What 24 owners told NHTSA about the 2020 Porsche Macan Gts

Led adaptive headlights of the Porsche macan S. S. Has malfunctioned spontaneously. Cost to replace the headlights is $5,400. This is an $80,000 car. Asked Porsche North America to look into this. There are multiple comments on online of people complaining about LED headlights on the passenger side. Spontaneously going out and having to spend this much money to replace the light. This is a safety measure and people who can't afford it may delay replacing the lights for a prolonged period of time If Porsche decides to put these kind of high-cost replacement items in lower level luxury cars then they need to support. My car has only $66,000 mi on it and it's only 5 years old

NHTSA ODI 11748249

I noticed that my passenger side headlight was out but no warning was given in the dashboard. If I hadn’t noticed that the ‘round the corner’ lights were not working it might have taken me a while to figure it out presenting a safety issue

NHTSA ODI 11738613

Passenger low beam headlight does not work. There is no “fault” message under “exterior lighting” indicating a problem with headlight.

NHTSA ODI 11733439

The contact owns a 2020 Porsche Macan. The contact stated that when the vehicle was started, the passenger’s side headlight failed to illuminate. The vehicle was taken to an independent mechanic, where it was determined that there was a failure with the passenger’s side headlight LED circuit and that the headlight needed to be replaced. The vehicle was not repaired. The vehicle was then taken to a dealer, but it was not diagnosed or repaired; however, the mechanic confirmed the failure. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.

NHTSA ODI 11731323

Passenger side headlamp failure. DRL and HB working. low beam failure. Seems to be a common issue with 2020 model headlamp control module. Safety issue with astronomical repair costs from dealer. Request safety recall.

NHTSA ODI 11730595

Problem Description: The low beam on the passenger side headlight has completely stopped working. Daytime running lights (DRLs) and high beams continue to function normally on the affected side. There are no dashboard warning lights other than the expected “check low beam” message. The vehicle was taken to Valley Imports Porsche in Fargo, ND, on 4/10/2026, where they diagnosed an internal failure of the integrated LED module in the sealed headlight assembly. They quoted approximately 5,000 for a full headlight replacement (no individual bulb or module repair is possible). This is a known recurring issue on 2019–2021 Porsche Macan models. Driving at night without functional low beams creates a significant safety hazard, as high beams alone are not a legal or safe substitute for normal low-beam illumination. Low beams are required under federal motor vehicle safety standards for safe roadway visibility. The failure occurred despite good overall service history. I request that NHTSA review this as a potential safety defect in the headlight system for these model years.

NHTSA ODI 11730478

Passenger side LED headlight low beam failed prematurely. Hi beam and parking lights worked for a few months until they failed. Same issue as reported by many Macan owners. Failure reported on only 1 side of the car appears to be a manufacturer design flaw.

NHTSA ODI 11725683

My passenger headlight low beam went out. And it is a widely known problem with the 2020 year.

NHTSA ODI 11719528

Passenger side head light stop working little over when car is out of the factory warranty at approximately 55,000 miles, to fix is very expensive, over $4000.00 because you cannot just change the bulb the entire unit need to be replaced. This seems to be a common problem with this model.

NHTSA ODI 11709056

There is a common problem with 2020 Porsche Macans that I believe is a Porsche responsibility to fix. This is being reported by many 2020 Porsche Macan owners. The issue: Right Side Low Beam failure. To fix it, you need to replace the entire headlamp assembly (roughly 5k in US dollars). No warning of it failing by a sensor, etc. I believe this is an electrical issue and not a lamp issue. Others have reported the same. Safety issue: Yes, not having proper lighting is a major safety issue. No warning of it failing. No sensor to tell me of issue. Has it been inspected: Yes, I am having a professional repair it - also consulted and reported it to the nearest porsche dealership. Was told by Porsche dealership that this is a known issue but no recall for it from Porsche. I keep my car highly maintained. Did research online - THIS IS A COMMON ISSUE FOR 2020 PORSCHE MACAN AND SHOULD BE RECALLED.

NHTSA ODI 11708887

The 2020 (and possibly 2019) Porsche Macan passenger (right) side headlight (low beam only) is failing. About four months ago the right headlight on my Macan went out and after taking to the dealer, I was informed that the critical headlight failed (the car was less than five years old. Taking the problem to the internet, I found the EXACT problem has occurred to many 2020 Porsche Macans, and seems limited to the right low beam headlight. There are multiple cases reported on Reddit, Macan Forum, Rennlist and other Porsche boards. The dealer informed me that the whole assembly needs to be replaced, which is what all of the posts online stated as well. the cost to replace the assembly if $5,000 ($4,500 part, plus labor). I'd estimate the vehicle is worth $40,000, so one headlight costs more than 10% of the vehicle value (?!?). The dealer seemed to agree with me and checked with Porsche, who acknowledged the problem but said there has not been a recall. A headlight is integral to the safe operation of the vehicle, and the car had no sensor to inform me it was out, and I only found out by a friend telling me. At this stage the vehicle would not pass a safety inspection.

NHTSA ODI 11692442