What 773 owners told NHTSA about the 2011 Chrysler Town And Country

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND RESUMED DRIVING. IN ADDITION, ALL THE DOOR LOCKS UNLOCKED INDEPENDENTLY, THE RADIO FUNCTIONED INDEPENDENTLY, AND THE TIRE, TRACTION CONTROL, AND ABS WARNING INDICATORS REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIPM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THEY NEVER HEARD ABOUT THE VEHICLE HAVING THAT TYPE OF FAILURE. NO ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

NHTSA ODI 11067086

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO RAIRDON'S CHRYSLER DODGE JEEP RAM OF MARYSVILLE (16610 SMOKEY POINT BLVD, ARLINGTON, WA 98223, (360) 653-5664) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

NHTSA ODI 11066493

THE FUEL PUMP REGULATOR GOES OUT AND THE WHOLE COMPUTER SYSTEM HAS TO BE REPLACED FOR 1100 PLUS DOLLARS.

NHTSA ODI 11065577

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING APPROXIMATELY 10 MPH, THE ALTERNATOR FAILED AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ALTERNATOR FAILED AND PRODUCED A REVERSE VOLTAGE, WHICH CAUSED THE ECU TO BE DESTROYED. THE VEHICLE WAS REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000.

NHTSA ODI 11065281

BLIND SPOT MONITORING SYSTEM FAILED BECAUSE SENSOR MODULE GOT WET ON THE INSIDE. SENSOR MODULE NOT SEALED ON CORRECTLY. CONNECTOR ALSO CORRODED BECAUSE OF SALT BEING USED ON STREETS HERE IN OHIO DURING WINTER MONTHS. THIS IS THE SECOND TIME THIS SYSTEM HAS FAILED FOR THE SAME PROBLEM. TALKED TO SERVICE MANAGERS AT 2 DIFFERENT CHRYSLER DEALERSHIPS AND WERE TOLD BY BOTH THAT THIS IS A COMMON PROBLEM WITH THIS PART AND THEIR OPINION IT IS A DESIGN FLAW WITH THIS PART DUE TO ITS EXPOSURE TO THE ELEMENTS.

NHTSA ODI 11063864

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE KEY WAS UNABLE TO TURN OVER IN THE IGNITION AND THE VEHICLE FAILED TO START. IN ADDITION, THE AUTOMATIC START FOB FAILED TO FUNCTION FOR MORE THAN TWO YEARS. THE DEALER (STEW HANSEN DODGE RAM CHRYSLER JEEP, 12103 HICKMAN RD, URBANDALE, IA 50323, (515) 331-2900) STATED THAT THE VEHICLE WAS EXCLUDED FROM A MANUFACTURER RECALL AND THAT THE TIPM NEEDED TO BE REPLACED. THE MANUFACTURER STATED THAT THE VEHICLE WAS EXCLUDED FROM A RECALL, BUT PROVIDED NO SOLUTION. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

NHTSA ODI 11062260

I SMELLED SOMETHING BURNING ON THE DRIVER'S SIDE OF THE VEHICLE. AFTER DRIVING A SHORT DISTANCE (15 MINUTES) I FOUND THE TIRE WAS VERY HOT. THE CAR HAD PREVIOUSLY BEEN INSPECTED 3 WEEKS PRIOR, HAD BRAKE PADS REPLACED, AND INSPECTION DETECTED NO ISSUES. HAD CAR TAKEN TO MECHANIC AND FOUND A BRAKE HOSE FAILED RESULTING IN CALIPER NOT RELEASING. BRAKE HOSE AND BRAKE PAD NEEDED REPLACED. THIS IS UNUSUAL FOR A CAR WITH ONLY 67000 MILES.

NHTSA ODI 11057420

WHILE DRIVING, MY VAN HAD AN ELECTRICAL MELTDOWN STARTING WITH MY SEAT WARMERS NOT STAYING ON. IT CONTINUED WITH GAUGES MALFUNCTIONING, HEADLIGHTS AND STEREO SHUT DOWN. FOLLOWED BY A COMPLETE SHUTDOWN OF THE VEHICLE. IT WAS DETERMINED THAT THE ALTERNATOR WENT OUT BUT ALSO FRIED THE ELECTRICAL SYSTEM RESULTING IN NEEDING THE TIPM AND ECM REPLACED. I SUSPECTED THE TIPM AS A PROBLEM SEVERAL MONTHS EARLIER WHEN THE VAN WOULD NOT START REGULARLY BUT IF YOU CONTINUED TO PUSH THE START BUTTON IT WOULD EVENTUALLY START. IT ALSO COMPLETELY SHUT DOWN ONCE WHILE DRIVING BUT THEN CAME BACK UP AFTER A COUPLE SECONDS. MY MECHANIC THOUGHT IT WAS THE STARTER. CHRYSLER HAS RECALLED THE TIPM FOR MY MAKE, MODEL, AND YEAR BUT SOMEHOW HAS SKIPPED MY VIN. A LAWSUIT WAS ALSO SETTLED IN 2015 WITH REGARDS TO THE TIPM AND THE VEHICLES NOT STARTING. I BELIEVE CHRYSLER SHOULD EXPAND THEIR VIN NUMBERS TO INCLUDE ALL VEHICLES LISTED IN THE YEARS INCLUDED IN THE LAWSUIT. IN ADDITION, CHRYSLER SHOULD BE FINANCIALLY LIABLE FOR ALL REPAIRS NECESSITATED BY THE MANUFACTURING/DESIGN DEFECT THAT CAUSES THE ELECTRICAL FAILURES.

NHTSA ODI 11057485

VAN WOULD NOT START, ONLY CRANK AND CRANK. TOWED TO REPAIR SHOP AND FUEL PUMP WAS REPLACED. NEXT DAY VAN HAD STARTING PROBLEMS AGAIN. VAN WAS TAKEN BACK TO REPAIR SHOP. MECHANIC WAS UNABLE TO SOLVE PROBLEM SO VAN WAS TOWED TO A CHRYSLER DEALERSHIP. THE CHRYSLER DEALERSHIP WAS ALSO UNABLE TO SOLVE PROBLEM AND VAN WAS RETURNED BACK TO ME. AGAIN THE VAN WOULD NOT START, I TRIED THE TIPM BYPASS IDEA FOUND ONLINE. THE VAN HAS RAN OK SINCE, ONLY HAVING TROUBLES WHEN VERY COLD. THE VAN ONLY HAS 87000 MILES AND A VERY WELL MAINTAINED HISTORY. I AM SCARED THIS VAN WILL FAIL AND SERIOUSLY HURT SOMEONE. THE COST FOR A NEW TIPM IS VERY EXPENSIVE AND I DON'T KNOW IF THIS WILL EVEN FIX THE PROBLEM. I HAVE ALREADY SPENT $900 ON A NEW FUEL PUMP AND HAVE THE SAME PROBLEMS. PLEASE HELP

NHTSA ODI 11056336

THE FUEL PUMP RELAY INSIDE THE TIPM (FUSE BOX CIRCUIT BOARD FUEL PUMP RELAY) THE VEHICLE WOULD NOT START SOMETIMES AND DIED A FEW TIMES OUT DRIVING IT OUT ON THE HIGHWAY. I BOUGHT A NEW RELAY AND HAD IT SOLDER IN TO MY TIPM AND IT WORKS GREAT NOW THEN A ENGINE LIGHT CAME ON AND IT SAY'S IT'S NOT COMMUNICATION WITH MY PCM THEN IT'S WORKING AGAIN. VEHICLE RUNS GREAT NOW AND STARTING. I HEAR CHRYSLER 2011 TOWN AND COUNTRY VANS ARE HAVING A LOT OF PROBLEMS WITH THE SAME ISSUES BUT NO RECALLS ON THE TIPM BOX MODULES.

NHTSA ODI 11055112

TRANSMISSION SLIPPING, OCCASIONALLY DOES NOT SHIFT OUT OF 1ST GEAR WHEN EXCELLERATING FROM STOP LIGHT OR SIGN. BACK DRIVER SIDE DOOR SOUNDS LIKE ELECTRIC SNAPPING LOUDLY FROM IT WHEN IN GEAR AND EXCELLERATING. THIS HAS HAPPENED MANY TIMES.

NHTSA ODI 11052901

THE CAR IS HAVING MAJOR ISSUES WITH THE FUEL PUMP CONTINUING TO RUN. IN THE LAST 30 DAYS IT IS NOT WANTING TO START IN THE MORNING. I HAVE READ ON THIS ISSUE AND CHRYSLER HAS HAD SEVERAL HUNDRED COMPLAINTS ABOUT THE TIPM BEING BAD CAUSING THE FUEL PUMP TO CONTINUE TO RUN OR THE VAN NOT TO START ON COLD MORNINGS. THIS HAS ALSO CAUSE THE VAN TO STOP RUNNING WHILE YOU ARE DRIVING THE VEHICLE DOWN THE ROAD.

NHTSA ODI 11052722

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. THE CONTACT STATED THAT THE IGNITION FAILED TO START THE VEHICLE. AFTER SEVERAL ATTEMPTS, THE VEHICLE FINALLY STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TAKEN TO A LOCAL DEALER (HENDRICKS HOVER AUTOMALL, 1626 MONTGOMERY HWY, HOOVER AL 35216) WHERE IT WAS DIAGNOSED THAT THE KEYS NEEDED TO BE REPLACED. THE KEYS WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

NHTSA ODI 11052731

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING, THE HORN INADVERTENTLY FAILED TO SOUND. THE VEHICLE WAS TAKEN TO LITHIA CHRYSLER JEEP DODGE OF TRI-CITIES AT (509) 591-0629 (7171 W CANAL DR, KENNEWICK, WA 99336) WHERE IT WAS DIAGNOSED THAT THE AIR BAGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS UNAVAILABLE. *TT CONSUMER STATED HORN IS BROKEN. UPDATED 8/9/18*JB

NHTSA ODI 11052592

WHEN BRAKING THE STEERING WHEEL AND CAR SHAKE.... HAVE HAD BRAKES CHECKED REPLACED POWER STEERING FLUID AND IT'S STILL HAPPENING ALSO HAS THE SAME PROBLEM IN REVERSE

NHTSA ODI 11052138

THE FUEL PUMP RELAY FAILED. THE FUEL PUMP RELAY IS MUCH SMALLER THAN THE INDUSTRY AVERAGE, AND THE CONTACTS OVERHEATED. THE RELAY RANDOMLY FAILED MULTIPLE TIMES WHILE DRIVING. THE PROBLEM WAS INTERMITTENT, AND THE VEHICLE WAS FUNCTIONING NORMALLY BY THE TIME IT MADE IT TO A SERVICE FACILITY FOR TESTING/REPAIR. THE RELAY ON THIS PARTICULAR DESIGN IS INTEGRATED INTO THE FUSE BOX, WHICH CHRYSLER CALLS A TOTALLY INTEGRATED POWER MODULE, OR TIPM. THE DESIGN MAKES IT PRONE TO FAILURE BECAUSE OF THE SIZE OF THE RELAY (TOO SMALL FOR THIS APPLICATION) AS EVIDENCED BY THE RECALL FOR JEEPS THAT USE THE SAME WIRING.

NHTSA ODI 11052262

SUMMARY: I BELIEVE THAT THE TIPM FUEL PUMP RELAY IS CAUSING THE ISSUES. IT HAS LEFT THE FUEL PUMP ON WHEN THE ENGINE AND POWER WAS OFF WITH THE KEY OUT OF THE VEHICLE. IT HAS MANY TIME CRANKED WITHOUT STARTING, WHILE STATIONARY WITH THE ENGINE COLD AND ALSO WHILE HOT. THIS MORNING IT SHUT OFF WHILE DRIVING MY KIDS TO SCHOOL IT SHUTOFF THE ENGINE WHILE DRIVING DOWN THE HIGHWAY FOLLOWED BY CRANKING IT WAS RESTARTED. IT FAILED TO START AFTER COMING OUT OF THE SCHOOL. I HAVE SEEN THAT CRYSLER RECALLED THIS PART ON DURANGOS WITH THE SAME ENGINE AND MODEL YEAR.

NHTSA ODI 11052285

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE DRIVING AT ANY SPEED, THE VEHICLE SLOWED DOWN AND GRADUALLY ACCELERATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO THE DEALER (CORNERSTONE CHRYSLER JEEP DODGE, ELK RIVER, MN, 763-441-2300) FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP RELAY WAS FAULTY AND WAS NOT UNDER RECALL. THE FAILURE RECURRED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 114,000.

NHTSA ODI 11050929

I BELIEVE THAT THE TIPM FUEL PUMP RELAY IS CAUSING THE ISSUES. IT HAS LEFT THE FUEL PUMP ON WHEN THE ENGINE AND POWER WAS OFF WITH THE KEY OUT OF THE VEHICLE. IT HAS MANY TIME CRANKED WITHOUT STARTING, WHILE STATIONARY WITH THE ENGINE COLD AND ALSO WHILE HOT. LAST NIGHT IT SHUTOFF THE ENGINE WHILE DRIVING DOWN THE HIGHWAY FOLLOWED BY CRANKING WITHOUT STARTING.

NHTSA ODI 11048452

VEHICLE STALLS OUT COMING TO A STOP. IT IS GETTING WORSE BY THE DAY. I HAVE TO PUT IT IN PARK TO START IT BACK UP. I AM CONCERNED THAT I WILL BE REAR ENDED. I UNDERSTAND THE DURANGO HAS BEEN RECALLED FOR THE SAME ISSUE. SPECIFICALLY THE TIPM IS FAULTY. WHY HAVE THEY NOT RECALLED ALL MODELS?

NHTSA ODI 11048513

TL* THE CONTACT OWNS A 2011 CHRYSLER TOWN AND COUNTRY. WHILE ATTEMPTING TO START THE VEHICLE, IT FAILED TO OPERATE. THE VEHICLE WAS TOWED TO AUTONATION JEEP (16300 W COLFAX AVE, GOLDEN, CO 80401) WHERE IT WAS DIAGNOSED THAT THE POWER TRAIN CONTROL MODULE NEEDED TO BE REPROGRAMMED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED BACK TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE BATTERY NEEDED TO BE REPLACED. THE BATTERY WAS REPLACED TWICE, BUT THE FAILURE RECURRED. THE CONTACT STATED THAT THE VEHICLE FAILED TO OPERATE WITH THE KEY, BUT NOT WITH THE REMOTE. THE VEHICLE WAS TOWED TO THE SAME DEALER WHERE IT WAS DIAGNOSED THAT THE INSTRUMENT CLUSTER PANEL AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT, WHEN THE TECHNICIAN TESTED THE VEHICLE, IT MISFIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

NHTSA ODI 11044489

CAR WILL NOT START FROM "PARK" OCCASIONALLY. LIGHTS WILL WORK, GAUGES WILL WORK, STARTER WILL NOT CRANK TO TURN THE ENGINE OVER. THIS USUALLY OCCURS WHEN VEHICLE IS AT NORMAL OPERATING TEMPERATURES, AFTER DRIVING TO THE STORE AND TURNING IT OFF. THEN TRYING TO START CAR WHEN LEAVING STORE. AFTER TWO TO SEVEN TRIES, STARTER WILL WORK AND ENGINE STARTS.

NHTSA ODI 11043383

THIS CAR HAS DIFFICULTY STARTING. THE BATTERY WAS CHECKED, REPLACED AND IT STILL HAPPENS. ALSO, THE CAR WILL STALL WHEN GOING BETWEEN 20-30 MILES PER HOUR. IT IS A VERY SCARY SITUATION.

NHTSA ODI 11042849

I HAVE A 2011 CHRYSLER TOWN AND COUNTRY. AS OF TODAY I HAVE HAD THE VEHICLE UNDER 3 YEARS AND HAVE HAD TO REPLACE THE ALTERNATOR 3 TIMES, 3 NEW BATTERIES, THE MASTER CYLINDER AND BREAK BOOSTER WAS REPLACED, MULTIPLE SENSORS, MY ABS AND TRACTION CONTROL NEVER FUNCTIONS CORRECTLY. THIS IS ALL BECAUSE OF THE TIPM THAT IS MALFUNCTIONING AND YOU CANT GET ONE OF THESE BECAUSE THEY ARE BACK ORDERED. AND WHEN YOU CALL THE DEALER SHIP OR CHRYSLER THEY TELL YOU THERE IS NOTHING THEY CAN DO.

NHTSA ODI 11041920

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

NHTSA ODI 11042024