What 119 owners told NHTSA about the 2012 Mini Cooper Countryman

The contact owns a 2012 Mini Cooper. The contact stated that the vehicle failed to start up after several attempts. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed. The contact was informed that water had entered the vehicle from the front passenger’s side footwell, causing damages to the junction box electronics and the footwell module. The contact was also informed that the VIN was not covered under NHTSA Campaign Number: 23V337000 (Electrical System). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 72,308.

NHTSA ODI 11545174

When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.

NHTSA ODI 11542960

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11540056

NHTSA recall 15V-205: OC3 Seat Occupancy Mat is missing other model years. my 2012 R56 was just diagnosed by a garage as having exactly this error. Why isn't NHTSA also recalling the other model years impacted by this safety issue? As the NHTSA must know, this safety issue is impacting many Mini Cooper model years, to the extent that a secondary market for bypass devices has emerged [XXX] ). Additionally, people have reported this safety issue to NHTSA since at least 2019 [XXX] and [XXX] ). Consider this communication as a formal report to the NHTSA of this instance of a safety issue and of the NHTSA inaction in face of this board and well-documented Mini Copper safety issue. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11537671

My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.

NHTSA ODI 11531545

Passenger side airbag light on with no one in seat. The repair shop stated that there is a seat sensor fault code is 93c3(passenger seat occupancy detector). If there is an accident the airbag may not deploy. I was told to by the BMW of Hawaii in Kona that it will cost $2030 for parts and labor.

NHTSA ODI 11531633

Mini coopers have faulty transmission problems, and well mine today it's transmission went out when I had my AC on, the car stalled in the middle of the highway in the middle of the road with oncoming traffic and refused to budge, like seriously this is highly dangerous on the interstate

NHTSA ODI 11526625

The car just randomly caught on fire while off in my driveway. Noticed a weird sound outside looked out and noticed the windshield wipers were going even though the car was off and I hadn't driven it. Opened the door to bellows of smoke coming out. fire department was called and had to rip it apart to get to the fire which was under the steering wheel in the left side

NHTSA ODI 11524794

Our Mini Cooper Countymen S was being towed behind our motorhome. I. saw smoke coming from the car I stopped and the car started to catch on fire. I got out motorhome disconnect just in time before the Mini was consumed by fire, it was a total loss. The Fire Investigator stated he believed the fire started in the right side of the engine compartment.

NHTSA ODI 11489819

I was driving down the road when a light popped onto my dash, it was the airbag/seatbelt light after some research. From what I've read, this will prevent the airbags from activating in case of a crash, and after talking to other MINI owners it is extremely common.

NHTSA ODI 11476707

timing chain failure which caused engine shut down. this is a known problem with other models. It was not recalled but BMW lost a class action lawsuit for the same problem in the same car, different years. They have not updated or repaired the issue. very expensive repair.

NHTSA ODI 11476173

Footwell module is not working due to rear left blinker is not signaling only the front light does work when turning left.

NHTSA ODI 11465066

Passenger side airbag light on with no one in seat, had it checked, the repair shop stated that there is a seat sensor fault, the code is 93c3(passenger seat occupancy detector). I have done some research on this and it seems that this a common problem, but there hasn't been any recalls by Mini, and if there is an accident the airbag may not deploy. I was told to by the dealer that it will cost $2300 for parts and labor.

NHTSA ODI 11458234

The failed component is the "Footwell Relay Module" (FRM) which enables communication between the instrument panel in the passenger compartment and the engine control components in the engine compartment. When this component fails the following essential controls become inoperable: emergency flashers, turn signals, door locks, and windows. Most other "convenience features controlled by the car instrument panel become inoperable as well. This problem was confirmed by an independent technician, a technician at Mini of Stevens Creek in San Jose, CA, and the owner. No inspections of the part were ever done and the FRM failed without warning. This is a common failure in Minis due to a faulty design. The part is insufficiently protected from inrush current surge when a fully-charged battery is reconnected following service. It is also not sufficiently protected from induced voltage surges from EMI such as C, K or Ka band radar or electrical storms. One or more integrated circuits in the part are destroyed when exposed to current or voltage spikes rendering the part inoperable. The cost to replace the FRM (parts & labor) exceeds $1000.

NHTSA ODI 11455359

The contact owned a 2012 Mini Cooper S Countryman. The contact stated while she was at a standstill in traffic, she saw smoke exiting from under the hood. The contact stated no warning light was illuminated. The contact was able to park on the emergency lane and exit the vehicle before the vehicle was engulfed in flames. The contact did not sustain any injuries nor seek medical attention. A police report was filed. The insurance company deemed the vehicle a total loss. The vehicle was towed to a towing lot. The contact spoke to the local dealer and made them aware of the failure. The vehicle was not diagnosed. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 18V248000 (ENGINE AND ENGINE COOLING), however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 180,000.

NHTSA ODI 11440756

The front passenger occupancy detector (or OC3) failed, making the passenger airbags inoperable. This is a common problem with minis and many other models have had the mat warranty extended. The dealer confirmed that the OC3 is bad but wanted $800 just to order the part which is embedded in the seat cushion. Consumers shouldn't have to bear the cost of a defective vital safety component that should last the life of the car.

NHTSA ODI 11428626

This car was maintained, by Mini and BMW authorized mechanics and only had OEM parts installed and followed management of vehicle as directed by manufacturer, throughout its history. It was always driven and kept in moderate weather conditions, no extreme heat, cold, wet, or speeds. Used almost daily for 30-60 minute commutes. Just after 100K miles, total engine failure was suddenly experienced on the freeway, due to combustion in two valves, damaging two cylinders and sudden leaking of the exhaust system under the hood. The manufacturer, BWM, has been shown evidence of malfunctioning of the four cylinder engine and will not show evidence of their grounds for why they will not take responsibility.

NHTSA ODI 11424692

AFTER DRIVING FEW MILES (10) UP HILL OUT THE DEALER MY CHECK ENGINE LIGHT TURN ON. IT’S NOT BLINKING BUY SEEMS LIKE IT’S HALF AWAY ON THE SIGNED ON THE CAR.

NHTSA ODI 11416755

MINI COOPER BASE MODEL WITH 90K MILES HAS SEAT BELT AND AIR BAG WARNING LIGHTS ILLUMINATED. WARNING LIGHTS STARTED INTERMITTENTLY GOING ON AND OFF AND NOW STAY ILLUMINATED CONTINOUSLY WHEN IGNITION IS ON. NO VEHICLE ACCIDENTS OR INCIDENTS TO CAUSE THIS PROBLEM.

NHTSA ODI 11377428

BOUGHT MINI FROM CARVANA A JANUARY 2020 AND HAVE HAD TOO MANY PROBLEMS. CAR OVERHEATED ON 48, HAD 2 NEW CYLINDERS PUT IN, 2 WEEKS LATER, DUE TO MANY NOTABLE PROBLEMS THIS CAR HAS HAD, ALL COOLANT LEAKED OUT AND WAS QUOTED BY MINI DEALERSHIP $9,000 TO FIX A PROBLEM THAT WAS CAUSED BY A RECALL NOT LISTED FOR MY YEAR

NHTSA ODI 11366813

THE PASSENGER AIRBAG WARNING SAFETY LIGHT COMES ON AND STAYS ON WHEN NO-ONE OR SOMEONE IS SITTING IN THE PASSENGER SEAT WITH AND WITHOUT THEIR SEATBELT FASTENED. I SEARCHED ONLINE REGARDING THIS AND FOUND SEVERAL OTHER PEOPLE EXPERIENCING THE SAME ISSUE. SINCE THIS IS POTENTIALLY A SAFETY HAZARD TO A PASSENGER IT MUST BE RECALLED SINCE MULTIPLE MINI COOPERS ARE EXPERIENCING THIS ERROR.

NHTSA ODI 11360812

MY MOTHER WHO OWNS THIS 2012 MINI COOPER HAS SUDDENLY NOW STARTED HAVING ISSUES WITH HER WATER PUMP LEAKING. I TOOK IT TO THE DEALERSHIP AND WAS TREATED WITH THIS RUDE EMPLOYEE BY CHRISTOPHER GUZMAN WHOM HAD A VERY UNPROFESSIONAL AND NO EMPATHY. VERY SHORT WITH RESPONSES AND SARCASM.KEEP IN MIND MY MOTHER IS ELDERLY AND KNOWS NOTHING ABOUT CARS. SO I LOG INTO TO YOUR SITE AND SEE THERE IS A RECALL ON WATER PUMPS BUT MY MOTHER'S IS NOT ONE OF THEM. AND GUESS WHAT HER WARRANTY JUST EXPIRED MARCH 2019. GO FIGURE. SO IF SOMETHING WOULD HAVE HAPPENED TO MY MOTHER BECAUSE OF DEFECTIVE WATER PUMP. AND HOW FUNNY HOW MY MOMS CAR WAS NOT A RECALL. I WOULD QUALIFY FOR THAT ACTION LAWSUIT. HOW DOES A 2012 WATER PUMP JUST GIVE UP WITH VERY LOW MILEAGE 24 000 I WOULD LIKE TO ESCALATE THIS FURTHER AND AN EXPLANATION HOW THIS COULD HAVE HAPPENED!! LOOK AT THE MILAGE!

NHTSA ODI 11291281

THE WATER PUMP IN THE CAR FAILED WITHOUT WARNING OR CHECK ENGINE LIGHT COMING ON, CAUSING IMMEDIATE OVERHEATING AND THE HEAD GASKET ON THE ENGINE TO BLOW. MINI REFUSED TO FIX THE CAR, AS THEY SAID IT WAS OUT OF WARRANTY, DESPITE THE FAULTY WATER PUMP BEING THE CAUSE OF THE OVERHEATING.

NHTSA ODI 11230081

THE PASSENGER SEAT AIR BAG SENSOR MAT IS FAULTY. THIS ISSUE WAS LISTED AS A RECALL ON PREVIOUS MODELS OF MINI COOPERS FROM NHTSA.

NHTSA ODI 11228391

THE VEHICLE STARTS INTERMITTENTLY. THE IMMOBILIZER OF THE VEHICLE DOES NOT DETECT THE PRESENCE OF THEY KEY FOB IN THE SLOT AND THEREFORE WONT START THE VEHICLE. THESE EVENTS HAPPEN INTERMITTENTLY. ONE INSTANCE WAS IN A GASOLINE STATION. I STOP THE ENGINE AND REFUELED. WHEN IT WAS OVER I COULDNT GET THE CAR TO START BECAUSE THER WAS NO RESPONSE FROM THE CAR. I TRIED TO INSERT/EJECT THE KEY FOB IN ITS SLOT AND AFTER COUNTELESS AND MORE THAN THIRTY MINUTES WAS ABLE TO GET IT STARTED. ONE TIME , I WENT GROCERY SHOPPPING AND WHEN I WAS DONE WHEN BACK TO THE CAR AND IT WOULDN'T START. KNOWING THAT THIS HAS BEEN HAPPENING , I DID THE INSERT/EJECT OF KEY FOB IN ITS SLOT COUNTLESS NUMBER OF TIMES. I DID THIS FOR OVER AN HOUR BEFORE I GOT A RESPONSE FROM THE CAR AND GET IT STARTED. MY WIFE IS AFRAID TO DRIVE THIS CAR BECAUSE SHE MAY GET STUCK IN THE MIDDLE OF NOWHERE. IF THERE IS A MEDICAL EMERGENCY AND THIS IS THE ONLY CAR AVAILABLE, IT WOULD BE BETTER OFF TO JUST WAIT FOR THE AMBULANCE THAN ATTEMPT TO BRING THE PERSON NEEDING MEDICAL ATTENTION TO THE HOSPITAL IN THIS CAR BECAUSE YOU MAY GET STUCK IN THE MIDDLE OF NOWHERE. ANY ROAD TRIP THAT WILL GET YOU 100 MILES AWAY FROM YOUR PLACE OR DRIVING AT NIGHT IS A SAFETY RISK BECAUSE YOU MAY RUN OUT OF FUEL AND REFUEL AT A REMOTE GASOLINE STATION BUT THEN YOU CANT GET THE CAR TO START AGAIN.

NHTSA ODI 11222428