What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

DRIVER SEAT RATTLE DURING ACCELERATING AND BRAKING, THE NOISE IS KIND LOUD, AND VERY NOTICEABLE. THE CAR HAS ALREADY DONE THE FRONT SEAT RECALL.

NHTSA ODI 10789152

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT THE ENGINE OVERHEATED AND LEAKED FLUID INTO THE WIRES CAUSING THE VEHICLE TO SHUT OFF. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 72,000.

NHTSA ODI 10788600

PER THE MANUFACTURER RECOMMENDATIONS I UPDATED MY VEHICLE TO SYNC VERSION 4.4. EVER SINCE THEM I HAVE HAD SEVERAL DISTRACTING ISSUES OCCUR WITH THE HAND FREE PORTION OF THE SYSTEM. WHEN A CALL COMES IN THE SYSTEM WILL CONTINUE TO RING AFTER THE CALL IS ANSWERED. THE SYSTEM'S VOICE RECOGNITION IS VERY UNRELIABLE WITH THE SYSTEM EITHER NOT PERFORMING THE ACTION REQUESTED OR NOT PERFORMING AT ALL. ITS A HIT OR MISS PROBLEM WHEN USING THE VEHICLE TO MAKE A CALL. WHILE DRIVING THESE ISSUES DISTRACT THE DRIVER FROM PAYING ATTENTION TO THE ROAD AND CAN CAUSE AN ACCIDENT. THIS HAPPENS NO MATTER IF THE VEHICLE IS STATIONARY OR AT ANY SPEED. FORD IS AWARE OF THIS ISSUE BUT SO FAR HAS FAILED TO ADDRESS IT . IN THE FORD FOURMS THERE ARE PROMISES OF A NEW UPDATE SOON B BUT SO FAR NOTHING HAS HABBENED. THE VERSION OF SOFTWARE AFFECTED ARE SYNV 4.4 AND GEN2 - VERSION 3.8. AS THIS SOFTWARE IS CURRENTLY INSTALLED IN ALMOST ALL FORD UNITS COULD YOU PLEASE GET THEM TO EITHER FIX THE ISSUES WITH THE SOFTWARE OR ALLOW DEALERS TO REINSTALL EARLIER VERSIONS THAT DID FUNCTION CORRECTLY

NHTSA ODI 10787801

DEALER SERVICE MANAGER STATES THE AIR CONDITIONING COMPRESSOR SUFFERED A "CATASTROPHIC FAILURE" OF ITS INTERNAL PARTS. AS A RESULT, THE VEHICLE SHUT DOWN WHILE IT WAS BEING DRIVEN. DEALER STATES THE ENTIRE AC SYSTEM HAS TO BE REPLACED AT A COST OF $2500.00. THE PCM MAY ALSO BE AFFECTED BUT THAT CANNOT BE DETERMINED UNTIL THE VEHICLE IS IN A STATE WHERE IT CAN BE STARTED, WHICH WON'T BE ACHIEVED UNTIL AFTER THE ENTIRE AC SYSTEM IS REPLACED. THIS EXORBITANT REPAIR COST IS NOT COVERED UNDER ANY WARRANTY.

NHTSA ODI 10787403

THE DOOR LATCHES WERE KNOWN BY FORD TO BE FAULTY. WHILE DRIVING, THE PASSENGER SIDE DOOR LATCH FAILED AND THE DOOR OPENED. AFTER CONTACTING THE DEALERSHIP'S SERVICE DEPARTMENT, WE WERE TOLD FORD DIRECTED THEM TO NOT FIX THE ISSUE UNTIL THE LATCH FAILED. I THEN CONTACTED FORD CUSTOMER SERVICE AND WAS TOLD THE DECISION WAS A JOINT ONE BETWEEN THEM AND THE NHTSA, ESSENTIALLY PASSING THE BLAME. FORD HAS KNOWINGLY PUT UNSAFE CARS ON THE ROAD AND SHOWN NO CONCERN FOR THE PERSONAL SAFETY OF THEIR CUSTOMERS.

NHTSA ODI 10787201

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT THE KEY FAILED TO START THE VEHICLE. AFTER NUMEROUS ATTEMPTS OR DISCONNECTING THE BATTERY, THE VEHICLE WAS ABLE TO START. THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V597000 (AIR BAGS), BUT THE DEALER STATED THE PART WAS NOT AVAILABLE. THE CONTACT ALSO STATED THAT THE EPS AND THE POWER TRAIN WARNING LIGHTS ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ODI 10786315

CAR STALLED AND WENT INTO LIMP MODE (LIMITED POWER) SEVERAL TIMES OVER A 3 WEEK PERIOD. IT WOULD STALL AT TIMES WHEN BACKING OUT OF PARKING PLACES. AT A STOP LIGHT ON A BUSY ROAD, IT STARTED SHAKING AND RUNNING ROUGH, DEALER COULD NOT FIND CAUSE AND SENT CAR HOME. DRIVING DOWN A STREET 2 DAYS LATER, IT LOST ALMOST ALL POWER LIKE IT WAS RUNNING OUT OF GAS, BARELY MADE IT TO SIDE OF THE ROAD AND WAS HARD TO RESTART. AFTER SEVERAL DAYS, DEALER STATES THE ISSUE WAS FOUND TO BE A FAULTY FUEL PRESSURE SENSOR. CAR ONLY HAD 23,700 MILES ON IT.

NHTSA ODI 10786194

REAR BRAKE PADS AND ROTORS NEED REPLACED AT ONLY 37,000 MILES.

NHTSA ODI 10785317

LOW BEAM HEAD LIGHT PASSENGER SIDE HAS DIMMED REFLECTIVE SURFACE APPEARS CLOUDY AS PER RECALL 12C27 WAS ORIGINATED TO ADDRESS, THIS VEHICLE CONFORMS TO THIS RECALL'S MANUFACTURE DATE OF OCTOBER 04-2012 AND AT THE AFFECTED FACILITY OF HERMOSILLO, MEXICO, THE DEALER WAS CONTACTED YET REFUSES TO HONOR THE REPAIR STATING THAT MY VEHICLE IS NOT AFFECTED BY THIS RECALL!

NHTSA ODI 10782821

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT THE AIR BAG LIGHT REMAINED ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V597000 (AIR BAGS, SEAT BELTS) AND STATED THAT THE PARTS NEEDED FOR THE RECALL REPAIR WERE NOT AVAILABLE. THE CONTACT ALSO STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 23,000. ...UPDATED 01/20/16 *BF COMPLETED UPDATED4/17/18*JB *TR

NHTSA ODI 10780904

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V597000 (AIR BAGS) AND 15V246000 (AIR BAGS); HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 12/10/15*LJ UPDATED 04/13/18*JB *TR

NHTSA ODI 10779019

FIRST PROBLEM WITH THE CAR WAS HAVING PROBLEMS WITH FIRST STARTING IT IN THE MORNING WITH IT ACTING AS IF IT WASNT GETTING GAS UNTIL I STEPPED ON THE ACCELERATOR WHILE IN PARK, DEALERSHIP CLAIMED IT WAS A CRACKED WATER PUMP. THEN THE CHECK ENGINE LIGHT CAME ON WHILE DRIVING, THEY REPLACED HEAD GASKET AND INTAKE GASKET DUE TO THE CODE FROM THE CHECK ENGINE LIGHT. THEN THE CAR STOPPED ACCELERATING ON THE INTERSTATE AND WHEN I PULLED OVER AND TURNED IT OFF IT MADE LOUD CRACKING NOISES AND WOULDNT START. DEALERSHIP SAYS A PIECE UNDERNEATH THE WATER PUMP FELL OFF THEY BELIEVE IT WAS DEFECTIVE BECAUSE THE BOLT WAS HALF THE SIZE IT WAS SUPPOSE TO BE AND RUINED THE ENGINE. FIRST PROBLEMS STARTED IN MAY UNTIL MOST RECENT ONE IN SEPT.

NHTSA ODI 10778680

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V597000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIRS WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10778354

POWER STEERING FAILURE ON HIGHWAY WHILE TRAVELING AT 70MPH. FORD DEALER DIAGNOSED FAILURE OF STEERING RACK AND REPLACED. NEW RACK WILL NOT COMMUNICATE WITH VEHICLE MAIN COMPUTER. AS OF 9/27/15 FORD WILL NOT PROVIDE PLAN TO RESOLVE, TIMELINE TO RESOLVE, OR ANY FURTHER INFORMATION. VEHICLE REMAINS AT DEALER FACILITY AND IS NOT BEING RELEASED BECAUSE DEALER REPORTS "WE DON'T KNOW WHAT IT WILL DO."

NHTSA ODI 10777901

WHEN I TRIED TO PULL OUT MY CAR FROM THE PARKING LOT, THE POWER STEERING WAS LOST - I STARTED THE ENGINE, RELEASED THE BREAK, WAS ABLE TO MOVE FORWARD OR BACKWARD, BUT WHEN I TRIED TO TURN AROUND, THE STEER WAS STUCK, I CAN ONLY MAKE LITTLE TURN BUT THEN IT'S TOO HEAVY TO CONTINUE THE TURN. THIS HAPPENED THREE TIMES WITHIN ONE MONTH, BUT THERE WAS NO ERROR MESSAGE ON DASHBOARD. WHEN IT HAPPENED, STOPPING THE ENGINE AND RESTARTING, ONCE OR MANY TIMES, FIXED THE ISSUE. TOOK TO A DEALER BUT THEY WERE NOT ABLE TO READ ANY "CODE", AND THEY REFUSE TO TAKE FURTHER ACTION. THEY ASKED ME TO MONITOR THE CAR AND TAKE THE CAR TO THEM WHEN IT HAPPENS AGAIN.

NHTSA ODI 10775886

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V246000 (LATCHES/LOCKS/LINKAGES); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10767517

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 14V597000 (AIR BAGS, SEAT BELTS) AND 15V246000 (LATCHES/LOCKS/LINKAGES), HOWEVER, THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA ODI 10766458

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING APPROXIMATELY 70 MPH, THE POWER SHUT OFF. THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE BATTERY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

NHTSA ODI 10763957

I WAS DRIVING ON THE FREEWAY, AND FOR 2-3 SECONDS THE DASH, INSTRUMENT CLUSTER, CLIMATE AND ENTERTAINMENT CONTROLS WENT DARK AND GAVE NO READINGS. THEN THE CAR CHIMED LIKE IT DOES AT STARTUP AND THE CONTROLS AND SPEEDOMETER CAME BACK.

NHTSA ODI 10763236

(1) 5/2015 RIGHT SIDE PASSENGER DOOR INADVERTENTLY OPENED WHILE CAR WAS MOVING IN TRAFFIC. DOOR WILL NOT CLOSE. TAKEN TO FORD DEALERSHIP WHO KEPT CAR FOR OVER A WEEK AND STATED 'IT IS FIXED'; ONLY ONE DOOR LATCH WAS ADDRESSED. (2) 07/22/15 RIGHT SIDE PASSENGER DOOR INADVERTENTLY OPENED WHILE CAR WAS MOVING IN TRAFFIC. DOOR WILL NOT CLOSE. TAKEN TO FORD DEALERSHIP WHO KEPT CAR FOR 2 DAYS AND STATED 'IT IS FIXED'; ONLY ONE DOOR LATCH WAS ADDRESSED. (3) 08/04/15 RIGHT SIDE PASSENGER DOOR INADVERTENTLY OPENED WHILE CAR WAS MOVING IN TRAFFIC. DOOR WILL NOT CLOSE. TAKEN TO FORD DEALERSHIP WHO KEPT CAR FOR MORE THAN A WEEK, RETURNED TO OWNER AND STATED 'IT IS FIXED, BUT WE USED THE SAME PART THAT IS DEFECTIVE SINCE FORD HAS NOT YET PROVIDED A "FIX" FOR THIS PROBLEM. ONLY ONE DOOR WAS ADDRESSED. SERVICE AGENT ALSO STATED THAT "DURING THE SECOND "FIX" (SEE (2) ABOVE) PART WAS NOT REPLACED BUT ONLY 'CLEANED' BECAUSE NO PARTS WERE AVAILABLE. FORD NOTIFIED NHTSA OF THIS ISSUE 04/23/2015. DEALER NOTIFICATION SAFETY RECALL 15S16 WAS 04/30/2015. FORD HAS KNOWINGLY RETURNED A DEFECTIVE AND ADMITTEDLY UNSAFE VEHICLE TO OWNER THREE TIMES, FAILING TO FOLLOW RECALL REQUIREMENTS, AND STATING THAT "NOTHING FURTHER WILL BE DONE UNTIL SOMEONE GETS HURT". APRIL 30 2015 SAFETY RECALL 15S16 REQUIRES 'OBTAIN DOOR LATCH KIT AND INSTALL NEW DOOR LATCH ON EACH OF THE FOUR DOORS'. 15S16 ALSO STATES THAT 'PARTS ARE CURRENTLY NOT AVAILABLE IN SUFFICIENT QUANTITIES TO REPAIR ALL VEHICLES AFFECTED ... CUSTOMER VEHICLES SOLD BE REPAIRED ONLY IF THE VEHICLE ARRIVES AT YOUR DEALERSHIP WITH A BROKEN DOOR LATCH'. AS NOTED, OUR VEHICLE ARRIVED AT THE DEALERSHIP THREE TIMES WITH A BROKEN DOOR LATCH, WAS NEVER REPAIRED PER THE RECALL, BUT WAS RE-PRESENTED TO OWNER BY DEALER THREE TIMES AS "FIXED".

NHTSA ODI 10760581

NOT HAPPY WITH MY VEHICLE IF MY FIRST TIME BUYING A FORD FOR MY FAMILY. AFTER I PURCHASED THE VEHICLE I FOUND OUT IT ALREADY HAD RECALLS AND THE DEALER AT FORD AND DIDN'T NOTIFY ME ABOUT IT I REALLY DON'T FEEL SAFE AT ALL DRIVING THE VEHICLE. I MADE A REQUEST WITH FORD MOTOR COMPANY FOR A BUY BACK ON MY VEHECLE. AT THAT TIME IT WAS DENIED BECAUSE THERE WAS ONLY ONE RECALL. WELL NOW THERE IS EIGHT AND I REQUEST FOR A SECOND TIME FOR A BUY BACK I REALLY NEED TO RETURN THIS VEHICLE SO THAT I COULD REALLY SPEND A LITTLE MORE MONEY AND GET IN TO A BENZ OR BMW

NHTSA ODI 10759868

THE REGENERATIVE BRAKING WILL CUT OUT UNDER SPECIFIC CIRCUMSTANCES AND THE CAR WILL FEEL LIKE IT IS LURCHING FORWARD INSTEAD OF SLOWING DOWN. THE SITUATION IS: BRAKING USING ONLY REGEN BRAKES, NO FRICTION BRAKES; STEADY PEDAL PRESSURE; GOING 15-20 MPH; TURNING THE STEERING WHEEL AT LEAST 90 DEGREES LEFT OR RIGHT; DRIVING ON SMOOTH PAVEMENT. DATA I HAVE LOGGED FROM THE SOBDMC INDICATES THAT THE TRACTION MOTOR BRIEFLY REDUCES ITS NEGATIVE TORQUE WHICH CAUSES THE CAR TO SURGE FORWARD. IN ONE INSTANCE THAT I LOGGED THE NEGATIVE TORQUE SHOWS AROUND 48 FT-LBS AND THEN SUDDENLY DROPS TO ABOUT 8 FT-LBS. THE TRACTION MOTOR THEN GRADUALLY INCREASES TORQUE BACK TO THE APPROPRIATE LEVEL. IN ANOTHER INSTANCE THE NEGATIVE TORQUE SUDDENLY WENT FROM ABOUT 28 FT-LBS TO 8 FT-LBS. THE DROP IN TORQUE OCCURS IN 1/10 OF ONE SECOND PER MY LOGGED DATA. IT TAKES ABOUT 2.5-3.0 SECONDS FOR THE TRACTION MOTOR TO RETURN TO THE APPROPRIATE LEVEL OF NEGATIVE TORQUE TO STOP THE VEHICLE. THIS BEHAVIOR BEGAN OCCURRING RIGHT AFTER OUR VEHICLE WAS SERVICED BY A LOCAL FORD DEALERSHIP. THE WORK DONE BY THE FORD DEALERSHIP INCLUDED REPLACING THE 12V BATTERY & 3 RECALLS: 14S21, 15E03 & 15S14. I BELIEVE THAT THIS SERVICE IS RESPONSIBLE FOR THESE PROBLEMS, AS THIS ISSUE WAS NOT PRESENT BEFORE OUR CAR WENT TO THE DEALERSHIP.

NHTSA ODI 10758745

WHILE DRIVING TO THE PARK WITH MY THREE YEAR OLD NEPHEW IN THE CAR THE FRONT PASSENGER DOOR FULLY OPENED WITH OUT BEING TOUCHED. I PULLED OVER AND CAR DOOR WOULD NOT LATCH. I CALLED FOR ASSISTANCE AS I COULD NOT DRIVE THE CAR WITH THE DOOR OPEN. THANKFULLY THERE WAS NO ONE IN THE FRONT PASSENGER SEAT BUT MY NEPHEW WAS RIGHT BEHIND IT AND THIS DEFECT PUT HIS LIFE IN DANGER.

NHTSA ODI 10750287

WHEN DRIVING AROUND A RIGHT HAND TURN THE DRIVES SIDE DOOR SWUNG OPEN. THE LATCH WILL NOT CATCH. THE CAR IS UNSAFE TO DRIVE AS THE DRIVERS SIDE DOOR WILL NOT LATCH CLOSE. THIS IS THE SAME PROBLEM THAT OTHER FORD CARS HAVING BUT THIS ONE IS NOT UNDER A RECALL. HOW CAN IT NOT BE? THIS IS A SERIOUS SAFETY PROBLEM. THE DEALERSHIP WOULD NOT REPAIR IT. THE COST IS $460 PLUS A RENTAL. MY WIFE WAS DRIVING THE CAR AT THE TIME OF THE INCIDENT. IF IT WAS ON THE FREEWAY THERE COULD HAVE BEEN SERIOUS INJURIES OR MORE NOT TO JUST MY WIFE BUT ANYONE CLOSE TO HER. THIS NEEDS A RECALL NOW NOT MONTH FROM NOW.

NHTSA ODI 10749756

REAR PASSENGER DOOR LATCH FAILED. DOOR WOULD NOT REMAIN CLOSED WHILE PARKED OR DURING TRAVEL.

NHTSA ODI 10749236