What 1,037 owners told NHTSA about the 2016 Ford Escape Gas

The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. Additionally, the contact stated that the engine was abnormally loud, and the vehicle stalled. The vehicle was taken to an independent mechanic where it was diagnosed with coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was unknown.

NHTSA ODI 11603252

Coolant leaked into the cylinders causing us to replace the motor.

NHTSA ODI 11597990

I was driving down the highway doing 70 mph my car lost all power and a warning light came on said engine failure. This is dangerous. We could've gotten killed.

NHTSA ODI 11597785

The crankshaft came loose, making a big racket. The pins that hold the crankshaft came looks this could cause a crash and is a big safety risk.

NHTSA ODI 11597264

The contact owns a 2016 Ford Escape. The contact stated that heavy white smoke was coming from the exhaust pipe at start-up. There was no warning light illuminated. The vehicle was taken to a dealer where a diagnostic test was performed. The diagnostic test determined that coolant had leaked into an engine cylinder and that metal shavings were found in the oil and air intake tube. The vehicle was diagnosed with engine failure. The manufacturer was notified of the failure but provided no assistance. The vehicle was not repaired. The failure mileage was approximately 100,000.

NHTSA ODI 11596139

What component or system failed or malfunctioned, and is it available for inspection upon request? -The engine block is cracked and leaking antifreeze into the combustion chamber. How was your safety or the safety of others put at risk? -no Has the problem been reproduced or confirmed by a dealer or independent service center? -Confirmed by dealer Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -Just the dealer Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -None

NHTSA ODI 11595574

The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, the vehicle was shuddering and chugging significantly. Additionally, the transmission was slipping between gears. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where the engine was replaced. Additionally, the contact stated while driving 70-75 MPH and depressing the accelerator pedal, the vehicle jerked and lunged forward. The contact also stated that while attempting to drive from a complete stop, the accelerator pedal was depressed, but the vehicle failed to respond while the engine was revving. The contact stated that he continuously depressed the accelerator pedal until the vehicle responded. The contact was able to continue driving. The vehicle was towed to the independent mechanic, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 114,000.

NHTSA ODI 11592660

The contact owns a 2016 Ford Escape. The contact stated that while her daughter was driving 60–65 MPH, coolant was leaking into the engine. The engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that an engine replacement was needed. The manufacturer was contacted and opened a case. The failure mileage was approximately 105,000.

NHTSA ODI 11592089

4/24/24 Vehicle began de accelerating quickly, going from 50mph to 28mph. The oil light came on, followed immediately by engine light, then seconds later, complete engine failure. Towed to dealership, where I was informed a week later that the engine needed to be replaced again. Ford replaced engine 1.5 years ago when another catastrophic failure occurred. That engine came with a 36 month warranty. Ford authorized the dealership to replace the engine again, however, was unwilling to provide a new 36 month warranty, indicating I would only have the remainder of the warranty period from the previous engine. This second incident could have resulted in serious injury to me, as it occurred on a busy road with no shoulder. I couldn’t open my driver door safely with speeding vehicles going by at 45-50mph to catch a ferry. My research indicates Ford was aware of potential problems with this model since before I purchased it new in 2016.

NHTSA ODI 11588518

The coolant leaks into the engine. I have already had it fixed before. It did it again and ruined my engine. I am now on the hook to replace the engine and still paying the car off. Looking to Google shows this is a known issue that ford refuses to address and has cost thousands of people a lot of money.

NHTSA ODI 11582796

I was driving my 2016 Ford Escape and stopped at a red light. When the light turned green I steeped on the gas and the car would not move. No check engine light came on and there was no indication that anything was wrong. The car had to be towed to two different repair shops. The first repair shop diagnosed that it was the transmission and they wanted to much to repair. I then had it towed to a transmission repair shop where they rebuilt my transmission. I picked up my car today and the shop told me that there was a recall on 2016 Ford Escapes. I called ford and they agreed there was a recall on 2016 Ford Escape transmissions but it did not include my car. This makes no sense as my car only has 63208 miles on it and the transmission went out with no warning. I don't understand my Ford says my car is not included when obviously there is a problem. Thank you for your time

NHTSA ODI 11582197

Check engine light came on, car was taken to mechanic. Coolant system cylinder 1, 2 were showing as codes and coolant was 1/2 gallon low. Coolant was found to be leaking into engine and engine replacement was the only fix. Mechanic also indicated there is a TSB for this issue, meaning it is a known problem that ford will not help with correcting.

NHTSA ODI 11578357

Check engine light is on at 63,000 miles. Ford dealer confirmed coolant in cylinder and immanent total engine failure, so vehicle is not safe to drive as it may stop at any time and loss of coolant. Only indication is the check engine light. Dealer quoted repairs for engine, turbo, and cat converter replacement at over $18,000. Research on the internet reveals that this is a common failure. Since the warranty is out of the time and 3k over the covered range they will do absolutely nothing to remedy the issue. The sticker price on the Escape Titanium is over $37,000.

NHTSA ODI 11565708

While driving home going about 40 mph my Ford Escape lost acceleration and then completely shut off IN THE MIDDLE OF THE ROAD! I was able to "limp" it to the side of the street where it would not start at all. I then placed it in reverse (as I was on a hill) to roll it backwards into a neighborhood to get it out of the way of on coming traffic. It was 10 PM at night! I waited for a few minutes and was able to get it to start but not change gears. I was able to get it to my neighborhood with hazards on going barely 10mph. It literally rolled into my driveway where it has been since (November 2023).

NHTSA ODI 11563752

engine coolant leaking into cylinders 1&2, causing check engine light to come on, misfires (over a period of 6 months)and block to crack. Had to replace. Bought escape in April 2023, Have car loan plus personal loan to pay for repairs. This was caused by defective design. Caused finical hardship for us. Could have caused engine overheating and fire. I will download one document for engine replacement, I have to many to download.

NHTSA ODI 11558845

On November 14th, 2023, a red alert appeared on the dash that indicated an engine temperature warning indicating that there was a high temperature warning and that I should find a safe place to pull over and immediately stop the vehicle. The temperature indicator on the dash showed the needle move instantly into the red/high area and then drop down. This happened twice, back-to-back. I checked the coolant and it was below the minimum level indicator as shown on the reservoir. A day later, the service engine light illuminated. I took the vehicle to Advanced Auto and asked to pull the service code and was told there were two, P0303 and P0304 which indicated a cylinder three misfire and cylinder four misfire. I noted that the coolant was also low once again despite seeing no fluid on the ground after allowing the vehicle to run. Bill Collins Ford inspected the misfires and coolant and found the issue to be related to a flaw in the engine design which allows coolant to leak into the cylinders. I was told this could have allowed the vehicle to overheat and catch on fire as well as causing the engine to lock up while in operation. Bill Collins Ford provided an estimate of $13,000 to repair the vehicle stating it required a new engine. I purchased this vehicle used from CarMax on August 2, 2023 and have put less than 3,000 miles on it before experiencing this issue.

NHTSA ODI 11556980

The contact owns a 2016 Ford Escape. The contact stated while driving approximately 55 MPH, the transmission inadvertently downshifted to a lower gear. The contact stated that the gear shifter became inoperable. The check engine and electronic throttle control system warning lights illuminated. The vehicle was taken to a dealer where it was diagnosed that the motor mounts and transmission bushing cable needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 94,000.

NHTSA ODI 11555451

The escape has a defective EcoBoost engine that cause coolant to leak into the cylinders, increasing the risk of engine failure or car fires. The 2016 escape had coolant leak into the cylinder of the engine that caused the engine to fail needing a new engine due to this. The problem of the coolant leaking into the engine has been documented by a Ford dealership and some models of the escape have been recalled due to this except the year of 2016. There was no warning lights or messages showing that this issue has happened. I was driving this vehicle when the issue was occurring and mine and my child’s safety was put at risk.

NHTSA ODI 11555322

While driving the car shuddered and then shut off. The transmission light came on with a warning about 5 minutes after it shut off. So there was never a warning and we were unable to get it to go back into any gear.

NHTSA ODI 11551697

The Coolant is leaking out of the engine somewhere. The dealership said it was fixed with a new coolant bypass valve Yet when got home the coolant bottle was empty and there was overheating warning again.

NHTSA ODI 11549970

Stalling in the middle of highway twice

NHTSA ODI 11545072

The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the temperature sensor illuminated, and the vehicle overheated. The contact stated he was able to drive the vehicle to the shoulder of the roadway. The vehicle was taken to the dealer, where it was diagnosed as having coolant intrusion and a warped engine block. The contact was informed that the engine block needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 128,000.

NHTSA ODI 11543836

The contact owns a 2016 Ford Escape. The contact stated while driving at an undisclosed speed, the vehicle started overheating. The contact pulled over on the side of the road and waited until the vehicle cool down and added coolant to the vehicle. The vehicle was towed to an independent mechanic who stated that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NTHSA Hotline for assistance. The failure mileage was 130,000.

NHTSA ODI 11540116

Vehicle check engine light goes on usually during hot weather. Vehicle stalls and hesitates on acceleration causing unsafe conditions with traffic, intersections, etc.

NHTSA ODI 11538688

Vehicle over heated and had to pull over to cool it down. Got vehicle home safe and check engine light was on. 116867 T1.0 for diag verified customer's concern. Quick test P1299, P0217, P0219 for over temp condition. removed spark plugs and found coolant intrusion into all the cylinders, WSM direction is to replace the long black. This same issue is happening with other Escapes and are on the recall list. I am requesting my VIN/car be added to the recall for the same issue.

NHTSA ODI 11537612