What 381 owners told NHTSA about the 2015 Chrysler Town And Country

The contact owns a 2015 Chrysler Town and Country. The contact stated while driving 35 MPH, the vehicle stalled. The vehicle was towed to an independent mechanic. The vehicle was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.

NHTSA ODI 11548511

Car was parked and I was standing outside the front passenger door. When I pulled the seat recline lever, the seat back shot forward quickly and the headrest exploded open. I cannot push it back into place OR take the headrest out. It is available for inspection, however I need to get it fixed for safety concerns asap. Anyone sitting in the passenger seat cannot keep their head in proper alignment, over their shoulders. Their head is forced forward. Not only uncomfortable, but mechanically unsafe. There was no warning lights or known malfunctions prior to the incident.

NHTSA ODI 11548143

Back up camera and dash display quit working. Had near miss when backing up vehicle and almost ran over someone.

NHTSA ODI 11545152

We have had multiple times when we are driving, and our vehicle shuts off and we lose power steering and power brakes. When the van does come to a stop, we are able to restart it and continue on. There is no warning that the van is going to shut off, it just does it. This is our family vehicle. I have found multiple forms online with customers complaining of the same issue with no positive results from the dealerships.

NHTSA ODI 11544982

headrest opened driving down the road and broke the plastic clips, now i have a loose headrest

NHTSA ODI 11543055

While the car was parked in the garage, person sat in the passenger seat and buckled, leaned back against the headrest and the headrest impact function triggered, pushing fully forward. Following Chrysler’s instructions on resetting it, I found the plastic locking mechanism was completely broken off.

NHTSA ODI 11539619

While driving at 70 mph on the highway on 8/13/23, the car electrical system failed. Power steering immediately failed. Brakes unresponsive. Lost control and almost veering into a semi beside us. Coasted and lane changed with no means to signal to others. Once we coasted to a near stop car was put into park without ability to press on break. After 3 min, attempted to start car again and it was responsive again.

NHTSA ODI 11538310

The sliding door on the passenger side has issues with the door lock actuator. It buzzes when unlocking and locking.

NHTSA ODI 11538507

We were traveling to Illinois when with out warning the car downshifted and went 55m/hr at 5000 rpm instead of 70m/hr at 2000 rpm. Incident occurred 7/22/2023. We were on the tollway coming in to Rockford Illinois at the beginning of rush hour. The mechanic found that the transmission had failed at 47,190 miles on the car. Of course the auto was out of warranty. 2015 Chrysler Town and Country Touring Van 5y or 60,000 mi on the powertrain. This could have been a very dangerous situation with the car accelerating and decelerating as we drove. The interesting thing is the certified transmission mechanic told us this was the 4th van he has seen in the last 2 weeks with the same issue. The transmission fluid was full of metal shards, now this does not seem right on an auto with only 47,190 miles on it There is documentation attached with the component data as per the computer record.

NHTSA ODI 11535114

The transmission started whining I brought it to the shop they say it’s the transmission pump. I need a new transmission

NHTSA ODI 11529782

Recall (ID-16V461000) VIN number said it was done But still having transmission issues. Bought used so not sure if it was completed or not. But when I put in my Vin it comes up no recalls BUT still having the same issues as recall (ID-16V461000)

NHTSA ODI 11525968

The engine died while traveling 80mph and power steering stopped. Engine died at a stop light in traffic. No lights display on dashboard and no codes display. Car runs fine after turning off then restarting. This is dangerous and appears common in town and countries. We could have died at 80mph.

NHTSA ODI 11518793

Numbers 1 & 2 engine misfires. Van could have stopped running at anytime and cause an accident. Engine light went on. Van is shaking when it runs.

NHTSA ODI 11517587

Both headrests in the vehicle have malfunctioned and popped without the occurrence of an accident. The headrests are broken and cannot be reset in their proper functioning position. Therefore, it poses a safety hazard for occupants. The components have not been inspected by the manufacturer or anyone else other than the owner of the vehicle. There are no indicators denoted the issue.

NHTSA ODI 11514522

The contact owns a 2015 Chrysler Town and Country. The contact stated that the check engine warning light was illuminated. The contact took the vehicle to two independent mechanics, where it was diagnosed with needing the transmission pump to be replaced. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. Upon investigation, the contact associated the failure with NHTSA Campaign Number: 16V461000 (Power Train), however the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 82,000. The consumer stated the vehicle was inspected by 3 different dealers and determined there was a faulty transmission pump. The consumer is appealing the recall and requesting to be part of the recall.

NHTSA ODI 11509891

In July 2020, while on a trip, driving on the interstate at approximately 70mph, the driver front door window trim flew off, luckily not hitting the vehicle behind me. I suspect if would have caused damage if it had, even possibly going through a window. It cost $92 for the new part (APPLIQUE. B Pillar. Left). In January 2022, while on a trip, driving on the interstate at approximately 70mph, the passenger front door window trim flew off, luckily not hitting the vehicle behind me. As stated above, it could have been a problem had it hit any vehicle behind us. It cost $86 for the new part (APPLIQUE. B Pillar. Right) . I was able to find the parts online rather than going through a dealer (cost $150+ from them). A friend who works for Caliber Collision offered to put the replacement parts on for us, saving us labor costs. He mentioned he has seen this problem on numerous Town and Country vans. The only warning we had was a sudden high whistle as the piece came off. The parts never felt loose so we had no reason to suspect they would come off. This seems to be a design flaw that I think we should be reimbursed for. I can supply the receipts if that is a possibility.

NHTSA ODI 11509622

Car passenger headrest is deployed and cylinder 6 is misfiring as described under the recall description from the previous years vehicles recalls.

NHTSA ODI 11503272

Halfway through a nearly 1000 mile trip from my home to Panama City Beach, FL, I noticed a noise slowly getting louder from the vehicle as the trip progressed. About 100 miles out from our destination, I noticed gears started slipping and the check engine light came on. Luckily, we did get to our destination and an Auto Service Center. From the attached invoice, we now know the "front transmission pump has low pressure starving transmission for fluid damaging transmission internally." This required us to replace the transmission, which was a nearly $6500 repair. It turns out, Chrysler recalled other 2015 Town and County vans for this exact same reason (recall number is 16V461000 and Chrysler's number is S44). However, my VIN was NOT a part of this recall. According to this recall description, "If the transmission loses hydraulic pressure, the vehicle may lose motive power, increasing the risk of a crash." The fact that my vehicle was not recalled but had the same issue as other vehicles that were recalled should warrant an investigation. I now know my family's safety was unknowingly at risk. I will also give this information directly to Chrysler.

NHTSA ODI 11502984

The contact owns a 2015 Chrysler Town and Country. The contact stated while driving approximately 50 MPH, the transmission inadvertently downshifted to first gear, causing the RPM’s to rev to 6,000 RPM. There were unknown warning lights illuminated. The contact pulled off the roadway and turned off and restarted the vehicle several times before the transmission regained normal functionality. The contact stated that the failure became constant. Additionally, the manual shifting and sports modes were inoperable. The contact drove the vehicle to a local dealer, where it was diagnosed and determined that the transmission pump had failed, and the transmission was damaged and needed to be replaced. The vehicle had not been repaired. The contact researched online and related the failure to NHTSA Campaign Number: 16V461000 (Power Train). The manufacturer had been informed of the failure. The failure mileage was approximately 135,000.

NHTSA ODI 11501141

Similar to NHTSA Campaign ID: 16V461000 While driving the van at highway speed, there was a sudden failure of the automatic transmission leading to lack of fwd/reverse motion control. Fortunately, this incident did not result in a crash; driver was able to coast to shoulder with hazard lights on. No warning lights appeared on the instrument cluster. Vehicle had to be towed away from scene. Vehicle is at Chrysler dealer who suspects hyd pump failure leading to transmission failure similar to above campaign. This van was manufactured in Nov 2014 (as a 2015) model and was not part of the OEM recall.

NHTSA ODI 11499790

Transmission pump failure, causing vehicle to be inoperable. Low pressure.

NHTSA ODI 11497447

My van has a leak at the valve seat in cylinder 1 on the intake side. It has been inspected my a mechanic and available for anyone else to look at it. My car is not old and low mileage. The mechanic said he had someone recently in with the same problem on the 3.6L engine, same year, same low mileage. This causes a problem because the combustion is not properly working in the engine so it has a health hazard for everyone because it has a larger and worse carbon footprint because the engine is not working/functioning properly how the car manufacturers intended it to be. I have searched forums and have found multiple people having the same problem with the cylinders. I believe the problem to be with the engine head because the mechanic said when he fixed the other engine he had to get the head off and get it re-machined. Also people are having the misfire in different cylinder. No warning lights were on before the issue happened.

NHTSA ODI 11496891

While driving the transmission started to make a loud whistling sound and would not change gears appropriately. At 5-6 thousand RPMs the vehicle would jam into the appreciate gear and cause the car to abruptly lurch forward and shudder. Upon examination of the transmission fluid, it was black and smelled burnt, and contained bits of metal. No previous OBD codes or engine lights identified any issues. After driving an additional 5 miles the vehicle would not accelerate or engage into drive (any gear) or reverse.

NHTSA ODI 11495924

The contact owns a 2015 Chrysler Town and Country. The contact stated that after she entered the vehicle through the front passenger’s side, the front passenger’s side air bag inadvertently deployed without warning. The vehicle was not diagnosed or repaired. The dealer nor the manufacturer was notified of the failure. The failure mileage was 97,841.

NHTSA ODI 11495791

Last month when driving my van started to stall when driving came to a stop at a light and the engine jerked, light turned green started to drive and it wouldn't go over 30 then all of a sudden it speeded up and the started making a weird sound pulled, off into a parking lot wasn't able to get it all the way in a parking spot. Called to have it towed. The transmission blew and it only has 65,000 miles. That cost me alot to get a transmission. Now the seatbelt on drivers side will not lock into place. Which I don't know what to do with that because you have to wear a seatbelt. When I bought this van brand new I had a lot of electrical issues kept taking it to the dealer they could never find anything. Lights would dim when driving, they was suppose to hook a machine up to it and it would register what was going on, this was requested by Chrysler when I couldn't get anywhere with the dealer ship. Chrysler set it up I go to the dealer and they don't have that equipment so they said they couldn't do anything, called Chrysler back told them was suppose to hear from someone never did. I feel this van is a death trap. The side doors act like they don't want to close at times. I have kept up on regular maintenance on the van. I just feel that when you pay $30,000.00 for a vehicle and take care of it things should last longer. I know it's 7 years old but low mileage and taken care of.

NHTSA ODI 11495364