What 1,347 owners told NHTSA about the 2014 Ford Fusion Hev

The contact owns a 2014 Ford Fusion. The contact stated while driving 45 MPH, the vehicle stalled. There was no warning light illuminated. The contact stated that he was able to slightly pull to the side of the road after 5-10 seconds. The vehicle failed to restart. The dealer was notified of the failure and advised the contact that the earliest availability for diagnostic testing was in 5 months. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 94,000.

NHTSA ODI 11612339

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the contact stated that several unknown warning lights were illuminated. In addition, the contact stated that the steering wheel had loosened. The vehicle was driven back to the residence. The following day, the vehicle was started, and the steering wheel seized. The vehicle was towed to the dealer where it was diagnosed with a failed electronic power steering module. The contact was informed that the electronic power steering module needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

NHTSA ODI 11610824

"Temporarily lost communication with climate system". This fault has appeared several times. When it comes up, no controls in the vehicle work. This includes ac/heater, windows and radio. My daughter had to drive home from work last week with no ac and no means of putting the windows down. The temperature in the car was pushing 100 degrees. This is not safe and it's not the first time. You can get online and find many examples of the same issue on several models. When I spoke to the local Ford dealer service department, they had no answer.

NHTSA ODI 11610690

Vehicle showing signs of coolant leak with no visible of signs of coolant on ground. Check engine light came on and running rough on startup and high speeds. White smoke and sputtering under load. Took to local mechanic and had signs of coolant in #3 cylinder. Replaced all spark plugs and ignition coils along with thermostat and pressure tested. Vehicle still throwing codes and having heavy misfires in #3 cylinder with coolant loss. Stated will need a new long block. Vin number not covered by recall. But Def needs to be.

NHTSA ODI 11610764

The contact owns a 2014 Ford Fusion. The contact stated that while driving out of the residence driveway at approximately 2 MPH, the traction assists and ABS braking assist warning lights illuminated. The contact stated that the steering wheel then seized. The contact turned off and restarted the vehicle and the vehicle regained steering functionality. The contact stated that the failure was intermittent but had become a recurring failure. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 15V250000 (Steering). The failure mileage was 184,513.

NHTSA ODI 11606779

The contact's girlfriend owns a 2014 Ford Fusion. The contact stated that while his girlfriend was driving at various speeds, the check engine warning light illuminated. Additionally, the driver noticed that there was coolant leaking onto her foot while depressing the accelerator pedal. The contact stated that coolant was leaking onto the accelerator pedal and floorboard. The local dealer and a secondary dealer, Prosper Ford (2200 W University Dr, Prosper, TX 75078 – (214)736-7779), were notified of the failure and informed the contact that the VIN was not included in NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 200,000.

NHTSA ODI 11606429

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, there was white smoke coming from the exhaust, and the check engine warning light was illuminated. The contact also stated that the vehicle was consuming an excessive amount of coolant; however, there were no visual coolant leaks found. The vehicle was towed to two independent mechanics for confirmation, where the vehicle was diagnosed with a coolant leak and a blown head gasket. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was informed that the repair was not eligible for coverage under the Technical Service Bulletin: 20-2100. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 111,000.

NHTSA ODI 11605796

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the exhaust pipes of the vehicle would abnormally blow white smoke. The check engine temperature warning light had been illuminated. The vehicle was taken to a local dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic for a second opinion where it was diagnosed that there was a coolant intrusion. The contact was informed of TSB: 22-2322. The manufacturer was made aware of the failure. The failure mileage was approximately 140,000.

NHTSA ODI 11605493

The contact owns a 2014 Ford Fusion. The contact stated while starting the vehicle, there was a significant amount of white smoke coming out of the exhaust pipe. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with coolant intrusion into the engine block. The dealer recommended the long block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling) because the VIN was not included. The failure mileage was approximately 102,330.

NHTSA ODI 11604482

The contact owns a 2014 Ford Fusion. The contact stated that while stopped in a parking lot with the engine running, the steering wheel independently started turning to the left. The contact stated that the Hill Start Assist, stabili-trak, and Loss of Power Steering Assist messages were displayed. The contact stated that the steering wheel was very difficult to turn. The contact stated there was smoke coming from under the hood. The contact turned off the vehicle and after opening the hood, the contact observed power steering fluid leaking onto the exhaust manifold. The contact had not taken the vehicle to a dealer nor an independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 15V250000 (Steering). The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.

NHTSA ODI 11604013

My car when it is parked it will randomly pop the trunk. A lot of issues I’m seeing is ford fusions 2014 and up! Few of my friends are having the same issues especially with keyless entry pad it’s causing issues from water damage or heat causing the car to to this! Their needs to be recall on that cause kids doors aren’t locking properly I have kids I had someone almost steal my car cause my trunk was popped open by itself! This is my second time reporting this I have [XXX] [XXX] and [XXX] I need my car! Can yall please fix this issue INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11603925

The contact owns a 2014 Ford Fusion. The contact stated that while his wife was driving 25 MPH, the Hill Assist warning light illuminated, prompting the driver to return to the residence. After a visual inspection, the contact became aware that the rear brake lights failed to turn off and remained illuminated continuously even without the brake pedal being depressed. There were no warning lights illuminated. The vehicle was not taken to the dealer nor an independent mechanic. The vehicle was not repaired. After investigating the failure, the contact related the failure to Safety Recall 22S02, Supplement #1. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 155,000.

NHTSA ODI 11600464

Took the car in for a forced recall it was the bushing on the transmission and now our transmission failed when it had showed no problems. The service department is claiming no fault.

NHTSA ODI 11600168

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel seized. There were two unknown warning lights illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with a failure in the steering wheel. The vehicle was not repaired. A local dealer was also contacted, and confirmed the vehicle was not under recall. The contact related the failure to NTSA Campaign Number: 19V632000 (Steering); however, the VIN was not included. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 109,000.

NHTSA ODI 11598588

The contact owns a 2014 Ford Fusion. The contact stated that the vehicle was taken to the dealer to be serviced. The contact stated while picking up the vehicle, the check engine warning light was illuminated. The dealer was notified of the failure. The dealer diagnosed that the O2 sensors had failed and informed the contact that a fee would be charged for the repairs. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 132,819.

NHTSA ODI 11597420

Coolant intrusion - engine needs to be replaced.

NHTSA ODI 11597553

My vehicle has lost all power steering, and is giving notice that steering assist fault service is required. The vehicle also is manufactured and produced during they same time recall notice 19S26 came out, however, Ford is stating the VIN is not associated with that recall.

NHTSA ODI 11596474

I recently noticed that the bolt that secures the steering wheel to the steering column has become loose. This seems to be the same problem for which a recall was issued but my vehicle wasn't included in the recall. I haven't had anyone look at it yet because it just started coming loose.

NHTSA ODI 11596156

The contact owns a 2014 Ford Fusion. The contact stated that the "Engine Coolant Overtemperature" message had flashed on the instrument panel while driving at an unknown speed. The contact added coolant to the coolant reservoir because the coolant level was low. Two days later, the vehicle started to jerk and hesitate upon the depression of the accelerator pedal with the check engine warning light illuminated. The vehicle was taken to the dealer where it was discovered that coolant had saturated the entire engine which resulted in engine failure. Upon investigation, the contact discovered NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling) which was linked to the failure. The manufacturer was notified of the failure and the contact was informed that there were no recalls on the vehicle related to the engine. The vehicle remained in the possession of the dealer. The failure mileage was approximately 162,000.

NHTSA ODI 11595787

The contact owns a 2014 Ford Fusion. The contact stated while driving 10 MPH around a curve, the steering wheel seized. The contact stated that several unknown warning lights were illuminated. There were abnormal beeping and chiming sounds detected. Additionally, the mileage changed from 54,529 to 88,529 without the vehicle being driven. The contact was able to park the vehicle. The vehicle was taken to an independent mechanic, who determined that the failure was due to the rack and pinion assembly and steering mechanism. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 88,529.

NHTSA ODI 11595532

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle lost power steering assist and an unknown warning light was illuminated. The vehicle was towed to an independent mechanic who related the failure with NHTSA Campaign Number: 19V632000 (Steering); however, the VIN was not included. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 190,000.

NHTSA ODI 11595176

I currently believe that the break pedal bumper has failed. My brake tail lights are permanently on, even when the car is off & unoccupied. My cruise control has been disabled and throttle control has been sporadic. The accelerator pedal does not respond properly when driving, it will either give no response or a sudden surge of power (Usually up to 5000 RPM), cause unsafe driving conditions and the inability to maintain accurate control of the speed of the vehicle. This may be because the vehicle thinks the brake is constantly being pressed. The vehicle is also a push button start and I can start it without pressing the brake, which leads me to believe it thinks the brake is always on. I've read there was a recall previously for brake bumpers, but it did not cover my location. I believe that recall needs to be expanded. I have found a yellowed (from age, was probably clear) chunk of a rubber washer/gasket on my floor board under the brake pedal. I have my vehicle scheduled to be looked at by a Ford dealer on Tuesday the 18th. There are no warning lights, messages, or anything else that indicates that the vehicle believes there is an issue. I can instruct the Ford dealership to hold onto the part, if it is the issue and if the NHTSA wants it, assuming I get a response prior to my appointment.

NHTSA ODI 11594622

Was departing in my vehicle for work, only got a short distance from my home and experienced a sudden loss of power steering. Vehicle became extremely difficult to steer and I was fortunate that there was not much traffic or was not at speed or in the middle of a turn when it happened. I have not yet taken it for service, it just happened, and when I searched the issue I found this has happened to many 14 Fusion owners but my vehicle VIN is not on the recall list. The dash lit up with a number of warnings: STEERING LOSS STOP SAFELY, SERVICE ADVANCETRAC, STEERING FAULT. The only symptom that I can remember before the incident happening this morning was the feel of small bump of reistance in the steering wheel as I was turning last night on my way home.

NHTSA ODI 11594326

The contact owns a 2014 Ford Fusion. The contact stated while driving 55-65 MPH, the engine made an abnormal revving sound. The contact stated that the check engine warning light was illuminated. The contact stated upon arriving to the residence and inspecting the vehicle, she noticed that there was a significant amount of air coming out of the gas tank flap. The contact stated that the failure occurred when the gas tank was less than half tank full. Additionally, the contact stated that after refueling the vehicle at the gas station, the vehicle failed to start up immediately. The contact stated that the accelerator pedal had to be depressed several times to start. Additionally, the contact stated that the rearview camera image was inaccurate and displayed objects and pedestrians on the opposite side of where they were physically located. The contact also stated that the rear-view camera image turned black intermittently while reversing. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under an unknown recall for the fuel tank and canister purge valve inspection and repair. The failure mileage was approximately 180,000.

NHTSA ODI 11593683

The rear brake and 3rd taillights turn on and won't go off. This presents a danger to other drivers, as they are not able to tell if I am braking or not. The lights won't turn off even after the car is off

NHTSA ODI 11592081