What 107 owners told NHTSA about the 2025 Hyundai Tucson Hybrid Hev

On XXX, in Wildwood Florida, our Hyundai Tuscan was traveling approximately 25-30 mph southbound on [XXX], when a truck stopped short directly in front of us. The driver hit the brakes to slow the vehicle down. However, the car immediately came to an abrupt stop thrusting the driver and passenger forward, so much so that the passenger hit her head on the windshield as her body was violently thrown against the dashboard. Fearing a concussion the passenger thought a visit to the local Wildwood ER was necessary. Additionally the ER deemed it necessary that the passenger go to a specialized Trauma Emergency Delartment in Ocala, Florida. Consequently the passenger incurred several bills totaling approximately $20,000. Due to the incident occurring with in a car, medical insurance denied payment. It should be noted that this same type of incident happened a second time as well. Please note, the local Hyundai dealership manager was notified of both occurrences, and he was unfazed and made no comment in regards to this complaint. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11746981

The rear hatch was open as I had loaded packages in it. My husband & I were both at the rear of the car. I was on the passenger side but told my husband I was going to drive home and began crossing over to the driver side. He pushed the button to close the hatch. It came down and hit me in the head. It lacerated my head and really hurt. I had to get 5 staples to close the wound. This is a very concerning safety hazard. As an adult it was painful and required medical attention. I believe it should have detected my presence and stopped. I am concerned what would have happened if this was a child. I believe they would have been seriously injured or killed. I have 3 grandchildren so it is very concerning.

NHTSA ODI 11688765

The contact owned a 2025 Hyundai Tucson. The contact stated that while the vehicle was parked and turned off, the rear of the passenger seat caught fire. The vehicle was unoccupied at the time of the fire. The fire was extinguished twice by the Fire Department since the fire reignited after the first time the fire was extinguished. A fire report was filed, and a report number was provided. The cause of the failure was determined to be a lithium battery failure. A police report was also filed. The dealer was contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was made aware of the failure. The failure mileage was approximately 800.

NHTSA ODI 11683137

I’ve had the car for 7 months. Three (3) times the forward collision avoidance (FCA) has engaged (full stop braking) when it was absolutely not necessary. All three times occurred while driving less than 30 mph on city side streets in Houston, TX. On the first and third occasions there was a car in front of me but that car and my car were both slowing down as we approached a red light. My car suddenly slammed on the brakes; I did not hit the car in front nor was I hit from behind. On the second occasion, I was making a right turn and the FCA slammed on the brakes and I was hit from behind. There was no damage to an older model car that hit me. My car had $785 in damage repairs. No insurance claim was filed. After incident #2 ( the one with damage) I adjusted the sensitivity of the FCA to have a slower reaction. It didn’t help as I had a third incident. My make/model will not let me permanently disable the FCA. After incident #3, I have been trying to remember to disable the FCA each time I start the car. I have not reported this to the dealer. I will be bringing the car to the dealer next week for this issue. The date below is for the incident when I got hit.

NHTSA ODI 11677398

Not sure what failed. At around 8:30 am on a sunny clear day the driver was maneuvering slowly up a ramp between first and second floors of a parking garage at the college campus where the driver works. Driver paused the vehicle and slowly turned to the right to park in an open spot about halfway up the ramp. There was a large concrete pillar to the right of the parking spot and a low steel cable wall at the end of the parking space along the inner structure of the garage. While turning into the space, the driver described suddenly feeling "a loss of control of the vehicle" wherein it "felt like it was in neutral and wouldn't stop". The car hit the wall with extreme force, enough for resulting in minor injuries, damaging the frond end and a total loss to the vehicle. The force was enough to rebound the car back approximately 30 feet from the wall after impact. No help or warnings from the collision detection mechanisms was apparent. In a single prior time during the tenure of ownership (approximately 6 months) the collision detection system had intervened and manually stopped the vehicle on its own due to a car that had erroneously driven in front of the vehicle too closely. The car's lane assist successfully kept itself in lanes on most occasions. Several software related notices on the car dash had been reported during the tenure of ownership and in no case was the dealership able to figure out what was wrong in any of the scenarios, one of the software notices on the dash did end up just "going away" after some time.

NHTSA ODI 11669668

The Automatic Emergency Braking system went off when there was no reason for it to. It seems to think I am closer to vehicles than I actually am. It frequently warns that I need to brake when I don't need to, either because I am already stopped or because the vehicle that had previously been in front of me changed lanes. Today the vehicle braked so hard that I thought I had been in an accident for a minute. There was appropriate clearance between my car and the car in front of me and no reason to auto brake. I now have wipe lash. Hopefully they recall and fix this issue ASAP.

NHTSA ODI 11669301

On 2 separate occasions, the forward collision warning system activated. On both occasions I was under control of the vehicle with my foot on the brake approaching a vehicle that had slowed while entering into a round about...I was approximately 10 feet from the car in front going about 6 mph. All of a sudden several warning indicators activated (audible and visual) and then out of nowhere, all four wheels locked and my car came to a skidding/juddering stop. I immediately looked in rear view mirror fearing I was going to get rear-ended. The vehicle in front proceeded to move on and I tried to get myself together and get moving. I was shocked that this had happened as it was totally unnecessary. I was completely in control of the vehicle prior to the activation.

NHTSA ODI 11662863

The automatic braking has almost caused me to be rear-ended, and the enraged driver behind me Leaned on his horn and flipped me off. Today, it caused a rear-end collision behind me because of the unwarranted abrupt locking of the brakes. I drove to the dealership and had them turn off this safety feature. It's VERY dangerous!

NHTSA ODI 11662177

The contact owns a 2025 Hyundai Tucson. The contact stated while driving 15 MPH and depressing the brake pedal to decelerate, an unknown warning light was illuminated and a beeping sound was engaged. The contact stated that the vehicle failed to decelerate as intended and came to a sudden stop, causing another vehicle to crash into the rear of the vehicle. The air bags did not deploy. There was no injury sustained. The contact was able to drive the vehicle away from the scene. No police report was filed. There was no property damage. The vehicle was taken to the dealer, where it was test-driven, but the failure could not be duplicated. The dealer informed the contact that they had turned off all the sensors, except for the rearview camera sensors, to prevent the failure from reoccurring. The vehicle was diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 760.

NHTSA ODI 11646076