What 119 owners told NHTSA about the 2012 Mini Cooper Countryman

This vin waa not included in a recall however had recall issues it obtained water in the footwell which mini has a recall issue for this and the car was caught on fire it is at the dealership in [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11750905

My 2012 MINI Countryman (R60) experienced a complete electrical shutdown and engine failure while operating due to a severe manufacturing defect. Authorized dealership Jackie Cooper MINI of Edmond diagnosed the vehicle under RO# [XXX] and confirmed in writing that the "JBE electronic connectors are heavily corroded" and "The FRM has water/corrosion damage," providing a repair estimate of $4,700 (including a specific $1,055.84 charge to replace the FRM and clean the sunroof drains). Water entering the footwell area through defective, shrinking sunroof drainage structures is the exact identical failure mechanism, component (FRM3 Module), and extreme safety/fire hazard covered under mandatory safety recall NHTSA Campaign 23V-337. However, MINI has improperly excluded the R60 Countryman model from active coverage despite it utilizing the identical electrical infrastructure and drainage engineering layout. Releasing this vehicle into traffic presents a catastrophic risk of a highway vehicle fire or sudden total loss of vehicle control and lighting at high speeds. NHTSA must expand Recall 23V-337 to include the 2012 MINI Countryman to protect consumers from these documented structural water-ingress fires. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11745835

ELECTRIC SHORT CIRCUIT. The electronic module in the driver side footwell area may short circuit. when I unlock the car or try to start, I hear loud electrical SHORT CIRCUIT noises coming out of the seating area. I am afraid to even unlock the car, and fear car might catch fire.

NHTSA ODI 11739897

The electronic control module in the driver’s side footwell short-circuit, battery and electrical in the car are being drained and car does not work properly and completely drains battery.

NHTSA ODI 11715494

My 2012 mini cooper has a Footwell Module recall and I took it to the dealer and they refused to replace it but they said i could pay to have it replaced even though it was a recall

NHTSA ODI 11645836

I went to have my 2012 mini coopers footwell control module replaced because it was recalled. They did not replace it because they said they found no corrosion and then marked my vehicle as the recall being fixed. When I left the dealership my blinkers or highbeans would not turn on as well as my four way flashers either. And that is dangerous. When I got home I took the cover off the footwell control module and found corrosion on the plug for it. There was also 9 codes for that when I scanned the vehicle and now is trying to charge me for a recalled part that they did not replace!

NHTSA ODI 11610271

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at undisclosed speeds, the vehicle stalled. The fuel tank was a third of the way full. The trunk was locking and unlocking continuously while driving or while the vehicle was parked. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical system). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The vehicle was taken to an independent mechanic, who determined that there was a short in the footwell module due to water intrusion. The drain was also clogged in the sunroof. The manufacturer was contacted and opened a case. The failure mileage was approximately 161,818.

NHTSA ODI 11609036

We purchased this vehicle used. It is a 2012 Mini Cooper hardtop and was owned by several owners in the Canada, NY and NJ area before being brought to FL and ultimately sold to us. This defect has been known since May, 2023, yet BMW/Mini has done nothing to rectify the problem. The FRM module failed immediately after we got the car which rendered it undriveable because the power windows, power door locks, turn signals and key fob were inoperable. We called BMW/Mini about the vehicle being inoperable and unsafe to drive and were told to take it to a repair facility to get the module replaced, which we did. We had to tow it there because it was not safe to drive. We were told we would be reimbursed for the repairs, since this was in fact a documented safety recall #23V-337 Footwell Control Module-FRM. After paying $759.18 for the repairs, I submitted the invoice and the requested information to BMW/Mini just to have them deny my request for reimbursement because they say after an entire year since the notice that there is no remedy available. This is unacceptable!! I could not drive this car without having this module replaced and I am sure I'm not alone in this situation. BMW/Mini should reimburse me for the repairs they instructed me to get done. They point blank LIED to me by stating the repairs would be reimbursed due to this being a safety recall. This is going to turn into a class action lawsuit because BMW/Mini refuses to accept responsibility for their faulty vehicles! This will be just another lawsuit to add to their collection.

NHTSA ODI 11593727

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that whenever it rained, several unknown warning lights illuminated, and the power windows failed to function as needed. The contact stated that after turning off the vehicle and attempting to restart the vehicle, the vehicle failed to restart. The contact stated that occasionally the battery would become drained and required the vehicle to be jumpstarted. The contact had spoken to a service manager at the local dealer; however, the contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The failure mileage was approximately 142,000. VIN tool confirms parts not available.

NHTSA ODI 11586043

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11579297

On the evening of [XXX] at approximately [XXX] my 2012 Mini Cooper S all 4 burst into flames. The car was parked in front of my building for 6 days (we don't use the car very much) in front of my building when the all of a sudden the head lights started flashing followed by the car cabin filling with grey smoke then followed by black smoke then there was a flash (spark?) and the entire cabin the became engulfed in flames. All of this has been captured by our building security camera. I reported the incident the following day to Mini/BMW customer care. I've been sharing emails with Thomas Lula who is investigating the "thermal event" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11577096

There is a recall existing for my car, by VIN mine is not included, however I have the exact same problem. Water in the driver side foot well electrical panel which has caused a fault in the lighting, hazard lights, and battery issue. The car cannot be driven because the hazard lights and daytime running lights will not turn off even with the key out. Running out the battery in the process. The mechanic found water and corrosion inside the electrical housing.

NHTSA ODI 11576223

The contact owns a 2012 Mini Cooper Countryman. The contact stated that while driving at approximately 40 MPH, the vehicle stalled. The vehicle was steered to the side of the road. The vehicle was able to restart after several attempts but had not started since. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ODI 11574533

started with lights not going off once i cut car off, then windshield wipers would come on it's on, then check engine warning lights, check fuel pump and check rear bulbs lights and several other warning lights would stay on, finally it got to it wouldn't crack until after three or four tries, then it started cutting off while driving, then I would have to wait for 30 min. or more, then it would crank back up. now it won't crack at all. I've been waiting on this recall since 5/12/23 recall #23V337. Please advise and Help!!

NHTSA ODI 11574247

i bought the car in august 2023 from carmax they were aware of recall , my car has no headlight, brake lights, door states open when not , windows do not roll down, cannot use alarm, will not lock, smells hot , i spoke with mini cooper and there is no remedy this is my only car i transport my grandchildren to and from school , i lost house due to a fire a yr ago , and lost everything , and see that a fire is at risk. mini cooper says nothing they can do because no remedy, carmax should not of sold this car with a recall .

NHTSA ODI 11573969

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11570113

My car is affected by this recall and I have no turn signals, dash lights, high beams, working windows, security system, or backup sensors. There are also codes thrown which prevents me from renewing my registration due to DEQ test failure. The dealership can’t do anything and BMW North America has done nothing to remedy things.

NHTSA ODI 11566575

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to drive the vehicle, the electrical system warning light illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 54,000.

NHTSA ODI 11554428

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11553722

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the vehicle failed to start. Additionally, the display screen was black. The contact stated that several unknown warning lights were illuminated. The dealer was made aware of the failure but confirmed that parts were not yet available. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 137,000. VIN tool confirms parts not available.

NHTSA ODI 11548149

The contact owns a 2012 Mini Cooper. The contact stated that the vehicle failed to start up after several attempts. There was no warning light illuminated. Due to the failure, the vehicle was towed to a dealer where a diagnostic test was performed. The contact was informed that water had entered the vehicle from the front passenger’s side footwell, causing damages to the junction box electronics and the footwell module. The contact was also informed that the VIN was not covered under NHTSA Campaign Number: 23V337000 (Electrical System). The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was 72,308.

NHTSA ODI 11545174

When the vehicle computer detects low voltage all turn signals, lights and instrument cluster immediately fail and do not turn back on. The Foot Well Module (FWM) or Foot Rest Module (FRM) computer becomes corrupt and deletes data from the module. This becomes a major safety hazard as a nighttime failure occurred causing several near accidents due to inability to signal to other vehicles. This is a known issue with Mini and they released an extended service bulletin knowing the factory footrest modules were manufactured incorrectly. Vehicles falling outside the initial warranty period are prone to safety risks when this occurs.

NHTSA ODI 11542960

The contact owns a 2012 Mini Cooper. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11540056

My 2012 Mini Countryman has had failed signal lighting. My dealer has diagnosed the issue as a failed FRM module which I have been informed that NHTSA issued in conjunction with Mini USA a warranty extension to service this module's failure. While as an owner of this car for the past 9 years, I received not notice from Mini. I recently appealed for warranty coverage of this part. Mini USA has denied coverage of my failed FRM module stating the warranty was only good for 10 years from in-service date. My vehicle went in-service 8/12/2012, or ten years and ten months. Mini is adamantly denying good will to replace this part and my car is off the road do to no working turn signals.

NHTSA ODI 11531545

Mini coopers have faulty transmission problems, and well mine today it's transmission went out when I had my AC on, the car stalled in the middle of the highway in the middle of the road with oncoming traffic and refused to budge, like seriously this is highly dangerous on the interstate

NHTSA ODI 11526625