What 254 owners told NHTSA about the 2020 Ford F-250 Supercab

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11685924

Recall is 9 months old and still no remedy available. Unable to use truck on platforms such as Turo because of the safety risk. No update from Ford, no dealer has a remedy.

NHTSA ODI 11682665

On or around July 14, 2025, my truck failed to start. The engine would turn over but would not fire. My vehicle was at home and had been driven within the past day before this incident. On July 14, 2025, I had my vehicle towed to Burns Ford of York for a diagnosis. Upon inspection, the Ford technician determined that the high-pressure fuel pump was damaged, causing metal to contaminate the fuel system. At the time of this failure, my odometer had 67,452 miles. A "fuel system replacement" kit and element were ordered - Ford parts #s PC3Z-9N184C & LC3Z-9B246B. As explained to me, the entire fuel system and components had to be replaced because the high-pressure fuel pump "exploded." Knowing there is an active recall on the fuel system (Campaign 24S78/24V957) a request was made to Ford to cover the repair costs since the active recall dealt with a known issue of aged biodiesel causing issues, including a failure to start, which I experienced. Ford failed to approve the repair costs, causing a total expense around $17,000, with approximately $7,000 being out of pocket after my extended warranty company paid the remaining balance. The issue is that there was no intentional direct cause for the fuel pump to fail and given it did so with an active recall on the fuel system and with only 67,000 miles I believe the active recall is associated with my failure and should be on Ford to cover repairs and acknowledge a permanent fix.

NHTSA ODI 11681907

Engine making heavy ticking noise from front of engine because of a cracked oil pump gear and the front main seal is now weeping oil. Ford is aware of this known issue as a TSB. Afraid to drive truck because I normally haul a large travel trailer into the mountains and the technician said the oil pressure could drop causing the motor to seize up.

NHTSA ODI 11680497

On July 31st, I was driving my 2020 F-250 in town, traveling approximately six miles from one location to another. Upon arriving at my destination, I noticed smoke coming from under the engine bay. When I opened the hood, I discovered diesel fuel had leaked throughout the engine compartment. I immediately contacted my local dealership and brought the truck in for inspection. I was informed that the fuel filter was cracked. After doing some research, I learned that this appears to be a common issue with similar models, and in some reported cases, it has even led to vehicle fires. Fortunately, this did not occur while I was driving a longer distance, which could have put me and my family at serious risk. I’m raising this concern in hopes of further investigation and a resolution, given the potential safety implications.

NHTSA ODI 11679893

2020 F250 Experienced the death wobble while traveling on freeway at 70 mph after running over bumps .

NHTSA ODI 11679675

Parked at gas station, after fueling attempted to start with key and engine started but electrical systems did not register that vehicle had started. Turned engine off but engine continued running. Additional attempts to start vehicle made no difference -- engine continued running but vehicle could not be shifted out of Park. Called dealer and was advised to pull fuel pump fuse to stop engine. Towed to dealer and dealer determined that water had indruded into battery junction box and junction box needed to be replaced at owner expense. Ford Technical Service Bulletin 20-2298

NHTSA ODI 11679498

Bushing in CDF drum has moved causing failure to transmission. This appears to be a common issue. When this occurred truck would not engage in certain gears at slow turns and stops causing lack of acceleration creating a hazard merging in traffic.

NHTSA ODI 11679523

The contact owns a 2020 Ford F-250. The contact stated while attempting to start the vehicle, the vehicle failed to start. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed with a failed junction box due to water intrusion. The contact was informed that the junction box needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11677640

The contact owns a 2020 F-250. The contact stated that while driving in low gear, the vehicle started surging, plunging, and shifting erratically. There were no warning lights illuminated. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and confirmed there were no open recalls on the VIN. The failure mileage was approximately 135,000.

NHTSA ODI 11676601

My truck lost power on the Highway. Had to coast down the off-ramp and ended up blocking a turning lane when the engine failed to start back up. Called a someone to tow me back to my house and parked it where it’s been there for months since Ford has not yet issued a solution to the recall.

NHTSA ODI 11676362

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (FUEL SYSTEM, DIESEL); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11675643

I have a 2020 F250 with the 10r140 transmission and the cdf clutch has went bad. My truck only has 67,000 miles on it. Ford is saying there is not a recall on my vehicle.

NHTSA ODI 11675757

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11675330

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The contact stated that the message "Reduced Engine Power" was displayed on the instrument panel. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 80,000. VIN tool confirms parts not available.

NHTSA ODI 11674006

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated while driving 45 MPH and accelerating to merge onto the highway, the contact heard an abnormal bang or pop coming from the front of the vehicle and started losing automotive power. The contact stated that several warning lights were illuminated on the instrument cluster and a "Reduced Power" warning light was flashing. The contact pulled over and the vehicle stalled. The contact was unable to restart the vehicle and had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the fuel pump had failed; however, the repair was not completed because the manufacturer had not approved the additional work required on the engine and the fuel system. The failure mileage was 121,000. VIN tool confirms parts not available.

NHTSA ODI 11673350

I am writing to formally report a serious issue with my Ford F-250’s fuel system. The system failed, which appears to have been caused by contaminated or aged fuel. As a result, I was forced to replace the entire fuel system at a personal cost of $15,000. Despite taking the vehicle to an authorized Ford dealership, the recall related to this issue has not yet been addressed. I am extremely concerned by the lack of resolution and the financial burden this has placed on me as a consumer. I respectfully request that this matter be reviewed promptly and that appropriate action be taken to ensure the recall is completed and I am compensated for the related repair costs.

NHTSA ODI 11673001

Ford just announced recall 25V455 for bad fuel pump for certain Ford trucks from 2021-2023 models. I purchased brand new 2020 Ford F250 SD with the 7.3 gas motor and from day one its had fuel pump issues. The vehicle hard starts like its starved for fuel. After several trips to the dealer they said it was a battery so I changed the battery. Didn't fix it. Then they said it was some other part and they replaced it, didn't fix it. I tried getting Ford to replace the fuel pump and the wouldn't. I've read forums online that discuss the same issue with many current ford models. I'm glad to see Ford do the recall but they need to extend the recall to include 2020 models. My truck has exhibited the same issues in this current recall and it gets worse during the hot South Carolina summer months. This is going to create a long term problem and Ford needs to include 2020s in their recall. I purchased the truck from Billy Howell Ford in Cumming, GA then moved to Columbia, SC where Jim Hudson Ford has been serving my truck.

NHTSA ODI 11672659

While driving on the interstate, my truck began to lose power and decelerate. A fuel pump and engine warning light appeared. I began to lose power steering while decelerating. When I finally stopped and the truck turned off, I tried restarting which resulted in a cranking noise and was not successful in starting. I had to contact a towing company for assistance and my truck has been undriveable since this date (7/6).

NHTSA ODI 11672666

The contact owns a 2020 Ford F-250. The contact stated that the sunroof had been leaking for approximately 2 years. The contact used rubber mats to cover the carpet, but the carpet was soaked. The contact stated that the vehicle was taken to a local dealer two times and the dealer informed the contact that the vehicle had been repaired; however, the failure persisted. The contact stated that recently the tailgate had an electrical short circuit following a period of heavy rain. The contact had taken the vehicle back to the same dealer. The vehicle was repaired. The contact informed the manufacturer of the failure and was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 6,000.

NHTSA ODI 11672555

The contact owns a 2020 Ford F-250. The contact stated while driving 70 MPH, the vehicle stalled with a loss of drive power message displayed. The vehicle was able to be restarted. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was unavailable. The vehicle was taken to the dealer where it was diagnosed and determined that the high-pressure fuel pump had failed and needed to the replaced. The vehicle was not repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 190,000. VIN tool confirms parts not available.

NHTSA ODI 11671948

The contact owns a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the transmission inadvertently downshifted with the transmission warning light illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 125,000.

NHTSA ODI 11672085

The contact owns a 2020 Ford F-250. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the vehicle failed to stop. No warning light was illuminated. In addition, the contact stated that a trailer was hitched to the vehicle during the failure. The contact stated that the trailer brakes was inoperable. The contact stated that the failure occurred while driving in the driveway. The contact was able to safely stop and park the vehicle. The vehicle was not diagnosed by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The contact referenced NHTSA Campaign Numbers: 25V401000 (Service Brakes, Hydraulic) and 25V132000 (Electrical System); however, the VIN was not included in the recalls. The failure mileage was approximately 38,800.

NHTSA ODI 11668990

High Pressure Fuel Pump Failure: On [XXX] While driving on the highway our 2020 F250 Super Duty Vin # [XXX] experienced a complete and sudden loss of power in the fast lane, creating an extremely dangerous situation. Our safety and the safety of others were at risk due to us merging across 4 lanes in heavy traffic with no power steering and no motor function, parking in a very narrow shoulder area and requiring a tow from the highway. After towing and a diagnostic evaluation, it was determined that the high-pressure fuel pump (HPFP) failed, a known safety concern with a recall issued our truck being built in Kentucky on August 2, 2020 The cost of repairs are around $15,000. This vehicle is housed at a local diesel mechanic, and is available for inspection upon request, and has not been inspected by anyone currently. When will this recall be remedied? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11667426

When shifting into drive the truck will lurch forward, a very hard shift. It also does the same thing in reverse. Several times the if my foot was not pressing very hard on the brake when shifting into drive or reverse the truck would lurch forward several feet. It there was an obstruction or person in front of the truck it would have put them at risk of being hit. While driving on cruise control it is very slow to shift and will skip multiple gears when shifting down when going up a hill. Sometimes also going downhill. This can cause the truck to slow down rapidly without a brake indicator which could cause a rear end collision if there is someone following closely. The truck is only 4.5yrs old and has 60,597miles. Symptoms started about 3-4months earlier when truck was well under 60,000 miles however I was unable to get it to the dealer until 60,597 which puts the truck out of warranty. The dealer was able to reproduce the issues and performed a code reset as well as a reprogram and the issue was not resolved. Dealer tore down the transmission and said one of the clutch packs in the transmission has failed along with several other parts. It is now requiring a full rebuild or replacement. There were no warning lights, alarms or messages. Date below is approximately when symptoms started occurring. I do not yet have my vehicle back so do not have the full report from the dealer. I will submit when I receive my vehicle back.

NHTSA ODI 11663421