What 119 owners told NHTSA about the 2012 Mini Cooper Countryman

This vin waa not included in a recall however had recall issues it obtained water in the footwell which mini has a recall issue for this and the car was caught on fire it is at the dealership in [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11750905

My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11745835

ELECTRIC SHORT CIRCUIT. The electronic module in the driver side footwell area may short circuit. when I unlock the car or try to start, I hear loud electrical SHORT CIRCUIT noises coming out of the seating area. I am afraid to even unlock the car, and fear car might catch fire.

NHTSA ODI 11739897

The electronic control module in the driver’s side footwell short-circuit, battery and electrical in the car are being drained and car does not work properly and completely drains battery.

NHTSA ODI 11715494

My 2012 mini cooper has a Footwell Module recall and I took it to the dealer and they refused to replace it but they said i could pay to have it replaced even though it was a recall

NHTSA ODI 11645836

Mini BMW is fully aware of an issue with their OC3 detection mat on the passengers side and offered a extended warranty of 10 years/ 100k miles. This is insufficient coverage for a crucial saftey part and has led to a grey market production of occupancy detection mats "emulators" which are being sold online as the only way to have your airbag system "functional".

NHTSA ODI 11628890

My front windshield wipers stopped working suddenly while driving in the rain

NHTSA ODI 11622283

No warning lights have come on and the car is braking on its own. I try to push the gas and it doesn't want to go. The car has around 42k miles on it. I took it to tom bush mini last week, the said the front axle was leaking some fluid, they ordererd the axle, changed all brake pads, changed the brake fluid and said it was good to go, cost about $2300. Got the car back, doing the same thing. Now they said all calipers need to be replaced and the hydro unit dsc needs to be replaced which will cost around $6400 and they can't get the hyro unit dsc or 2 months. If this was the problem why didn't they know last week? It doesn't seem like the car has enough miles to have such a big issues and no part for 2 months. I don't know what to do.

NHTSA ODI 11621018

I went to have my 2012 mini coopers footwell control module replaced because it was recalled. They did not replace it because they said they found no corrosion and then marked my vehicle as the recall being fixed. When I left the dealership my blinkers or highbeans would not turn on as well as my four way flashers either. And that is dangerous. When I got home I took the cover off the footwell control module and found corrosion on the plug for it. There was also 9 codes for that when I scanned the vehicle and now is trying to charge me for a recalled part that they did not replace!

NHTSA ODI 11610271

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.

NHTSA ODI 11609036

We purchased this vehicle used. It is a 2012 Mini Cooper hardtop and was owned by several owners in the Canada, NY and NJ area before being brought to FL and ultimately sold to us. This defect has been known since May, 2023, yet BMW/Mini has done nothing to rectify the problem. The FRM module failed immediately after we got the car which rendered it undriveable because the power windows, power door locks, turn signals and key fob were inoperable. We called BMW/Mini about the vehicle being inoperable and unsafe to drive and were told to take it to a repair facility to get the module replaced, which we did. We had to tow it there because it was not safe to drive. We were told we would be reimbursed for the repairs, since this was in fact a documented safety recall #23V-337 Footwell Control Module-FRM. After paying $759.18 for the repairs, I submitted the invoice and the requested information to BMW/Mini just to have them deny my request for reimbursement because they say after an entire year since the notice that there is no remedy available. This is unacceptable!! I could not drive this car without having this module replaced and I am sure I'm not alone in this situation. BMW/Mini should reimburse me for the repairs they instructed me to get done. They point blank LIED to me by stating the repairs would be reimbursed due to this being a safety recall. This is going to turn into a class action lawsuit because BMW/Mini refuses to accept responsibility for their faulty vehicles! This will be just another lawsuit to add to their collection.

NHTSA ODI 11593727

The clutch has been a problem. The clutch wears out prematurely, causing loss of acceleration, which caused loss of power trying to merge into freeway traffic, which nearly resulted in a collision with a semi. Looking up repair or replacement information, it appears this is a common problem that Mini has, some people were replacing the clutch 3 times before 50,000 miles, and also refusing to honor their warranty, claiming it’s the user fault. I got a quote from Mini Cooper in Tacoma, to replace the clutch, and I was quoted $3400. I paid $12,000 for my Mini Cooper. To change it myself is about impossible due to ‘special’ tools required. I think this is scam set up to get money. It is very unsafe to lose acceleration in places where it’s vital like freeway merging. If people cannot afford to get these these fixed then that’s another safety issue. I’m now stuck figuring out how to get this fixed. Please look into this.

NHTSA ODI 11588255

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that whenever it rained, several unknown warning lights illuminated, and the power windows failed to function as needed. The contact stated that after turning off the vehicle and attempting to restart the vehicle, the vehicle failed to restart. The contact stated that occasionally the battery would become drained and required the vehicle to be jumpstarted. The contact had spoken to a service manager at the local dealer; however, the contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The failure mileage was approximately 142,000. VIN tool confirms parts not available.

NHTSA ODI 11586043

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11579297

On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11577096

There is a recall existing for my car, by VIN mine is not included, however I have the exact same problem. Water in the driver side foot well electrical panel which has caused a fault in the lighting, hazard lights, and battery issue. The car cannot be driven because the hazard lights and daytime running lights will not turn off even with the key out. Running out the battery in the process. The mechanic found water and corrosion inside the electrical housing.

NHTSA ODI 11576223

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at approximately 40 MPH, the vehicle stalled. The vehicle was steered to the side of the road. The vehicle was able to restart after several attempts but had not started since. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ODI 11574533

started with lights not going off once i cut car off, then windshield wipers would come on it's on, then check engine warning lights, check fuel pump and check rear bulbs lights and several other warning lights would stay on, finally it got to it wouldn't crack until after three or four tries, then it started cutting off while driving, then I would have to wait for 30 min. or more, then it would crank back up. now it won't crack at all. I've been waiting on this recall since 5/12/23 recall #23V337. Please advise and Help!!

NHTSA ODI 11574247

i bought the car in august 2023 from carmax they were aware of recall , my car has no headlight, brake lights, door states open when not , windows do not roll down, cannot use alarm, will not lock, smells hot , i spoke with mini cooper and there is no remedy this is my only car i transport my grandchildren to and from school , i lost house due to a fire a yr ago , and lost everything , and see that a fire is at risk. mini cooper says nothing they can do because no remedy, carmax should not of sold this car with a recall .

NHTSA ODI 11573969

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11570113

My car is affected by this recall and I have no turn signals, dash lights, high beams, working windows, security system, or backup sensors. There are also codes thrown which prevents me from renewing my registration due to DEQ test failure. The dealership can’t do anything and BMW North America has done nothing to remedy things.

NHTSA ODI 11566575

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to drive the vehicle, the electrical system warning light illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 54,000.

NHTSA ODI 11554428

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11553722

While traveling on the highway at speed, the forward (retractable) sunroof exploded with no apparent provocation or warning. When the failure occurred there was a loud bang followed by glass forcefully raining down into the front and back seat area of the vehicle. There were no vehicles immediately ahead, and no overpasses or trees from which something could have fallen. The driver immediately slowed but did not swerve and there were no other vehicles close by so there was no secondary incident. The glass from the roof continued to fall on subsequent bumps in the road until all of the loose glass had fallen. The size of the glass pieces varied in size and sharpness greatly, with some pieces being very small clear slivers (causing mild cut to hand when exiting the vehicle). In addition when exiting the vehicle a piece of glass from the sunroof found its way into the driver's seatbelt fastener and as a result can no longer be buckled. The vehicle has not yet been inspected by anyone and is available for inspection on request.

NHTSA ODI 11550092

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to start. Additionally, the display screen was black. The contact stated that several unknown warning lights were illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 137,000. VIN tool confirms parts not available.

NHTSA ODI 11548149