What 55 owners told NHTSA about the 2024 Ford Ranger

While driving, randomly and intermittently the vehicles drive mode will change on its own, usually requiring the driver to slow down to allow for a 4X4 shift, as called out by messages on the dash and an audible warning. This has happened multiple times and ford cannot replicate this issue. I was going to just replace the drive mode selection knob but as it turns out it's on national backorder.

NHTSA ODI 11745023

one brake rotor has warping issues from faulty made parts,truck only has 11,000 miles and should not have an issue with brake rotors.Espically just one

NHTSA ODI 11744377

The truck shifted its drive mode from normal driving into Baja mode by itself, and also shifted the transmission from 2H to 4H, potentially damaging the transmission and causing a safety issue on the highway.

NHTSA ODI 11744587

Vehicle experienced unintended transmission gear change without driver input from the gear selector. While driving, the transmission shifted unexpectedly into 4H even though the selector was not touched. This created a safety hazard due to sudden change in vehicle behavior, including: loss of acceleration, lurching and unexpected movement. Issue occurred at approximately 30 mph. Concern is potential electronic transmission control or shift-by-wire malfunction causing unintended gear engagement.

NHTSA ODI 11739691

When accelerating, occasionally there is a hesitation. This becomes dangerous when accelerating from a side street onto a 55mph road when there’s an occasional break in traffic that I need to jump into. There’s been times where I got concerned when it hesitated and there was oncoming traffic. The other day I was going under 10mph around a curve and it hesitated so much, I looked at my gas gauge, thinking I was running out of gas (but I had a half tank). I’ve seen complaints online about this problem. I’ve had it to two different dealers and they found nothing wrong. I’ve had this problem since I purchased it new and I now have 12K miles. Thank you! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11738091

When using the rear camera while towing a trailer, the image is partially blocked by a persistent message stating “full view not available”. This creates a safety issue as it obscures the driver’s view of the trailer and/or the trailer load. It is critical to be able to monitor the trailer and the load during towing to ensure a hazardous condition is not developing. I believe the rear view camera is working as designed, that is I do not believe there is a defect or failure in the hardware. However the design of the message is the problem. If the driver needs to know that “full view not available” then the message should be moved to a different part of the screen to not obscure the view of the trailer.

NHTSA ODI 11738102

The incomplete recall 26V238 is a concern. They say in the letter from Ford that it could be a fire issue. It seems the harness in the A pillar gets pinched and could short out causing the overhead lighting or mirror lighting to either cause a smoke issue or fire. BUT THE ANSWER IS NOT GOING TO BE AVAILABLE UNTIL LATE JULY MAYBE!! Why send a letter and state you have no answer yet or will have for a couple of months!!! Am I supposed to be happy that I will know why the fire breaks out? Some 1400 potential failures out of 140,000 is the prediction per a conversation with your [XXX] on the chat line. This is to me a lame response to an issue with a potential for a real safety issue and should have more response than "WE ARE WORKING ON THE ANSWER AND MAYBE END OF JULY" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11737091

The vehicle has had hard down shift at slow speeds. Sometimes so hard that i thought I got rearended when stopping. Sometimes you can feel it but not horrible, other times it's bad! I've been trying 6 months to get Coggin Ford to look at it and they keep putting me off.

NHTSA ODI 11734739

The brake pedal is extremely soft and routinely travels to the floor during normal driving conditons. It also catches at various levels. It is impossible to tap the brakes to slow the vehicle down when rounding a corner which has led to several scary incidents and near misses. The truck is currently at Crossroads Ford in Indian Trail NC for 3 weeks. It has been there once before and 3 times at Town and Country Ford in Charlotte. Both dealers said this is the way the brakes are supposed to work. I was also told by a service manager that this is due to the electronic braking system and they are reluctant to spend time on troubleshooting because Ford cut their renumeration. A service Field Engineer stated that the brakes were in spec and traveled 2 3/4" toward the floor. This is a subjective observation as every person uses different foot pressure. The gas pedal is at 3" off the floor and the brakes are 5". The brake pedal passes the gas pedal and many times, my foot hits both pedals. My inspection with a ruler shows the brake pedal going 1 1/2" past the gas pedal. There were no warnings the first time this happened. I have taken the vehicle to an independent mechanic who bled air out of both rear brake lines which helped. This repair lasted 3 months and now the issue is back. I've been told by independent mechanics that the problem is in the ABS module (which pulls the pedal to the floor when activated).

NHTSA ODI 11734275

My 2024 Ford Ranger XLT 2W has been suddenly losing power or stumbling upon initial acceleration. This has been occurring intermittently. My truck now has approximately 20,000 miles. The problem has become increasingly frequent. It seems to occur most often when accelerating from a complete stop. The loss of power can last for several seconds, then normal power is regained. Several times, the truck has lost power while making a left turn. It simply will not accelerate, and I find that I am stuck, unable to complete my turn and clear the oncoming traffic. I have taken my truck to a local dealer who attempted to diagnose the problem and they didn’t offer a solution since they were unable to reproduce the problem during their road test. It has happened many times since then and I am scheduled to return the vehicle to the same dealership to attempt to diagnose and fix the problem again soon. The problem seems to occur, regardless of which drive mode the truck is in and also occurs with Electronic Stability Control both enabled and disabled. There are no warning lights or check engine codes shown.

NHTSA ODI 11731068

My 2024 Ford Ranger Raptor has been suddenly losing power or stumbling upon initial acceleration. This has been occurring intermittently since it was nearly new. My truck now has approximately 10,500 miles. The problem has become increasingly frequent. It seems to occur most often when accelerating from a complete stop. The loss of power can last for several seconds, then afterwards, normal power is regained. It poses a safety risk since it has nearly caused collisions. Several times, the truck has lost power while making a left turn in front of oncoming traffic. It simply will not accelerate, and I find that I am stuck, unable to complete my turn and clear the oncoming traffic. Once when accelerating away from a stoplight, the truck lost power, and I was nearly struck by following vehicle. I have taken my truck to a local dealer who attempted to diagnose the problem and they didn’t offer a solution since they were unable to reproduce the problem during their road test. It has happened many times since then and I am scheduled to return the vehicle to the same dealership to attempt to diagnose and fix the problem again soon. The problem seems to occur, regardless of which drive mode the truck is in and also occurs with Electronic Stability Control both enabled and disabled. There are no warning lights or check engine codes shown.

NHTSA ODI 11728371

The contact owns a 2024 Ford Ranger. The contact received notification of NHTSA Campaign Number: 24V597000 (VISIBILITY); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was unavailable.

NHTSA ODI 11714031

I received a letter several months ago for: Manufacturer Recall Number25C41 NHTSA Recall Number25V541 I called the Ford dealership to schedule the recall repair and they told me parts were not available. I explained to them I had a recall letter stating parts were now available and to schedule the repair. The dealer said they had the parts on order and they have not received any yet. I asked them if I could get put on their schedule for when parts came in and they agreed. They said they would call me as soon as they had parts to make the repair. Meanwhile, I received another recall letting from Ford saying parts are available, please schedule the repairs. I have been calling Ford recall hotline and the Ford dealership for over two months trying to get the safety recall repairs completed. They will not fix my compromised airbags and I am not getting any support from Ford to get this resolved.

NHTSA ODI 11711896

I came up to a stop sign on a snow cover highway. When I applied the brakes my ABS brakes came on, but instead of slowing down, I felt the vehicle accelerating instead. I was pushed into the middle of the intersection and involved in an accident. An accident report was filed with the state of Wisconsin. No injuries occurred. I mentioned the problem to the Ford dealer, but they said there was no recall notice on file. An insurance adjuster inspected the damage to my vehicle last week. I have made an appointment with a body shop in February. I have not driven the vehicle since the accident. There were no warning messages before the accident.

NHTSA ODI 11710739

I am the original owner of this vehicle and the engine and controls have not been modified in any way. Yesterday while driving at approximately 30 mph on a surface street with dry road conditions in the “2H” setting on the Drive Modes Selection Dial my truck spontaneously shifted into four-wheel drive high and then attempted to switch into four-wheel-drive low – “Rock Crawl Mode.” The rear differential locked, speed was suddenly reduced, and the steering became more difficult. Luckily, I was able to safely pull over. I captured a video at this time documenting the control settings and display image. It took multiple attempts, even in Park and Neutral, to get out of 4WD and back into the 2H setting. Once back in 2H, the truck drove normally. I have had similar experiences at least twice before in this truck with months between them. In those cases, I wondered if I had accidentally bumped the dial control. I am certain that this was not the case yesterday, so this was a spontaneous event initiated by the truck’s computer and/or mechanical controls. I consider this to be a very serious safety hazard, as it dramatically and unexpectedly affected the speed and handling of my truck. I did some online searching today and found that multiple other Ranger Raptor owners have experienced this issue, suggesting that this may be a serious design flaw affecting multiple vehicles. I plan to schedule a service appointment with Ford and notify them directly of this problem and hazard.

NHTSA ODI 11709682

Didt show how close car was to pole

NHTSA ODI 11706351

Loss of power/accelleration. Multiple times. Issue has always occurred when turning left quickly then trying to accellerate. to make the immediate uphill. The accellerator goes dead for 3-4 seconds, then works. Engine RPM does not speed up when commanded, but then does after several seconds. By then it has been pushed to the floor attempting to make it over the upcoming hill. This is going to cause an accident, especially when pavement is slick, then truck quickly responds to the pedal position. The truck displays no codes or lights. Dealer says they have no idea what it could be. There are multiple reports on [XXX] . [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11703525

I purchased a Ford Ranger truck with an EPA/NHTSA fuel economy label stating 20 mpg city and 25 mpg highway, 22 mpg combined. In reality, despite proper maintenance, the vehicle achieves only 16.26 mpg combined and as low as 14.72 mpg in city. While I understand fuel economy varies, this discrepancy is significant and may pose safety concerns. I relied on accurate fuel economy estimates to plan trips and refueling. This overstated MPG has lead me to unexpected fuel depletion, and stranding me in an unsafe condition (ran out of gas on HWY 287). I request NHTSA review whether Ford’s labeling practices meet regulatory standards and whether corrective action is warranted. I have taken the Ford Ranger to two different dealerships. One, Ford Automation, Frisco, Texas, refused to investigate what might be the issue, as they stated that was normal for the Ford Ranger. The second dealership, Five Star Ford, Dallas, Texas, reported in their tests they were averaging 26.1 mpg, combined. They did not tell me how they arrived at that figure. Your site would not allow me to upload fuel receipts to prove my statements above.

NHTSA ODI 11702371

Truck will shift into offroad modes unexpectedly. Will shift into these modes at highway speeds

NHTSA ODI 11701809

The contact owns a 2024 Ford Ranger. The contact stated that while reversing, the differential indicator independently moved, and there was an abnormal sound coming from the transmission. The abnormal sound could be heard for a short while, and then the sound dissipated. The contact stated the sound could be heard intermittently. The vehicle was taken to the dealer; however, no cause for the failure was found. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 4,200.

NHTSA ODI 11695500

The battery has been dying since the last update which causes my rear camera to just go black screen when I am reversing my battery shouldn't be dying after a year and my camera should still work

NHTSA ODI 11694083

while driving between 5-10 MPH on a dry, smooth paved road, the transmission began cycling through 4WD modes and began shifting from normal mode to 4WD Sand mode, i was able to pull over and park, but the transmission continued shifting and fully transitioned to 4WD mode. This is the second time it has occurred, the first time the transmission fully switched 4WD and i was barely able to pull off the road to reset it. after first issue, dealership noted the following "3131 confirmed concern. pulled codes with FDRS and found P05D3 in ABS module. Referred to workshop manual and run pinpoint test AH for concern. AH1 yes. AH2 had me reconfigure ABS module with As-Built data rerun self test. No codes returned and system operating correctly at this time." There multiple online forums with owners having the same problem. https://www.ranger6g.com/forum/threads/24-rr-shifted-while-driving.18956/ Truck will be going to dealership for assessment again.

NHTSA ODI 11693898

Why hasn't Ford found replacement parts for this airbag defect. I don't feel safe driving a car that may cause more injury to my person if I'm in an accident. This should fixed immediately. Or I would like to return my vehicle for full refund or get a new one with out safety issues.

NHTSA ODI 11684270

I have had the truck for 2 weeks. Three times I've almost rearended a car in front because of a braking system that doesn't stop the truck quickly enough. The pedal will travel 6" at times before it engages. This is very dangerous especially when braking when travelling around curves or round a bouts. I've taken the vehicle to two dealers and an independent brake shop. Dealers say it's normal. Independent brake shop warned against driving the truck. Town and Country stated that the pedal going to the floor is normal. No warning prior to this incident.

NHTSA ODI 11683910

I was slowing down, foot off of throttle, to make a left turn. After completing turn and wanting to speed up, I had no throttle response for 2 or 3 seconds. Then all of a sudden back to normal. There was no accident. This has happened before, at least 3 times. Same/similar circumstances and result. I have not taken it to the dealer yet after reading other owners doing so and was not resolved.

NHTSA ODI 11683130