What 55 owners told NHTSA about the 2024 Ford Ranger

one brake rotor has warping issues from faulty made parts,truck only has 11,000 miles and should not have an issue with brake rotors.Espically just one

NHTSA ODI 11744377

The brake pedal is extremely soft and routinely travels to the floor during normal driving conditons. It also catches at various levels. It is impossible to tap the brakes to slow the vehicle down when rounding a corner which has led to several scary incidents and near misses. The truck is currently at Crossroads Ford in Indian Trail NC for 3 weeks. It has been there once before and 3 times at Town and Country Ford in Charlotte. Both dealers said this is the way the brakes are supposed to work. I was also told by a service manager that this is due to the electronic braking system and they are reluctant to spend time on troubleshooting because Ford cut their renumeration. A service Field Engineer stated that the brakes were in spec and traveled 2 3/4" toward the floor. This is a subjective observation as every person uses different foot pressure. The gas pedal is at 3" off the floor and the brakes are 5". The brake pedal passes the gas pedal and many times, my foot hits both pedals. My inspection with a ruler shows the brake pedal going 1 1/2" past the gas pedal. There were no warnings the first time this happened. I have taken the vehicle to an independent mechanic who bled air out of both rear brake lines which helped. This repair lasted 3 months and now the issue is back. I've been told by independent mechanics that the problem is in the ABS module (which pulls the pedal to the floor when activated).

NHTSA ODI 11734275

I came up to a stop sign on a snow cover highway. When I applied the brakes my ABS brakes came on, but instead of slowing down, I felt the vehicle accelerating instead. I was pushed into the middle of the intersection and involved in an accident. An accident report was filed with the state of Wisconsin. No injuries occurred. I mentioned the problem to the Ford dealer, but they said there was no recall notice on file. An insurance adjuster inspected the damage to my vehicle last week. I have made an appointment with a body shop in February. I have not driven the vehicle since the accident. There were no warning messages before the accident.

NHTSA ODI 11710739

I have had the truck for 2 weeks. Three times I've almost rearended a car in front because of a braking system that doesn't stop the truck quickly enough. The pedal will travel 6" at times before it engages. This is very dangerous especially when braking when travelling around curves or round a bouts. I've taken the vehicle to two dealers and an independent brake shop. Dealers say it's normal. Independent brake shop warned against driving the truck. Town and Country stated that the pedal going to the floor is normal. No warning prior to this incident.

NHTSA ODI 11683910

When truck was new at 400 miles Abs traction controll rear collision and all braking erro codes were displayed on dash. Brought to dealer had a bad wheel speed sensor in rear. At that time I asked about large amount of rear brakes dust on vehicle like if the brakes were dragging. Technician said just poor oem pads. Now at 14k miles rear pads at 6mm thickness back wheels are always covered in brake dust. I was at dealer asked if there is anything they could do regarding initial build quality. Dealer said no there is no fault just poorly made pads. As a consumer ths is less then except able of a vehicle to almost need new rear brakes at 14k miles. Delaer should be replacing these pads on there behalf not the customer.

NHTSA ODI 11679680

Vehicle randomly upon start up, shows error codes on dash, of important Safety System Tech, including: Pre-collision Assist not available Service Advance Trac Auto Hold System Fault Antilock Brake Fault Service vehicle soon Vehicle warnings make Truck unsafe to drive.

NHTSA ODI 11670110

Air vent under steering wheel does not provide proper clearance for brake applications. Foot gets tangled/caught on vent. Had a few close calls during emergency situations. Problem gets worse with thicker sole shoes.

NHTSA ODI 11648889