What 1,037 owners told NHTSA about the 2016 Ford Escape Gas

The contact owns a 2016 Ford Escape. The contact stated that while revering in a parking area at low speeds, the vehicle suddenly lost all motive power, and the contact was unable to shift the gear selector. As a result, the vehicle rolled into a busy intersection. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission shifter cable. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V413000 (Power Train), and the VIN was included but had already been repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA hotline for assistance. The failure mileage was 184,000.

NHTSA ODI 11578494

The contact owns a 2016 Ford Escape. The contact stated while driving 65 MPH, the vehicle shuddered and stalled. The contact was able to pull to the side of the road. The contact was able to restart the vehicle; however, the vehicle failed to move upon depressing the accelerator pedal. The message "Insufficient Transmission Fluid. Service Now" was displayed. The vehicle was towed to the dealer, where it was diagnosed that the torque converter had failed, and the transmission fluid was leaking. The dealer determined that the transmission needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 22V413000 (Power Train). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was 159,834.

NHTSA ODI 11577619

Out of the blue on highway. Tachometer reved up to 6 without using throttle. No power, then it jumped out of gear to neutral down a hill. I almost got hit by a truck , no dash lights came on till I called fot help and my husband drove to a safe area and ford escape reared up in air . Then transmission default light came on . A guy put transmission module in to it and it didn't work. So this is not right if it was recalled and now it is doing the issue later

NHTSA ODI 11576915

The contact owns a 2016 Ford Escape. The contact stated that while the vehicle was in for routine maintenance, the mechanic discovered fluid leaking from the rear of the vehicle. The vehicle was examined, and the contact was informed that the rear differential unit was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 34,573.

NHTSA ODI 11574076

The contact owns a 2016 Ford Escape. The contact stated while driving approximately 70 MPH, the vehicle started losing motive power. The contact depressed the accelerator pedal, but the vehicle failed to respond as designed. The contact stated no warning light was illuminated. The contact was able to pull over when the vehicle stalled. The contact was unable to restart the vehicle and had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was 101,224.

NHTSA ODI 11565752

Driving the car with no signs at all, car instantly drops rpm’s and won’t accelerate at a busy intersection. Warning for transmission faulty or engine issues did not come on at all. Car was driving normal and then stopped as clutch started slipping. Confirmed with dealership that transmission is out. The car stopped in traffic.

NHTSA ODI 11564487

This wasn’t an accident. Over Christmas weekend, my vehicle’s transmission would no longer shift gears correctly. After being told I was looking at thousands of dollars to repair, I decided to sell it. When I listed it on AutoTrader, I discovered a recall from 2022 FOR EXACTLY THE PART OF MY TRANSMISSION THAT MIGHT BE BROKEN. If Ford was supposed to notify me of this in 2022, they certainly did not. So now here I am with a vehicle that doesn’t move.

NHTSA ODI 11563904

I am the original owner of this vehicle. I bought it brand new in 2016 and had all service done by Ford Dealership. I was told to have transmission flushed and serviced at 80,000 miles which I did. I was never advised to have anything done to the transmission before 80,000 miles. On 12/06/2023 with absolutely zero lights on the dash I went to put the car in reverse and it didn’t move. I had the car towed with 121,000 miles to a transmission shop where it cost $5,121.79 to have the transmission REBUILT! Again never had a check engine, service transmission not a single light or anything on the dash. I know nothing will get done but I have driven cars reach 200,000 miles with zero transmission problems. I see this is clearly a common problem with Fords across the board but it would have been nice to have been told by Ford to service the transmission every 30,000 miles as I have now been advised by the mechanic who rebuilt my transmission. Just disappointing this is my first Ford and I love this car it’s just really disappointing to have no indication that the transmission needed service BEFORE it shit the bed!

NHTSA ODI 11562325

When driving the car at interstate speeds the transmission overheats after just a few minutes. When this happens it triggers the car’s information system to send a message stating “Transmission Fault Service Engine Now.” Just a moment or two later it sends another message stating “Speeds Reduced To Lower Engine Temperature.” Once that message is received you no longer have any throttle control and speed will continue to decline, speed dropped from 70 mph to 30 is maybe an minute, until you pull over and let the transmission cool down. This is especially hazardous on the interstate if your in faster moving traffic with cars behind you and you can no longer accelerate with no way to signal this to the traffic behind you except the four ways. The problem seems to be the fan to cool the transmission never gets the signal to turn on and cool down the transmission. This is an ongoing issue with this vehicle and has been since I got it, there are also multiple site and forums full of this same year make and model having the same issue.

NHTSA ODI 11561730

The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, the rear wheels failed to roll and were dragging. Additionally, there was an abnormal popping sound heard. The contact pulled over to the side of the road after each failure. The contact stated that the vehicle was towed several times. The contact stated that the front and rear axles had been replaced by an independent mechanic; however, the failure persisted. The vehicle was towed to an independent mechanic, where it was diagnosed that the rear differential had failed and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.

NHTSA ODI 11559869

On November 14th, 2023, a red alert appeared on the dash that indicated an engine temperature warning indicating that there was a high temperature warning and that I should find a safe place to pull over and immediately stop the vehicle. The temperature indicator on the dash showed the needle move instantly into the red/high area and then drop down. This happened twice, back-to-back. I checked the coolant and it was below the minimum level indicator as shown on the reservoir. A day later, the service engine light illuminated. I took the vehicle to Advanced Auto and asked to pull the service code and was told there were two, P0303 and P0304 which indicated a cylinder three misfire and cylinder four misfire. I noted that the coolant was also low once again despite seeing no fluid on the ground after allowing the vehicle to run. Bill Collins Ford inspected the misfires and coolant and found the issue to be related to a flaw in the engine design which allows coolant to leak into the cylinders. I was told this could have allowed the vehicle to overheat and catch on fire as well as causing the engine to lock up while in operation. Bill Collins Ford provided an estimate of $13,000 to repair the vehicle stating it required a new engine. I purchased this vehicle used from CarMax on August 2, 2023 and have put less than 3,000 miles on it before experiencing this issue.

NHTSA ODI 11556980

The contact owns a 2016 Ford Escape. The contact stated while driving approximately 55 MPH, the transmission inadvertently downshifted to a lower gear. The contact stated that the gear shifter became inoperable. The check engine and electronic throttle control system warning lights illuminated. The vehicle was taken to a dealer where it was diagnosed that the motor mounts and transmission bushing cable needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 94,000.

NHTSA ODI 11555451

The contact owns a 2016 Ford Escape. The contact stated that while his daughter was at a stop light and attempting to accelerate, the vehicle failed to move forward. There were no warning lights illuminated. The vehicle was towed to an independent mechanic, but the vehicle was not repaired. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact called three transmission specialists and was made aware of other vehicles with the same failure. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The approximate failure mileage was 120,000.

NHTSA ODI 11554820

The transmission went out suddenly while driving. My safety was at risk since it suddenly went out while the vehicle was in motion on a typically busy road. I had to pull over with my hazards on hoping no one would hit me.The car was taken to a local dealer where they determined there were metal shavings in the transmission and it needed to be replaced. A warning came up on the screen but when it came up it was determined that the cause was not need to fix immediately and did not relate to the transmission.

NHTSA ODI 11553862

The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the vehicle lost motive power. An unknown warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 87,277.

NHTSA ODI 11553474

Randomly on10/26/23 my car started shaking while in the drive mode at a stop light. When I took off from the light the car stalled. This continued to happen all the way to my job. When I realized it would not shake when it was in neutral at a stop I would just do that. The stalls would continue. Next after one of the shake a wrench light came on saying "Engine Fault service now" I got to my destination. At lunch I went to take my car to Bobby and Erick at W.B Motors in Fairfax VA for a diagnostic thinking maybe a coil issue. I also noticed the wrench light was gone. No further lights ever came on. The evaluation from the shop was: "No codes or pending codes stored in the engine or transmission. The misfire counter shows zero misfires. Found engine idles very rough in gear. The actual slip RPMS under transmission data is less than 500 while desired is around 1000rpms. We believe the torque converter clutch may be sticking" They referred me to High Tech Transmissions. I called and spoke to a Gary before driving there. They could not get me in. Gary spoke to Bobby about the issue. I got back on the phone with Gary. He explained that I would have to leave the car. My only car had to get home. Here is where my complaint is. Gary said that he had 4 other ESCAPES IN his SHOP with the SAME issue. Being a female I didn't get into did he figure those out. I was so upset about mine. BUT 4 others. So I dropped it off at a ford dealer near my home for further diagnostic. That manager told me he has an ESCAPE with the same issue. I am guessing this isn't just an isolated problem. I will know more today on the exact issue. I feel this should be looked into. Was just confirmed I need a torque converter , valve body and solenoid.

NHTSA ODI 11552181

When travelling on a surface roadway, we received a transmission failure warning. We were able to get to a safe area at reduced speed. I feel that if this had happened while on a freeway, our lives could have been jeopardized. The Ford tech said that the transmission needed to be replaced. The torque converter failed. The transmission has been replaced. I don't know where the failed component is now

NHTSA ODI 11550198

My vehicle has 57 thousand miles bought it at Ford Dealership with 48k miles and already having transmission issues. Tow truck driver who picked my vehicle up claimed “Every Ford escape i pick up for a tow is always a transmission issue” Horrible car, Waste of money.

NHTSA ODI 11550014

I was driving home in 2016 Ford Escape and I noticed the RPM's getting higher and higher, but car's speed was actually declining. All maintenance work has been done at Maxwell d in Austin TX. Never had any problems with the transmission and no warning lights, nothing. Until this day....Transmission fault, Service Soon. I was close to being home, so somehow I made it. Be then, everybody wanted know what was going on so did i. I called the dealership, talked to Andrew and made arrangements for car to be towed to Ford on Tuesday, October 3rd. They finally looked at it the car on Monday the 9th....new transmission and labor, almost $8,000. I can not afford that. Having it towed to another repair shop. Getting an estimate from second shop. Why is this not a recall. It should be. Call me [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11549101

Transition suddenly failed when under normal driving. No symptoms were present when driving. Failed out of nowhere.

NHTSA ODI 11549091

The contact owns a 2016 Ford Escape. The contact stated that while driving at various speeds the vehicle would jerk, lose power, and would not properly accelerate while pressing the accelerator pedal. Also, a warning message to "Turn the Vehicle Off" was displayed. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was later taken to an independent service center that replaced the transmission but the failures continued to occur. The manufacturer was notified of the failures but no assistance was offered. The failure mileage was 100.

NHTSA ODI 11548003

Stalling in the middle of highway twice

NHTSA ODI 11545072

The contact owns a 2016 Ford Escape. The contact received notification of NHTSA Campaign Number: 22V413000 (Power Train). The contact stated that while the gear shifter was shifted to drive the vehicle jolted forward violently. The vehicle was taken to an independent mechanic to be diagnosed. The contact was informed that the transmission shifter cable needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ODI 11541393

The contact owns a 2016 Ford Escape. The contact stated while driving 65-70 MPH, the vehicle lost motive power. The contact coasted to the side of the roadway. The "Transmission Fault" message was displayed. The vehicle was towed to a transmission specialist, who diagnosed that an unknown pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 72,566.

NHTSA ODI 11541424

The contact owns a 2016 Ford Escape. The contact stated while driving approximately 65 MPH, the vehicle failed to shift into gear as needed and stalled. The vehicle failed to go forward or reverse. The driver was able to shift into park, and the transmission service needed message was displayed. There were no warning lights illuminated. The vehicle was taken to a transmission shop and the contact was informed that the transmission needed to be repaired. The vehicle was towed to the local dealer, where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 61,000.

NHTSA ODI 11538867