What 115 owners told NHTSA about the 2017 Lincoln Mkz Hev

I am paying on a 2017 Lincoln MKZ with total engine failure due to coolant leaking into it. I am aware that NHTSA in early October 2023 there was an investigation into more than 700000 late model Ford due to catastrophic engine failure. Why was people not informed on this matter, or a recall established.

NHTSA ODI 11697281

The contact owns a 2017 Lincoln MKZ. The contact stated that upon starting the vehicle, the check engine warning light remained illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the engine had failed due to coolant intrusion. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 74,000.

NHTSA ODI 11678744

Vehicle began to feel as if it was losing the ability to get any power to the engine. I would push the pedal to accelerate but even fully compressed the vehicle would not go above 30mph. I attempted to drive the vehicle in to be inspected at a dealership and while on the way the steering wheel completely locked and an Emergency Light appeared on the dashboard stating "Safely Park Vehicle". It was a Horrifying Experience to be driving In traffic and lose control of the vehicle but luckily I was able to coast the vehicle to the side of the road to safety without crashing! Although the vehicle was fully powered, it would not move and I had to call AAA in order to get the vehicle towed to the closest AAA Approved facility which was AutoWorks Diagnostics & Repair in Kittery, ME. They observed fluids had leaked out but were unable to locate where the leak was coming from and very Loud Noises that appeared to be coming from in between the Engine and Transmission . After researching online they found that there were Two Recalls involving the welds on the Torque Converter detaching from the engine. They also found a recall on the front brake hoses rupturing & leaking brake fluid as well as a Recall with the steering wheel retaining bolt loosening & detaching while driving which could also have contributed to the issues experienced with the vehicle and the safety concerns associated as I was driving in traffic and lost Total Control of the vehicle which could very likely have caused a Major Accident! Unfortunately None of these recalls have been associated with the VIN connected to this vehicle and the manufacturer; Lincoln, to this point has refused to discuss any of the issues having to do with the four recalls being associated to my specific 2017 Lincoln Hybrid Premier 2.0L gas engine with 6 speed transmission although this specific year, make & model has each of these reported recalls.

NHTSA ODI 11678937

When I stop at a stop sign & then turn right, my steering wheel locks up. It does clear up after trying to turn it but I’m stuck in traffic & cannot move because the steering is locked. This happened twice in 4 days. Brought car to dealership & they never heard of this.

NHTSA ODI 11674743

Transmission slipping, side airbags deployed, seatbelt cut, TPMS light on, unsafe to drive.

NHTSA ODI 11674202

I purchased my 2017 Lincoln MKZ Select on November 11, 2024. The vehicle was determined to need a new engine, per Murgado Lincoln of Chicago. They had my car for over 48 days while putting in a new engine. After this was completed the car had to be sent back due to a mistake the mechanics made by not attaching a gasket properly. After this, I began experiencing odd noises underneath the hood and throughout the vehicle; delayed timing belt in both acceleration and deceleration, and so forth. I was then involved in a hit-and-run car accident (not my fault). All side airbags deployed and my passenger side rear wheel is destroyed. I had this car assessed just a few days ago by a certified Auto Care Company who said I needed a completely new transmission and that this car is not street legal at the moment... insurance is not helping me at all.

NHTSA ODI 11673818

At any given time without warning the car will down shift into 4, 3, 2, or 1. It is intermittent but in the last 3 weeks has become very frequent. I have taken it to the dealership. They state that it is the internal clock spring in the the steering column. They have told me that my power train warranty and/or technology extended warranty will honor the replacement, so I looked up possible recalls on this model vehicle and found there is in fact a recall on the steering column internal clock spring but the concern was on the airbag. The issue I am having with the downshifting is going to cause someone to rear end me. There is no pre-warning. I have driven on service roads, the interstate, my neighborhood streets, and on highway. It seems to happen more as I am following the curve of the road, or when I am turning or changing lanes/merging onto interstate. If I am at a complete stop and turn either left or right it will downshift to 1. I am also concerned to the extent of damage this may be doing to my transmission and engine, as it happens during speeds of 45 to 75 mph on the highways and interstate. I do have video on my phone of this behavior and I can send it to you if I have an email address you have access to. I have placed the most current date of this behavior in the incident box, however this has happened numerous times over the past few months, It just wouldn't give a code to any dealerships for diagnosis.

NHTSA ODI 11671573

I am submitting this complaint to formally report that my 2017 Lincoln MKZ experienced engine block damage due to a failed torque converter weld, a known safety defect covered under NHTSA Recall 17V-427 / 18V-390 (Ford campaign 17S16). This recall specifically affects vehicles like mine equipped with a 2.0L gas engine and 6-speed automatic transmission, due to improperly welded torque converter studs. This failure causes loss of power and potential transmission or engine damage—precisely what occurred with my vehicle. When I brought my vehicle to an authorized Lincoln dealership in Alexandria, Virginia, the service department refused to cover the cost of repair, despite the vehicle falling within the recall parameters. Their refusal directly contradicts federal recall law (49 U.S. Code § 30120), which mandates that manufacturers and authorized dealers must remedy safety defects at no cost to the vehicle owner, regardless of ownership history or age. As a result of their denial, I am left with significant out-of-pocket costs for damage that should be addressed under a federally mandated safety recall. This poses both a financial burden and a public safety risk if other owners are similarly turned away. I am requesting that NHTSA: Investigate this dealership’s noncompliance with federal recall obligations. Ensure that Ford Motor Company and its authorized dealers are held accountable for safety-related repairs. Assist in compelling the dealer to honor the recall and reimburse or cover the cost of required repairs.

NHTSA ODI 11666062

The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, the engine seized, with the check engine warning light illuminated. The vehicle was taken to the dealer and the contact was informed that a tune-up was needed. The vehicle was not repaired. The vehicle was taken to an independent mechanic who performed the tune-up. The vehicle was repaired; however, the failure reoccurred. The vehicle was towed to the dealer and was diagnosed with coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 107,500.

NHTSA ODI 11664931

Ford have a Huge problem with the 2.0 ecoboost. Where coolant pass through the cylinder and make engine mix oil and coolant. Ford have a thousand of claim about this and still doesn’t have any solution and they make customer pay everything

NHTSA ODI 11663927

While driving the car in commuter traffic on Route 22 Highway the car transmission stopped working and car bucked and then stopped. Upon getting out of the lane of traffic there was a large amount of transmission fluid on the ground. Car had to be towed as it would not move. Danger was the car stopping on the highway in busy traffic. Upon inspection by car dealer they found it had a broken transmission cooler line . The Lincoln dealer put in a Tube Assembly repair kit and replaced all trans cooler lines at a cost of $ 1,029.72 to me. No Warning lamps or messages came on before the lines broke.

NHTSA ODI 11661398

The contact owns a 2017 Lincoln MKZ Hybrid. The contact stated that while driving 35 MPH, there was an abnormal sound coming from the engine. No warning light was illuminated. The vehicle was taken to a dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 106,800.

NHTSA ODI 11658567

Approximately 2 weeks ago, my 2017 Lincoln MKZ Reserve began sputtering/hesitating during acceleration. On 03/31/2025, I took it to the Heiser Ford-Lincoln in Glendale, WI for service and the diagnosis was I needed to replace my “engine long block” because of engine coolant leaking into the engine cylinders. I was given at an estimated cost of $8,000. I researched and found Technical Service Bulletin 22-2229 listing this issue as a not-so-uncommon problem with Ford’s 2.0 Liter engines. I am highly concerned that this could cause the engine to seize while driving with coolant compromising the viscosity of the engine oil. I firmly believe this should be elevated to a Recall status as this engine is used in several 2017 through 2019 Ford and Lincoln car models - and the occurrence has been frequent enough to have a TSB created.

NHTSA ODI 11652407

The contact owns a 2017 Lincoln MKZ. The contact stated that after starting the vehicle, while the vehicle was idling, the vehicle was shaking and vibrating abnormally. Additionally, after shifting to drive, the vehicle erroneously lunged forward, and while shifting into reverse the vehicle jerked backwards. The vehicle was taken to the local dealer who diagnosed that the torque converter and engine were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in NHTSA Campaign Number: 18V390000 (POWER TRAIN). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 100,000.

NHTSA ODI 11651990

I have purchased a used 2017 Lincoln MKZ Reserve 2.0l in August of 2023 that started losing coolant and smoking from exhaust. Upon further investigation the coolant was noticed in the cylinder 2 through the spark plug opening. I had changed the head gasket and noticed the slotted coolant journals between the cylinders which was clear this was where the coolant was leaking from. After replacing the cylinder head gasket it run fine for about another month before starting to have same issues of losing coolant and smoking from exhaust, coolant was observed in cylinders 2 and 3. Ford recommended replacing the engine to the new design engine that eliminated the slots, this would be at Customer cost. Engine cost was $2,618.67 in March of 2024 just to purchase the engine, i replaced the engine myself. Vehicle was at 58,735 miles but warranty was out of date. 

NHTSA ODI 11651649

dashboard showing Check engine light. Car hesitating, running very rough. Not driveable. Dealership diagnosed problem as coolant leaking into cylinder requiring engine replacement to fix the issue. Cost for Dealer to Diagnose problem $254.00. Cost to repair Estimate ...$7,700 + Taxes & Fees. Dealer states no assistance from Ford/Lincoln available as vehicle is out of warranty. TSB was issued June 26 2019 regarding this problem related to 2017-2019 Model Years MKZ with 2.0 L Ecoboost engine. Although there are many, many reports of this problem being a widespread issue, to date, nothing has been done to remediate the problem for owners experiencing this issue. Many other Ecoboost engines have been recalled for issues relating to failure.

NHTSA ODI 11645965

I have a 2017 Lincoln MKZ; coolant is leaking into the engine block; have to replace the entire engine. Car has 82K miles on it. Bad thing is that my daughter's Ford Fusion (2017) had the same problem just two months. I had to replace the engine in her car. It is clear that Ford/Lincoln has this problem, Stories on the internet. Ford did issue a recall but just for the 1.5 Liter car; both of mine were 2.0 liter. These engines should be recalled - should not be happening. Daughters car just has 45K miles on it.

NHTSA ODI 11640428

Vehicles Navigation fails to keep accurate information - offsetting by 2-3 miles of actual location, and SYNC display fails to work properly after Reverse Camera is engaged, completely freezing for 5 - 15 minutes.

NHTSA ODI 11636989

On Jan. 10, 2025 all the brake fluid leaked out of my MKZ. Fortunately, this occurred a few miles from my home and was able to get the car into the drive. I was first alerted of the problem by the "low brake fluid" message on the dash panel and virtually no braking power. On 1/13/25 I had the car towed to a local Ford Dealer and was informed that the brake lines to both rear wheels were indeed severely rusted thru and had to be replaced. (Approx. 117K mi) (The front hoses were also replaced as per a recall notice on 9/26/23.)

NHTSA ODI 11636641

The contact owns a 2017 Lincoln MKZ. The contact stated that while driving at various speeds, the temperature gauge would indicate that the vehicle was hot(H). In addition, the vehicle would lose power upon depression of the accelerator pedal. The vehicle was taken to a dealer where they replaced the engine under warranty. After the engine was replaced, the contact experienced an engine oil leak which was also repaired under warranty. Almost a year later, the check engine light appeared on the instrument panel; this time, the vehicle was taken to another dealer(Planet Ford Dallas-3333 Inwood Rd, Dallas, TX 75235). The contact was later informed by the dealer that coolant had leaked into the engine which resulted in engine failure. The manufacturer was notified of the failure. The failure mileage was approximately 103,000.

NHTSA ODI 11635258

There was a recall for a loose steering wheel bolt . The recall was repaired at the dealership but now the steering wheel is loose again. I feel like this issue is grounds for a second recall. Not sure what is going on . Please advise before something bad happens

NHTSA ODI 11630323

The contact owns a 2017 Lincoln MKZ The contact stated while driving 35MPH, the check engine light illuminated. The vehicle was taken to the dealer where it was diagnosed that coolant was in the number two cylinder and the engine needed to be replaced. The vehicle was not repaired. The contact was relating the failure to TECHNICAL SERVICE BULLETIN 19-2172 (Coolant In Cylinders, White Exhaust Smoke, And/or Illuminated MIL)  however the VIN was not included in the service bulletin. The manufacturer was notified of the failure and offered no assistance informing the contact that the VIN was not included in the service bulletin. The failure mileage was 7,500.

NHTSA ODI 11625492

The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11623511

The contact owns a 2017 Lincoln MKZ. The contact stated while driving at an undisclosed speed, there was a whining sound coming from under the hood. The vehicle was driven to the residence. The contact stated that on the following day, the vehicle was started; however, while driving 30 MPH, the accelerator pedal was depressed but the vehicle failed to accelerate as intended. The contact stated that the vehicle failed to exceed 30 MPH. The vehicle was driven to the place of employment. The contact stated that after work, the vehicle was started, and the accelerator pedal was depressed; however, the vehicle failed to accelerate as needed. The vehicle was driven to the residence. The contact stated that on the following day, the vehicle was started; however, the vehicle failed to move forward. The contact stated that the vehicle instead rolled backward. In addition, the contact stated that the vehicle became undrivable. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact referenced NHTSA Campaign Number: 18V390000 (Power Train); however, the VIN was not included in the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 127,000.

NHTSA ODI 11622794

Loose steering wheel issues as described in existing recall Safety Recall 18S08 Dealer repaired at a cost, and was informed that the vehicle was not eligible for the recall. Bolt replaced and retorqued to sped. Service performed by Fiesta Lincoln 1720 S Mesa Dr, Mesa, AZ 85210 on 10/21/2024 with approx cost of $240 (final invoice not available at this time.)

NHTSA ODI 11621049