What 371 owners told NHTSA about the 2022 Jeep Wrangler Unlimited Phev

There was a prior recall where if there was discoloring or charring of the battery terminal a new battery was suppose to be installed. I reported this and showed the damage, and they just cleaned the terminals and sent me down the road. Now that these are burning houses down I would like to get out of this lease, its almost up anyway.

NHTSA ODI 11617396

The contact owns a 2022 Jeep Wrangler. The contact stated that while the vehicle was parked, the contact started smelling an abnormal odor and became aware there was diesel fuel leaking from the engine. The vehicle started spraying diesel fuel. The vehicle was driven to a dealer where it was diagnosed the fuel line was damaged and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was 36,000.

NHTSA ODI 11617471

The contact owns a 2022 Jeep Wrangler. The contact stated while operating the vehicle and depressing the accelerator pedal, the vehicle hesitated while accelerating and failed to immediately respond as needed. The contact stated that the failure was intermittent but had occurred while making a turn within a busy intersection and while merging into freeway traffic. The vehicle was taken to the local dealer who was unable to duplicate the failure or determine the cause of the failure. In addition, the contact stated that after starting the vehicle, the transmission shifter would not shift from park(P) and the vehicle could not be driven. The vehicle was towed to the local dealer who replaced the 12-volt battery, and the vehicle was repaired. The manufacturer was not yet contacted regarding the failure. The failure mileage was 7,000.

NHTSA ODI 11615230

The contact owned a 2022 Jeep Wrangler. The contact stated while the vehicle was parked unoccupied and turned off, there was smoke coming from the vehicle. The contact stated the fuse box located on the passenger side of the vehicle had caught on fire. The fire was extinguished by the Fire Department. A fire report was filed, and a fire report number was provided. The contact was informed that the cause of the fire was that the fuse box failed. A police report was not filed. There were no injuries sustained. The dealer was not contacted. The vehicle was not diagnosed or repaired. The insurance company sent a fire investigator to determine the failure. The manufacturer also sent an investigator and confirmed that the failure was due to a faulty component in the vehicle but no further information was provided. The vehicle was destroyed. The manufacturer was not made aware of the failure. The failure mileage was approximately 10,000.

NHTSA ODI 11613732

Vehicle has a recall on it for the high pressure fuel pump. I have been told by the dealership this part is on back order and can take 12 months before they can fix the High Pressure Fuel Pump. I called a second dealer ship and they also told me it could take 3-12 months before they could fix it due to limited supply of the part. DMV will not give me my car tags until this recall is remedied.

NHTSA ODI 11613825

22’ JEEP 4xE LOSS OF MOTIVE POWER Vehicle wouldn’t start for approximately 15 minutes. Showed charging system error and a battery light was on. Once vehicle started it was driven 5 minutes, parked and turned off. Within 30 minutes it was started again, and driven down the street when it lost power and indicated the speed was limited. I attempted to turn around to get back and park it when it quit in the middle of an intersection. Vehicle had a message to put it in park. I did. It wouldn’t restart or go into neutral to even push it out of the road. After about 10 minutes it started and I drove it back. It kept losing throttle and rolled opposite direction down a hill while in gear and still running. The throttle intermittently would work and rev then move forward. I backed it uphill into my driveway with it continued to roll forward and then rev the engine and reverse. When it losses power to the pedal it doesn’t rev the engine and will roll. Instrument panel and lights/entertainment still work when it does this. Mine and my children’s safety were put at risk. We called the dealer where we purchased from ‘Orangeville Chrysler Dodge Jeep Ram - 207163 Highway 9 East, Orangeville ON L9W 2Z7’ was told to bring it in. I said it was extremely dangerous and unsafe to drive. I asked for them to have it towed in and they refuse to pay for the towing. We mentioned a query into safety recall 22V-865 by ODI we found but they stated it was unknown to them and VIN didn’t show an open recall. We are without a vehicle as it sits in the driveway presently. (incident may be related) In nov 2023, about 9 months prior to this my [XXX] daughter was driving with my 9 and 11 y/o in the back seats and went into a ditch, damaging the front passenger fender, front bumper and hood. She mentioned something happened to the car and she lost control. There was no police report for this. There were engine lights on. We called a tow to get it out. The engine light went away on it own. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11613432

There is a confirmed recall 92A for the gear position sensor on my 2022 Jeep Wrangler. I took it to River Oaks dealership in Houston to have the recall work done in March 2024. They told me the work was complete; I returned to pick up my vehicle and found out the work had not been done because they didn't have the parts, so I took my vehicle home. I'm now told that they actually ordered the parts for the recall without telling me, and I was never informed that the parts arrived at the dealership or were going to be returned after that. I have now brought my vehicle to a different dealership (Helfman in Houston) for a repair and to have that recall fixed. They are unable to order the parts from Jeep to fix the recall, because River Oaks had previously ordered them under my VIN and have most likely returned them. No one at River Oaks is willing to help in any way. The recall manager says I should have known that they received the parts in stock after I left without any kind of notification, and the parts managers won't answer or return my calls. Jeep corporate has stated that they cannot cancel the previous parts order, but that River Oaks can cancel the previous order so that Helfman can put in a new one with my VIN. River Oaks has denied this. At this point, I cannot get a mandated safety recall fixed on my Jeep because of the previous and ongoing actions of River Oaks dealership. My options are apparently to leave it at the dealership indefinitely or take it back with a safety malfunction.

NHTSA ODI 11610342

I own a 2022 Jeep Wrangler Rubicon 4xe, I purchased the vehicle new on [XXX] (purchased in TN, registered in VA). Since owning the vehicle it has been in the shop 9 times, most recently in the shop because it was completely dead and they found out the battery was leaking acid, this is the same battery they had just replaced a year earlier. It has lost all power and shut off several times, Jeep continues to say there is no issue. The loss of power is concerning because it happens when driving on busy roadways. I filed 2 lemon claims with them, both times offered $2800 for inconveniences and $3600 the last time. I have also been instructed to park the vehicle outside of my garage and told it might be a good idea to not charge it daily due to a fire hazard, when buying a hybrid, I paid extra in hopes to get better gas mileage when traveling to and from work, now I put my children's lives in jeopardy everyday while driving it! And most recently when driving across a bridge or rough roads (I live in the south so rough roads are an everyday thing), it has started shaking so badly that I have pulled off the road due to fear of the vehicle flipping or causing an accident. It is frustrating to pay for a vehicle that is a hazard and does not work properly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11607951

The contact owns a 2022 Jeep Wrangler. The contact stated that while driving approximately 65 MPH after refueling, the check engine warning light illuminated. There was exhaust smoke coming from near the driver's side door and a burning odor started entering the cabin of the vehicle. The vehicle was taken to the dealer where it was diagnosed and determined that the burning odor and exhaust smoke was coming from the catalytic convertor. The catalytic convertor had been replaced; however, the failure reoccurred. The contact stated while driving approximately 15 MPH and then pulling over to park, there was white cloud of smoke coming from the driver's side of the vehicle into the cabin of the vehicle. The contact stated that the cabin was full of a strong burning odor. The contact opened the driver's door and became aware that the exhaust smoke was coming from the catalytic convertor. The vehicle was taken to the dealer where the cause of the failure was confirmed. The vehicle had been returned to the dealer. The vehicle had not been repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 3,000.

NHTSA ODI 11608010

The contact owns a 2022 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 23V263000 (Fuel System, Diesel) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11607612

My 2023 Jeep 4XE shut down in the middle of the highway in Arizona while traveling at 65 mph. The dashboard displayed an error message: “Service Charging System.” Shortly after, the vehicle experienced a total loss of power, and the screen instructed, “Put in park to start vehicle,” with a flashing “D” on the gear indicator. This has happed before in a 2022 that we traded in because we didn't feel safe driving. We have a service appointment 8/7/24 at Larry H miller Jeep in Avondale AZ.

NHTSA ODI 11606884

water pump fail

NHTSA ODI 11605603

I have received at least three 19A recall notices for my vehicle. Each time I call the dealer to schedule an appointment they tell me they have to order the part, they will call when it is in and that they are only allowed to order a certain number of parts each week. Still waiting on that call back! Yesterday when I called and was given the same "we'll order and call you", and "no I don't see anything previously ordered for you", the service clerk also told me that the 19A recall was not a big deal, not a safety issue and I didn't need to be concerned. Seriously? I don't know what else to do. I am afraid to drive this vehicle that I spent a ridiculous amount of money for. Someone should be holding Stellantis accountable. Sarasota Chrysler Dodge Jeep Ram, 7745 S. Tamiami Trail, Sarasota FL 34231 (941) 922-2400

NHTSA ODI 11605714

Jeep was parked. Charging. Neighbors ran over to tell us they saw it smoking. Electric battery ignited. Jeep caught on fire. Took 3 hours to get jeep cooled enough to tow it away. Electric battery was still at 180° when towed.

NHTSA ODI 11605154

The contact owns a 2022 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 23V116000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11605161

The contact owns a 2022 Jeep Wrangler. The contact stated while driving at an undisclosed speed, the vehicle lost motive power, with the rear axle warning light illuminated. The vehicle was able to be restarted; however, the failure recurred. The vehicle was diagnosed with rear axle failure. The contact was informed that the rear axle needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 17,000.

NHTSA ODI 11604354

E-torque battery issue. My e-torque battery was having issues for 20k miles that caused a “stored” code to appear saying the e-torque had a fault. I started bringing in the wrangler at 35,500 miles still under bumper to bumper warranty but because it was a stored code there was no repair order issued. This continued until around 50k miles when the jeep started shutting off at low speeds. The dealer took it in and Jeep Corporate stated that because it was still a stored code they would not release the battery pack needed for the repair. The dealer fought the warranty department for 3 weeks holding on to my vehicle. They eventually returned the car to me un-repaired per Jeep Corp instruction. The check engine light came on days after it was returned to me. No repair but documented at dealer. 12 days after the car was repaired it died again rolling to a stop light and then again in the same trip. The second time, it died in rush hour traffic, with a semi truck behind me. Thankfully I was traveling at about 20 miles an hour and the semi had several car lengths behind me because it shut off as though it was so dead it was sitting in my driveway. It did start back up when I placed it in park. I drove it to the dealer where they kept it for 2 more months fighting warranty to release the battery pack. I went through five jeep cares case managers and had multiple “star cases” that were opened and closed without the dealership being made aware at times that they were closed. They finally approved the repair. I have had the vehicle returned to me and plan to sell it as soon as possible because I do not know when this next battery pack will fail.

NHTSA ODI 11604113

The contact owns a 2022 Jeep Wrangler. The contact stated that while driving approximately 80 MPH, the vehicle suddenly lost motive power and started to decelerate. During the failure, the "Hybrid System" message was displayed. After parking and restarting the vehicle, the vehicle operated normally. The vehicle was later driven to the local dealer. The cause of the failure was not yet determined. The manufacturer was not contacted regarding the failure. The failure mileage was 10,500.

NHTSA ODI 11603858

Turnpike driving, approximate speed 70 mph. Hit a patched/bump in road. Experienced severe vibrations and wobbling in front end. Had to pull off onto shoulder to slow and stop vibrations. Then was able to resume normal driving. This was second experience of this kind in approximately 5 months.

NHTSA ODI 11602921

The loss of power battery pack issue its been already 4 weeks in the shop

NHTSA ODI 11602315

05/03/2024: while driving my 2022 Jeep Wrangler Sahara 4xe the vehicle unexpectedly had a complete loss of power resulting in my Jeep shutting down without warning. The warning light “service hybrid electrical system” illuminated after the I attempted to restart it. My Jeep would not restart or engage out of park. The vehicle was towed to the dealership where it remains in the same exact spot with no repair or identified problem. FCA/Stellantis is aware as I have an open case with Jeep Cares who really don’t seem to care. This complete loss of power could have resulted in a severe accident putting myself, passengers, and other drivers on the road at risk as there was no prior warning.

NHTSA ODI 11601791

Vehicle has had multiple instances of lurching forward and/or not even moving when gas pedal is pressed. Several of these instances have occurred when coming to a stop or when trying to start from a stop. When the brake would be pressed the vehicle would jump forward. In one very memorable occurrence I was at a 4 way intersection coming to a stop and the vehicle lurched forward into the intersection almost hitting another vehicle. It also has issues when pressing the gas, you will give is gas and it won’t go anywhere and then all of a sudden lurch forward. We have several instances of a hard transmission shift where the vechile will “buck” and jar you into your seat. Vehicle has been to 3 dealerships, all state nothing is wrong, no codes were thrown.

NHTSA ODI 11601366

UNKNOWN. This recall has been on my vehicle for approximately a year and a half, with no fix. I have not parked my vehicle in my garage due to fear of the pressure plate in the clutch catching on fire.

NHTSA ODI 11601618

My 2022 4xe has been in the shop a total of 10 months due to engine shut down, (slamming to a stop while driving along w/ auto park engaging). All of this started after having the 22V865 recall preformed in 2023. The dealership has yet to figure out the remedy, despite popping multiple codes. This is a SERIOUS SAFETY issue that could ultimate kill someone, if Stellantis continues to turn a blind eye. The dealership released my Jeep unfixed, I am now looking for another dealership who may have an idea how to correct the problems.

NHTSA ODI 11601174

We ordered in April 2022, a 2022 Jeep Wrangler 4xe Sahara plug-in hybrid, arriving late May 2022. In mid-June 2024, when starting the Jeep, it went into "limp" or "safe" mode. The Samsung EV battery was fully charged, indicating a 99% charge available, which translates to an approximate 24 mile range on the EV motor. The check engine light (CEL) came on as well as a "charging system failure" message came on in the center of the message center. The Jeep dealership in Temecula, CA, received the Jeep, which would only operate on the Internal Combustion Engine, and even then at 50% of available power, with the a/c system non-operable. The Internal Combustion Engine would not respond to throttle input, where it would not start (from engine off mode) more than a dozen times while en route to the Jeep dealership. It was unsafe being at the front of a long-line of cars when a light turned green and then applying the throttle, nothing happened, where we very nearly got rear-ended on multiple occasions. The DCH Temecula dealership who is servicing the Jeep advises the Samsung EV battery had an internal failure and requires replacement. The Samsung EV battery is on order or in transit/shipping, has not arrived. We have been without the Jeep approaching a month. In addition to our concern for this happening to others, we are really concerned about this being a recurring issue and problem.

NHTSA ODI 11600623