What 1,347 owners told NHTSA about the 2014 Ford Fusion Hev

We are the owners of a 2014 Ford Fusion model vehicle. We took this vehicle to a local Ford service dealer to have the tires rotated. Dealer service manager told us they could not do the tire rotate because the chrome plating on the wheel lug nuts had swollen and their wrench would not fit the lug nuts. The offered non OEM replacement lugs nuts for our cost of $134.95 plus tax. I believe this is a safety issue as we could be stranded along any roadway should we have a flat tire needing us to use our spare, and unable to remove the flat tire. Our vehicle has a total of about 60,813 miles shown on the odometer. Apparently this swollen lug nut issue is a known problem with this vehicle? Can you help us resolve this?

NHTSA ODI 11623994

6 speed transmission has major manufacturers flaws.

NHTSA ODI 11623107

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the vehicle was hesitating. Additionally, the contact stated that the vehicle was not driving properly. The contact stated that later that day, while the vehicle was parked, the contact saw fluid on the ground underneath the front driver’s side of the vehicle. The vehicle was taken to the dealer where it was diagnosed with transmission fluid leak and half shaft seal failure. The contact was informed that either the half-shaft seal or the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The contact was informed of an unknown recall repair; however, the VIN was not associated with the recall. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 113,098.

NHTSA ODI 11622821

The seat belts are fraying at the stitching and the female end sometimes doesn’t want to let you put seat belts in or after there in they pop out for no reason

NHTSA ODI 11622547

When accelerating from a stopped position, the throttle is staying stuck wide open. Without my foot on the accelerator, the engine still accelerates wide open. Stepping on the brake, doesn't do anything or make it stop. It has now happened 3 times in the last 2 weeks. I was not taking off at a fast speed. I was accelerating at a normal rate.

NHTSA ODI 11621795

I've had my Ford Fusion SE ecoboost 1.5, 2014 in for service on 2 separate occasions a day apart for the same reoccurring problems. The first service there was the actions done related to recalls which are consistent with 20S15 A-C and recall 23E03 B. The reasons for my Ford Fusion 1.5 to have been brought to the Premier Ford, Waveland, Ms was as follows: The temperature overheat lamp light was jared, there was 3 leaks from the overheat, there was a Shutter and sounds that came from the engine, (LIMP*)and there was no fuel power through acceleration. There had been moisture located on exhaust before brakedown without having been driven for approximately 10hrs before brakedown. 2ed service was as follows: temperature overheat lamp light jared, no power through fuel to accelerate, and issues starting. LIMP* I had not on this brakedown paid attention to if my Fusion needed water, the engines performance in regards to shakes or sounds nor did I look to notice nor did I look for leaks. I called directly to Premier Ford, Waveland and had my Ford towed in. The service was as follows: 1) 3U2Z*14S411*HYB WPT988 WIRE ASY 2) DS7Z*8501*E PW556 PUMPASP-WATER 3) BE8Z*8507*A GASKET-WATER PUMP 4)VC*13*G 3801132 ANTI-FREEZE 5) 6 BM5Z*6K2543*S437 SCREW 6) BM5Z*6K254*A TENSIONER - TIMING BELT With the parts 261.44 Labor 1748.99 misc charges 50.00 for a total of after taxes 2204.66 I picked up my Ford Fusion on October 4, 2024 and on October 9, 2024 I went beck to the Premier Ford and spoke with the service department because I had to stop and let my Fusion cool every 20 to 30 minutes, I stated that there was some loss of water and it was overheating, the power train light warning notify me of an issue, and that my Fusion would not go over 80miles per hr. The service department associate seemed frustrated with me and argued the fact that it had ran hot and said that the reason for the speed issue was that the lamp was Identifying the keylock complete on pdf

NHTSA ODI 11619482

Attachment to last complaint

NHTSA ODI 11619485

another attachment!

NHTSA ODI 11619497

The contact owns a 2014 Ford Fusion Hybrid. The contact stated while driving 20 MPH, there was an abnormal sound coming from the front of the vehicle. The vehicle was driven to the dealer to be diagnosed. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and a case was opened. The failure mileage was approximately 76,000.

NHTSA ODI 11619359

The contact owns a 2014 Ford Fusion. The contact received notification of NHTSA Campaign Number: 14V736000 (Electrical System); however, the contact was informed by the dealer that during the reprograming of the instrument cluster, the instrument panel system had failed. The contact was informed that to repair the instrument cluster the dealer needed to perform a diagnostic test. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 89,000. Parts distribution disconnect.

NHTSA ODI 11619368

Slowing driving out of store parking lot, sudden heavy steering, loss of power steering, 'service advancetrac' & 'hill start assist unavailable ' traction control warning lights on

NHTSA ODI 11619221

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, an unknown warning light illuminated, and the contact noticed a ticking sound coming from the vehicle. The contact stated that the check engine warning light later became illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with engine failure. The contact was advised to take the vehicle to the dealer for assistance. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 32,000.

NHTSA ODI 11618160

The contact owns a 2014 Ford Fusion. The contact stated while attempting to drive, the gear shifter was moved to drive(D), but the vehicle failed to respond after several attempts. There was no warning light illuminated. The vehicle was towed to the residence. The dealer was notified of the failure and advised the contact to take the vehicle in for diagnostic testing. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Numbers: 19V362000 (Power Train) and 22V413000 (Power Train). The manufacturer was notified of the failure and informed the contact that the VIN was not included in a related recall. The failure mileage was approximately 114,000.

NHTSA ODI 11617825

Power steering failed after highway driving for approximately 1 1/2 hours. Was recently brought in for transmission wiring repair. Issue occurs intermittently, restarting the vehicle fixes it for a few minutes, but inevitably reoccurs.

NHTSA ODI 11617378

This is a attachment to my last Inquiry.

NHTSA ODI 11617112

On [XXX] ford premier out of waveland evaluated my car after I had to have it towed in due to overheating. The high temperature warning notification was lock and wouldn't change to normal after it cooled. I was not fully aware of my car overheating due to no warning other the the temperature overheat warning. A couple of days prior without driving it for 10hrs I noticed a moist to the exhaust pipe. When it broke down the engine had a misfire, a shake, and had not power to the engine to accelerate. There was 3 different puddles of fluids underneath the car. When I had spoke to the service department on this breakdown I made them aware of everything with one of the Mechanics witnessing the shake within the engine. There was a confusion on my part due to the sticker showing a 1.5l and my Insurance showing through carfax a 2.5l with also Descripting a 1.5l that showed for my car to be compatible to a 2.0l, 1.6l Installation of coolant system, that of which lead me to request recalls through Vin# on [XXX] through Verified and it was shown to be compatible for recall. Premier Ford service department Assured me that nothing was wrong with the coolant system that the power train control module reprogramming took care of the breakdown. He assured me when I picked up my car That nothing was wrong with my car. Except for me needing to go, change the brakes so that he could change the brake hoses that are part of the recall associated with the brakes. This was on [XXX]. On [XXX] I broke down again with the same issue with this time before the breakdown there was a stall when I started my car And when they had my car on [XXX] I asked them the check the Fuel Injections and he stated there was nothing wrong with the fuel injections. My car has shown every sign that shows through the coolant system of a fire hazard. I am requesting that the Department to assign the safety recall 17s09 to my vin# [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11617127

Complaints 11617112 and 11617127 Thank you for your patience with me!

NHTSA ODI 11617131

The contact owns a 2014 Ford Fusion. The contact stated while driving approximately 45 MPH and following a curve in the road, the steering wheel became firm. The contact stated that it was difficult to turn the steering wheel to the left or the right. There was no warning light illuminated. The contact stated that the failure was intermittent but was a recurring failure. The contact had taken the vehicle to an independent mechanic who diagnosed the vehicle and determined that the electronic power steering assist had failed and referred the contact to a dealer for assistance. The vehicle was not repaired. The contact stated that the steering wheel was no longer functional, and the vehicle was no longer being driven. The contact had researched online and related the failure to NHTSA Campaign Number: 15V250000 (Steering). The manufacturer was informed of the failure. The failure mileage was 106,329.

NHTSA ODI 11616389

The contact owns a 2014 Ford Fusion. The contact stated while driving at various speeds, there was a misfire coming from the engine. The vehicle lost motive power with white smoke coming from the exhaust system. Upon inspection, it was discovered that there was no coolant in the coolant reservoir. The vehicle was examined by an independent mechanic who determined that the engine short block was faulty due to coolant intrusion. The contact was informed that the engine short block needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 164,000.

NHTSA ODI 11616166

The contact owns a 2014 Ford Fusion. The contact stated that while adding coolant, the coolant was leaking out. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate properly. The vehicle was turned off and restarted and there was smoke detected. The contact opened the hood and noticed that the coolant level was low. The check engine warning light was illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 17V209000 (Engine and Engine Cooling). The vehicle was towed to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 60,000.

NHTSA ODI 11616205

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle lost motive power. The vehicle was taken to the dealer where it was diagnosed with a failed brake pedal bumper switch. The contact was informed that the brake pedal bumper switch needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ODI 11615976

The contact owns a 2014 Ford Fusion. The contact stated that the sternum of the steering wheel where the front driver's side air bag was located was popping out, and the front driver's side air bag was visible and seemed to be partially deployed. There was no warning light illuminated. The contact stated that the vehicle was unsafe to drive. The dealer was notified of the failure and advised the contact to the take the vehicle to their location for diagnostic testing. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under Ford Campaign Number: 19K02. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 91,000.

NHTSA ODI 11615550

The contact owns a 2014 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering warning light illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was towed to the dealer where it was diagnosed and determined that the steering wheel had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 119,000.

NHTSA ODI 11615285

My 2014 ford fusion titanium 2.0 ecoboost engine has Coolant leaks causing engine overheating, missfire on cylender 4, car keeps shuddering and stalling while driving. Contacted ford about this issiue they refused to fix it even though there is a mass recall on the same Caras mie for the same issiues

NHTSA ODI 11612922

See attached document for complaint.

NHTSA ODI 11612236