp Lejeun when he heard a “pop” sound. Assuming something was wrong, he pulled over to the breakdown lane. The vehicle began to smoke and the temperature gauge shot up to the hottest it could register. At that time, he turned off the vehicle and exited. He noticed the front of the vehicles so in flames and began to run away from the vehicle and saw the vehicle violently explode. He called 911. Stare Trooper Joseph Worley arrived and he called a tow truck. When the fire went out, the trooper left without checking to see if Ryan was okay or had a ride anywhere. The tow truck dropped Ryan at the nearest rest stop and the tow truck took the vehicle to Interstate Garage.

NHTSA ODI 11427776

The contact owned a 2010 Newmar Essex RV hauling a 2017 Ford F-150 Raptor. The stated that while driving at 60 mph, he was alerted by another driver that the 2017 Ford F-150 Raptor, had caught fire. The contact stated that the fire started from the hood and grille assembly of the vehicle. The contact attempted to extinguish the fire with a fire extinguisher, but was unsuccessful. The fire engulfed both vehicles. The fire department was able to extinguish the fire. A police report and fire department reports were filed. No medical attention was received however, the contact stated that his cat was injured. Both vehicles were towed to a wrecking yard and was deemed totaled by the insurance company. The vehicles will later be towed to salvage yard for the insurance company to perform an investigation. The dealer was made aware of the failure. The manufacturer was made aware of the failure and a complaint was filed with the manufacturer. The failure mileage was 45,846.

NHTSA ODI 11418080

ADDING PHOTOS TO THE FIRST COMPLAINT

NHTSA ODI 11384450

I LIVE IN NEW HAMPSHIRE AND THE WEATHER IS COLD. I STARTED MY FORD F150 TRUCK TODAY USING MY FORD PASS. THE TRUCK RAN FOR 15 MINUTES. WHEN I PREPARED TO LEAVE IN THE TRUCK I NOTICED THAT IT WAS COLD INSIDE. WHEN I LOOKED IN THE REAR VIEW MIRROR, I REALIZED THE REAR SLIDING WINDOW WAS COMPLETELY SHATTERED. UPON CLOSER INSPECTION I REALIZED THE WINDOW BLEW OUTWARD AND A YELLOW LINE X STICKER ON THE RIGHT REAR OF THE WINDOW HAD BURN MARKS ON IT. THE STICKER WAS DISCOLORED TO INDICATE THAT A LOT OF HEAT WAS DIRECTED TOWARD IT. THE WINDOW WAS COMPLETELY SHATTERED AROUND THE OUTSIDE EDGE. ALSO, I LOCATED A COVER THAT HAD BLOWN OFF THE WIRES THAT RUN TO THE REAR DEFROSTER. IT APPEARS THAT THE REAR DEFROSTER RAN TO THE POINT THAT IT OVERHEATED THE GLASS AND CAUSED IT TO BLOW. I DISCOVERED THAT THIS HAS OCCURRED IN THE PAST WITH FORD F150 TRUCKS AND NTSA HAS RECEIVED COMPLAINTS. I CONTACTED FORD TODAY AND I AM WAITING TO HEAR BACK FROM CUSTOMER SERVICE

NHTSA ODI 11384439

THIS IS WHILE STATIONARY, CAR ON OR OFF. WHEN THE DOORS ARE LOCKED AND THE PASSENGERS WANT TO GET OUT OF THE CAR, THEY ARE UNABLE TO OPEN THE DOOR. ONLY WAY FOR THEM TO OPEN THE DOOR IS FOR THE PASSENGERS IN THE FRONT SEAT TO PRESS THE UNLOCK BUTTON ON THE DOOR. I FEEL THIS IS A SAFETY ISSUE AS IT ACTS LIKE A PERMANENT CHILD LOCK. WHEN TAKING THE CAR TO THE FORD SERVICE DEPARTMENT AND CALLING 1(800) TO MAKE A CLAIM, THEY SAID THAT IS HOW THE CAR IS ENGINEERED. EVERYONE FROM FORD DEALERSHIP AND THE 1800 NUMBER ALL AGREED THAT IT COULD BE A SAFETY ISSUE. EXAMPLE 1: IF THE CAR IS LOCKED WHILE DRIVING AND THERE IS A CRASH, AND THE DRIVER GETS KNOCKED OUT AND THERE IS SOMEONE IN THE BACK SEAT, THE ONLY WAY FOR THEM TO GET OUT OF THE CAR IS TO ROLL THE WINDOW DOWN AND CLIMB OUT. THEY CANNOT GET OUT BY OPENING THE DOOR HANDLE, THEY HAVE NO UNLOCK BUTTON, THEY'RE ONLY HOPE IS FOR THE WINDOW TO ROLL DOWN OR BREAK THE WINDOW. EXAMPLE 2: THIS ONE ACTUALLY HAPPENED TO US. MY DAD WAS DRIVING WITH MY NEPHEW AND BROTHER IN LAW IN THE BACK SEAT. THEY GET PULLED OFF THE ROAD BY A CRAZY DRIVER. THE CRAZY DRIVER GETS OUT OF THE VEHICLE AND CONFRONT MY OLD FATHER AND STARTS TO THREATEN HIM. MY BROTHER IN LAW WHO WAS IN THE BACK SEAT WITH MY NEPHEW WAS TRYING TO GET OUT OF THE CAR TO HELP MY DAD BUT HE COULD NOT BECAUSE MY DAD DID NOT PRESS THE UNLOCK BUTTON ON THE DRIVER DOOR THUS FORCING MY BROTHER IN LAW TO ROLL THE WINDOW DOWN AND CRAWL OUT. WHEN HE DID THIS, HE GOT HIS FOOT CAUGHT AND ENDED UP FALLING RIGHT ON HIS SHOULDER CAUSING BRUISING AND SCRAPES. IF HE WAS ABLE TO GET OUT OF THE BACK SEAT OF THE CAR, NONE OF THIS WOULD HAVE HAPPENED. ALSO IT IS AN ANNOYANCE. PASSENGERS IN THE BACK SEAT HAVE TO WAIT FOR THE DRIVER OR FRONT SEE PASSENGER TO UNLOCK THE DOORS FOR THEM TO GET OUT.

NHTSA ODI 11363633