What 82 owners told NHTSA about the 2021 Mercedes-benz Gle-class Hybrid

While driving on the highway on three separate occasions the blind spot warning will pop up and show as inoperative, next the active break assist warning flashes as inoperative, and then the entire vehicle shows as inoperative and loses all acceleration and breaks down. This has happened three times. Stayed over night at the dealership they “drove it for 70 miles” it didn’t happen to them. They released the truck back to me saying it was perfectly fine. A day later it happened again while on the highway. Highly unsafe!

NHTSA ODI 11746371

At approximately 87,000 miles, my 2021 GLE350 (M264 2.0T engine) experienced a severe engine misfire resulting in a flashing check engine light, rough idle, engine shaking, significant loss of power, and near-stall condition. The vehicle was taken to Speedhaus Automotive (Newbury Park, CA) where all four ignition coils and spark plugs were replaced. Total repair cost was approximately $635. This failure pattern is consistent with the documented M264 exhaust valve seat wear issue acknowledged by Mercedes-Benz technicians. A Mercedes dealer service report on an identical 2021 GLE350 explicitly states: "COMMON ISSUE FOR EXHAUST VALVE SEATS TO WEAR — KNOWN ISSUE WITH 260 AND 264 MOTORS." Mercedes-Benz has extended the warranty on the M260 engine (transverse variant) for this identical failure mode but has not extended it for the longitudinally-mounted M264 despite the same defect being present. Repair costs for full cylinder head failure on the M264 are being quoted at $6,000–$13,000. I am requesting NHTSA investigate whether a safety recall is warranted for the M264 engine across all affected GLE350, GLC300, C300, and E350 vehicles.

NHTSA ODI 11741934

2021 Mercedes-Benz GLE 350 W. APROX: 30,000 MILES. PURCHASED THE VEHICLE 3 YEARS AGO, WHEN IT HAD 17,000 MILES ON IT. WHEN DRIVING AT TIMES THE PASSENGER REAR SHOCK WILL START MAKING SQEAKING / CREAKING NOISES. BEEN LIKE THIS FOR ALMOST 1 YEAR NOW. I DONT DRIVE THE VEHICLE VERY OFTEN, BUT WHEN I DO DRIVE IT IT IRRITATES ME. THE DEALERSHIP SAID THE SHOCK NEEDS TO BE REPLACED. THERE ARE NO VISIBLE LEAKS, NO ABNORMAL RIDE QUALITY, ETC.

NHTSA ODI 11740482

My Mercedes GLE 580 experienced a complete failure of the 48V battery system due to the exact defect outlined in NHTSA Recall Campaign 24V207 (defective 48V ground connection causing high resistance and fire risk). The official status for my VIN shows 'Recall Incomplete.' The vehicle is currently at Mercedes-Benz of Barrington. The dealership is actively refusing to remedy this safety recall under warranty and is attempting to charge me $5,313 out of pocket for the battery replacement. Furthermore, the dealership refuses to submit the correct diagnostic error code (B183371) to my extended warranty provider to block coverage. My family has been left completely stranded without transportation for 7 days, and the manufacturer refuses to provide a loaner vehicle while the vehicle is unsafe to drive due to this fire hazard recall.

NHTSA ODI 11739128

An authorized dealer returned a vehicle with loose hardware in a moving mechanical track, posing a risk of mechanical failure or distraction while driving.

NHTSA ODI 11737556

The contact owned a 2021 Mercedes-Benz GLE 350. The contact stated that warm air was blowing from the A/C unit while activated. The vehicle was taken to an independent mechanic, and the contact was informed that a leak had caused the A/C unit failure. The mechanic referred the contact to the dealer for assistance. The vehicle was taken to the dealer where a diagnostic test was performed. The contact was informed that the HVAC system was inoperable and an estimate for the repair was provided. The manufacturer was notified of the failure, and the contact was provided a case number. The manufacturer denied responsibility for the failure but offered a monetary credit towards the repair. The vehicle was not repaired. The contact later traded the vehicle due to the A/C unit failure. The failure mileage was approximately 66,000. The VIN was not available.

NHTSA ODI 11732682

While driving at night all error light showed up. I slowed down to the side of the road and while I was slowing down the engine died. I tried to start the car which worked but when I pressed the gas the engine died again. Tried it two more times with the same results. Then turned the car and waited a bit with the engine running. slowly started driving and was able to get home driving 20 mph. The next day took it to a shop that said that the battery was weak and they replaced the battery. Drove out of the shop and started hearing nosies from the engine. Immediately came back and was advised to take it to the dealer. Towed it to the dealer that checked it and said that they found metal in the oil filter and that I need to install a new engine. I read online and found many complains about the same engine issue with 2021 Mercedes GLE 350. Mercedes refuses to take responsibility that they built a faulty engine.

NHTSA ODI 11719430

The vehicle has repeatedly experienced a sudden loss of acceleration, entering a reduced-power state while driving. Most recently, this occurred less than one week after I was advised that the issue had been fully resolved through a relay replacement. Critically, these incidents have occurred while my [XXX] child was in the vehicle, creating an unsafe and unacceptable situation. Below is a summary of the work that was done to resolve the safety concern. October: Drivetrain/Powertrain control unit internal fault Replacement of gateway/powertrain control module Wiring, grounding, and software inspections November: Active Brake Assist, ESP, and voltage supply faults Failure of both rear wheel speed sensors Replacement of left and right rear wheel speed sensors December: Dealership identified a faulty relay as the root cause Relay replaced and vehicle returned to service January, the vehicle again lost acceleration. And now, again in February. The same loss in acceleration incident. At this point, the vehicle has demonstrated a pattern of unresolved, safety-critical electrical failures. Given the repeated nature of the issue, the prior replacement of major components, and the involvement of braking and drivetrain systems, I no longer feel confident that additional part replacement without corporate oversight will result in a safe or permanent resolution. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11718456

This is regarding a 2021 gle 350. The car was parked overnight and in the morning was unable to start or crank . I had to tow the vehicle to the service center that has maintained the car since purchased date and they told Me there’s a problem with the engine and I will need a new engine costing $28,000 dollars., the car has 42,000 miles and has an impeccable service history with Mercedes Benz. They did not tell me any specific engine part that’s faulty. There was no warning lights, check engine lights. Had I been driving this car and it happened it could have been catastrophic.

NHTSA ODI 11717456

There is a known issue with the Cylinder Heads on specific models of Mercedes vehicles. Symptoms of M264 Cylinder Head Failure If your GLE 350 is experiencing these symptoms, it may be covered under the extension: Check Engine Light (MIL): Often triggered by misfire codes. Rough Idle: Noticeable shaking or uneven idling when stopped. Loss of Power: Potential stalling or significant power reduction during acceleration. Low Compression: Diagnostic tests often reveal low pressure in one or more cylinders. This is not being addressed my Mercedes USA where Mercedes Canada has offered an extended warranty. Using social media I have comprised a list of over a hundred impacted owners. Many more exist. What this does is cost catastrophic failure of the engine leaving the driver stranded in whatever lanes they were traveling in. I am disabled and for me this created a life threatening situation. When reaching out to MBUSA the answer is simply "not warranty exists" where MB Canada has extended the warranty to an additional 15k miles from notice. My engine blew. The replacement cost is near $20,000 dollars. The mileage on my engine was 65k. Many others are impacted and a class action lawsuit is the only other course of action it seems. Regards, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11709741

Sunroof makes loud, high pitched noise when it’s windy or driving high speeds. Sunroof complaints found online for bad seals or components of sunroof being bad or unaligned. Sounds could cause driver not to hear other safety issues with vehicle as well as leaking if water.

NHTSA ODI 11708279

According to the dealer, there are fault codes in the system for Transmission control unit failing. Thats what caused the vehicle to go into "limp" mode... That needs to be replaced. In an instant, the warning lights and reduction in power occurred simultaneously. The car slowed down and had to coast to shoulder of the highway crossing multiple lanes of traffic. The warnings that came on said “car cannot shift”, “battery failure warning” and when stopped; “do not restart the car.” The shoulder was very narrow and we could have easily been hit by the cars passing at high speeds on the beltway. We had to wait 2 hours for Mercedes roadside assistance to arrive. The dealer is saying it will be $6,000 to repair this.

NHTSA ODI 11707885

My vehicle suddenly started shaking and losing power, the check engine light came on and the problem continues to vibrate when idling, it will not shift into gear to go. Very unnerving and unsafe as it happened in a intersection. Sometimes it drives fine and then vibrates and goes into low gear and loses power. I took to a certified Mercedes dealer and they changed the spark plugs and 4 coils as well - After 4 weeks, I am told the CYLINDER HEAD needs to be replaced. It has 68k miles. The mechanic has already had 2 other 2021 GLE 350 with exactly the same issue. There are several similar cases discussed online as well.

NHTSA ODI 11705869

Original owner of a 2021 GLE, purchased on April 21, 2021. The vehicle is currently 4 years and 6 months and 22 days old with approximately 49,000 miles. Despite meticulous adherence to all scheduled maintenance performed and no warning lights activated the vehicle suddenly shutdown and would not restart. According to MB maintenance department it suffered a catastrophic and complete engine failure. This type of premature and total engine failure in a properly maintained, low-mileage vehicle is clearly a defect in material or workmanship. This is a serious safety defect that rendered the vehicle completely inoperable with no warning. Issues are resulting from valve guide wear issues, camshaft codes, valve openness, and no-compression symptoms, camshaft, timing chain, etc.

NHTSA ODI 11704589

we own a Mercedes-Benz GLE 350 model 2021. Our vehicles engine has stopped running on two different occasions, resulting in a very scary near miss accident situation. The first time this happened was it 22,000 miles, the engine shut off as a result of a failure in the engine cylinder head valve that burned up, causing the car to shut off in the middle of an intersection. The second incident happened at 56,000 miles where the vehicles engine shut off. This was also in the middle of an intersection, this time turning left in front of traffic. The reason why the engine turned off was because the lower part of the engine lost a rod bearing.this is what the dealership told us which cause the engine to have low compression and turn off. In both incidences, the check engine light did not come on. There was no warning. There are several people that have exactly the same problem with their vehicle and have also had the same two situations with two separate repairs made to their cars. People online are calling these Covid engines because the materials that were used to build the engines were made during Covid and they have defects. The GLA 350 model year 2021 appears to be the only year the GLE 350’s are having these issues. Mercedes-Benz refuses to acknowledge any of these issues and is not willing to help properly fix the engines. The only way to properly fix the engine is to completely replace it because it is full of defective parts and after the engine has failed the engines cannot be repaired.. This leaves us with no alternative to try and repair the vehicle ourselves so we are 100% relying on Mercedes to do the right thing and fix the problems that they caused to this 2021 model year GLE 350.

NHTSA ODI 11700231

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the cylinder head. The vehicle was repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 74,000.

NHTSA ODI 11699818

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while driving 65-70 MPH, the vehicle was skipping. The contact immediately veered towards an exit ramp. The contact noticed knocking sounds coming from the engine, and the vehicle stalled on the exit ramp. There was smoke coming from underneath the hood. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the engine had imploded and sustained a hole. The dealer determined that the engine needed to be replaced. Additionally, the dealer took the engine apart and informed the contact that the cause of the engine implosion could not be determined even with the assistance of the engineers. The vehicle was not repaired due to the cost. The contact then brought an independent mechanic to the dealer to inspect the vehicle. The mechanic inspected the engine and informed the contact that the failure had occurred due to a lack of engine oil; however, the contact stated that the dealer had performed an oil change on the vehicle 27 days prior to the failure. The manufacturer was notified of the failure but denied assistance in covering the repair. The manufacturer informed the contact that the engineers had not yet determined the cause of the engine implosion. The failure mileage was 69,100.

NHTSA ODI 11695392

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that the floor mats were wet after it had rained, and mold had formed on the floor mats. The rear hatch door occasionally unlocked unintendedly, and the radio would change stations independently. The contact stated that other electrical malfunctions occurred suddenly and intermittently. The vehicle was taken to the dealer, and the contact was informed that the sunroof drains were clogged and caused the water to build up, which then caused the electrical shortages inside the vehicle. The contact learned that the failure occurred due to the ends of the drainage system for the sunroof being tapered. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 49,200. The VIN was unavailable.

NHTSA ODI 11695417

The contact owns a 2021 Mercedes-Benz GLE350. The contact stated that while reversing, the back over prevention camera screen was black and there was no image displayed, causing a visibility hazard for the driver. The vehicle was taken to the local dealer, who indicated that the VIN was not included in NHTSA Campaign Number: 21V354000 (BACK OVER PREVENTION, ELECTRICAL SYSTEM). The contact stated that the vehicle had experienced the failure listed in the recall. The vehicle was not repaired. The failure mileage was 29,000.

NHTSA ODI 11694682

Location: Dallas, TX – Woodall Rodgers Freeway near North Hall Street exit Mercedes-Benz USA Case #: 18469650 What component or system failed or malfunctioned, and is it available for inspection upon request? The vehicle’s 48-volt electrical architecture appears to have failed, specifically the DC/DC converter or Integrated Starter-Generator (ISG) that provides 12-volt power to all control modules. When this component failed, it caused a total loss of propulsion and electrical power. The vehicle is currently at a Mercedes-Benz dealership in Dallas and available for inspection upon request by NHTSA or Mercedes-Benz USA (case #18469650). How was your safety or the safety of others put at risk? While driving approximately 50 mph on the Woodall Rodgers Freeway with my family in the car, the vehicle suddenly lost all engine power and throttle response without warning. The accelerator stopped responding, and the engine stalled completely within seconds. I was able to coast partially onto an exit ramp, but once stopped, the car would not restart and could not be shifted into Neutral. We were stranded in live traffic with limited steering assist and no way to move the vehicle, placing my family and other motorists at serious risk of collision. Has the problem been reproduced or confirmed by a dealer or independent service center? The vehicle is currently at a Mercedes-Benz authorized dealer, and the failure has been logged with Mercedes-Benz USA under case #18469650. Initial findings point to a malfunction of the DC/DC converter or 48-volt system. Full STAR diagnostic data and fault codes are pending. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? Mercedes-Benz USA has been notified and opened case #18469650. The vehicle has been inspected by the dealership’s certified technicians and is awaiting official diagnostic reporting and possible engineering review through Mercedes’ Technical Assistance

NHTSA ODI 11693255

Not sure vehicle was parked and caught on fire from the drivers side completely burning

NHTSA ODI 11691671

I am writing to document a recurring and serious issue with the Mercedes-Benz GLE equipped with the M264 engine, specifically relating to premature cylinder head failure. In my case, the vehicle began showing the following symptoms: Rough engine idle and noticeable vibration during startup Loss of power, especially when accelerating Check engine light with fault codes related to misfire or combustion issues Oil and/or coolant loss, with no external leaks Engine knocking or ticking noises near the top end of the engine After a professional inspection and diagnostic testing, I was informed that the issue is likely due to a defect or failure in the cylinder head, possibly involving warping, cracking, or failure of the valve seats or head gasket area. Upon further research, I discovered that this issue is not isolated. Multiple owners of vehicles with the M264 engine—including various GLE, C-Class, and E-Class models—have reported similar problems, often occurring well before 70,000 miles and despite regular maintenance. The pattern suggests a possible design flaw or quality issue with the engine’s cylinder head. As of now, it appears no formal recall or technical bulletin has been issued by Mercedes-Benz regarding this specific problem. However, the number of similar reports suggests the issue is widespread enough to merit formal investigation or at least acknowledgment by the manufacturer.

NHTSA ODI 11688533

Engine light came on at 44K miles

NHTSA ODI 11687634

The car has stalled 4 or 5 times, while driving in traffic. This can obviously be life threatening. The check engine light came on yesterday. We recently brought the car to Mercedes Benz in Daytona Beach, Florida. They told us we had low pressure in the cylinders, and needed a new cylinder head for $10,000. The cylinder pressures on their test however were all normal. They never mentioned a recall for a fuel pump defect causing cars to stall. A local independent repair company confirmed the cylinder pressure test was normal. Mercedes recalled 324,000 vehicles for this defective fuel pump between 2012 and 2020 (abc news). They recalled over 143,000 vehicles from June 2021 to 2023. My model, GLE350, was included in both recalls. I called Mercedes customer service. They said my car was built in February 2021, and there is no recall for this vehicle. There have been recalls for defective fuel pumps from 2012 to 2020, and June 2021 to 2023. I strongly suspect my vehicle built in February 2021 has the same defective fuel pump. I will bring the vehicle to an independent well qualified service center. If they diagnose a fuel pump problem. I would like Mercedes to reimburse me for the repair.

NHTSA ODI 11679179

Replacement of Cylinder Head (#1)

NHTSA ODI 11676073