What 207 owners told NHTSA about the 2015 Ford F-350 Super Crew

See attached document for complaint.

NHTSA ODI 11743227

The contact owns a 2015 Ford F-350. The contact stated that the camera was inoperable. At times the camera was blank. No warning lights were illuminated. The contact received the recall notification letter 25V572000 (Back Over Prevention). The vehicle was taken to the local dealer, who confirmed the parts were not available. The vehicle was not diagnosed or repaired. The manufacturer was called, but there was no response. The failure mileage was approximately 50,000.

NHTSA ODI 11735735

The contact owns a 2015 Ford F-350. The contact stated that a certified mechanic had installed a disaster kit on the vehicle to prevent a fuel system failure. The independent mechanic later found metal shavings inside the filter going into the manifold. The independent mechanic recommended that the fuel pump be replaced. The contact was concerned that the replacement of the fuel pump with the same part would be a temporary fix. The vehicle was not yet repaired. The dealer was contacted and advised the contact to take the vehicle in for a diagnostic test. The manufacturer was not contacted. The failure mileage was approximately 81,000.

NHTSA ODI 11723818

The contact owns a 2015 Ford F-350. The contact stated that while in reverse(R), the rearview camera displays a blue screen or a blank screen while in reverse. The contact then received notification of NHTSA Campaign Number: 25V572000(Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was notified of the failure and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time to repair the recall. The manufacturer was notified of the failure and gave the contact the same information as the dealer. The vehicle was not repaired. The failure mileage was approximately 55,000.

NHTSA ODI 11719089

Odometer Fraud. The contact's spouse recently sold a 2015 Ford F-350; however, the spouse still had the vehicle in possession. The contact discovered that there was a mileage discrepancy after viewing the post online. The vehicle was a private sale. At the time of the sale, the mileage was 650,000. Upon checking Facebook Marketplace, the mileage was 120,000.

NHTSA ODI 11716154

The contact owns a 2015 Ford F-350. The contact stated that the rearview camera displayed a black image while in reverse(R). The vehicle was taken to the dealer, where two modules were replaced, and the new modules were reprogrammed at the contact's expense; however, the failure reoccurred approximately two months later. The contact later received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention), and the vehicle was taken to the dealer, where the recall repair was completed. The contact requested reimbursement from the manufacturer and sent supporting documents; however, the manufacturer denied reimbursement because the vehicle was previously repaired due to a rearview camera black image while the recall pertained to a blank image. The failure mileage was approximately 35,576.

NHTSA ODI 11716220

What component or system failed? The Steering and Suspension system failed. Specifically, the front axle hubs, track bar, and U-joints failed, causing a violent loss of steering control known as "Death Wobble." These components are currently available for inspection; however, they were diagnosed as "FAILED" and requiring immediate replacement to make the vehicle safe to drive. How was safety put at risk? The failure caused violent, uncontrollable shaking of the steering wheel and front end at highway speeds. This resulted in a near-total loss of directional control, putting the driver and surrounding traffic at immediate risk of a collision. The defect made the vehicle impossible to steer safely above 45 MPH. Has the problem been confirmed? Yes. The failure was reproduced and confirmed by an independent certified service center, AutoNation Ford Gulf Freeway. Their inspection explicitly diagnosed the front axle hubs, track bar, and U-joints as "FAILED" and unsafe. The repair estimate to correct these safety defects totaled 6,128.09. Has the vehicle been inspected? Yes. It was inspected by AutoNation Ford Gulf Freeway (a certified Ford dealership) immediately following the incident. Were there warning symptoms? The symptoms (violent wobble) appeared immediately after purchasing the vehicle. During the pre-purchase test drive, the selling dealer's agent physically manipulated the steering wheel ("pulled the wheel") to prevent the wobble from occurring, concealing the pre-existing safety defect. The failure manifested fully as soon as the vehicle was driven at highway speeds without the agent's interference. Summary: The vehicle was sold with critical safety components (hubs, track bar) in a "FAILED" state. The selling dealer (AutoNation Ford Corpus Christi) concealed this known safety hazard. The vehicle is currently a roadway hazard until the 6,100 repairs are completed.

NHTSA ODI 11715853

My truck is been having a death wobble for years now. It's scary, I changed tires suspension and I still have the issue.

NHTSA ODI 11710270

The touch screen interface is misaligned and occasionally not working at all. The misalignment means that to activate a button the driver must click somewhere else in the screen than the location where the button is displayed. This offset appears to change infrequently. This cause the driver to have to hunt for the location where the button responds and not pay attention to the road. If the wrong location is touched it may open random menus or start unintended functions, causing additional distractions and requiring multiple screen interactions. The car does not have physical buttons for most functions. On several occasions I found myself drifting out of lane due to this problem.

NHTSA ODI 11695511

The contact owns a 2015 Ford F-350. The contact stated that while reversing, the back-over prevention camera went blank off and on. In addition, the contact stated that occasionally, the back over prevention screen displayed a foggy image. The contact received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention). The vehicle was taken to the dealer; however, the vehicle was not inspected. The contact was informed that an appointment was required and that the vehicle needed to be inspected to confirm the failure. The contact was informed that if the failure was confirmed, the parts would be ordered for the repair to be performed. The contact stated that the recall notification indicated that the back over prevention camera was on recall and needed to be replaced. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11695098

The contact owns a 2015 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V270000 (BACK OVER PREVENTION). However, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, which prevented the driver from safely operating the vehicle. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The approximate failure mileage was 100,000.

NHTSA ODI 11690975

The contact owns a 2015 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V270000 (BACK OVER PREVENTION); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ODI 11686872

The contact owns a 2015 Ford F-350. The contact stated that while driving at an undisclosed speed, the contact became aware that the electronic power steering was not functioning properly, requiring the steering wheel to be manually returned to center after completing a turn. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.

NHTSA ODI 11684506

The contact owns a 2015 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V270000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the rearview camera displayed a black screen while the vehicle was in reverse(R). The contact stated that the failure obstructed the driver's visibility, preventing the driver from safely operating the vehicle. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 70,000. VIN tool confirms parts not available.

NHTSA ODI 11676632

2015 Ford F350 6.7 liter Diesel Turbocharger with only 58,000 miles malfunctioned while accelerating on to freeway without any prior warning indicators or symptoms. Immediately engine acceleration was reduced drastically causing freeway cars to nearly rear end my vehicle and other cars swerving to avoid accident. A message showed up simultaneously while reduced acceleration occured on vehicle’s dash display indicating something to the effect “Reducing Acceleration” and a yellow check engine icon lit up on dash display. I limped the vehicle to the side of Freeway and shut engine off. Upon restarting engine discovered engine and turbo operated properly and was able to drive vehicle to a non-Ford Service Center to be repaired. The Technician could not find anything wrong with the operation of the engine-turbocharger and cleared the trouble code. Drove vehical for approximately 500 miles and the same reduced acceleration problem re-occurred while accelerating on to freeway. Pulled vehicle over to safe area, shut engine off, re-started engine, engine and turbocharger operated properly, drove home and then to Ford Dealership (check engine icon still lit). Discovered vehicle can not be smog tested with this intermittent problem due to check engine icon. My safety, my passengers safety, and others safety while driving on the freeway were put at high risk. The reduced acceleration problem does reoccur. Ford diagnosed the vehicle problem to be a bad turbo with an estimate of $5,100 dollars for removal and replace with new Ford Turbocharger which only has a two year warranty. The repair work is currently in process. I consider this turbocharger to be pre-mature failure and a safety risk! This turbocharger intermittent failure in my opinion should be a mandatory recall and paid 100% by Ford.

NHTSA ODI 11676208

The contact owns a 2015 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V270000 (BACK OVER PREVENTION); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11671909

The contact owns a 2015 Ford F-350. The contact stated that while in reverse, the back over prevention camera displayed a solid black or blue screen, or a severely distorted image. Additionally, the message "Camera Unavailable - Please Contact Your Dealer" was displayed. The contact stated that the failure was intermittent. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the NHTSA Campaign Number: 25V270000 (BACK OVER PREVENTION). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 78,000.

NHTSA ODI 11671931

The contact's wife owns a 2015 Ford F-350. The contact received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that while reversing, the rearview camera image was intermittently distorted or blank. Additionally, the messages “Camera Unavailable” and to “Contact Dealer” were displayed. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 186,000. VIN tool confirms parts not available.

NHTSA ODI 11670582

Rear Camera intermittent failure. I was just notified of the recall, but I'm experiencing the issue. Ford doesn't want to authorize the repair under the recall, even though they sent the notice, and I'm having the problem.

NHTSA ODI 11668807

Brake light failure. Appears that the brake lights were stuck in the illuminated position while the vehicle was not being used. I had to disconnect the batteries to disable the lights.

NHTSA ODI 11668808

My truck started "The Death Wobble" a few years ago. I have replaced shocks, tires and ball joints. The problem recently became almost undriveable on the highway as any small bump at a legal (70 MPH) triggered 5 instances on a trip to and from a destination that was 70 miles away via the interstate. I have ordered additional parts based on internet research to try to fix this issue, however in my research it is clear the is a COMMON issue. Why is this allowed to continue?

NHTSA ODI 11668678

The contact owns a 2015 Ford F-350. The contact stated that while reversing, the back over prevention camera system failed to function as intended. The contact stated that the back over prevention camera system displayed a black screen. The contact turned the back over prevention camera off and proceeded to reverse, and the back over camera system independently reset. The vehicle was taken to the dealer, and the contact was informed that parts were not available. The contact received notification of NHTSA Campaign Number: 25V270000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 218,500. VIN tool confirms parts not available.

NHTSA ODI 11668558

Odometer Fraud. The contact’s son owns a 2015 Ford F-350. The contact’s son purchased the 2015 Ford F-350; however, while attempting to sell the vehicle, it was discovered that there was a mileage discrepancy. The vehicle was a private dealer sale. At the time of purchase, the vehicle mileage was 127,000 and at the time of attempted sale, it was discovered that the mileage was 389,000.

NHTSA ODI 11664332

Odometer Fraud. The contact filed the complaint on behalf of his son. The contact purchased the 2015 Ford F-350 from the dealer on June 14, 2024. The contact stated when the vehicle was purchased from the dealer, the odometer and the odometer disclosure form indicated the mileage was 127,656. The contact stated that the Carfax report indicated that on February 27, 2023, the vehicle was serviced, and the odometer mileage reported at the time was 389,490. In addition, the Carfax report indicated that on April 25, 2024, the vehicle was serviced, and the odometer mileage reported at the time was 96,901. The dealer was made aware of the issue. The manufacturer was made aware of the issue.

NHTSA ODI 11663800

The back up camera on my F350 froze the image on the screen as I was backing up, and I didn’t realize that I had backed into my daughter’s car. I ripped my fender off and wedged my tires up underneath her CRV there was no warning and I didn’t realize there was a recall on it because I hadn’t gotten anything in the mail. I did it my own driveway so I didn’t call the police and I haven’t turned on insurance yet. I wanted to see what I needed to do

NHTSA ODI 11662847