What 107 owners told NHTSA about the 2025 Hyundai Tucson Hybrid Hev

The instrument cluster and the information center screen unexpectedly go out while driving! It is totally unacceptable and fatal to occupants because None of the informations available while driving, such as speed, navigation, any warnings, alerts, lightings, etc.

NHTSA ODI 11750775

My vehicle is subject to the Hyundai Forward Collision-Avoidance Assist (FCA) safety recall (NHTSA Campaign 26V316 / Hyundai Recall 302). The front camera software logic is overly sensitive, creating an imminent danger of unexpected, severe, and sudden automatic braking at high speeds. This manufacturing defect poses a catastrophic safety hazard to myself, my family, and other motorists on the highway. I consider the vehicle completely unroadworthy and unsafe to drive. Despite the severe risk to human life, Hyundai Motor Finance is refusing to allow a fee-waived early lease termination, attempting to financially penalize me for refusing to drive an inherently dangerous vehicle that they manufactured. I am filing this complaint to document the severe hazard of the defect and Hyundai's failure to provide a safe, penalty-free resolution for a life-threatening vehicle glitch

NHTSA ODI 11750434

The rear occupancy alarm and the seat belt alarm frequently go off without anything being in the back seat. This has happened too many times for us to count and we have had the car for 1.5 years.

NHTSA ODI 11749822

Almost crashed a few times because of the automatic breaking.

NHTSA ODI 11747919

On June 30, 2026, at approximately 8:45 AM, I was driving my 2025 Hyundai Tucson Hybrid on the freeway with cruise control set at 74 mph. While driving, the vehicle displayed a message that cruise control had been disabled. As the vehicle began slowing down, I pressed the accelerator pedal, but the gas pedal did not respond. I had to carefully move over to the right as the vehicle continued slowing, then pull over to the side of the road. Fortunately, there was a safe place available for me to pull over. After stopping, I turned off the engine, waited approximately one minute, then restarted the vehicle. After restarting, the vehicle operated normally again. I contacted Hyundai. They stated there was no specific update for this exact issue, but they did advise that there was an update for the steering cluster. I have completed that update.

NHTSA ODI 11747483

Backup camera is intermittent. This puts persons behind me in danger of accidental back-over. The vehicle has been reproduced and seen and confirmed by the dealer's Service Mgr. The vehicle has been turned in to the servicing Hyundai dealer on 4 occasions and they have failed each time to repair the issue. The system has been intermittent over for 5 repair attempts and a period of 5 months. It has been at an authorized Hyundai dealer for repairs for a total of over 60 days. There is no warning as to when this will occur other than the screen turns either green or blue when placed in reverse with the following: Check surrounding for your safety. No camera signal received. Please try again later."

NHTSA ODI 11747088

On XXX, in Wildwood Florida, our Hyundai Tuscan was traveling approximately 25-30 mph southbound on [XXX], when a truck stopped short directly in front of us. The driver hit the brakes to slow the vehicle down. However, the car immediately came to an abrupt stop thrusting the driver and passenger forward, so much so that the passenger hit her head on the windshield as her body was violently thrown against the dashboard. Fearing a concussion the passenger thought a visit to the local Wildwood ER was necessary. Additionally the ER deemed it necessary that the passenger go to a specialized Trauma Emergency Delartment in Ocala, Florida. Consequently the passenger incurred several bills totaling approximately $20,000. Due to the incident occurring with in a car, medical insurance denied payment. It should be noted that this same type of incident happened a second time as well. Please note, the local Hyundai dealership manager was notified of both occurrences, and he was unfazed and made no comment in regards to this complaint. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11746981

Vehicle: 2025 Hyundai Tucson Hybrid | Purchase Date: 10/2025 | Mileage: ~2,800 | FAILURES: On 5/11/2026, the AEB warning light (FCA system) activated without cause while parked. On 5/13/2026, the left side instrument cluster went completely dark and was unresponsive. Multiple reboots failed to restore it. Infotainment (right side) rebooted; instrument cluster did not. Vehicle brought to Hyundai of Las Vegas on 5/15/2026. RECALL CONNECTION: This is consistent with Recall 26V047000 (Hyundai #293), issued 1/26/2026, for 2025 Tucson instrument panel failure violating FMVSS No. 101. My VIN is not in the database. I request VIN inclusion review as my experience is identical. The OTA/dealer software update was never applied prior to this failure. SAFETY RISK: Loss of instrument cluster eliminated ability to monitor speed, fuel, and warnings while driving. Unprompted AEB activation raises concern about FCA reliability — risks unexpected braking to cause potential crash or failure to engage. Consistent with FCA recall issued 5/16/2026 for my vehicle. DEALER: Hyundai of Las Vegas confirmed and repaired under warranty, described to me only as a hard reset. Diagnostic was not indicated on my report. Service advised me that recurrence is likely. Note: FCA recall issued 5/16/2026 was not addressed during this visit. Second appointment required. NHTSA: 26V047000 | Hyundai Recall: #293 | Case: 42767545

NHTSA ODI 11747047

I was driving using adaptive cruise control, and my entire instrument cluster went blank. Everything, I couldn't see my speed, if cruise control was on, the HUD display everything went dark then came back on in about 10-15 seconds. This was very concerning. I had no way to know if the safety systems like adaptive cruise control, forward crash section etc were still working. Lost my GPS directions, couldn't tell my speed This was extremely dangerous.This needs to be fixed asap.

NHTSA ODI 11747066

The contact owns a 2025 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, the vehicle unintendedly stopped. The vehicle suddenly experienced an automatic emergency braking failure. The vehicle was stuck in gear and was jerking while moving forward. While in drive, there was an abnormal popping sound coming from the vehicle. The battery discharge message was displayed and after several minutes the vehicle resumed normal operation. The vehicle was taken to the local dealer previously, but the dealer was unable to determine the cause of the failure. The local dealer was contacted again, and the contact was informed about NHTSA Campaign Number: 26V316000 (Forward Collision Avoidance) and about a trade-in. The vehicle was not diagnosed or repaired. The contact called another local dealer Feldman Hyundai of New Hudson Service & Parts Center (30492 Lyon Center Dr, New Hudson, MI 48165); where an appointment was scheduled for a later date. The manufacturer was contacted and filed a claim. The failure mileage was approximately 100.

NHTSA ODI 11746737

The center infotainment display flickers then goes fully blank while driving, caused by a defective coaxial cable with undersized shield width (Hyundai TSB MC-11010978-0001). When the screen blanks, the backup camera also stops working, leaving no rear visibility when reversing. Audio and head-up display still function. The vehicle and component are available for inspection. Safety risk: the display and backup camera fail without warning during normal driving and while reversing, eliminating rear visibility and risking striking pedestrians, objects, or vehicles. Failures are triggered by heat, potholes, and braking—routine conditions—so the loss is unpredictable. The dealer reproduced and confirmed the problem, identified the TSB cable defect as root cause, and made multiple failed repairs: tightening clips, replacing the wiring harness, replacing the head unit, and performing the TSB repair. The identical symptom returned after the TSB fix. The vehicle has been inspected only by Hyundai's authorized dealer through these repeated visits—not by police, insurance, or a field engineer (field engineer involvement is being requested). No warning lamps or messages precede the failure. The first symptom is the screen flickering, immediately followed by the screen going blank and the backup camera failing. Symptoms first appeared at 10,717 miles on 07/23/25.

NHTSA ODI 11745577

While vehicle was at dealership service department for an oil change, dealer performed FCA (Forward Camera Assist) Update recall. After leaving dealership, the vehicle displayed several warnings. "Check Emergency Stopping function", "Smart Cruise Control disabled", and "Forward Safety system limited". This never happened previously, and these safety systems became disabled within two miles after leaving the dealership where the update / recall to them was performed. The recall was intended to prevent unnecessary emergency braking. Somehow the update resulted in completely disabling that safety system. Invoice from dealership shows 17012 miles out, and photos of dashboard show 17014 miles. Return appointment for them to look at this is three weeks out. Contacted Hyundai customer service to report this.

NHTSA ODI 11745294

Navigation screen flickers and goes black and then reboots and comes back on while driving. Extremely distracting and dangerous. Dealer kept car for ten days and replaced the screen but problem persists. Happens almost every time I drive. Might be triggered by uneven road surface but difficult to tell. Much online chatter about the issue. Dealer acted like they’d never heard of it before.

NHTSA ODI 11742336

I was going northbound on highway 77 in Bloomington, MN, switching lanes to get on an exit ramp to westbound 494. Another vehicle in front of me was also changing lanes but I had slowed down so we can switch lanes appropriately as we were both going at decent speeds and as I was braking and this car ahead of me crossed lanes, my forward collision warning activated and emergency braking occurred which inappropriately activated and caused me to abruptly stop while driving on an exit ramp on a freeway. Luckily the car behind me did not hit me but it was terrifying and scary and I had my two young children in the car. I have set up plans for updating the software for this vehicle with the current recall.

NHTSA ODI 11741253

The rearview camera system on my vehicle intermittently and unpredictably malfunctions when shifted into reverse. Instead of displaying the live rear camera feed, the infotainment screen abruptly turns entirely green or blue, completely obscuring the rearward view. Component that failed: The rearview camera system and/or the main infotainment display module. The components are currently on the vehicle and available for inspection upon request. Safety risk: This failure severely compromises safety by eliminating critical rear visibility while backing up. The sudden loss of the camera feed creates a significant blind spot, increasing the risk of backing into a pedestrian, a moving object, or another vehicle, especially in busy parking lots or residential driveways. Dealer confirmation: Yes, this is a persistent defect that has been reproduced, confirmed, and documented by an authorized dealership service center during multiple service visits. Despite the dealer and the manufacturer being informed of this defect over two months ago, neither has been able to successfully repair the vehicle or provide a permanent fix. Inspected by others: The vehicle and the malfunctioning components have been inspected by the manufacturer’s authorized dealer technicians during multiple attempts to diagnose and repair the ongoing issue. Warning lamps/symptoms: There are no warning lamps, check engine lights, or error messages on the dashboard prior to or during the failure. The sole symptom is the immediate and spontaneous green or blue screen takeover on the center display precisely when the vehicle engages the reverse gear.

NHTSA ODI 11740137

This is an ongoing issue. The panel lights and indicators associated with climate control setting module (in front of/below) the dash are very dim. In normal to bright daylight it can be impossible to see. As a result drivers have to take their eyes off the road and bend down a little to see what the climate control lettings are set on or whether a selection has been set properly. This has obvious potential safety issues. Hyundai tell customers the modules are performing normally, but there are many, many complaints on the web. These modules need to be recalled and replaced.

NHTSA ODI 11739811

The contact owns a 2025 Hyundai Tuscon. The contact stated that while driving at various speeds the vehicle had erroneously stopped in the middle of the road. The contact indicated that the failure had occurred at highway speeds and while driving in a residential neighborhood. The contact indicated that the failure had occurred on multiple occasion in which a Tractor Trail nearly collided into the rear of the vehicle. The cause of the failure was not yet determined. The local dealer was contacted. The manufacturer was not yet contacted. . The failure mileage was 25.

NHTSA ODI 11738524

On 4/3/2026 heading to [XXX] on I 95 (outside of [XXX] ) traveling with traffic (3-4 lanes) I was in the middle lane going approx 74mph when on 5 separate but in close approximation (estimated within 20 mi) times, my car which was on cruise control, suddenly threw up warnings to pull over, shook my steering wheel, yanked my car toward the left lane (with traffic flowing the same way as I was) and suddenly decreased my speed to 64 mph before I could regain control! It was a beautiful, sunny day with no precipitation. Cars were swerving and beeping . My family was in the car. I stopped all cruise control and drove the remaining five hours to my destination scared out of my mind. I called local dealership, country club Chevy, dodge, jeep, Hyundai etc. at 607432-9300 and told Gavin what had occurred. I was unable to get into a dealership while I was in [XXX] for the brief time I was there. On my way home I tried cruise control on I 95 in the right hand lane all the way over so that no traffic could be on my right side. It was a beautiful day. It happened again to me, the warning lights, the decrease and speed the yank to the right the shaking steering wheel and the sudden breaking while I was in the state of [XXX] . I turned off cruise control again. I didn’t have a problem after that. When I I returned home, , I took the car in to be looked at at the dealership . They said they couldn’t find anything wrong. I contacted Hyundai motor corp at 800-523-4030. Case number 42576997 was assigned. I was put to Hyundai finance. No resolution. I contacted Hyundai Corp Office at 714-410-4382 and spoke with Mohammed. To date, as of May 7 there has been no resolution as the dealership doesn’t have access to drive this car on a 4 Lane Rd. as we live in a real area. I do not feel safe driving this car. It is going to kill someone else on the road or someone in my family. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11736354

The vehicle randomly brakes when there isn’t anything around me. It initiates the emergency braking at 100% and I’ve nearly been rear ended because of this two times

NHTSA ODI 11732090

On [XXX], my 2025 Hyundai Tucson Hybrid displayed a red dashboard alert instructing me to “stop vehicle and check brake system.” The vehicle experienced brake system warnings and a loss of power steering, requiring me to pull over. I immediately contacted Hyundai through the Bluelink system, and the Bluelink operator confirmed that multiple fault codes were visible in Hyundai’s system. I scheduled a Hyundai service appointment at the next available date. On [XXX], before the scheduled service appointment could occur, the vehicle experienced a sudden and total electrical failure while traveling at highway speed (approximately 65 mph). The vehicle lost propulsion and displayed brake system warnings. After reaching the shoulder, the vehicle also lost hazard lights while disabled in heavy rain. The vehicle was towed via Hyundai Bluelink to a Hyundai dealership and removed from service. The occupants at the time of the incident included my wife and my minor child. The loss of propulsion, braking warnings, power steering, and hazard lights created a serious risk of a rear-end collision and injury. Due to repeated and escalating safety-related failures involving electrical, braking, and steering systems, I no longer consider the vehicle safe to operate. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11711220

The contact owns a 2025 Hyundai Tucson Hybrid. The contact stated that while attempting to make a left turn in a line of other vehicles, the brakes locked up and the vehicle came to an immediate stop. The contact stated that vehicle drove normally after the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 4,500.

NHTSA ODI 11706476

Intermittent flickering of the infotainment + backup camera screen. The screen displays glitching bands of static, loses touchscreen functionality, and reboots on its own. The flashing light presents a significant safety hazard when driving at night. Dealer has tried replacing the head unit and adjusting the coaxial cable with no success.

NHTSA ODI 11695669

Vehicle propulsion system failed, as a result vehicle rolled down an inclined driveway in to the street and was stuck in the middle on the street in traffic. Vehicle had started normally, was able to shift into Drive, no obvious warning lights or error messages displayed. Vehicle would shift into Drive/Park/Reverse as required but would not move. Upon shutdown an restart two warning lights were display but Vehicle would still not move. Vehicle only had 168 miles on the odometer. Vehicle is a Hybrid, engine was running and Battery charged. Apparently the problem was a failed "Over the Air Software Update", this was corrected by Dealer (see attached file). Safety issue is that the Vehicle, 1 Failed to display any error regarding a Failed Update, 2 Failed to immobilize the Vehicle allowing to move in an unsafe state, 3 Failed to notify Owner that Updates had been done, 4 Proceeded with an over thew air Update that could potentially place the Vehicle in an unsafe state.

NHTSA ODI 11692522

Car stopped abruptly in backed-up traffic on I-84 when there was no danger of hitting the vehicle ahead. It created a danger of being struck by the vehicle behind.

NHTSA ODI 11691558

The Driver Attention Warning alarms every few minutes in highway driving. The loud ringing bell and the dashboard display are very distracting and a hazard in their own right.

NHTSA ODI 11691560