What 1,347 owners told NHTSA about the 2014 Ford Fusion Hev

The car is suffering random shutdown and intermittent times. The battery is no longer holding a charge and when it shuts down this places me at extreme risk. Ford is unable to fix it so this is no longer happening without replacing the High Voltage battery - battery from ford alone is 11k. I cannot be the only one who is dealing with this car doing this.

NHTSA ODI 11749732

I had multiple coolant leaks in the pass and I have to constantly replace the hose about every 2000-3000 miles Also my screen went out in my dashboard causing me to not be able to make any audio changes or station adjustments in my car Lastly whenever I get ready to increase my speed my car jerks back

NHTSA ODI 11665681

Nothing on my steering wheel that controls dash works

NHTSA ODI 11656670

The contact owns a 2014 Ford Fusion. The contact stated that while leaving a parking lot at approximately 10 MPH, the steering wheel seized. The contact turned off the vehicle and waited for a while before restarting the vehicle. The contact restarted the vehicle 3 times before being able to turn the steering wheel; however, the power steering functionality remained inoperable. The contact stated that the Service Advancetrac, Lane Keep Assis system malfunction, Hill Start Assist Not Available, Steering Assist Fault, and Service Required messages were displayed on the instrument panel. The dealer was contacted and informed of the failure. The dealer suggested that the contact take the battery to be tested. The battery was tested and there was no failure found with the battery. The vehicle had not been taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 150,000.

NHTSA ODI 11653101

A third party hacked my CPU/Transmission Control System causing malfunction with the engine. The engine randomly would cut off during traffic, and I would need to press gas directly after starting the vehicle to go. My vehicle was fairly new and transmission module should not be ineffective after purchasing my vehicle last July 2023 with less than 80K miles. The notification that makes the vehicle stay in the lane would malfunction randomly notifying me of failure to sensor active crash alert. I also have inability to connect to Ford vehicle app with no reason provided to cut off WiFi connectivity. Please review external IP as I can hear communication of third party observing my way of driving and communication while attempting to drive causing distraction affecting safety of myself, my location placement, and health of the car. Possible CPU/transmission/AC connectivity from July 2023 to Malfunction of vehicle starting 10/2024.

NHTSA ODI 11637520

When driving the car will stall out and die in the driving state. This occurs without warning from any sensor light error warnings. After acceleration to 35 it will sputter as if the fuel is not flowing, yet then it will correct but stall and completely die during operation while driving. Have had both the upper and lower full pumps installed within the last calendar yet still currently having the problem or issue. Experiencing the exact same Eco boost concerns as other Ford models have been recalled for as of recent

NHTSA ODI 11624341

I've had my Ford Fusion SE ecoboost 1.5, 2014 in for service on 2 separate occasions a day apart for the same reoccurring problems. The first service there was the actions done related to recalls which are consistent with 20S15 A-C and recall 23E03 B. The reasons for my Ford Fusion 1.5 to have been brought to the Premier Ford, Waveland, Ms was as follows: The temperature overheat lamp light was jared, there was 3 leaks from the overheat, there was a Shutter and sounds that came from the engine, (LIMP*)and there was no fuel power through acceleration. There had been moisture located on exhaust before brakedown without having been driven for approximately 10hrs before brakedown. 2ed service was as follows: temperature overheat lamp light jared, no power through fuel to accelerate, and issues starting. LIMP* I had not on this brakedown paid attention to if my Fusion needed water, the engines performance in regards to shakes or sounds nor did I look to notice nor did I look for leaks. I called directly to Premier Ford, Waveland and had my Ford towed in. The service was as follows: 1) 3U2Z*14S411*HYB WPT988 WIRE ASY 2) DS7Z*8501*E PW556 PUMPASP-WATER 3) BE8Z*8507*A GASKET-WATER PUMP 4)VC*13*G 3801132 ANTI-FREEZE 5) 6 BM5Z*6K2543*S437 SCREW 6) BM5Z*6K254*A TENSIONER - TIMING BELT With the parts 261.44 Labor 1748.99 misc charges 50.00 for a total of after taxes 2204.66 I picked up my Ford Fusion on October 4, 2024 and on October 9, 2024 I went beck to the Premier Ford and spoke with the service department because I had to stop and let my Fusion cool every 20 to 30 minutes, I stated that there was some loss of water and it was overheating, the power train light warning notify me of an issue, and that my Fusion would not go over 80miles per hr. The service department associate seemed frustrated with me and argued the fact that it had ran hot and said that the reason for the speed issue was that the lamp was Identifying the keylock complete on pdf

NHTSA ODI 11619482

Attachment to last complaint

NHTSA ODI 11619485

another attachment!

NHTSA ODI 11619497

The contact owns a 2014 Ford Fusion. The contact received notification of NHTSA Campaign Number: 14V736000 (Electrical System); however, the contact was informed by the dealer that during the reprograming of the instrument cluster, the instrument panel system had failed. The contact was informed that to repair the instrument cluster the dealer needed to perform a diagnostic test. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 89,000. Parts distribution disconnect.

NHTSA ODI 11619368

Slowing driving out of store parking lot, sudden heavy steering, loss of power steering, 'service advancetrac' & 'hill start assist unavailable ' traction control warning lights on

NHTSA ODI 11619221

"Temporarily lost communication with climate system". This fault has appeared several times. When it comes up, no controls in the vehicle work. This includes ac/heater, windows and radio. My daughter had to drive home from work last week with no ac and no means of putting the windows down. The temperature in the car was pushing 100 degrees. This is not safe and it's not the first time. You can get online and find many examples of the same issue on several models. When I spoke to the local Ford dealer service department, they had no answer.

NHTSA ODI 11610690

My car when it is parked it will randomly pop the trunk. A lot of issues I’m seeing is ford fusions 2014 and up! Few of my friends are having the same issues especially with keyless entry pad it’s causing issues from water damage or heat causing the car to to this! Their needs to be recall on that cause kids doors aren’t locking properly I have kids I had someone almost steal my car cause my trunk was popped open by itself! This is my second time reporting this I have [XXX] [XXX] and [XXX] I need my car! Can yall please fix this issue INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11603925

My vehicle has lost all power steering, and is giving notice that steering assist fault service is required. The vehicle also is manufactured and produced during they same time recall notice 19S26 came out, however, Ford is stating the VIN is not associated with that recall.

NHTSA ODI 11596474

The contact owns a 2014 Ford Fusion. The contact stated while driving 10 MPH around a curve, the steering wheel seized. The contact stated that several unknown warning lights were illuminated. There were abnormal beeping and chiming sounds detected. Additionally, the mileage changed from 54,529 to 88,529 without the vehicle being driven. The contact was able to park the vehicle. The vehicle was taken to an independent mechanic, who determined that the failure was due to the rack and pinion assembly and steering mechanism. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and opened a case. The failure mileage was approximately 88,529.

NHTSA ODI 11595532

I have 2014 ford fusion SE. Here lately my car has randomly been unlocking itself not only that popping trunk as well. I have took the time replacing the key fob battery first the checking lock adapters to my doors and also my keypad. I have it checked out. Yet nobody knows. I’m [XXX] with two kids this is very stress as a single parent trust that car is ensured locks it’s not. Yall need to do recall and fix this. I did speak with police department stating issues filing a report I didn’t have number but they said it documentation INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11591862

Power steering failing, will not correct itself to straight while driving without manual assistance, can stay locked in turned position.

NHTSA ODI 11573508

My transmission has failed multiple times. Luckily my car is under warranty, because I have been able to have it replaced twice, but both times, these malfunctions have put my life and countless others in danger, because the failure is sudden and not preceded by any warnings. This problem has reproduced twice and been confirmed and fixed both times by Sun’s Auto in Spring Texas. The vehicle has been inspected recently by the manufacturer as my shifter bushings also disconnected as part of a separate recall, resulting in a similar situation as the transmission failure. There have been no warnings prior to any of these issues occurring, and at this point recalling individual parts is not sufficient. The transmission and shifter bushing issues alone cost more to repair than the car is worth at this point, and they are extremely dangerous, especially when combined with the other active safety recalls for this same car such as the brakes, door latches, and steering. Almost every aspect of this car is unsafe as manufactured .

NHTSA ODI 11545286

Turned vehicle on one day & the parking break light came on, attempted to disengage with the parking break button but nothing released the breaks. Wouldn’t let me move the car when in drive. After trying to disengage with the button many times, decided to undo the battery because its electric & i was hoping to reset it & wait 20 mins. After doing so the release parking break warning, park break malfunction warning & parking break light was still on & it still didn’t move for another 20 minutes then suddenly after putting it in drive again it let me move. Now the release parking break warning, park break malfunction warning & the parking break light stays on even when actively driving & beeps the entire drive. No auto shops I’ve been to knows how to fix this! HELP PLEASE

NHTSA ODI 11543529

Rear view video system is failing either completely or halfway during the back up. Warning message says to contact dealership, who wants to run diagnostics in order to figure out cause. Despite video failure, the audio has continued to work properly. Did not want to pay costly fee to run diagnostics without shopping around for lower price.

NHTSA ODI 11542268

“Temporarily lost communication with the Climate System” error. Alert suddenly came on while driving, no prior issues or signs of error. Windows will not go down, air conditioner will not come on, cannot use climate touch screen or control volume from dash.

NHTSA ODI 11536644

The contact owns a 2014 Ford Fusion. The contact stated that while driving at various speeds, the vehicle inadvertently shut off after the ignition switch was slightly touched. The contact stated that the "Transmission Not in Park" message was illuminated on the instrument panel. The dealer and the manufacturer were notified of the failure and informed the contact that the vehicle was not under recall for the failure. The vehicle was not repaired. The failure mileage was 147,829.

NHTSA ODI 11527358

This problem has happened multiple times over the last few years. The windows, air conditioning and radio just stop working. Safety issue - hot day and can't roll windows down or turn the air on! Dealership wouldn't fix it because everything turned back on when we got to dealer, and then again stopped working again later. Very sporadic. Currently not working again.

NHTSA ODI 11522986

The contact owns a 2014 Ford Fusion. The contact stated that the horn was inoperable. Additionally, the rearview camera intermittently failed to operate while the vehicle was in reverse. The vehicle was taken to the dealer, where it was determined that the rearview camera and an unknown part needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 52,000.

NHTSA ODI 11516899

The trunk on my 2014 ford fusion SE randomly opens. This occurs 3 to 4 times per day. Sometimes while driving, other times while its parked. This obstructs my view, and can cause danger to other drivers if contents in my trunk fly out.

NHTSA ODI 11511094