What 67 owners told NHTSA about the 2025 Hyundai Santa Fe Hybrid Hev

The car went from 70 miles an hour to 25 miles an hour all of a sudden on the highway and then would not allow to accelerate afterwards. Battery stopped charging and we had to stop it multiple times to get it to continue to drive no faults or issue on the dashboard.

NHTSA ODI 11745451

The vehicle has gone into a limp mode unexpectedly while driving on the highway at 60+ mph. The first issue was on May 13, 2026. The car immediately stopped driving and went into limp mode and cannot go over 30 mph. It was taken to a service dealer. They could not replicate the problem, therefore the vehicle was given back as undiagnosed. This next incident occurred and almost caused an accident, and that was on June 3, 2026, again driving on the beltway around Maryland. The car went from 70 mph to 30 mph. The vehicle stayed at 25 to 30 mph the entire time. Could not get it to do anything else. Drove cautiously on the side of the road and got to the dealership after driving 30 minutes at 25 mph.

NHTSA ODI 11741876

Sudden loss of power while driving on the interstate (65 MPH) , car would no longer accelerate and slowed down to ~10 MPH. Had to merge onto emergency lane, car struggled to power over 30 MPH. Warning light came up to "Park with engine On to charge battery". Parked car and restarted car and still did not resolve issue. Had to switch the car into "Sport" mode to drive home.

NHTSA ODI 11741466

While driving on the freeway at approx 65mph, the car suddenly starting de-celerating and forced me to pull over to emergency shoulder/lane and try to determine the cause. The car is a "Hybrid" and the dashboard stated to put car in Park and Idle the Engine over 2000rpm to charge up the Battery. ( i still don't know which Battery they were speaking of...Engine Battery or Hybrid Battery) I sat there Idling the Engine for 15 minutes and slowly proceeded to get off the freeway and limped the car back to my home. I then called my selling Hyundai Dealer, as the car was still in warranty, and told them of my sudden problem and asking them what could it be??? They said they did not know until they saw the car and tested it with their computer equipment...please have it towed into their shop. So i did and 2 days later they called to say..NO Computer Codes showed any problem. They could not duplicate problem. I said ..."look on the internet...many people have reported sudden lack of power and limp mode activation....all pointing to the High Pressure GDI Fuel Pump Assy failure". Dealer said ..Oh..thanks we will look into that. 5 hours later Dealer called and said I was right, we replaced the Fuel Pump and come pick up the car. 4 months later and 6,000 miles later car is performing normally. I felt compelled to come forward to discuss this part failure as this incident on the freeway could have turned into a tragedy. Thank you

NHTSA ODI 11741374

My 2025 Hyundai Santa Fe Hybrid AWD was serviced under warranty on 4/22/2026 for a driveability concern after experiencing a loss of power while driving. The service history shows part HY35326-2M500 was replaced. On or about 5/25/2026, the same issue occurred again while driving at highway speed. The vehicle suddenly lost motive power and dropped from approximately 70 mph to approximately 30 to 40 mph, creating a serious safety risk because the vehicle could not maintain speed with surrounding highway traffic. No warning lamps, dashboard messages, or diagnostic codes appeared during the failure. The vehicle is currently at a Hyundai dealership for inspection and repair for the repeat issue and should be available for inspection upon request. The prior dealer record appears to describe the issue generally as a “driveability concern,” but the current repair diagnosis and full repair notes are still pending. It is unknown whether the dealer has reproduced or confirmed the failure during the current visit. I am reporting this as a sudden loss of motive power at highway speed involving the fuel/propulsion system, engine, and/or powertrain.

NHTSA ODI 11740281

Driving home from church this morning, the vehicle experiences a sudden loss of power and the car went into “limp mode”. Even the pedal floored and the engine rpms high, the car would barely go about 25 or 30 mph. A message from the dash board told me to pull over and leave the engine running to charge the EV batteries. The batteries would charge enough for what I thought would get me home but quickly drained leaving repeat the action until I could limp the six miles home with flashers on and cars passing me to get around. No warning lights and no indication there was a problem until it happened leaving me baffled and frustrated. I was just thankful that I wasn’t going faster when it happened. If I had been going faster when this happened, it could have created a major accident. Dangerous! Since this happened on Sunday, the dealer wasn’t open. I hope to get it to the dealer tomorrow to find out what is going on and how to fix it. The car has only 14850 miles on it.

NHTSA ODI 11736908

The contact owns a 2025 Hyundai Santa Fe. The contact stated that while driving approximately 65 MPH, the vehicle unexpectedly decelerated to 25 MPH with a “Vehicle Will Shut Down” warning message displayed. The contact stated that the engine then began to shut down, and although the accelerator pedal was depressed, the vehicle failed to accelerate and stalled. The failure occurred on multiple occasions, requiring the vehicle to be towed each time. The vehicle was towed to the dealer; the vehicle was not diagnosed or repaired and the contact was informed that the failure could not be duplicated. The manufacturer was made aware of the failure and multiple cases were opened, The failure mileage was approximately 3,300.

NHTSA ODI 11736009

Since February 2026 I have had daily incidents of the hybrid system error where the vehicle is only relying on the hybrid battery to move. I've had a few near miss accidents as my car crawls through an intersection. Was almost rear-end after leaving a stop sign and the hybrid system error popped up and the car doesn't accelerate. In order to temporarily fix the system, the car must be shut off and restarted. There is not always a safe place to be pulled over to perform this shut down. It is a driving hazard and not safe to drive. It has been to the shop now a 3rd time with no resolution. I have reached out direct to Hyundai Corporation with my concerns and they have documentation. The car is a 2025 model and has less than 5,000 miles. I fear a serious accident from this system error and Hyundai needs to resolve ASAP.

NHTSA ODI 11733192

I had stopped and put gas in for a full tank. Pulled out onto the Hwy heading towards Houston TX and was accelerating up to speed limit of 50MPH when the warning on the instrument panel displayed HYBRID SYSTEMS DISABLED pull over and stop immediately. Which I did, but I could not accelerate and was losing speed in traffic. I got safely parked and turned the vehicle off. I let the car sit for a few minutes and started it back up. All warnings were gone and the vehicle has performed normally since up to the current mileage of 9374. I took the vehicle to Hyundai today, 4/13/2026 and they hooked it up to the diagnostic system and it showed NOTHING.

NHTSA ODI 11730952

Gas Motor is not engaging to assist electric drivetrain on a hybrid AWD 2025 Santa Fe. This resulted in a dangerous situation crossing a busy road from a stop sign. The Santa Fe rolled into the intersection at the drivers request, but did not accelerate normally (only to a maximum of a few miles per hour) and felt like an eternity to cross the road. Fortunately oncoming drivers from left and right were paying attention and slowed down and in one case honked aggressively to point out we driving badly. Pulling over to the side of the road, turning the vehicle off and then back on again has sometimes made it run normally, but we limited our trips at that point to first getting safely home and then delivering it to the dealer. The 20 mile drive to the dealer required pulling over twice to reset the vehicle so the electric motor would assist. We have had repeated warnings from the onboard system including "Follow up checks required - Engine Management System" and "There may be a problem with the engine management system Contact your Dealer". I will note that we have 11,000 miles and 11 months experience with the vehicle with NO problems. It may not be relevant, but these new faults began 2 days routine service for oil and tire rotation when recall was performed including ECU Software Update for Recall 25-01-028-1. Dealer is uncertain of problem and referring with outside tech assistance from Hyundai but we were told to expect 2 weeks for parts and repair and uncertainty as to whether that would fix it. In the meantime a vehicle with unreliable acceleration and top speed is unsafe and parked. I do note on this NHTSA website 2025 HYUNDAI SANTA FE HYBRID SUV AWD that there are 47 Complaints. 9 relating to this problem all beginning October 2025 and none prior back to the first post of Nov 2024 for this model. Complaints similar to this for engine management and speed and power loss account for 50% of complaints for this vehicle on the NHSTA website since October 2025.

NHTSA ODI 11727705

Vehicle experienced a loss of acceleration while driving. When pressing the accelerator, engine RPM increased significantly but the vehicle did not increase speed. The vehicle felt as though it was stuck in one gear and would not upshift or downshift. The issue was most noticeable while driving uphill, where the vehicle was unable to maintain speed despite full throttle input. This created a safety concern as the vehicle could not accelerate normally in traffic conditions. The problem has been progressively worsening over time. Initially there were mild symptoms, but it has become more severe and frequent, culminating in a near-complete inability to accelerate under load. No warning lights or messages were observed prior to or during the failure (if that’s true—adjust if needed). Vehicle has approximately 28,000 miles. The vehicle is currently at a dealership for inspection and diagnosis, but the issue has not yet been confirmed or resolved at the time of this report.

NHTSA ODI 11726897

Vehicle would not accelerate in high speed zone.

NHTSA ODI 11726542

While driving at highway speeds (59–75 mph), the vehicle suddenly lost propulsion power and entered a reduced-speed “limp mode,” rapidly decelerating and creating a dangerous traffic situation. The dashboard displayed a “Hybrid Power Control Unit” warning along with audible alarms. During the second incident, the vehicle failed to shut off when the engine stop button was pressed. Multiple adult witnesses were in the vehicle on each dangerous traffic situation.

NHTSA ODI 11714689

I was stopped at a red light. When the light turned green, I proceeded to apply the gas and accelerate. I quickly noticed that the vehicle began accelerating at a faster rate than I was intending. The vehicle continued to accelerate without me applying my foot to the gas pedal. Nothing would stop the continued acceleration (application of brake). I crashed into the rear of a vehicle in my lane going approximately 50-60mph (estimate). I am unsure what the issue was that resulted in this crash. In doing some internet searching, it seems it could have something to do with the transition from electric to gas when I was stopped temporarily at the intersection. It could have been a faulty sensor (throttle position) or software glitch. These components have not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps, messages or other symptoms of the problem prior to the failure. The crash resulted in the airbags being deployed, I was taken to the hospital with a likely concussion and moderate injuries to my chest and hand. The vehicle that I rear ended was a [XXX] woman with a [XXX] old in the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11707043

Description of the Problem: I own a 2025 Hyundai Santa Fe Hybrid Limited with approximately 3 months of use. While driving on highway, the vehicle suddenly stalled displaying “Hybrid System Failure-Stop by side”. I had to stop on shoulder and restart, drove it couple of days and it happened again. Engine would not start, leaving the vehicle stuck in EV mode only with no ability to accelerate properly, Vehicle wouldnt go beyond 35mph. The vehicle then stalled and became unsafe to operate on a public road. After restarting, the vehicle displayed a Check Engine Light. Tookk it to the dealer and the dealer reported DTC P1122000, but did not provide clear evidence of an internal system fault. The dealer claimed the event was caused by “20% ethanol in the fuel,” which is inconsistent with U.S. pump labeling laws. When I checked my credit card entries around the time for refuel, all of them are reputed gas stations with nothing lower than "87" gas which is in alignment with car manufacturer's recommendation. This sudden stall created a serious safety hazard, and I am concerned this may be a broader issue with the 2025 Hyundai Santa Fe Hybrid drivetrain, fuel system sensors, or hybrid control module. I am requesting NHTSA to look into whether similar complaints exist, as this failure mode can result in loss of propulsion at speed, putting occupants at risk.

NHTSA ODI 11703527

My 2025 Hyundai Santa Fe Hybrid has experienced repeated, dangerously abrupt power loss while driving at highway speeds, causing the vehicle to go into "limp mode" without any warning or prior indication. This safety hazard occurred on three separate occasions: First Incident: 7/29/25; Mileage: 9,205. Situation: While traveling at 70 MPH on the interstate, the vehicle suddenly decelerated to 35 MPH and entered "limp mode" without any warning lights or notifications. Dealer Repair: Replaced ignition coil assembly (Parts: 27301R1H, 27301-2M417). Second Incident: 8/27/25; Mileage: 12,898 Situation: While accelerating to 65 MPH on the interstate, the same loss of power and abrupt forced deceleration occurred, again with no warning. This sudden loss of speed created a serious safety hazard for me and other drivers. Dealer Repair: Replaced fuel pump & O Ring Assy-High Pressure (Parts: 35326-2M500, 35305-2m414 LH). Third Incident: 9/25/25; Mileage: 14,830. Situation: Traveling at 70 MPH on the interstate, the car abruptly decelerated, again entering limp mode. This caused surrounding vehicles to swerve to avoid rear-ending me, putting myself and others at risk. Dealer Repair: Replaced High Pressure Sensor (3534202M400), Packing Fuel Pump (31115-0W000), and Fuel Pump and Tube Assy (31119-L1400). In all three cases, there was never any warning light, check engine notification, or app alert before the incident. Hyundai and my dealership confirmed and replicated the issue during each repair. I have reported the vehicle to the Texas DMV, Hyundai and the dealer.These recurring “limp mode” incidents have repeatedly jeopardized my safety, my family’s safety, and the safety of the public due to the sudden, unanticipated loss of power at high speeds. Since the underlying issue persists and has required three separate major repairs, I am fearful for my safety while operating this vehicle and believe it constitutes a serious safety defect needing federal investigation.

NHTSA ODI 11692982

Stopped for gas, vehicle started but would not go into gear, engine lights indicated 'Check hybrid system', warning lights shown. 1/2 hr on the phone with dealership to assist. No problem detected when returning to home dealer. Second episode occurred, vehicle at dealer for the past 4 weeks. Episode repeated at dealership yet "no abnormalities are detected with diagnostics ".

NHTSA ODI 11674691

I was on a semi residential-commercial street that turns on to a freeway entrance. I was turning right and unavoidably entered the freeway when the sudden loss of power occurred. The car slowed down to about 20 mph and pressing on the gas medal didn't yield any more power. I immediately pulled over to the emergency lane upon entering freeway to let fast moving vehicles pass me on the left side. I turned off the vehicle and turned it back on. It seemed to turn on as normal so I proceeded to drive home slowly, staying on the slow right lane of the freeway driving under the speed limit until I took my exit to get to my home. All seemed ok until I turned onto residential street near my home. Again the car slowed down suddenly to 20mph and giving it more gas did not make a difference. The time difference between the first and second (recorded) incident was 25 minutes apart, having driven the vehicle only 140 total miles. The dashboard flashed a 20mph speed limit even though I never set those parameters, didn't set cruise control, and I didn't have auto stop or hold buttons engaged. The car simply slowed down to a 20mph speed limit without my input to the vehicle settings.

NHTSA ODI 11664480

Hi Hyundai- my 2025 Santa Fe calligraphy HEV, with around 900 miles wasn’t turning on and only able to start with a jump. After parking, it was unable to maintain a charge to start up again even after driving 1-2 hours. The dealer wasn’t sure why, replaced the 12v battery first and recharged it overnight. Unfortunately it also drained. Finally diagnosed that the hybrid starter generator needed replacing. More bad news, after replacing they discovered what the service manager said was a defective relay pack of some sort had fused. And the kicker is the part is unavailable until January. I am not sure how widespread or rampant this issue is, but I am concerned there might be more or further issues identified.

NHTSA ODI 11626427