What 159 owners told NHTSA about the 2021 Ford F-250 Supercab

The contact owns a 2021 Ford F-250. The contact stated that while attempting to reverse out of a parking spot, the rearview camera displayed on the center console failed and the screen was blue with the message "Camera not Available" displayed. The contact stated that the screen was fuzzy, and the image was jump around on the screen. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed because the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 40,000.

NHTSA ODI 11663541

The contact owns a 2021 Ford F-250. The contact stated that while driving at an undisclosed speed, there was a loud clanking sound coming from the rear of the vehicle. There was no warning light illuminated. The contact stated that the vehicle went into LIMP mode, and then lost motive power. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The vehicle was towed to the dealer, where it was diagnosed and determined that the fuel system and fuel pump module had failed and needed to be replaced. The dealer confirmed that parts related to the recall repair were not yet available. The manufacturer was made aware of the failure. The failure mileage was approximately 115,000. VIN tool confirms parts not available.

NHTSA ODI 11663197

The contact owns a 2021 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle lost motive power while driving at various speeds and while idling. The contact would restart the vehicle; however, occasionally the vehicle failed to start. There was an unknown warning light illuminated. The dealer was contacted. The manufacturer was made aware of the issue and opened a case. The failure mileage was approximately 130,000. VIN tool confirms parts not available.

NHTSA ODI 11662371

The contact owns a 2021 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power, with the check engine warning light illuminated. The vehicle was scanned by an independent mechanic, and DTC: P0087; was retrieved. The vehicle was towed to the local dealer, where the vehicle was diagnosed and remained for further investigation. The manufacturer was made aware of the failure. The failure mileage was approximately 133,071. VIN tool confirms parts not available.

NHTSA ODI 11661251

The contact owns a 2021 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V048000 (Back Over, Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was contacted. The manufacturer was not made aware of the issues. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11657705

We were on the interstate and our truck had reduced power and then failed. The diesel particulate filter light came on as well as the service engine soon warning. We were hauling our 40 foot 5th on the way home from a trip. We were able to make it to the side of the road but it would not start. It would crank for a while then quit. We were stuck on a very busy/dangerous highway for over 2 hours waiting on a tow truck to get us. It cost $500 to be towed to the ford dealership 2 miles away. We were nearly 3 hours from home. Our truck and 5th wheel are both still at the dealership. We were told today that the fuel pump exploded leading to shards of metal throughout the system and that it would be $15000-18000 to repair. There isn’t a solution with the recall but it will be covered under our powertrain warranty. We are left without a truck and have no way to get our camper home until it’s repaired.

NHTSA ODI 11657627

Engine loss of power - engine failure. My vehicle was serviced regularly with Ford dealership. Just weeks after an oil change at dealership I had sudden catastrophic engine failure. They found metal in my oil and stated my engine had failed due to faulty pump. I contacted ford dealership and customer service center, and they refused to repair as I was about 125864 miles (25k over warranty) on a truck they told me would last 400k with proper Maintenace. I have been making my monthly payments on this large paperweight and now there is a recall, and I still cannot get ford to repair the vehicle

NHTSA ODI 11655279

The contact owns a 2021 Ford F-250. The contact stated that while the vehicle was parked and idling, the vehicle shut off and failed to restart. There were no warning lights illuminated before the failure. The contact stated that several unknown warning lights illuminated after the failure. The vehicle was towed to the local dealer, where it was diagnosed and determined that the fuse box needed to be replaced. The contact stated that the vehicle was not communicating with the fuse box. Additionally, there was moisture in the fuse box. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline; however, no assistance was provided. The failure mileage was approximately 73,000.

NHTSA ODI 11654530

The contact owns a 2021 Ford F-250. The contact stated that while using the key fob to unlock the doors, the alarm activated. The contact stated that the front driver's side failed to lock as intended. No warning lights illuminated. The vehicle was taken to the dealer. However, the vehicle was not diagnosed or repaired due to costs. The contact related the failure to TBS: 21-2207. The contact stated that the failure had occurred several times. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11654102

The contact owns a 2021 Ford F-250. The contact stated that while driving at an undisclosed speed, the tailgate independently opened, and items in the bed of the vehicle were lost due to the failure. The vehicle was taken to the dealer several times; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. In addition, the contact was informed that Customer Satisfaction Program: 21M05; repair was performed in June 2022, and the technician disconnected the tailgate indicator light. The contact stated that the failure had occurred several times since Customer Satisfaction Program: 21M05; repair was performed. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 23,735.

NHTSA ODI 11653626

Death Wobble Severe steering problems occur with this vehicle. Especially when hitting even a slight bump in the road. When pulling a trailer across a bridge, it became so severe that the truck and trailer changed lanes and I had NO control. This problem occurs regularly and is a very dangerous situation!

NHTSA ODI 11653166

The exhaust manifold bolts broke and it’s leaking toxic fumes in the path of the cab and it gives me a headache I’ve done research and this is a common issue

NHTSA ODI 11647765

The contact owns a 2021 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11646041

See attached document for complaint.

NHTSA ODI 11644760

See attached document for complaint.

NHTSA ODI 11644798

The contact owns a 2021 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11642752

The contact owns a 2021 Ford F-250. The contact stated that upon attempting to start the vehicle, the engine was struggling to turn over, and the vehicle failed to start. There was no warning light illuminated. The local dealer was contacted; however, the vehicle was not diagnosed because the contact was unable to take the vehicle to the dealer. The contact was advised to contact the NHTSA Hotline for assistance. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL) as a possible cause for the failure. The manufacturer was notified of the failure. The approximate failure mileage was 67,994.

NHTSA ODI 11641413

The truck has developed a significant knock coming from the intake manifold. It is loud enough to hear with the hood closed. The problem exists warm and cold. The knock was verified by Sunrise Ford in Fontana, CA in December of 2024. The Dealership had another F250 on the lot with the same 6.2 engine and that it also has a knock coming from the intake manifold, so they considered the situation "normal". There is a significant amount of information available that the knock is related to an impending failure of the Intake Manifold Runner Control (IMRC). If the IRMC fails, the parts will go into the combustion area and could cause an immediate catastrophic failure of the engine. At best this problem creates a loss of power and a pulsing vibration at idle.

NHTSA ODI 11640370

1st incident, weather conditions were rainy. Drove to store, shut off truck, started truck, service engine soon light came on #1-Ford pass message-powertrain control module lost communication or has detected incompatible software from the glow plug. service engine soon light #2-Powertrain control module lost communication with the glow plug, additional alerts along with a hard start or no start condition may accompany this fault. Service engine soon light #3-A communication fault over vehicle network has occurred between several modules. Service engine soon #4-The powertrain control module lost communication with the exhaust particulate matter sensor. Service engine soon #5-The transmission control module is sending invalid information over the internal vehicle communication network to one or more modules. Message #6-Pre-collision assist not available. I thought if I shut the truck off it would reset. When I tried to restart the truck it did nothing. Had it towed to Archie Cochrane Ford in Billings, MT. They replaced the DEF wiring harness. 2nd incident on [XXX], drove through rain on way to Provo, UT. Service engine soon light came on with all the same messages + five other messages. Had it towed to Larry H Miller Ford in Provo, UT. They replaced the Battery Junction Box. Drove to Yuma, AZ without incident but had them look it over and they could not reproduce the issue. Drove to Dickinson, TX, encountered fog on 1/3/2025. Incident #3, drove to the gas station on [XXX], started the truck up and the same messages came up. Roads were dry, although it had rained the night before. Drove straight to McRee Ford where the technician observed the issue firsthand. While the vehicle was in park it was constantly surging. We researched online for the same problem and have found others that have had this same type of issue. We have had to rent cars when the truck was in the shop. We believe this is an engineering issue and Ford should fix the issues without charging. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11635087

bad transmission at only 75,000 miles

NHTSA ODI 11634434

The high pressure fuel pump failed while traveling causing the truck engine to shutdown placing us at risk of a collision when we took the vehicle to ford dealership in Morrilton, AR we were advised that the CP4 pump or high pressure fuel pump failed containing the entire fuel system with metal shavings. The cost to repair this failure is over $13,000 causing us to take out a loan.

NHTSA ODI 11633914

The contact owns a 2021 Ford F-250. The contact stated that while driving at an undisclosed speed, the transmission failed to shift as intended. The contact stated that the transmission was shifting erratically. Additionally, the contact stated that the vehicle was difficult to start and was idling rough. The vehicle was taken to the dealer however, the contact was informed that without the check engine warning light illuminated, there was no need for a diagnostic test. The contact stated that the failure was intermittent. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was 95,000. VIN tool confirms parts not available.

NHTSA ODI 11633657

On or about [XXX], [XXX] I contacted Ford customer relations about the roof installed molding Rear mounting points had broken apart on my vehicle (both sides) and the molding is lifting up. Advised that if could become dislodged during operation. Received a Case # [XXX]. After several calls, I was told no action will be taken on their part because the vehicle over 3yrs old. I contacted the local Ford dealership (Lafayette Ford) and was told by one of the addon tech that it's a known issue and that Ford currently carries the newly designed replacement part. He spoke to manager in the service department . He then sttn that I would need to get a case number, I told him that I'd had one and provided it to him. More phone calls made and they will not change their position. On 11/1/2024 I was told that the case was closed almost immediately after it was opened. Ms Tara sttd that the supervisor was going to request that the case be reopened. 11/18/2024, I called back because of no response. Ms Jaclyn sttn, not covered, Ford not doing anything. I don't know how long or when they broke. The roof has never been used to carry anything. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11633681

I am the original owner of this 2021 F250, (by my notes, dates & miles may differ slightly by Ford/Dealer records) I first noticed Death-Wobble around [XXX] @ 3,040 miles & Ron Alpen Ford checked factory alignment & ordered an updated steering stabilizer. Updated steering stabilizer was on back order until around 8/8/23 @ 26,647 miles when it was installed on the F250. As you can see, over two thirds of this truck's three year bumper to bumper warranty was dissolved by back order. This is where I believe Ford Motor Company's engineering group got involved & recommended a custom alignment, I believe this was performed by Ron Alpen Ford around 4/8/24 @ 33,486 miles. As you can see, over half of this truck's remaining warranty was dissolved waiting on Ford Motor Company's assistance. Ford Motor Company fell silent after recommending I take the truck to a different Ford Dealer for a second opinion... I still do not believe a second opinion was the correct opinion of Ford... Ford should have supported Ron Alpen Ford further in this repair. I set up an appointment at Courtesy Ford, Courtesy had the truck for two full weeks straight... Ford claimed that the truck had conveniently made it outside of the warranty period... 12/3/24 @ 35,922 Courtesy replaced the drag link & the steering stabilizer a SECOND time as the continuing death-wobble had destroyed the first updated steering dampener at my expense because the truck was conveniently out of the 3 year warranty period... Courtesy also decided to return the truck to its original factory alignment even though they were asked not to. Death-wobble continued as of [XXX] @ 36,105 miles. I have contacted Ford Motor Company, Ron Alpen Ford & Courtesy Ford on 12/11/24 to inform them the truck still has Death-Wobble & as of 12/27/24 no reply from any one. I have called Courtesy Ford requesting my money back because they guaranteed the truck would be fixed & it clearly is not. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11632600

The contact owns a 2021 Ford F-250. The contact stated that while driving 55 MPH, the steering wheel started to feel loosened and shaky. The contact pulled on the steering wheel and the steering wheel detached. The steering wheel was re-attached. The vehicle was taken to a dealer but was not yet diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 127,000.

NHTSA ODI 11630446