What 286 owners told NHTSA about the 2016 Ford F-250 Supercab

AT 42000 MILES I STARTED TO EXPERIENCE WHAT IS KNOWN AS THE DEATH WOBBLE WHEN I HIT A ROUGH PATCH IN THE ROAD. TOOK THE TRUCK TO THE LOCAL DEALER AND THEY HAD IT FOR A WEEK AND TOLD ME THE COULDN'T FIND AN ISSUE. ISSUE IS GETTING PROGRESSIVELY WORSE AND OCCURING MORE FREQUENTLY.

NHTSA ODI 11267902

WHILE TRAVELING 65MPH IN A POSTED 65MPH ZONE, I DROVE OVER UNEVEN PAVEMENT. THIS CAUSED THE STEERING WHEEL AND VEHICLE TO VIOLENTLY SHAKE. SO SEVERE WAS THE SHAKING THAT MY COFFEE CUP SHOOK OUT OF THE SNUG CUP HOLDER IT WAS IN, THE OVERHEAD SUNGLASS STORAGE COMPARTMENT CAME OPEN AND THE PASSENGER-SIDE SUN VISOR CAME DOWN. WHEN I APPLIED THE BRAKES, THE SHAKING BECAME WORSE AND I COULD NOT CONTROL THE VEHICLE. ONLY WHEN I DECELERATED WITHOUT BRAKING DID THE SHAKING STOP, AT ABOUT 35MPH. THIS WAS EXTREMELY TERRIFYING, SO MUCH SO THAT A FELLOW MOTORIST, WHO WITNESSED THE ORDEAL, STOPPED BEHIND ME ON THE SHOULDER TO MAKE SURE I WAS OKAY.

NHTSA ODI 11265497

THIS TRUCK STARTING DOING THE DEATH WOBBLE AT ABOUT 50 MPH. RAN OVER SOME RUMBLE STRIPS APPROACHING A STOP SIGN AND THE WHEELS SHOOK VIOLENTLY. PUT NEW DRAG LINK, TIE ROD AND STEERING DAMPNER, STILL DID IT. PUT NEW TRACKBAR AND BALL JOINT, BUSHING AND HAD ALIGNMENT STILL DOING IT. IT IS AT DEALER NOW REPLACING TRACK BAR BALL JOINT, SHOCKS AND HAVING ALIGNMENT SHIMMED. TOTAL COST ABOUT 3500.

NHTSA ODI 11246732

WHEN DRIVING ON ROAD/INTERSTATE OVER 60 MPH AND HIT A ROUGH SPOT IN THE ROAD THE FRONT END SHAKES VIOLENTLY. ALMOST LOOSING CONTROL OF THE VEHICLE. THIS HAPPENS VERY OFTEN. SHAKES SO BAD YOU NEED TO SLOW DOWN TO ABOUT 30 MPH BEFORE IT STOPS. NOT SAFE.

NHTSA ODI 11244056

WITH 37K MILES ON MY VEHICLE AND ALL MAINTENANCE PERFORMED AND FOLLOWED BY DEALER, I WAS DRIVING DOWN HIGHWAY AT 70 MPH HAULING A 13K LB 5TH WHEEL RV WHEN SUDDENLY TRUCK AND STEERING STARTED TO SHAKE VIOLENTLY. WITH A HEAVY LOAD ATTACHED I BRAKED AND SLOWED VEHICLE TO 50 MPH TO STOP SHAKING. I WAS 200 MILES FROM NEAREST FORD DEALER IN EL PASO AND DROVE TRUCK AND RV THERE FOR IMMEDIATE SERVICE. INTERNET RESEARCH SHOWS THIS CONDITION IS COMMON WITH F250 TRUCKS EVEN UNDER 10K MILES! THIS IS A VERY DANGEROUS AND LIFE THREATENING EPISODE ESPECIALLY AT HIGHWAY SPEED. THERE IS A FORD TSA WHICH DESCRIBES THIS PROBLEM.

NHTSA ODI 11219457

DEATH WOBBLE- 2016 FORD F-250 IS EXPERIENCING THE DEATH WOBBLE AT SPEEDS ABOVE 60MPH. THIS IS A CONTINUING PROBLEM, THE SERVICE MANAGER AT MY LOCAL DEALERSHIP STATED THERE IS NO TSB FROM FORD RECOGNIZING THE 2016 HAS A PROBLEM WITH THE DEATH WOBBLE. THE DEALERSHIP HAS REPLACED THE PARTS IN THE FRONT END THAT FORD SAYS TO ON MODELS THAT EXPERIENCE THE SAME ISSUE. THIS HAS NOT FIXED THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE WITH ALL THESE VEHICLE AND FORD KNOWS ABOUT THIS ISSUE AND HAS NOT DONE ANYTHING TO HELP THE CONSUMER. I HAVE SPENT OVER $2000 TO FIX THIS AND IT'S NOT FIXED YET.

NHTSA ODI 11206903

AT 82000 MILES HAD A SHIMMING IN THE FRONT END OCCUR. WAS NOT ALWAYS PRESENT WHILE DRIVING BUT AT TIMES THE STEERING WHEEL WOULD START SHAKING MAKING IT HARD TO MAINTAIN IN THE ROAD.

NHTSA ODI 11191422

VEHICLE HAS A HOPPING THAT OCCURS AT SPEEDS OF 40-80 MPH, HAVE TRIED SEVERAL REMEDIES, NONE OF WHICH WORK. HOPPING SENSATION IS SO SEVERE THAT I WOULD BE WORRIED TO PUT CHILDREN IN THE BACK SEAT OF THE VEHICLE. MANUFACTURER IS AWARE OF THE PROBLEM, HAS A TSB IN AN ATTEMPT TO REMEDY THE PROBLEM. THE MANUFACTURER NUMBER OF THE TSB IS 16-0087. MANUFACTURER CLAIMS ISSUE IS CAUSED BY FRAME FLEX. NO KNOWN FIX FOR THE ISSUE. ENGINE ALSO HAS A CONSISTENT ISSUE OF PUTTING DIESEL FUEL INTO THE ENGINE OIL, MANUFACTURER ALSO CLAIMS THIS ISSUE IS "NORMAL"

NHTSA ODI 11123364

VEHICLE EXPERIENCES SEVERE BOUNCE BETWEEN 70-75 MPH. FORD HAS CONFIRMED ISSUE AND HAS STATED IT IS A "CHARACTERISTIC OF THE VEHICLE". ISSUE WAS REPORTED TO DEALER AND FORD AT TIME OF PURCHASE. BOUNCE IS VERY PRONOUNCED AND VEHICLE IS NOT SAFE DURING OPERATION.

NHTSA ODI 11014734

I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN TWICE WITHIN 10 MILES OF EACH OTHER MY TRUCK STARTED VIOLENTLY SHAKING ALOST SENDING ME INTO ANOTHER LANE AND LOSING CONTROL. HAD TO SLOW DOWN ALMOST TO A STOP BEFORE IT WOULD QUIT. *TR

NHTSA ODI 10920115

TL* THE CONTACT OWNS A 2016 FORD F-250. WHILE DRIVING 40 MPH, THE VEHICLE BEGAN TO BOUNCE UP AND DOWN. AT 70 MPH, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 17,000. UPDATE 01/05/2017*CT

NHTSA ODI 10916472