What 647 owners told NHTSA about the 2015 Tesla Model S 60

HAVE AN ISSUE WITH THE CENTRAL TOUCH SCREEN PANEL GOING BLANK. THE EMBEDDED MULTI-MEDIA-CARD MEMORY (EMMC) IN THE MCU INS LIKELY THE ISSUE. THIS IS CAUSING THE CENTRAL TOUCH SCREEN PANEL (THAT CONTROLS AIR BAGS, NAVIGATION, MUSIC, HEATING ETC..). THIS SCREEN HAS BEEN CAUSING A PROBLEM FOR MANY MONTHS. WE GOT A 'TEMPORARY FIX' BY A RESET THAT COST 100S OF DOLLARS - BUT IT WENT BLANK AGAIN. THIS IS A DESIGN FLAW THAT HAS NOTHING TO DO WITH HOW WE DRIVE THE CAR - IT HAS GOT FIXED IN THE 2018 AND LATER MODEL S MODELS - BUT IT LOOKS LIKE IT IS A SYSTEMATIC ISSUE IN MANY CARS PRIOR TO THAT.

NHTSA ODI 11354363

RE INVESTIGATION PE 20-010, MCU HAS FAILED AND LOSS OF REAR VIEW CAMERA DISPLAY IS A RESULT. REACHED OUT TO TESLA APPROXIMATELY ONE MONTH AGO AS THE MCU WAS BEGINNING TO FAIL. KNEW IT WOULD TAKE APPROXIMATELY ONE MONTH TO GET AN APPOINTMENT/PARTS. TESLA REFUSED (VIA EMAIL) TO REPLACE UNDER WARRANTY UNTIL MCU WAS IN COMPLETE FAILURE. UNIT COMPLETELY FAILED ON 9/8/2020. MADE APPOINTMENT FOR REPLACEMENT; FIRST AVAILABLE APPOINTMENT WAS 9/30/2020.

NHTSA ODI 11354045

CENTER 11 INCH SCREEN GOING FUZZY, CONSTANTLY NEEDS TO REBOOT COMPUTER TO GET NORMAL SCREEN...OCCURRING 2-3 TIMES A DAY, CAN OCCUR STATIONARY OR IN MOTION

NHTSA ODI 11353489

CENTER SCREEN (MCU) WENT OUT , LOSE ALL SAFETY FEATURES BECAUSE THE SCREEN IS ALL BLACK

NHTSA ODI 11352983

MEC FAILURE ON CENTRAL PANEL....CONSOLE IS ALL BLACK AND MINIMAL FUNCTION ON DRIVE DISPLAY...NO AC/HEAT.... CAUSE NO HORN NO DISPLAY NO CAMERA NO AUDIO.NO AC NO TURN SIGNALS. WHILE DRIVING NO CONTROLS ACCESS TO THE CAR..NO CENTER DISPLAY NO AIRBAG AND AIRBAG ERROR...NO APP ACCESS EITHER AND CAR COULD NOT REBOOT EITHER...AND STRANGE CHARGING SOUND IN FRONT BATTERY

NHTSA ODI 11352868

TOUCH SCREEN FAILS TO OPERATE. DIRECTIONAL SIGNAL LIGHTS ARE INOPERABLE. CAR IS UNSAFE TO DRIVE. PROBLEM WAS SUSPECTED 2 MONTHS AGO AND PART HAS BEEN BACK ORDERED SINCE THEN.

NHTSA ODI 11351958

TL* THE CONTACT OWNS A 2015 TESLA MODEL S. THE CONTACT STATED THAT THE ELECTRONIC SYSTEM FAILED CAUSING THE TURN SIGNALS AND THE NAVIGATION SYSTEM TO NOT OPERATE. THE VEHICLE WAS TAKEN TO THE DEALER (TESLA 10250 SANTA MONICA BLVD STE 1340, LOS ANGELES, CA 90067 (310) 553-5767). THE DEALER AFTER A MONTH TOOK THE VEHICLE IN AND PERFORMED A SOFTWARE FIX ON THE ELECTRICAL SYSTEM. THEY DID NOT REPLACE THE MCU UNIT AS THEY ORIGINALLY DIAGNOSED. THE FAILURE HOWEVER RECURRED WITH THE TURN SIGNALS STILL FLASHING ON AND OFF AND THE INSTRUMENT PANEL INCLUDING THE NAVIGATIONAL SYSTEM ALSO NOT WORKING CONSISTENTLY. THE CONTACT HAD NOT BEEN ABLE TO RESCHEDULE AN APPOINTMENT ONLINE WITH THE DEALER. THE FAILURE MILEAGE WAS 37,000.*DT *JS

NHTSA ODI 11351564

TESLA MCU1 EMMC FAILURE. MY MCU WENT OUT IN JULY. THE TESLA BURBANK SERVICE CENTER KNEW THIS, EVEN HAD THE MCU ON ORDER, BUT ONCE I TOOK MY CAR IN, SAID A FACTORY RESET WAS ALL I NEEDED. A MONTH LATER, PROBLEMS HAPPENED AGAIN. BLANK TOUCHSCREEN, BLINKERS DON'T WORK, AND AC GOES OFF AND ON - IN THE MIDDLE OF A HEATWAVE!!! I TRIED CALLED THE BURBANK SERVICE CENTER, LEFT A MESSAGE, OF COURSE NO ONE CALLED BACK. I SET UP ANOTHER APPOINTMENT THE ONLY WAY TESLA ALLOWS, ON THE APP, NO WAY TO TALK TO A HUMAN. THEY SAID A MOBILE TECH WOULD COME TO MY HOUSE IN A BOUT A WEEK. (BASED ON WHAT BURBANK SC TOLD ME, I KNEW A MOBILE TECH COULDN'T FIX THIS; BUT THE APP DIDN'T ALLOW ME TO SPECIFY THIS). THE DAY BEFORE THE APPOINTMENT, THEY FINALLY READ MY NOTES. SHOCKER, IT ISN'T SOMETHING A MOBILE TECH CAN FIX. SO COME TO VAN NUYS SERVICE CENTER, A WEEK AWAY, ON 9/1/20. NOW (08/27/20) I'M BEING TOLD, VIA TEXT THAT NO ONE RESPONDS TO, THAT IT'S BEEN DELAYED TO 9/8/20. MEANWHILE I'M HAVING TO DRIVE A CAR THAT ISN'T SAFE, ESPECIALLY IN THE MIDDLE OF A HEATWAVE WITHOUT WORKING/DEPENDABLE AC.

NHTSA ODI 11351667

THE CENTER SCREEN OF MY TESLA STOPPED WORKING WHEN I STARTED THE CAR ONE DAY (CAR WAS PARKED), RESULTING IN A LOSS OF THE BACKUP CAMERA AND ACCESS TO MANY DRIVER SETTINGS, SUCH AS REGENERATIVE BRAKING, AUTOMATIC LIGHTS, ETC. REBOOTING THE UNIT DID NOT HELP, AND THE CAR WOULD NOT SHUT OFF ONCE THE ISSUE OCCURRED.

NHTSA ODI 11351484

MCU ON TESLA CRASHED AGAIN. LAST YEAR IT WAS REPLACED, AND THIS YEAR CRASHED AGAIN. TESLA KEEPS POSTPONING REPAIR. SAYING THEY ARE TOO BUSY. WITH THE MCU CRASHED, TURN SIGNAL DOES NOT WORK AND MAKES CAR NOT DRIVEABLE. I UNDERSTAND YOU ALL ARE INVESTIGATING THIS ISSUE? THE DATE IDENTIFIED BELOW IS THE SECOND TIME. THIS HAPPENED LAST YEAR AS WELL.

NHTSA ODI 11350703

TL* THE CONTACT OWNS A 2015 TESLA MODEL S. THE CONTACT STATED THE MEDIA CONTROL UNIT WAS NOT OPERATING PROPERLY AND THE SCREEN WAS INOPERABLE. THE CONTACT CALLED THE LOCAL DEALER TESLA LOCATED AT 5544 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33417, 561-232-8984, WHO SENT A TECHNICIAN TO HIS RESIDENCE TO DIAGNOSE THE VEHICLE. THE CONTACT WAS INFORMED THAT THE COMPUTER NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 51,000.

NHTSA ODI 11350511

ON 7/2/20, CENTER CONSOLE STOPPED WORKING WHEN STARTED UP. THIS AFFECTS/CONTROLS CLIMATE CONTROL, BACK UP CAMERA, BLINKERS, AND MAPS. CAR IS ABLE TO DRIVE, BRAKE, AND STEER. INABILITY TO USE BLINKERS IS HAZARDOUS. I BELIEVE IT IS A KNOWN PROBLEM WITH THE MCU CHIP. MANY TESLAS ARE HAVING PROBLEMS WITH THIS CHIP 4-5 YEARS INTO OWNERSHIP. SERVICE CENTER STATES THERE IS A LONG BACK ORDER, ESSENTIALLY MAKING IT SO THAT THE BEST-CASE SCENARIO IS I AM WITHOUT MY CAR FOR 8 WEEKS AS IT IS UNSAFE TO DRIVE.

NHTSA ODI 11350156

CAR WAS CHARGING AT THE KNOXVILLE SUPERCHARGER. I COULDN'T CONNECT FROM RESTAURANT WITH MY APP TO SEE IF IT WAS COMPLETELY CHARGED. WHEN I GOT TO CAR TOUCHSCREEN WAS BLACK, WOULDN'T COME BACK WITH SOFT OR HARD RESETS, APP WAS LOCKED UP, NO NAVIGATION, NO MUSIC, ALL SCREEN AND APP ABILITIES GONE, TURN SIGNALS DIDN'T WORK, AC WASN'T WORKING. TESLA SERVICE CENTER HAS DIAGNOSED MCU 1 FAILED. THEY WERE ABLE TO REVIVE IT IN THE APPOINTMENT ALTHOUGH SOME APPLICATIONS SLUGGISH. A DAUGHTER BOARD HAS BEEN ORDERED TO FIX IT WHICH I WILL PAY FOR, APPOINTMENT FOR THAT COMING UP AUGUST 28, 2020.

NHTSA ODI 11349967

MCU1 WENT OUT WITH 41000 MILES

NHTSA ODI 11349721

MCU FAILURE, WHEN BACKING UP THE REAR CAMERA DOES NOT TURN ON, CENTER SCREEN CONSOLE HAS GONE BLACK AND WILL NOT REBOOT DESPITE MULTIPLE ATTEMPTS TO DO SO. SEEMS LIKE A MCU FAILURE. CAR IS ESSENTIALLY VERY HARD TO DRIVE - HARD TO BACK UP - REAR CAMERA IS NOT FUNCTIONING, HAS BECOME A SAFETY PROBLEM. HAS BEEN INTERMITTENT OVER LAST FEW WEEKS, NOW PERMANENT.

NHTSA ODI 11349148

THERE IS A KNOWN PROBLEM WITH MCU VERSION 1 IN MODELS BEFORE 2018 THAT CAN CAUSE TOTAL ELECTRICAL FAILURE, MY CAR LOST ITS ABILITY TO USE TURN SIGNAL AND CONTROL OF ALL OTHER ELECTRICAL EQUIPMENT.. THEY NEED TO ISSUE A RECALL ON THIS. THIS IS A WELL KNOWN ISSUE AND TESLA NEEDS TO STEP UP TO PLATE AND FIX THE PROBLEM. THIS CAN CAUSE BOTH UNJUST EXPENSE FOR OWNERS NOT TO MENTION HAVE SAFETY RAMIFICATIONS.

NHTSA ODI 11349219

MONITOR FAILURE. WITH LOST OF NAVIGATION, AIR CONDITIONING ETC.WHILE STATIONARY. HAPPENED 2018. REPLACED MONITOR AND I WAS CHARGED 2000 DOLLARS.

NHTSA ODI 11348955

THE DRIVER'S DISPLAY PANEL WHICH DISPLAY THE SPEED AND OTHER IMPORTANT INFORMATION ABOUT THE STATE OF THE VEHICLE IS BUBBLING AND MAKING IT DIFFICULT TO READ THE CURRENT SPEED. THIS IS A COMMON PROBLEM WITH THIS MODEL ACCORDING TO THE OWNERS FORUM. EVEN THOUGH THIS IS A COMMON SAFETY PROBLEM, TELSA HAS NOT ISSUED A RECALL FOR THIS PROBLEM.

NHTSA ODI 11349026

THE MEDIA CONTROL UNIT ON THE CAR FAILED AND NEEDS TO BE REPLACED. IN ADDITION TO ALL CONTROLS OPERATED BY THE TOUCH SCREEN, INCLUDING THE BACK-UP CAMERA, THE CAR'S BLINKERS DO NOT WORK.

NHTSA ODI 11349132

ISSUE WITH THE MCU1 OR INFOTAINMENT SYSTEM FAILING. THIS RESULTED IN AN UNSAFE CONDITION WHILE USING AUTO PILOT THE SYSTEM FROZE AND SHUT DOWN DURING THE OPERATION OF THE VEHICLE. THE AI CAMERAS, RADARS, TRIP ROUTING ARE ALL CONTROLLED BY THIS INFOTAINMENT SYSTEM AND ALL OF THEM SHUT DOWN AT ONCE WHILE THE VEHICLE WAS MOVING. THIS COULD HAVE EASILY RESULTED IN AN ACCIDENT AS FEATURES LIKE ASSISTED LANE CHANGE, COLLISION ASSISTANCE, SUMMON, AUTO CAR DISTANCE, AUTO PILOT 1.0, STOP SIGN AND STOP LIGHT SENSING ALL RELY ON THIS COMPUTER WHICH IMMEDIATELY STOPPED WITHOUT WARNING. ALSO, ALL VIDEO PROVIDED FOR THE BACK UP CAMERA NOW NO LONGER WORKS OR COLLISION DETECTION FROM THE RADARS WHILE BACK UP COMPLETELY STOPPED WHICH IS A SAFETY ISSUE WHEN PULLING OUT. WHEN ASKED THE DEALERSHIP TRIED TO UP SELL ME INTO THE NEXT MCU FOR 2500 DOLLARS TO FIX THIS 'KNOWN' SAFETY ISSUE. THIS ALLEGEDLY HAPPENS BECAUSE OF THE MASSIVE CROWD ERROR LOGGING THAT TESLA USES IN ITS FLASH MEMORY (WHICH CAN ONLY BE OVER WRITTEN SO MANY TIMES) TO BETTER ITS PRODUCTS BUT THE USER IS UNABLE TO SHUT THE LOGGING OFF. THIS FORCES AN EVENTUAL INDEFINITE FAILURE. THE INDIVIDUAL USER HAD AND STILL DOESN'T HAVE THE ABILITY TO SHUT THIS OFF. TESLA IS FORCING ITS USERS TO PAY FOR AN UPGRADE AFTER THE MEMORY BURNS OUT BECAUSE OF A DATA COLLECTION EFFORT THAT IS COMPANY IMPOSES AND BY CONSEQUENCE ROBBING ITS USERS OF IMPORTANT SAFETY FEATURES IN THE MEAN TIME. WHEN THIS IS COMBINED WITH REAL AI THAT THE USER NEEDS TO DRIVE IT CAN EVEN CAUSE AN ACCIDENT IN REAL TIME.

NHTSA ODI 11348740

WHILE BACKING OUT OF THE GARAGE ON A LEVEL SURFACE WE HEARD A LOUD POP. UNSURE WHAT THE NOISE WAS I DID A WALK AROUND THE CAR BUT DID NOT SEE ANYTHING UNUSUAL. WE DROVE THE CAR TO THE MOUNTAINS AT SPEEDS UP TO 55MPH. AS WE STARTED TO DRIVE HOME WE HEARD MORE SOUNDS LIKE SOMETHING WAS LOOSE IN THE SUSPENSION. WE CALLED TESLA EMERGENCY ROAD SERVICE AND ASKED IF THERE WAS A HISTORY WITH SUSPENSION ISSUES. WE ALSO ASKED IF IT WAS SAFE TO DRIVE HOME. THE TECH SAID THERE WAS NO SERVICE BULLETIN ON THE SUSPENSION. HE WAS UNSURE IF IT WAS SAFE TO DRIVE. WE DID DRIVE THE VEHICLE SOME DISTANCE OUT OF THE MOUNTAINS WITHOUT INCIDENT. WE STOPPED TO VISIT A RESTAURANT AND WE HEARD FURTHER SOUNDS FROM THE SUSPENSION ON THE DRIVER'S SIDE OF THE VEHICLE. INSPECTION SHOWED THAT THE LEFT FRONT DRIVERS WHEEL HAD MOVED BACK OUT OF CENTER IN THE WHEEL WELL AND HAD RUBBED THE WHEEL WELL LINER. FROM THIS POINT THE VEHICLE WAS TOWED TO THE TESLA SERVICE CENTER. WE LATER LEARNED FROM AN INTERNET SEARCH THAT EVEN AT LOW SPEEDS WITHOUT ANY SHOCK TO THE SUSPENSION, TESLA MODEL S CONTROL ARM/FORE LINK ASSEMBLIES FAILED IN 2015 VEHICLES. THIS IS A DANGEROUS SITUATION AND COULD BE CATASTROPHIC IF THE FAILURE OCCURRED AT HIGH SPEED. WE SHOULD HAVE BEEN INFORMED THAT THERE WAS A HISTORY OF FAILURES AND IT WAS NOT SAFE TO DRIVE. WE FEEL THAT BOTH THE FRONT AND REAR SUSPENSION OF THE 2015 ARE PRONE TO FAILURE AND SHOULD BE RECALLED FOR SAFETY REASONS. ALTHOUGH THE TESLA IS ALMOST 5 YEARS OLD THE VEHICLE HAS JUST 23,170 MILES. SUSPENSION FAILURES SHOULD NOT BE HAPPENING AT THIS POINT. THE TESLA SERVICE CENTER DID REPLACE BOTH LEFT AND RIGHT LOWER FORE LINK ASSEMBLIES AS A GOOD WILL MEASURE SINCE THE CAR WAS NO LONGER UNDER WARRANTY. .

NHTSA ODI 11348941

WHILE STATIONARY, MIDDLE TOUCH PANEL (MCU) ON MY 2015 TESLA MODEL S 85 (~60,000 MILES) STARTED FREEZING UP BETWEEN VEHICLE CONTROLS (LOWER LEFT 'CAR' ICON) AND GARBLING SCREEN WHEN TRYING TO SWITCH BETWEEN THEM, A COUPLE OF DAYS AGO. I NOTICED FIRST SYMPTOMS ABOUT A WEEK AGO WHEN PERCENT CHARGED ON THE MIDDLE TOUCH PANEL DIDN'T UPDATE TOGETHER WITH THE INSTRUMENT PANEL WHILE SUPERCHARGING. NOW I HAVE TO SCROLL-WHEEL-RESET MY CAR TWICE A DAY: BEFORE DRIVING TO WORK (IT'S FROZEN IN THE MORNING) AND AGAIN BEFORE DRIVING HOME FROM WORK (FROZEN AGAIN IN THE AFTERNOON). AN ADDITIONAL SYMPTOM MANIFESTED ITSELF TODAY: MY REARVIEW CAMERA STARTED GETTING A NASTY 'GRAY VEIL' OVER IT SO YOU CAN'T SEE ANYTHING; IT SEEMS TO KEEP APPEARING AND DISAPPEARING.

NHTSA ODI 11348516

RANDOM FAILURE INCLUDING LOSS OF CONTROLS USING MCU1. FREQUENT RE-SETTING / RE-BOOTING REQUIRED TO OPERATE THE VEHICLE USING MCU 1 CONTROLS.

NHTSA ODI 11348577

COMPLETE FAILURE OF MCU WHEN STARTING THE CAR AFTER ONLY 31K MILES, CAUSING BLACKOUT OF AL SCREENS, DRIVER INFORMATION, CONTROLS, ETC. TESLA HAD ME DRIVE IT TO THE SERVICE CENTER IN THAT CONDITION AND CHARGED $1,462 TO REPLACE WITHOUT ANY INDICATION THAT IT IS A KNOWN DESIGN PROBLEM. (NOTE INCIDENT DATE IS APPROXIMATE.)

NHTSA ODI 11348590

THE MEDIA CONTROL UNIT (MCU) TOUCHSCREEN FAILED (COMPLETELY DARK/NON-OPERABLE) AND GREATLY REDUCED MY REAR VISIBILITY WHEN PUTTING THE CAR IN REVERSE GIVEN THE LOSS OF THE REAR CAMERA DISPLAY. THIS OCCURRED UPON LEAVING WORK AND GETTING INTO MY PARKED CAR.

NHTSA ODI 11348626