What 115 owners told NHTSA about the 2017 Lincoln Mkz Hev

Factory Rim cracked causing tire to not stay inflated

NHTSA ODI 11620751

The contact owns a 2017 Lincoln MKZ Hybrid. The contact stated that while attempting to replace all four tires, the contact became aware that the lug nuts were swollen. The vehicle was taken to the dealer, who informed the contact that the lug nuts needed to be heated to remove from the wheel studs. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000.

NHTSA ODI 11533667

Lugnuts are stripped and swollen at only 60k miles. An improperly seated lug nut could result in the tire coming off at high rate of speeds posing a safety hazard. The dealer found and confirmed the swollen and stripped lug nuts. Lincoln dealer is the only entity who has serviced the vehicle while in my possession. After speaking with advisor, they said this is a common problem - indicating Lincoln is aware of the issue. After researching, MANY Ford and Lincoln owners are filing complaints, and lawsuits over this issue and Ford is denying them. This indicates Ford and Lincoln are aware of the problem. Part was inspected by the manufacturer, Lincoln. No warning lamp, message, or symptom indicating the problem. Last service appointment (approx 5100) miles ago did not indicate any issue with the lug nuts.

NHTSA ODI 11452150

After a year with the purchasing dealer we are still having on-going electrical issues with the vehicle. Apple Sync, voice control. Still have issues with rims pitting after only less than 10,000 miles on the vehicle. Bolt rusting on under carriage. Film on back window. Lincoln Corporate has been following this case for a year now and my rep is Mr. Dehane Davis. This file is still open at Lincoln Corporate.

NHTSA ODI 11451750

I went to the dealer for a tire rotation and could not do it because they said I had swollen lug nuts , they are not covered on my extended warranty

NHTSA ODI 11447792

TL* THE CONTACT OWNS A 2017 LINCOLN MKZ. WHILE DRIVING 25 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE PULLED TO THE RIGHT OR LEFT INTERMITTENTLY WITHOUT WARNING. THE VEHICLE WAS TAKEN TO GRAND LEDGE FORD LINCOLN (6080 E SAGINAW HWY, GRAND LEDGE, MI 48837, (517) 627-8100) WHERE IT WAS TEST DRIVEN. THE DEALER DID NOT FIND ANY FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO LAFONTAINE FORD OF LANSING (5103 S CEDAR ST, LANSING, MI 48911, (517) 394-7000) WHERE IT WAS TEST DRIVEN. THE DEALER CONFIRMED THAT THE ALIGNMENT WAS UNEVEN. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED MULTIPLE TIMES. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V167000(STEERING). THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND PROVIDED CASE NUMBER: 24864137. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000.

NHTSA ODI 11279778