What 334 owners told NHTSA about the 2019 Ford Fusion Hev

I have a 2019 Ford Fusion. The bolt holding the steering wheel to the steering shaft has come loose. in May 2018 there was a recall for this same loose steering wheel issue on 2014-2018 versions of the Fusion. There is no loose steering wheel recall for the 2019 Fusion. Ford's remedy for the loose steering wheel was replacing the bolt holding the steering wheel to the steering shaft with a longer bolt on the 2014-2018 Fusions. I would expect the longer bolt was used in production in my 2019 Fusion steering, and that's why it is not recalled. But that longer bolt has also come loose like the older shorter bolts. This would make me suspect the repaired older recalled Fusion steering wheels could eventually come loose again just like my steering wheel did.

NHTSA ODI 11750923

The contact owns a 2019 Ford Fusion Hybrid. The contact stated while driving 30 MPH, the contact became aware that the steering wheel was very loose. No warning light was illuminated. The vehicle was taken to a dealer to be diagnosed; however, the diagnostic result was not provided to the contact. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 90,555.

NHTSA ODI 11656888

The contact owns a 2019 Ford Fusion. The contact stated that while the vehicle was parked under direct sunlight, the control panel on both sides of the steering wheel melted and cracked. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and directed the contact to the NHTSA Hotline for assistance. The failure mileage was unknown.

NHTSA ODI 11580725

Thr steering wheel stopped turning. The car is not old enough to have such problems with power steering failures.

NHTSA ODI 11572521

My car in February of 202: got stuck in park they said it was electrical issue, then months later I ended up with a coolant leak that then combusted my engine. New engine in August of 2023 fast forward to November 2023 my car is doing the same thing it stalled in the road with myself and newborn in the car, lost all speed and now it will not go in drive or reverse just like it did in February of 2023. It’s been in the shop twice and now ongoing it’s third time and I find this to be a severe issue because if my car is going to keep stalling while driving there is no reason to keep fixing this car. I’m aware past fusion’s have been recalled for something of similar problems so it makes me wonder if this should be recalled as well.

NHTSA ODI 11557028

While I drive my steering got stuck and stiffed. Hard to turn the wheels. Luckily when I entered my neighborhood stop the vehicle. Then I got the message from Ford Pass app saying *Electronic power steering control module fault and *collision warning system lost radar signal. If the steering stuck happened in highways while drive possibly life threatening issue

NHTSA ODI 11502472

While driving to work on I35 the a red message popped up on the dash saying "Stop Safely Now" and the engine/hybrid motor instantly completely died. Steering and breaking were almost impossible because I am not a strong person and I was nearly rear ended several times. I had no chance to get to the shoulder and was blocking the lane in the middle of traffic till I was able to get someone to tow it to a side street. Completely unacceptable and very dangerous for the car to die completely like this.

NHTSA ODI 11499349

My Steering wheel is very loose. The steering wheel moves up and down, also the the steering wheel moves left to right. I am afraid to drive my car.

NHTSA ODI 11437013

The contact owns a 2019 Ford Fusion. The contact stated that while operating the vehicle, the steering wheel was loose and would move up and down. Upon inspection, it was discovered that a bolt was unsecured under the steering wheel cover. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 77,000.

NHTSA ODI 11431913

TL* THE CONTACT'S SPOUSE RENTED A 2019 FORD FUSION. WHILE DRIVING APPROXIMATELY 35-40 MPH, THE STEERING SEIZED WITHOUT WARNING. THE DRIVER WAS UNABLE TO MANEUVER THE VEHICLE. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SUSPENSION FRACTURED AND CAUSED THE FRONT DRIVER'S SIDE WHEEL TO MAKE CONTACT WITH THE INNER WHEEL WELL AND SEIZE IN PLACE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FRONT SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. ENTERPRISE RENTAL CAR WAS NOTIFIED OF THE FAILURE AND THE RECOVERY TEAM WAS SCHEDULED TO RETRIEVE THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

NHTSA ODI 11278013