What 635 owners told NHTSA about the 2014 Chrysler Town And Country

The contact owns a 2014 Chrysler Town and Country. The contact stated that the TPMS warning light was illuminated and when the tires were rotated, the passenger’s side rear sensors could not be located, failing to identify a low tire pressure failure. The dealer was contact and stated the failure was outside the warranty window and the recall. The contact referenced NHTSA Campaign Number: 14V632000 (Tires) as a possible solution to the failure however, the VIN was not included in the recall. The manufacturer was notified of the failure. The failure mileage was approximately 119,000.

NHTSA ODI 11575731

The rear power outlet caught fire while driving today 03/05/2024. Nothing was plugged in to the outlet.

NHTSA ODI 11575792

When vehicle is exposed to consistent sunlight and heat during the spring/summer months, the driver's side power sliding door will not latch properly, causing the door to repeatedly try to latch itself shut. This occurs when opening/closing the door, and also while the vehicle is in motion. For example, if the door is shut properly, and the vehicle goes over a bump or something disrupts the ride, the door will think it is open, the warning light comes on the dashboard, the interior lights activate and the electric latch motor will repeatedly activate until the van thinks the door is closed. Even when parked, I have returned to the vehicle to find the door trying to close itself

NHTSA ODI 11573500

While driving on the highway, the passenger side headrest deployed without any warning or accident causing it to. A plastic part that holds a metal bar in place seems to have broken. No one was injured at the time. This seems to be a common problem. Chrysler needs to fix this! Who knows when the driver side one will deploy on its own with no accident.

NHTSA ODI 11572525

The contact owned a 2014 Chrysler Town and Country. The contact stated that after starting the vehicle five minutes later, it caught fire. The contact's daughter opened the driver's side door and noticed flames emerging from the door panel. There were no reported injuries. The fire department was called to extinguish the fire. A police report was not filed. There was no air bag deployment. The contact stated that the siding of the house had melted due to the fire. The vehicle was towed to a salvaged yard. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss by the insurance company. The contact mentioned that the failure may be related to NHTSA Action Number: PE20012 (Electrical System). The manufacturer was not contacted. The failure mileage was approximately 86,000.

NHTSA ODI 11571606

Transmission Oil Cooler Lines Leaking and Oil Filter Adapter Housing is Leaking.

NHTSA ODI 11569142

I am the original owner of a 2014 Chrysler Town & Country minivan. In the Spring of 2023 I went out to go run and errand and when I got into my van I saw that the headrest on the passenger side front seat had opened up. I tried to close it but it wouldn't move. When I got home I started checking to see what the deal was with the headrest and found out that the headrest had deployed without there being any sort of accident and fortunately there was no one in the seat at the time. Chrysler is not taking any responsibility for the problem. Now I have a failed headrest that is supposed to prevent injuries to passengers that is inoperable. And I have a questionable headrest on my driver's side seat that I don't know when it might decide to deploy one day when I am driving my vehicle. This is totally unresponsible of Chrysler and I think they need to be held responsible for this and replace their headrests at their own expense.

NHTSA ODI 11563120

I have a huge issue with the safety of my vehicle. while i am driving the car will race the RPMs up 6,000 up and down while I am going 65 on the highway, but the car down not speed up. the only way to stop it is to pull over the busy highway and restart the van. it will also sometimes drop down in gears and cause the vehicle to skid and shift the back end to the side. I called the deanship and they said the will not help. this is scary for me and my kids. to fix it would be over $5000 and that is more then the van is worth and I think it would be bad to sell it knowing this issue.

NHTSA ODI 11562462

Active head rest deployed without collision (or even being hit slightly).

NHTSA ODI 11559600

1.) my tire pressure warning light remains on and unable to detect if tires are actually low or not. It remains on even when tire pressure is at correct level. I got it checked by mechanic and he agreed that something is wrong with the sensor/system. 2.) both of my side mirror sensors will not turn off. I was driving and they were off (were previously working as normal), but then I went to get into another lane and someone was in my blind spot and I nearly hit them. Now they stay on and aren’t able to be utilized or trusted. There was no prior warning to any of these issues and now my vehicle feels extremely unsafe as I cannot use the safety features nor trust the tire pressure indicator.

NHTSA ODI 11554681

Driver and Passenger headrests have both deployed without an accident occuring.

NHTSA ODI 11554682

The passenger side head rest basically exploded it felt as if we had been rear ended but were not. It threw my head forward my seatbelt locked around my chest and neck we were in stop and go traffic so moving very slowly. My husband was driving he and I had no idea what happened we pulled over and examined it then i used my phone to look it up online. The head rest is supposed to have a safety mechanism similar to an air bag so that on impact it is supposed to release with a spring and bounce back to help prevent neck injury. However I found that Chrysler among other manufacturers opted to use a plastic and aluminum pin system which has been proven to just "let go" for no reason thankfully it was not the driver's side because we would have gone off the road or struck the vehicle in front of us. I had a headache and neck and upper neck pain for a few days but without health insurance i didn't get seen. We are only looking at getting this repaired i have attempted to contact a local dealership to fix it as it is still separated and looks awful. This is a safety issue and we should not have to pay for this repair. We financed the van in June and will be paying for it for the next few years. Thankfully nothing more serious did not happen when it malfunctioned

NHTSA ODI 11549360

2014 Town and Country - 78,000 miles vehicle experiencing crank no start. Known issue and no recall issued by manufacturer for this model.

NHTSA ODI 11544278

Drivers rear sliding door is in a locked position and it can not be opened. The dealership said it was a malfunctioned door lock actuator. Its the same part as the 2015 and up actuator that Chrysler extended the warranty on to replace the faulty part. My van falls under the mileage limit, but will not be covered because its a 2014. My opinion is , if the part was found faulty for the 2015 and is the same as the 2014, then the 2014 part is also faulty and should be covered.

NHTSA ODI 11544324

Before I started the car I tried to open the passenger sliding door but the door would not open with key fob, manually or interior dash button. (Only makes a clicking noise ). Then after driving 5-10 minutes the door opens on its own while driving. Kids and new born in car. Items fell out of car while driving. Interior light came on and my eldest was able to close the door. Very dangerous and distressing!

NHTSA ODI 11540411

I drive for Lyft and Uber and have had this vehicle spontaneously shut down while I am driving. I have had three places check it and it is NOT the starter, battery, or alternator. I have replaced the ECU and other items and the mechanics cannot tell me what's wrong. Furthermore, there are NO codes that show on the vehicle. The vehicle on the way to the mechanic shut down in traffic and as per usual, started back up and the traction control light came on. When the mechanic disconnected the positive cable on the battery to check the alternator, battery, and starter the code disappeared and the car drove fine on the way home. I have lost a lot of wages due to this issue and now I am afraid to drive the car. I have seen on several forums that this was an issue in the 2011 recall and now it is happening yet again. My car is a 2014 and others are both older and younger, all suffering from this same very scary detail. I hope I am not injured, nor anyone else will be injured, due to this issue. Mechanics are stumped with the problem. I have contacted an attorney and my next step is to call Chrysler but I do not expect them to address this issue unless or until many people die, are injured and then they get sued. Please let me know what, if anything, else I should do. I am putting you on notice of the issue and it's being widespread. In order to make sure I cover all my bases, this issue has happened now about 4x a week, it is not predictable, nor is it consistent with how fast or how slow I may be driving. I have had plenty of gas in the engine.

NHTSA ODI 11540160

The passenger side sliding door made an awful noise when closing and since then will not lock. It occasionally makes noises like it isn't closing properly but then does close. This happened about 2 weeks ago but we have not had it checked for repair as I feel this is a safety issue that should be addressed by Chrysler since my research has shown it is a very common complaint with Chrysler sliding doors as well as expensive repair. We are worried about the security of not being able to lock our vehicle as we frequently travel and even sleep in it.

NHTSA ODI 11538854

The driver side sliding door is not latching fully. The door will be shut and the indicator in blinking, the lights are going inside the car and the door is repeatedly trying to latch. The consumer stated that they brought the car to a certified Chrysler dealer to inquire about repairing the sliding door latch. At this time, the consumer is expected to cover the full cost of the repair.

NHTSA ODI 11534755

When hot, the drivers side passenger door does not latch. Multiple people have made comments about the same issue (many for the 2014 model) through various forums. No known solution exists. Would like NHSTA to see if/how many other complaints received as this should be a recall. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11534589

Driving along vehicle shut off. Back doors locked would not open had a 2 and 3, year old in car seats. Trunk wouldn’t open only front doors. Had to climb over the bucket seats to get the children out, trapped in heat, 2 year old with epilepsy. Got the children out, had to then pull their car seats over the bucket seats. Towed to garage. Was told it needed a fuse box $1500. On back order for 5 days. We are 2,000 miles from home. Repair shop tried to put part in van starts smoking Tells us to send it to the dealer who now says it needs a tipen for $2800. How does a vehicle just stop and lock its occupants in? If it was on fire, one or both of our babies could be harmed. We then had to fly home since we at the time had no vehicle and were way past our vacation. Our broken van is in Massachusetts.

NHTSA ODI 11534224

Passenger headrest randomly deployed. No accident no reason to deploy. Deployed when getting inside the vehicle.

NHTSA ODI 11532667

Right passenger sliding door has trouble latching when the weather is hot. For the past three years, every time the weather turns hot the sliding door acts up. It will close but won't completely latch unless you push hard on the back of the door, and even that doesn't last. I'll be driving down the road and randomly it'll unlatch and try to relatch with the door ajar alarm on the dash. I fear that the door will open on its own with my children in the back. But this only happens in the heat of the day. Many times I will hear my car alarm going off when I'm inside my home because it's trying to relatch itself.

NHTSA ODI 11532869

My vehicle engine light came on. Error code P0302 detected. Private mechanic referred to dealership for repair. Dealership confirmed original diagonals. Engine issues consistent with NHTSA bulletins D-14-22, 18-069-16 and 09-002-14. As part of the bulletin vehicle warranties were extended for select vehicle years. My vehicle is under both the year and mileage extension however, does not “qualify” per dealership due to vehicle year not being listed on the bulletins.

NHTSA ODI 11526912

Passenger Side Headrest literally exploded open due to a broken plastic tab. I was only mildly injured but definitely felt the after effects in my neck and back. Definite Safety concern. I'm worried the driver side headrest will do the same thing as we are driving. Absolutely should be a safety recall.

NHTSA ODI 11526578

I bought my 2014 Chrysler Town and Country not even a year ago and this is the second transmission that has went out on my van. I’m now in the process of fighting with the warranty company to get it replaced if possible. There’s no reason for this. The first time it went out was a month after I purchased it June 2022. Second time May 2023 (still in shop waiting).

NHTSA ODI 11526412