What 344 owners told NHTSA about the 2022 Ford Bronco 2dr

The windshield washer fluid reservoir cracked along its seam and drains completely after a few hours. This was not due to an accident and I have not done off-roading. I live in a snowy environment and not having an operating windshield washer is a MAJOR safety hazard as road salt quickly builds up on the windshield dramatically reducing forward visibility. It also affects the rear window washer, but that’s not as troubling an issue. The defective reservoir is available for inspection. My local mechanic confirmed that the reservoir is cracked. My photo shows the fluid leaking onto the ground. The component has not been inspected by the manufacturer, police or insurance, but has been inspected by a mechanic at my local Chevron station. A “washer fluid low” warning and idiot light appears after the reservoir drains, goes off when fluid is added, and goes on again when the fluid drains out again. I have ordered a replacement reservoir from Ford (which has been revised from the original) plus two required hoses for $477.28 (without installation). An internet search suggests this is a common problem for my vehicle.

NHTSA ODI 11711496

The rear hardtop panel on my 2022 Ford Bronco has developed serious cracking and surface separation after only three years of light, garage-kept use. The fiberglass is fracturing near the seams, exposing the underlying material. Water is now visibly collecting in the openings, which will lead to internal moisture intrusion, mold, and eventually corrosion of structural components underneath the hardtop mounting area. This poses a serious long-term safety concern, especially in the event of rear impacts or rollover situations. A Ford dealer inspected the issue and submitted a warranty claim, which was denied. The Ford representative acknowledged the damage but said they could not act without a recall or broader investigation. No warning lights or messages appeared; the issue is external and has progressed gradually. The damage began well before my bumper-to-bumper coverage expired, but has recently worsened. Ford’s own General Service Bulletin GSB 23-7174 lists rear hardtop panel cracking and edge delamination as warrantable conditions. My panel clearly fits those descriptions. Still, I was quoted nearly $10,000 for a full replacement, which is unreasonable. This is not an isolated case. Many 2021–2022 Bronco owners have posted identical problems online. Ford is clearly aware of this issue—which is why they issued that bulletin—but is denying claims unless pressured through complaints. I believe this is a materials or manufacturing defect and ask NHTSA to investigate this clear and ongoing failure.

NHTSA ODI 11677056

The contact owns a 2022 Ford Bronco. The contact stated that upon entering the vehicle and closing the door, the driver's side rear quarter panel window separated from the vehicle and fell on the ground. A Safelite mobile technician replaced the driver's side rear quarter panel window at the residence. The vehicle was repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and informed the contact that the VIN was not under recall for the failure. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 39,000. The VIN was not available.

NHTSA ODI 11669189

See attached document for complaint.

NHTSA ODI 11662128

The contact owns a 2022 Ford Bronco. The contact stated while driving approximately 40 MPH in the rain and attempting to clean the windshield, the windshield washer fluid failed to operate as intended, and the windshield wipers became inoperable while driving approximately two weeks later. Additionally, the contact stated that she had noticed a fluid leak on the rear passenger's side interior door. The vehicle was taken to New Canaan Auto Body Inc., where it was diagnosed that the windshield wiper motor had failed, and the windshield washer fluid was leaking on the rear passenger's side interior door. The contact stated that additional diagnostic testing was being performed. The vehicle was not yet repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 49,000.

NHTSA ODI 11658924

There is a bulletin that ford sent out that includes wipers intermittently not working properly when detecting rain. The issue happens when the normal steady wiper speed is selected and the issue isn’t resolved until the wipers are turned off and on again then the issue persists. Ford will not cover this issue even with a bulletin for a car 2,000 miles over their warranty. Further more fords extended warranty they offer at their dealerships will not cover this issue as well even though it extends the manufacturer warranty. This is a safety issue while driving in the rain

NHTSA ODI 11637094

Drivers side front door window vibrates and shakes significantly when in the open half-way position or less. When driving over bumps, rough roads, offroad it is very present. Window has to remain closed or fully open position. Hall Ford Dealer in Elizabeth City NC has been aware and confirmed it's an issue but they don't have a fix for it.

NHTSA ODI 11635289

I was sitting in my car and the back wind shield exploded over my dog and I. Ford was made aware of the issue, and apparently the Bronco's rods hyper extend and cause the tempered glass to break. Ford wont cover any damages done, and says it isn't covered by warranty. Although the dealership and Ford acknowledge no pressure was existenet to cause the window to burst randomly. In addition, Ford is aware the plastic placer screws in the removable hardtop is defective and cracks over time. However, they are not warrantying this repair.

NHTSA ODI 11616384

The contact owns a 2022 Ford Bronco. The contact stated that while the vehicle was parked, she became aware of a crack at the very beginning of the windshield on the passenger's side. The vehicle was taken to an independent mechanic who advised the contact to reach out to the manufacturer because he believed that the failure was related to a recall. The vehicle was not repaired. The contact related the failure with the NHTSA Campaign Number: 22V451000 (Visibility); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and referred the contact the NHTSA Hotline for assistance. The failure mileage was approximately 33,000.

NHTSA ODI 11592374

The contact owns a 2022 Ford Bronco. The contact stated that when the front driver’s and passenger’s side windows were rolled halfway down, an abnormally loud, rattling sound was coming from the vehicle while driving over bumps in the roadway. In addition, the front passenger's window was off track and failed to lower itself while attempting to exit the vehicle. The contact stated that since the window did not lower, he was forced to exit the vehicle through the passenger side door. The dealer was notified of the failure and the contact was referred to the manufacturer for assistance. The manufacturer was made aware of the failure and a case was filed. The contact was then referred to the NHTSA Hotline. The vehicle was not repaired. The failure mileage was approximately 9,000.

NHTSA ODI 11583299

The contact owns a 2022 Ford Bronco. The contact stated that when the front driver's and passenger's door glass were rolled down, the contact noticed a rattling sound. In addition, the front passenger's side door glass was off tract and independently released and rolled down. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to report the failure to the NHTSA Hotline. The failure mileage was approximately 11,000.

NHTSA ODI 11580641

While driving on interstates 99 and Interstate 80 eastbound on 212/2024 I encountered a snowstorm with my 2022 Ford Bronco wildtrak and as I was driving I was unable to see after a few minutes in the snowstorm because my headlights were covered with snow I couldn't easily pull off on the side of the road on the highway due to all of the truck and vehicle traffic so I had to attempt to drive unsafe behind a tractor trailer until I can get to an exit to wipe the headlights off this is the second time this has happened to me as the Ford dealer said basically the LED headlights do not generate heat so you should expect to have this with every snowstorm as long as you own the vehicle I found it to be very unsafe as I had my wife and daughter in the car with me and I had to pull over approximately every three miles due to the headlights being iced over and not even ice just snow and like it was a wet heavy snow

NHTSA ODI 11571734

I drive a 2022 Ford Bronco and I now have had to replace my windshield for a third time in 5 months from just a tiny rock hitting it. This most recent time on January 22, 2024 was a tiny rock that hit on my windshield on the lower left side of the drivers view. It made contact on the brow or bottom part of the windshield and the following morning it had grown vertically 3 inches. I went to drive to the grocery store and it was raining. The crack then grew as I was driving horizontally across the entire windshield almost reach the other edge on the passenger side of it. I do believe it’s the more straight angle of the windshield that makes it take direct impact so I am proposing Ford go to a strong gorilla glass for its windshields like Jeep did. I’ve heard from a few Bronco owners and Ford employees this has been an issue. Can you please look into this as I don’t think Ford Bronco owners should be punished with constant windshield repairs.

NHTSA ODI 11569180

While driving in temperatures 20 degrees F or below the wind shield wipers function and wipe but the fluid does not squirt out. It has created issues of extreme reduced visibility because of the smearing with no fluid. The vehicle is undrivable on a cold sunny day or dark night. In warmer temperatures the wipers wipe and squirt fluid adequately. Issue can easily be reproduced with low temperature weather. The issue has not been inspected by dealer or other 3rd party. Vehicle is available upon request.

NHTSA ODI 11565858

Driving 25 mph on a residential concrete road lost vision through windshield . A sudden storm caused leaves to block sewer grates from draining water . When going through 6-8” at curb side . I started turning wipers to high and I didn’t see improvement quickly. I slowed down to 20 mph for the following one and same thing again total loss of visibility . Thinking about it I’ve driven through the same amount of rain sitting on this same road with many different automobiles… And never experienced this kind of loss of visibility, especially at this slow of speed . Help us before someone gets hurt or killed .

NHTSA ODI 11556608

While wipers are in full-time mode, they will occasionally switch to intermittent mode even though rain continues to accumulate on the windshield. This forces me to take my left hand off the steering wheel to 'reset' the wiper system while driving with limited windshield visibility. Taking my hand off the wheel during a downpour is unsafe and should be the last thing I need to be concerned about. My vehicle is available for inspection. Dealership replicated the fault on similar Broncos and said it was 'normal operations'. They claim that the wipers go into intermittent mode so the wipers motor doesn't overheat. However, there is plenty of rain on the windshield when I've experienced the transition to intermittent mode. No warning lamps, messages lit up during this failure. I have a video available that documents this issue.

NHTSA ODI 11529774

The wiper system when turned to the standard or fast wiping position during any rainfall condition will slowing reduce its speed in less than a minute to the slowest speed for both positions and stay at that speed regardless of rainfall conditions. Even in normal rainfall conditions this has caused serious responses because of the delay with wiper returning to clear water from window. Whether your coming to a stop behind someone or passing on a turnpike with semi's or even following in heavy traffic. I have been able to work around with a switch back and forth from standard to fast or fast to standard to keep the wipers moving however the same issue arises. Today is my first scheduled oil change and tire rotation, which is when I asked about the wipers. The service person had not been aware of the wiper issue. He looked it up and is told by Ford that there is no problem. No warning lights or messages.

NHTSA ODI 11526683

When driving in heavy rain and you put the wipers on High (or even Low), they automatically switch to Intermittent after about 1 minute. They actually stop wiping at a high speed and pause between wipes for several seconds. In order to keep the wipers going in heavy, blinding rain you have to keep switching the wipers from Low to High to keep them moving. This is a safety hazard since you honestly cannot see though the windshield during heavy rain. Our Bronco is currently at the dealership being serviced. We were blinded in the rain storm traveling on the interstate. This is a very serious issue that needs to be resolved before someone is killed!!

NHTSA ODI 11526458

Wipers do not maintain constant speed. They slow down in dangerous situations when I need them to wipe continuously. They skip and slower speeds Had happened every time it rains

NHTSA ODI 11521916

During wiper operation in the low speed setting, after approximately 40-50 seconds of operation the wipers sometimes reduce in speed to a slow intermittent setting and stay that way until the wiper is turned to a new setting. This happens even in heavy rain, which can result in a significant safety hazard.

NHTSA ODI 11520144

Windshield easily chips and cracks. Vehicle has only 4500 miles and two chips without cracking and one chip with cracking. None happened at highway speeds and seemed to be small objects.

NHTSA ODI 11518834

When wipers are turned on full in heavy rain they slow down and come to a stop. I have to constantly adjust wiper speed to keep them active.

NHTSA ODI 11514970

I do not have auto wipers or rain sensing wipers. I’ve now driven through two major rain storms and sleet all three instances required the windshield wipers to be placed into constant on speed of medium and high. The issue results after the wipers are running in these constant on positions for a short while. The issue: The wiper blade speed while in demand of constant on medium and high speed will randomly reduce speed to intermittent making a massive safety hazard when at higher speeds and visibility is poor do to high rain, sleet, and snow volume. To get the wipers to operate at the intended speed the driver must rotate the speed control to a slower speed and back up to the required speed to handle the weather situation. This has to be done frequently and is a major hazard. Many people are reporting this same wiper issue on Bronco Forums such as Bronco Nation and Bronco6G.

NHTSA ODI 11513884

have a wiper control issue where at fast speeds the wipers start to slow down and go intermittent. It almost impossible to see at times. You have to play around with it to keep them going. So if it is raining small or hard all of a sudden they stop working and go intermittently and some times stop completely. This happens a lot when raining and I have told the dealer about it a few times and showed them as well from video.

NHTSA ODI 11513723

When driving in the rain with the wipers set on the low or high constant setting, the wipers will intermittently slow down or stop all together. When this issue occurs I have to cycle the wipers off then back on and the issue often repeats itself and leads to periods of zero visibility during cycling off on to correct issue. This is a serious safety concern that my dealer said is "normal" "that's how the rain sensing wiper system works". This cannot be right, I have never experienced a vehicle where the wipers slow down or stop whenever they want.

NHTSA ODI 11513725