What 262 owners told NHTSA about the 2023 Ford Maverick Later Release

The vehicle shakes during acceleration, specifically in the 40mph-65mph range. The shaking is worst around 55-60mph, especially—but not exclusively—when accelerating from a stop. The shaking does not occur at these speeds while coasting; acceleration prompts the issue. This is a known problem among 2022 Maverick owners, according to online forums including Maverick Truck Club, Reddit, and influencers on YouTube. Drivers widely report that the CV Axle is the culprit here, and report that replacing the CV Axle alleviates the shaking.

NHTSA ODI 11616308

pre collision assist stops working or false alert when driving around 25-35 miles i had the truck for about 15 months and had many issues with the pre - collision sensor / camera. i took the truck to the dealer and could not duplicate the issue or fix it the sensor show and sound the alarm about crash and no car close in the front of the truck. some times the alert sound when a car is parked on the side and i am driving in a small street i have the alert recorded in the ford mobile App also rear brake locks without pressing the pedal on highway driving

NHTSA ODI 11615969

The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed, the transmission inadvertently shifted into neutral(N). There was no warning light illuminated. The failure recurred the next day while driving 70-75 MPH, and the vehicle lost motive power. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 12,000.

NHTSA ODI 11614783

2023 Ford Maverick 2.0L engine current mileage 5300 Noticed oil leak on top of engine valve cover. Ford Mechanic stated there are (3) current service related engine leak issues with Maverick. (1) Plastic valve cover cracked (2) Turbo Oil leak (3) Timing Cover Leak. Mechanic stated a die test will need to be performed. After review of online forums, this appears to be a more common issue and can cause engine fire, especially since High Pressure fuel pump is also located on top of the engine. With Ford spreading repairs across three known issues, A recall investigation should be opened. Repair Sevice schedule for 9/19/24. Can provide repair invoices if desired after service. From research the valve cover, most likely culprit based on oil leak location, is a 2 week repair.

NHTSA ODI 11613769

Shortly after startup the infotainment screen on my Maverick froze. After shifting into reverse it was unable to display the reverse camera image. I attempted several shifts between Drive, Park, and Reverse and it remained frozen. I attempted a short key cycle, powering the truck down, including opening the drivers door in an attempt to cycle power to the infotainment and upon restart it remained frozen. After arriving at my destination and leaving the power off for 10-15 minutes it returned to normal behavior on the next key cycle. I have video of the failure occurring, including attempted solutions noted above.

NHTSA ODI 11612721

I have just recently bought a brand new truck, a hybrid model. Not a single mile on it when I purchased it, and I strongly feel that I almost died or caused an accident, completely not my fault but the truck’s fault. This has happened on 3 separate occasions. The first two times, as I was driving up the highway on a mountain road, I lost power, but just kind of chalked it up to maybe the fuel sloshing around, and no other vehicles were around me. The third time, I was returning home from work, on a busy 4-lane highway that goes across the pass and over the mountains, I was in the left lane, a semi truck was to my right, and a semi truck was behind me, we were passing the slower truck that was on the right, and I was traveling at around 55 mph, the truck completely shut off and was flashing red at me to pull to the side of the road. I lost all power, the steering, gas, and everything was not working. I need to mention that I was in front of semi truck, a larger truck that cannot stop on a dime, so he had to swerve to miss me, as I did not have control of the truck. The slower truck went by me and there was a another pickup truck behind him, and there was a little bit of a gap between them, so I jerked the wheel over and drove into the ditch. It was absolutely frightening, and kind of switched something in my head that I was very close to causing a large crash and maybe a death, of myself or someone else. I was in the ditch and the truck would not start back up. Nothing worked. To add to that, I was in a spot of the mountains that I do not get cell phone service. So I popped the hood and just sat there trying to turn the ignition and start the vehicle. 30 minutes passed and I slammed the hood and got back inside the truck and this time the truck turned over, but it said it was running on electric only, and the check engine light was, so I was able to limp home which was about 30 miles away, driving 20-30 mph. It sent the codes to my phone and I contacted the dealer.

NHTSA ODI 11612646

Note: Nobody was hurt, I am pre-emptively reporting this as I see it as a potentially dangerous issue. Transmission can jump/nudge the car a bit, especially in cold starts and if the engine is under load (e.g. AC or Heat). I've seen it online in Reddit reported, but mine seems to be a fairly strong version of it. It occurs pretty much every time the engine is cold. As I learned in a trip, if you don't press the brake hard enough, it can move. We did a road trip. I was stopped at a light (fully stopped). Brakes were pressed hard enough to not move, but not 'to the floor'. The vehicle jumped and moved about a foot into the crosswalk when I was stopped properly before then. Freaked me out. Nobody was in the crosswalk, so thankfully nobody was hurt. But this could be very dangerous behavior in a city where there are a lot a people. A surprising lurch when you think it's stopped isn't safe, and is going to create a liability for me. Me living near a big city, it's a worry. I've already brought it to a dealer about this, they said 'it's normal for mavericks' after investigating it for 25 days. I will re-raise this with them, but am not expecting much. I ran the truck with a diagnostic tool I own, no codes thrown through the bus, no warning lights during the event either. Examples: [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11612688

Saturday [XXX] I was driving on the [XXX] in SW PA and as I attempted to accelerate there was no power. I looked down at my transmission dial and it was set in neutral. I rolled the dial back to drive and pushed the gas and was able to accelerate. This is the 5th TIME this has happened in this vehicle 3 while driving on the Interstate, 2 while accelerating after a stop. Apparently there is a fix for this, recall 23V330/24S33 . I have been working with a local ford dealer to rectify the situation but it has not been resolved. I guess they updated most of the modules in my truck hoping to unlock a TCM update to preform the correct recall but it didn't work so they can not do the correct update to fix this problem. I also filed a complaint with you for same issue in May 2024 and received an email from Jason Winick. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11611075

Under 19k Ford replace my axle underwarranty. now 22000 miles the axle is broken again.

NHTSA ODI 11610661

There are/were no warning lights or errors that popped up. When I am coming to a stop (last couple seconds of slowing) I will often feel like there is suddenly no brakes, then a harsh braking suddenly. There has not been an incident where this has resulted in an accident, but it makes me feel like I don't have control of the vehicle if I can't anticipate braking behavior on perfectly dry, smooth surfaces. This would be compounded if there were wet or otherwise slippery/rough conditions.

NHTSA ODI 11606770

On 7/27/24 I was driving my 2023 Ford Maverick Hybrid with approximately 17,500 miles on the New York State Thruway @ approximately 70 mph. All of a sudden without warning the vehicle lost propulsion power. All types of warning lights appeared on the dashboard and the vehicle slowed down to 35mph. I could not control the acceleration or speed of the vehicle with the gas pedal. The vehicle stayed at 35 mph unless I applied the brakes. I was able to exit the interstate several miles down the road and have the vehicle towed to the nearest Ford dealer. This vehicle malfunction caused an extremely dangerous situation as I was almost rear ended several times by vehicles approaching from the rear that were not aware of my lack of ability to keep up with the flow of traffic. Ford repaired the vehicle 3 days later. When I was at the dealer picking up the car I was informed this is a very common problem with the Hybrid model. This needs to be corrected before someone is killed because of this common malfunction.

NHTSA ODI 11606399

Currently at mileage 11,200; was driving about 40 mph at 11:30 am in Folsom, CA; all of a sudden the truck slowed dramatically and I got several error messages: Power-train malfunction/Reduced power, engine service soon, and pre collision assistance not available." Was able to pull off the road safely, although several vehicles were right behind me. Had several recall repais within the last 3 months which involved software updates.

NHTSA ODI 11606300

Rear Passenger Window failed to come back up after being opened. Diagnosed as Master Window Control. Seen several complains on Maverick Truck Forum similar to mine.

NHTSA ODI 11605401

Main infotainment screen keeps freezing, and can't reset or power off. Back up camera does not work during this time, creating a dangerous situation while I am doing constant pickup and drop offs.

NHTSA ODI 11604003

There's a repeated issue for the backup camera. This happens around every other time I put the car in reverse, but for a few seconds only though. The backup camera often lags when reversing. This is a safety hazard when backing up if it's not real-time.

NHTSA ODI 11604043

Driving at approximately 65 miles per hour. Vehicle suddenly went into neutral I was forced to pull over on a busy highway. The dashboard was illuminated with several warning lights and messages. After one key cycle, I was only able to drive in a limited limp mode. After a second key cycle and waiting a few minutes, I was able to drive like normal but an engine light stayed illuminated.

NHTSA ODI 11603646

Upon starting vehicle and entering drive vehicle instrement cluster warnings went off and car applied emergancy brakes and suddenly stopped. upon vehicle restart driver was able to releace brakes and manually start ICE componant of hybrid drive train. vehicle entered drive mode and accelerated without touching gas pedal. brakes were jerky but responsive and vehicle accelerated by itself up to 35 mph while on way to dealer service. vehicle servace alerts given at time of drop off were: pre-collision malfunction Powertrain malfunction engine system fault

NHTSA ODI 11601486

I have a 2023 For Maverick hybrid pickup. While driving on the highway at about 70-75 miles an hour, the engine abruptly shut off. I had to carefully make my way to the shoulder while cars zipped by. Scary and very unsafe. My wife was hysterical and does not want to ride in the truck anymore. Once stopped at shoulder, I turned the ignition to the off and on positions several times. The gas engine would not crank. Three or four messages scrolled on the screen: "Service engine immediately," "Pre-collision assist not available," and others I don't exactly remember. When I would turn the ignition to on, the electric engine would start but when I accelerated in Park, the gas engine did not accelerate, not did it work in Reverse, Neutral or Drive. I was able to limp off the highway about 30 miles and hour under what I presume was electric battery power with my hazard flashers on and park at a gas station. I had to have the truck towed to the dealer on a Saturday night at a cost of $400.00 and leave it for repairs. The Service Department told me the truck was not giving any error codes and they were trying to get further guidance from Ford. They required extensive driving and time to input and test Ford updates. The final result was that they were not able to verify any issues after performing additional PCM updates. I was advised they are all done and will deliver the truck tomorrow Wednesday. However, they still don't know what caused the power failure. I have seen numerous similar incidents being posted about on the Internet.

NHTSA ODI 11600644

Having issues with my Back up Camera. Many times I can back almost all the way out of a spot before the camera comes on. Saturday night my screen froze while driving with maps on the screen, and the reverse camera did not work at all for 6 hours of driving until I let the truck sit until morning. Shutting it off for 10 minutes did not reset the system. The Backup camera was completely disabled. Other times there is a 5-10 second delay in it turning on. I am often times done backing up before the screen on the dash shows the camera view.

NHTSA ODI 11598314

[XXX]: Driving to work on the highway during rush hour. My vehicle started slowing down and wouldn't go out of neutral. The instrument panel lit up and the display panel brought up collision ahead. A lot of other codes and things popped up as well. I avoided being hit by a semi truck and was able to pull over to the shoulder. I turned my vehicle off and on. The vehicle went into drive and i to got it off the highway. It was in limp mode after that. I tried turning the vehicle off and on several times, and to no prevail. I called a tow truck to have them take it to the dealership. Keep in mind that this happened so fast and I was more worried about getting out of the way to avoid a collision. To hear that this is a recall is ridiculous. I drive with kids in the backseat, and I will never feel comfortable driving this vehicle again! I waited 9 months to get the maverick and I've had nothing but issues. Under 5k miles, I had a code pop up saying they detected air in the engine compartment. I was on the road trip to Canada at the time. I spent my vacation worrying if I was going to make it home. Luckily I did and it needed an "update". 2 other times, my left blinker failed. When it failed, my hazard lights would go off. Zumbrota ford "fixed" it the first time. Only for it to happen a month later. Zumbrota ford said they didn't know what the issue was, but they "fixed it". Now I had this even occur where the vehicle would go into neutral and limp mode. I'm not taking anymore chances, risking my life, driving this ford maverick. I've wasted so much time dealing with issue after issue and have missed several days of work. I just want a SAFE functioning vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11597972

The CV drive shift on either the driver side or passenger side of tbe hybrid model is going bad prematurely, currently at 20,000 miles but multiple other Maverick Hybrid owners have experienced the same issues and this is a safety risk as it could break while driving and cause an accident. It has not happened to me yet, as I'm not driving it until it can get fixed by the dealership but it's a concern I think ford needs to address,especially because most dealerships don't have vehicle loaners that customers can use unless they are willing to wait an extended period of time and their only option may be is continue to drive the unsafe vehicle or rent a car if they don't have a second vehicle.

NHTSA ODI 11595251

I was driving at 60-70 MPH on the highway and lost gas power. The electrical power in the hybrid motor continued working, but I was unable to accelerate or maintain full speed. IMPORTANT: I had this very thing repaired in accordance with a previous recall and an identical issue in January, approximately five months ago. I am reporting in case an additional recall and new software patch is needed.

NHTSA ODI 11594508

The contact owns a 2023 Ford Maverick. The contact stated while driving 15 MPH in hard rain during the day, he was unable to see out the front windshield. The contact stated that the windshield was blacked out. There were no warning lights illuminated. While cleaning the windshield, the contact noticed scratches going vertically and diagonally in the driver's view. Additionally, while sitting in the driver's side front seat, the contact noticed that the dark blue dashboard was reflecting on the windshield, making the windshield appear to be darker. The contact called the local dealer and was informed there were no recalls on the windshield. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 10,000.

NHTSA ODI 11594414

My driver side door hinge has a broken spot weld and has come unattached from the door and it goes inside and blocks the power window from coming down when the door is closed. Ford has had these breaking hinge problems since 2019. I took it to the Ford dealership for them to look at the problem and they want me to pay for it. I have attached pictures. As of October 2023, the National Highway Traffic Safety Administration (NHTSA) is investigating a potential defect in the front door weld of the 2020 and 2021 Ford Escape and its hybrid variant. This defect could cause the door to open unexpectedly while the vehicle is moving, which is a significant safety risk. Some owners have reported a popping noise followed by the door opening, while others have reported their doors not opening at all after a creaking noise. Some owners have also reported being unable to close the vehicle after the door opens. If the issue requires a recall, it could affect up to 346,071 vehicles.

NHTSA ODI 11594452

5th INCIDENT: On 06/09/2024, at approximately 5:25pm, I was pulling up to a stop sign after just leaving my home. Traveling about 10mph I began applying the brakes and vehicle suddenly lurched to a complete stop and shifted itself into park. Various warning prompts, chimes and cluster lights came on (see attached photos). Vehicle then accelerated all on its own without any pressure on the gas pedal. This is the 3rd such incident in nine (9) days. 1st time: 04/16/24, Complaint #11583215 2nd time: 05/26/24, Complaint #11590922 3rd time: 06/01/24, Complaint #11592069 4th time: 06/07/24, Complaint #11593195 5th time: 06/09/24, Current complaint.

NHTSA ODI 11593341