What 262 owners told NHTSA about the 2023 Ford Maverick Later Release

I took my vehicle in to have the transmission looked at. The dealership told me that the problem was resolved. While driving down the road the transmission went into park in the middle of a two lane road. When the vehicle came to a complete stop I was stopped in the middle of the lane and the vehicle transmission would not shift out of park. After getting it to another shop where it is currently located I was informed that the transmission needs to be replaced and that this is a problem that they are seeing in several Ford vehicles. I contacted Ford who stated that there are no current recalls for this problem. Obvious safety concerns are not being able to control the vehicle when it shifts to park while driving as well as being stopped in the middle of the roadway where a collision is likely.

NHTSA ODI 11688266

CV axle

NHTSA ODI 11688193

CV axles failed at 30,000 miles, repaired under warranty. Replaced axles have failed again at 60,000 miles, no warranty. No hard driving, simply highway miles. This seems to be common in these vehicles and need to be recalled for defective parts. This has caused me poor fuel mileage, damage to new tires, instability while driving, and possible unknown damage to transaxle.

NHTSA ODI 11683637

I have previously had the backup camera recall repaired/updated the software and it worked fine for awhile. This week I had it freeze up on me and almost cause me to back end to another vehicle

NHTSA ODI 11679520

The contact owns a 2023 Ford Maverick. The contact stated while driving at an undisclosed speed and upon attempting to make a left turn, the steering wheel seized with the “Power Steering Assist Fault” message displayed. The contact was able to pull over on the side of the road. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the steering column was faulty and needed to be replaced. The vehicle was repaired; however, the failure persisted. The contact stated that the failure had also occurred while driving 20 MPH and making a left turn. The vehicle was taken back to the same dealer where it was diagnosed again, and the contact was informed that the steering column was faulty and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 13,600.

NHTSA ODI 11673787

I purchased the 2023 ford maverick xlt with about 12,000 miles in may, right from the start I started having problems with the steering freezing up, almost hit a wall exiting the freeway, a few times it happened close to my house, it happens without warning, the warning "steering assist fault service required"comes up on dashboard , I have gone to the dealer a few times, the first time they said they had taken care of it, but I drove the truck after and later the steering froze up again, I took it in again and they said it was the steering column, it had a internal fault, so I left the vehicle there and next day they called me that the vehicle was ready, so I drove it home which is about eight miles from the dealer, no sooner had I was about to turn in the driveway that the steering froze on me, I borrowed my wife's car and went to the dealer told them what happened and the manager said to take it in again so they could check it , but I told the manager that I couldn't because iam afraid to drive the truck for my safety and other innocent people, so my truck sits in my driveway unable to drive it.

NHTSA ODI 11673144

While driving on the highway at normal speed in normal conditions, I suddenly lost ABS, traction control, downhill assist, hold assist, AdvanceTrac, Cruise control, and a severe reduction of power. The engine went into limp mode and would not rev past 3k RPM. This made driving on the highway very dangerous as I could not keep up speed and risked getting rear-ended. The wrench icon came on, as well as ABS and traction control. Cruise control would not work. Messages appeared stating "Service engine soon", "Service AdvanceTrac", "Downhill assist issue", "Hold assist issue", and a few more I can't recall. Sometimes they go away on its own and the vehicle works fine, sometimes restarting the vehicle clears the issue. The issues will appear randomly, sometimes very soon after starting the car and driving, sometimes 100 miles later.

NHTSA ODI 11671480

I Was backing into my designated parking spot in front of our store and a estranged driver cut me off and parked in two parking spots including the designated parking spot in front of the store and a handicapped parking spot next to the designated parking spot causing me to back into another car illegally parked in a third handicap in front of the store. The passenger side view mirror was clipped and the glass cracked on the passenger side door.

NHTSA ODI 11669210

The contact owns a 2023 Ford Maverick. The contact stated while driving at various speeds and attempting to depress the brake pedal, the brakes made a loud screeching sound and the vehicle surged forward before coming to a complete stop. There was no warning light illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and the contact was advised that the passenger’s side axle was faulty and needed to be replaced. The vehicle was repaired, however the failure persisted. The manufacturer was notified of the failure. The approximate failure mileage was 50,000.

NHTSA ODI 11666056

I bought a pre-owned "Gold Certified" 2023 Ford Maverick from a Ford dealer. The vehicle had around 32,000 or so miles at purchase. Soon after purchase, discovered that while accelerating from around 50-60 mph, the front end of the vehicle started heavily shaking without warning. The vehicle was taken to the Ford dealer who informed us that both front axles needed to be replaced. They informed us that they have seen this issue with other Ford Mavericks. The repairs were covered under warranty, and nobody was injured. This is an unsettling, since I have seen on this website numerous complaints about this same issue. Yet there has not been a TSB or recall to my knowledge.

NHTSA ODI 11660997

Bad CV axles causing vibration while accelerating.

NHTSA ODI 11652687

12 volt battery does not recharge properly. Vehicle is always in deep sleep mode.

NHTSA ODI 11652220

Since new in Sept 2023 this vehicle has suffered from consistent charging problems with the 12 volt battery, it sends "deep sleep" warnings to the Ford App and disables certain safety features. Charging the battery only restores functionality temporarily, driving the car ends up depleting the 12 volt battery over time. It affects all Ford Maverick Hybrids including mine.

NHTSA ODI 11652195

The contact owns a 2023 Ford Maverick. The contact stated that upon unlocking the vehicle remotely, the exterior lights of the vehicle failed to illuminate. Additionally, the contact stated that the cabin lights failed to illuminate upon entering the vehicle, making it difficult to find the ignition switch to start the vehicle at night. Additionally, the contact stated that he had received notification from the Mobile App that certain vehicle functions were disabled due to low battery and to contact the dealer. Additionally, the contact stated that the battery charge displayed 11.4 Volts instead of 12 Volts after charging the battery overnight and for an extended time. The contact stated that while driving 50 MPH and depressing the accelerator pedal, the vehicle lost drive power. There was no warning light illuminated. The contact pulled to the side of the road. The contact stated that upon turning off and restarting the vehicle, the vehicle responded as needed. The vehicle was taken to the dealer, where the vehicle was diagnosed. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Numbers: 25V158000 (Power Train, Electrical System) and 25V019000 (Electrical System); however, the VIN was not included in the recalls. The manufacturer was not notified of the failure. The failure mileage was approximately 7,000.

NHTSA ODI 11649190

The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 40 MPH, the brake warning light illuminated. The contact attempted to depress the brake pedal; however, the brakes failed to stop the vehicle. The contact shifted into neutral and coasted to a patch of grass where the vehicle came to a stop. The vehicle was turned off and after a while and shifted into park and restarted. The contact stated that several unknown warning lights were illuminated. The contact turned off and restarted the vehicle and became aware that the lights were no longer illuminated and continued driving. The dealer was contacted, and it was confirmed there were no recalls on the VIN. The contact stated that approximately 3 months after the first failure, the failure reoccurred while driving approximately 45 MPH, causing the contact to coast onto the off-ramp and a curb while in neutral to stop the vehicle. Several unknown warning lights were illuminated. The contact was able to restart and drive the vehicle to the dealer with the hazard lights activated. The dealer was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case. The failure mileage was approximately 18,000.

NHTSA ODI 11647462

The contact owned a 2023 Ford Maverick. The contact stated that while driving at 45 MPH, another vehicle driving at approximately 20 MPH crashed into the front passenger side. The vehicle came to a stop at a ditch after the crash. There were no warning lights illuminated. The driver’s and passenger’s side air bags did not deploy. There was no property damage. A police report was filed. The contact sustained a rotator cuff tear and a pinched nerve. It is unknown if the other three people in the other vehicle sustained any injuries. The vehicle was towed to an impound lot. The vehicle was deemed a total loss by the insurance company. The manufacturer was not notified of the failure. The dealer was not contacted. The failure mileage was 37,000.

NHTSA ODI 11646990

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. The VIN was not available. VIN tool confirms parts not available.

NHTSA ODI 11646813

I recently reported my Ford maverick for the failure of the front right CV joint/axle at 22k miles. Well when I picked it up from Ford. They notified me that the front left is also bad. And I'm at 23k miles. These are clearly an issue that's happening everywhere.

NHTSA ODI 11646623

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The contact stated that after starting the vehicle, the instrument panel failed to illuminate, and the vehicle was unable to drive forward immediately while the transmission was in drive(D). Additionally, while reversing the vehicle, the rearview camera image was blank. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact also related the failure to NHTSA Campaign Number: 25V123000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was not made aware of the failure. The failure mileage was approximately 9,000. VIN tool confirms parts not available.

NHTSA ODI 11646186

The manufacturer has not corrected the recall in a timely manner. The recall 24V684 was started in September 2024. It is six month later March 2025 and no fix has been identified.

NHTSA ODI 11646313

The contact owns a 2023 Ford Maverick. The contact received notification of NHTSA Campaign Number: 24V684000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while reversing out of the driveway, the back-over prevention camera failed to display an image behind the vehicle. The passenger had to verbally inform the driver of what was behind the vehicle. The dealer was not contacted. The manufacturer was made aware of the issue. The failure mileage was 12,377. VIN tool confirms parts not available.

NHTSA ODI 11646334

Front Left CV Axle replaced at 5000 miles. Same CV axle needs to replaced now at 10287 miles.

NHTSA ODI 11646093

I was driving normally at speed. The truck suddenly lost power. The gas pedal was unresponsive. It took a moment to realize what had happened since the truck showed no indication of an issue. No warnings showed on the dash, the radio was playing as normal. Pressing the gas pedal did nothing. Brakes worked. I was on a road where was I luckily was able to coast into a parking lot and stop safely. I shut off the vehicle and immediately turned it back on. Everything started normally and the vehicle drove normally from that point.

NHTSA ODI 11645521

My backup camera freezes while in reverse, which makes it difficult to gauge my surroundings accurately and has almost caused an accident a number of times now.

NHTSA ODI 11645552

The contact owns a 2023 Ford Maverick. The contact stated while the vehicle was parked, the instrument cluster darkened and became inoperable. No warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the battery needed to be replaced. The vehicle was repaired. The contact researched and was made aware of NHTSA Campaign Number: 25V019000 (Electrical System); however, the VIN was not included in the recall. The manufacturer was not notified of the failure. The failure mileage was 43,740.

NHTSA ODI 11645602