What 344 owners told NHTSA about the 2022 Ford Bronco 2dr

On June 13, 2025 my 2022 Ford Bronco and was involved in a serious collision in which the airbags did not deploy, the emergency braking and forward collision warning did not activate either. The second vehicle was t-boned at an estimated speed at the point of impact was 45mph. Both vehicles were a total loss. The Bronco suffered a bent frame and the passenger door would not open. The repair estimate was in excess of $36,000. I have reported the concern to Ford Motor Company under case number CXH-04933824-C1C3G9. At the time of the accident, there were no open recalls, warnings or notifications affecting the airbags or other safety systems. The vehicle was as-delivered by Ford from the factory with all regular service conducted by the local Ford dealership.

NHTSA ODI 11672794

The contact owns a 2022 Ford Bronco. The contact stated that while attempting to accelerate, the vehicle hesitated. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 40,000.

NHTSA ODI 11672821

The vehicle currently has three active recalls with each not having a remedy as of to date although one I was notified of 7 months ago. I have already had to have a faulty fuel pump repair within the first month or so of onset of purchase where vehicle just lost power and died on side of the road and had to be towed. Then had to fight the dealership and write complaint to Ford after having defective camshaft which took multiple attempts and documentation for FORD and the dealership to repair properly. Vehicle would shift between 2wd/4wd/AWD randomly while driving. Then I had been notified about a windshield wiper motor recall that just dropped of out the system before attempting repair. So never had that update ran or problem addressed. Now I have three other major safety recalls. Definitely a LEMON. Need Ford to stand behind their vehicle. I pay way too much not be safe. None of these failure or problems provided any prior warming indicators.

NHTSA ODI 11672361

The contact owns a 2022 Ford Bronco. The contact stated while driving at an undisclosed speed, there was an abnormal metal-on-metal sound coming from the vehicle. In addition, the contact was hauling a trailer during the failure. The vehicle was taken to the dealer, and the contact was informed that parts were not available. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 30,000. VIN tool confirms parts not available.

NHTSA ODI 11671570

The contact owns a 2022 Ford Bronco. The contact stated that upon placing the vehicle in reverse(R), either a blue or blank image was displayed on the rearview camera screen. The contact stated that over the past year, the contact had received notifications of NHTSA Campaign Numbers: 25V273000 (Back Over Prevention), 25V025000 (Suspension) and 25V315000 (Back Over Prevention); however, the parts to do the recall repairs were not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 18,000. VIN tool confirms parts not available.

NHTSA ODI 11671766

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving approximately 70 -75 MPH, the vehicle was driven over a bump in the roadway, the vehicle started bouncing abnormally and failed to remain in the intended lane. The contact continued driving the vehicle and the failure was self-corrected. There were no warning lights. The contact stated that while driving over bumps or uneven pavement, the vehicle was bouncy and unstable. The vehicle was taken to the dealer, who determined that the rear shock absorbers were leaking fluid and needed to be replaced. The vehicle was not repaired. The contact spoke with another dealer, Jack Demmer Ford (37300 Michigan Ave, Wayne, MI 48184); and it was confirmed that parts were not available for the recall repair. The manufacturer was made aware of the issue and opened a case. The failure mileage was approximately 45,000. VIN tool confirms parts not available.

NHTSA ODI 11670832

The contact owns a 2022 Ford Bronco. The contact stated that while driving at an undisclosed speed, the steering wheel locked up. The contact used force while turning the steering wheel to make lane corrections. The vehicle was taken to the dealer, who determined that the steering gear needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V155000 (Steering); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 29,500.

NHTSA ODI 11669539

The contact owns a 2022 Ford Bronco. The contact stated that upon entering the vehicle and closing the door, the driver's side rear quarter panel window separated from the vehicle and fell on the ground. A Safelite mobile technician replaced the driver's side rear quarter panel window at the residence. The vehicle was repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 39,000. The VIN was not available.

NHTSA ODI 11669189

The contact owns a 2022 Ford Bronco. The contact stated that while shifted into reverse(R), and occasionally while driving on several occasions at various speeds, the cross-traffic alert icon illuminated, and the message "Cross Traffic Alert Function Not Available" was displayed. The vehicle was not diagnosed or repaired. The contact believed that the failures were associated with an unknown recall. The manufacturer was notified of the failure. The failure mileage was approximately 34,000.

NHTSA ODI 11667121

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while her husband was driving at an undisclosed speed, the vehicle was bouncing and was nearly uncontrollable while exceeding 35 MPH. The vehicle was taken to a dealer who diagnosed the vehicle and determined that both rear shock absorbers had failed and needed to be replaced; however, parts were not yet available. The failure mileage was approximately 36,000. VIN tool confirms parts not available.

NHTSA ODI 11666734

The contact owns a 2022 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the rear tires of the vehicle. The vehicle was taken to two different dealers to be diagnosed and the contact was informed that the failure was related to the suspension. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The dealer contacted the manufacturer. The manufacturer was notified of the failure and informed the dealer that due to the mileage on the vehicle, the vehicle was out of warranty. The contact related the failure to NHTSA Campaign Number: 25V025000 (SUSPENSION); for which the VIN was included. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 47,000.

NHTSA ODI 11664646

Main instrument cluster panel goes completely black. Not able to see what gear vehicle is in, gas miles till empty. Digital speedometer is gone. If a safety warning pops up you cant see it. Started about a month ago and took it in for repair. Ford said it was a module and it was fixed for 2 weeks but it is now doing it again. Dealer is aware of the issue and apparently is happening in other Ford Broncos according to the main Bronco forum.

NHTSA ODI 11663722

When turning right, with the turn signal active, the turn signal will over-correct back to neutral and activate the left turn signal. This happens almost every time a sharp right turn is made, such as leaving a parking lot. The signal stalk must then by manually moved back to neutral. This is repeatable and occurs multiple times a week. This creates risk by presenting a false left turn signal to other drivers. This is a common issue on the Bronco, but Ford Motor Company has not provided a fix, TSB, or Recall.

NHTSA ODI 11662853

See attached document for complaint.

NHTSA ODI 11662128

The contact owns a 2022 Ford Bronco. The contact received notifications of NHTSA Campaign Numbers: 25V273000 (Back Over Prevention) and 25V025000 (Suspension); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11661810

When turning the steering wheel right or left going in a slight decline or incline the wheel seems to lock up or requires a hard pull to move the wheel, its now to the point my wife can no longer drive the car. I have almost run off the road one time and just this morning almost hit my neighbors mail box I am taking the car to the dealer but they say there is no recall, There are certain models of the same year that are being recalled, I think the company, slow in adding models of my type. I have stopped driving the car, Hopefully the dealer will fix it.k to the dealer and Ford and both say this problem is not part of the recall. the car has 27000 miles and is 3 years old.

NHTSA ODI 11660450

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated while driving at various speeds over a bumpy road surface, the rear end of the vehicle was bouncing significantly. The contact was concerned that the failure could cause a loss of control of the vehicle while driving. The vehicle was taken to the dealer, where it was diagnosed and determined that the failure was related to the recall. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000. VIN tool confirms parts not available.

NHTSA ODI 11659442

The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 40 MPH in the rain and attempting to clean the windshield, the windshield washer fluid failed to operate as intended, and the windshield wipers became inoperable while driving approximately two weeks later. Additionally, the contact stated that she had noticed a fluid leak on the rear passenger's side interior door. The vehicle was taken to New Canaan Auto Body Inc., where it was diagnosed that the windshield wiper motor had failed, and the windshield washer fluid was leaking on the rear passenger's side interior door. The contact stated that additional diagnostic testing was being performed. The vehicle was not yet repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.

NHTSA ODI 11658924

Random cracks to my hard top with no damage

NHTSA ODI 11659022

When parking or turning at stop lights periodically my steering wheel will lock up and become extremely hard to turn. I get stuck in the middle of an intersection or a parking lot not being able to turn my wheel. I have had the dealership look at it however they could not recreate the issue. The only warning I can feel is the steering starts to tighten up.

NHTSA ODI 11658327

I am on my 3rd Fuel Pump, it is currently at the Ford Dealership. My wife was accelerating through an intersection, making a left turn, when the engine shuddered, stalled and quite running. Luckily her momentum was able to get her through the intersection and avoid oncoming traffic. The Dealer has installed the 3rd faulty pump with the previous pump only lasting 3 months. Upon research this is a widespread manufacturing issues with the 2.7 ecoboost. I firmly believe this engine/fuel pump should be recalled due to the frequent malfunctions.

NHTSA ODI 11656844

The D-pillar clips are flimsy and break easily resulting in a soft top back panel that is no longer water proof and could fall apart.

NHTSA ODI 11655164

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (SUSPENSION); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available .

NHTSA ODI 11654951

The contact owns a 2022 Ford Bronco. The contact received notification of NHTSA Campaign Number: 25V025000 (Suspension); however, the part to do the recall repair was not yet available. The contact stated that while driving 30 MPH, the vehicle bounced and veered to the right. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the rear shocks had failed and needed to be replaced. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 23,500. VIN tool confirms parts not available.

NHTSA ODI 11654496

Driving in wet sticky snow the unheated LED headlamps collect snow quickly and provide almost zero projection of light forward. When driving in areas without overhead lighting at night this becomes a serious safety concern and may lead to a serious accident when drivers cannot see any possible obstructions in the roadway or accurately see the edge of the road surface. Have been unable to demonstrate this flaw to any dealers due to snow being unpredictable and dealerships being closed at night. I do have dash cam video showing the issue that can be provided for review, video uploaded to youtube here [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11652915