What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

WE WERE DRIVING DOWN THE HIGHWAY 2 HOURS FROM HOME AND I HAD A WARNING LIGHT COME ON, ENGINE COOLANT TEMPTRESS OVERHEATED. SO ME AND MY HUSBAND PULLED OVER ON THE SIDE OF THE ROAD EVERYTHING LOOKED FINE, WE HAD COOLANT.WE SAT FOR ABOUT 10 MINS TO BE SAFE. AND PROCEEDED DOWN THE HIGHWAY. AFTER 2 MINS WE HAD ANOTHER WARNING LIGHT COME ON STEERING SYSTEM FAILURE. AT THIS POINT HE COULDN'T MOVE THE WHEEL SO WE PULLED OVER AGAIN AND AS SOON AS WE STOPPED BLACK SMOKE CAME IN THE VENTS AND UP THE WINDSHIELD. AS WE OPEN OUR DOORS THERE IS FLAMES COMING IN THE DOOR ON THE FRONT PASSENGER SIDE WE QUICKLY EVACUATED THE VEHICLE AND CALLED 911.

NHTSA ODI 10967382

RIGHT PASSENGER DOOR FLEW OPEN WHILE IN MOTION ENTERING MY PARKING GARAGE. PASSENGER DOOR WON'T CLOSE AT ALL.

NHTSA ODI 10967043

TL* THE CONTACT OWNED A 2013 FORD FUSION. WHILE ATTEMPTING TO DRIVE 5 MPH, THE CONTACT'S VEHICLE WAS STRUCK ON THE FRONT DRIVER'S SIDE BY ANOTHER VEHICLE. THE DRIVER'S SIDE AND CENTER AIR BAGS DEPLOYED, BUT THE PASSENGER SIDE AIR BAG DID NOT DEPLOY. THE CONTACT ALSO STATED THAT THE DRIVER'S AND FRONT PASSENGER SEAT BELTS FAILED TO RETRACT AND SECURE DURING THE IMPACT. THE CONTACT SUSTAINED A HAND (METACARPAL) INJURY THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT COULD NOT BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

NHTSA ODI 10966186

WHILE DRIVING AT LOW SPEED (LESS THAN 10MPH) THE CAR BEGINS TO RUN VERY ROUGH, RPM DROPS, AND WHEN PRESSING THE ACCELERATOR, THERE IS NO POWER, AND THE CAR THEN DIES. IT CAN BE RESTARTED, BUT IT'S A BIT HARDER THAN NORMAL, AND THEN IT RUNS. TWICE HAPPENED IN PARKING LOTS, BUT ONCE PULLING INTO TRAFFIC FROM A PARKING LOT, NEARLY CAUSING AN ACCIDENT. DEALERSHIP HAS CHARGED $190 ONLY TO TELL ME THEY CAN FIND NOTHING WRONG. SERIOUS SAFETY ISSUE. FORD CASE #CAS11900027

NHTSA ODI 10966203

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING 35 MPH, THE FRONT PASSENGER SIDE DOOR FLEW OPEN. THE CONTACT STATED THAT THE DOOR FAILED TO LATCH SECURELY. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE INSIDE DOOR LATCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.

NHTSA ODI 10965935

ON DECEMBER 5TH 2016 AT APPROXIMATELY 6:15, MY VEHICLE WAS INVOLVED IN A VIOLENT REAR END ACCIDENT. A 1980 STEEL PICK UP RAN INTO THE BACK OF MY STATIONARY 2013 FORD FUSION. CAUSING MAJOR REAR END DAMAGE AND PHYSICAL INJURY TO THE OCCUPANTS OF THIS STATIONARY CAR. MY MOTHER WAS PROPERLY PLACED IN HER PASSENGER SEAT'S SEAT BELT. HOWEVER, HER RIGHT ARM WAS DAMAGED DUE TO IMPROPER SUSPENSION UPON IMPACT. AS A RESULT SHE NO LONGER HAS USE OF HER RIGHT HAND DUE TO NERVE DAMAGE.

NHTSA ODI 10960265

TL* THE CONTACT OWNS A 2013 FORD FUSION. ON SEVERAL OCCASIONS, WHILE DRIVING THE VEHICLE AT DIFFERING SPEEDS, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.

NHTSA ODI 10959155

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING AT LOW SPEEDS IN A PARKING LOT, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO RESTART THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. UPDATED 05/17/17*LJ UPDATED 05/25/2017 *JS

NHTSA ODI 10958874

I RECEIVED A RECALL FOR A DEFECTIVE SEAT BELT ASSEMBLY IN MY 2013 FORD FUSION WEEKS AGO. BECAUSE THIS VEHICLE IS USED IN A FLEET CAPACITY, I PULLED IT FROM SERVICE IMMEDIATELY. I TALKED TO FORD AND WAS TOLD THERE IS NO REMEDY AT THIS TIME. I THEN ASKED FOR A LOANER VEHICLE UNTIL MY VEHICLE WAS SAFE TO DRIVE AND WAS TOLD THAT FORD DOESN'T HAVE A RENTAL PROGRAM FOR RECALLS. I DON'T KNOW HOW THIS MANUFACTURE DOESN'T HAVE A PLAN TO RECTIFY AN INCONVENIENCE THAT THEIR CUSTOMERS HAVE TO GO THROUGH REGARDING A PROBLEM THAT WASN'T THE CUSTOMERS FAULT TO BEGIN WITH. I'M VERY UNHAPPY FORD TREATS CUSTOMERS LIKE THIS.

NHTSA ODI 10957803

MY HUSBAND WAS DRIVING HIS FORD FUSION INTO THE DRIVEWAY OF OUR HOME WHEN THE PASSENGER CAR SIDE DOOR OPENED. SINCE THEN PASSENGER SIDE DOOR WILL NOT CLOSE PROPERLY. I RESEARCHED THIS A BIT AND FOUND THAT THERE HAVE BEEN A LARGE AMOUNT OF RECALLS ON THE DOORS BECOMING UNLATCHED WHILE DRIVING FOR THIS 2013 FORD FUSION BUT WHEN I SPOKE WITH THE FORD DEALERSHIP THEY SAID THAT MY VEHICLE WAS NOT COVERED UNDER THE RECALL.

NHTSA ODI 10957451

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V875000 (SEAT BELTS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 10957274

I HAVE HAD MY FORD FUSION FOR 6 MONTHS. OVER THE LAST 2 MONTHS I HAVE HAD ISSUES WITH BRAKING. THE BRAKES FAIL FOR A SPLIT SECOND JUST BEFORE COMING TO A COMPLETE STOP TO ADD TO THAT IT SOMETIMES DECIDES TO SURGE AND LURCHES FORWARD JUST BEFORE IT STOPS. IT HAS BEEN IN AND OUT OF THE FORD DEALER FOR REPAIR, THE FIRST FEW TIMES I WAS TOLD NOTHING WAS WRONG. THE LAST TIME, THEY DECIDE TO REPLACE THE THROTTLE BOTTLE AND A MODULE. FOR A FEW DAYS THE CAR SEEMED TO BE DOING BETTER UNTIL TODAY WHEN PULLING INTO MY DRIVEWAY. AS I WAS STOPPING TO PARK, THE CAR LURCHED FORWARD INTO A PILE OF WOOD. IF THIS HAD BEEN AT AN INTERSECTION OR SOMEONE CROSSING IN FRONT OF ME THIS COULD HAVE BEEN FATAL. I AM NOW SCARED TO DRIVE THE CAR AT ALL! LET ALONE LET MY TEEN DRIVE BEHIND THE WHEEL. I AM OUT OF OPTIONS! I CANNOT REFINANCE ANOTHER CAR.

NHTSA ODI 10957385

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING VARIOUS SPEEDS, THE FRONT PASSENGER SIDE AIR BAG WARNING INDICATOR ILLUMINATED "OFF", WHETHER OR NOT THE SEAT WAS OCCUPIED. THE CONTACT ALSO MENTIONED THAT THE VEHICLE WAS DIFFICULT TO START AND WOULD STALL. THE VEHICLE WAS ABLE TO RESTART AFTER SEVERAL ATTEMPTS. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

NHTSA ODI 10957429

ON MULTIPLE OCCASIONS MY CAR HESITATED AND STALLED, USUALLY WHEN JUST TAKING OFF OR PULLING OUT INTO INTERSECTIONS. IT HAS NEVER DONE THIS WHILE SITTING AT IDLE AND ONLY ONCE WHILE DRIVING HIGHWAY SPEED. SOMETIMES THE CHECK ENGINE LIGHT DOES NOT COME ON AND SOMETIMES IT COMES ON AND THEN GOES RIGHT BACK OFF. MY MECHANIC COULD NOT PULL A CODE AFTER THIS HAPPENS.

NHTSA ODI 10956894

EVER SINCE I PURCHASED MY CAR (USED) IT HAS MAKE A LOUD POPPING NOISE WHEN I TURN THE STEERING WHEEL ALL THE WAY TO THE LEFT. I HAVE TAKEN IT TO MANY AUTO SERVICE SHOPS (INCLUDING AUTHORIZED FORD SHOPS) AND NO ONE COULD EVER FIND THE ISSUE (SOUNDED LIKE IT WAS COMING FROM THE TIRE). THE OTHER DAY WHEN I GOT IN MY CAR TO GO TO WORK, THE ABS AND POWER STEERING WARNINGS WERE BOTH BLINKING ON MY DASH. I TRIED TO TURN MY WHEEL TO SEE IF THE POWER STEERING WAS OUT AND IT WAS NOT WORKING. I TURNED MY VEHICLE OFF AND BACK ON AND IT SEEMED TO RESET BOTH THE ABS AND POWER STEERING MODULES. I WAS ABLE TO DRIVE MY CAR TO WORK AND THEN TO THE DEALERSHIP TO GET IT CHECKED OUT. THE STEERING GEAR IS FAILING, MY VEHICLE IS ONLY 2 YEARS OLD AND HAS LESS THAN 80K MILES. THIS IS A RECALL FOR 2013 FORD FUSIONS BUT MY VIN # IS NOT INCLUDED. I HAVE DONE RESEARCH AND HAVE READ OTHER'S STORIES AND THIS CAN HAPPEN WHILE I AM DRIVING, I GOT LUCKY THIS TIME AND IT SHOWED UP FIRST THING WHEN I TURNED MY VEHICLE ON.

NHTSA ODI 10956683

CAR ENGINE STALLS WHEN STARTING OFF AND AT SLOW SPEEDS.

NHTSA ODI 10956212

NOVEMBER 2016 WHILE I WAS COMING FROM THE GROCERY STORE MY CAR SUDDENLY STALLED AND COMPLETELY STOPPED. I IMMEDIATELY STARTED THE CAR BACK UP AND DROVE FOR A GOOD 2 MINUTES AND IT DID THE SAME THING, BUT THIS TIME I WAS IN THE STREET. AFTER LETTING MY VEHICLE SIT FOR 15 MINUTES IT DID EVENTUALLY START BACK UP AND DROVE SMOOTHLY. BUT THAT WASN'T THE LAST TIME MY CAR WOULD JUST SUDDENLY STOP. IN DECEMBER I TOOK MY CAR TO THE DEALERSHIP FOR AN OIL CHANGE AND TOLD THEM WHAT HAD HAPPEN TO MY CAR. THE CHECK MY FLUIDS AND TOLD ME NOTHING WAS WRONG (WHICH WAS A LIE). EVERYDAY SINCE NOVEMBER IF I DRIVE MY CAR TOO MUCH, IT SHUTS OFF. IF I AM ON THE FREEWAY IN TRAFFIC, MY CAR WILL JUST TURN OFF. NOW FEBRUARY, I RECEIVED AN ERROR MESSAGE (ENGINE COOLANT OVER TEMPERATURE) AND MY CAR WILL NOT MOVE AT ALL. CALL FORD MOTOR AND WAS TOLD MY CAR WASN'T INCLUDED IN THE RECALL IN REGARDS TO THE ENGINE, CONTACT THE DEALERSHIP AND I HAVE TO PAY FOR IT TO BE TOWED TO THEM , BECAUSE THE PART MIGHT NOT BE INCLUDED IN MY WARRANTY. MY CAR HAS 76,000. I DO MY OIL CHANGES AND MAINTENANCE ON TIME, AND ALWAYS GO TO THE DEALERSHIP. MY CAR LIGHTS IN THE INSIDE TURNS ON WHILE I'M DRIVING WITHOUT ME EVEN PUSHING THEM (CREEPY). MY SEAT BELT DOESN'T REALLY RESTRAIN ME AND MY SEAT DOESN'T REALLY MOVE BACK AND FORWARDS LIKE IT SHOULD.

NHTSA ODI 10956303

ON LOCAL ROAD, VEHICHLE HESITATES WHEN I STEP ON THE GAS. WHEN I GET TO A STOP LIGHT IT SHUDDERS THEN STALLS. THIS OCCURS FREQUENTLY FOR THE PAST TWO WEEKS AS OF THIS ENTRY DATE.MY VEHICLE HAS UNDER 53K MILES AND THE DEALER SAYS THE PART AND FIX IS NOT UNDER WARRANTY. ITS CALLED A LO PRESSURE GAS SENSOR I BELIEVE. IF ITS ATTACHED TO THE GAS TANK THEN HOW COULD IT NOT BE UNDER WARRANTY WITH UNDER 60K MILES STANDARD COVERAGE.IS THIS STANDARD FOR ALL DEALERSHIPS WITH WARRANTY COVERAGE OR LACK THERE OF FOR THIS PART.

NHTSA ODI 10956402

WHILE DRIVING THE CAR ON A LOCAL ROAD THE STEERING ABRUPTLY STOPPED WORKING, ALMOST CAUSING AN ACCIDENT. THE CAR BECAME VERY DIFFICULT TO CONTROL AND THE ABS, TRACTION CONTROL, TRACTION CONTROL OFF AND AIRBAG WARNING LIGHTS ILLUMINATED. AN EPAS WARNING APPEARED ON THE SERVICE MONITOR SCREEN. WHEN I PULLED OVER AND TURN THE CAR OFF AND ON AGAIN EVERYTHING OPERATED NORMALLY. WHEN I MADE A LEFT TURN INTO A GAS STATION THE SAME PROBLEM OCCURRED ALMOST CAUSING ME TO DRIVE INTO A CAR EXITING THE GAS STATION BECAUSE IT WAS SO DIFFICULT TO TURN THE VEHICLE. THE SAME WARNING LIGHTS CAME ON. IT APPEARS TO BE A DEFECTIVE PART IN THE ELECTRONIC POWER STEERING. I DON'T KNOW IF THIS IS THE SAME PART INVOLVED IN THE PREVIOUS GENERATION OF FUSIONS WITH THE EPAS THAT WAS RECALLED. PLEASE INVESTIGATE, THIS IS DANGEROUS PROBLEM AND THERE ARE A LOT OF 2013+ FUSIONS ON THE ROAD WITH THIS SAME EPAS SYSTEM AS MINE.

NHTSA ODI 10955763

WEAR OR CORROSION ON THE FRONT SPEED SENSOR HARDNESS LED TO THE DISABLING OF ALL TRACTION/STABILITY CONTROL, REAR PARK ASSIST, ABS AND AIRBAG OPERATION.

NHTSA ODI 10956042

ONE OF THE HEADLAMPS WENT OUT 2 YEARS AGO AND IT IS DEALER ONLY REPAIR FOR $250.

NHTSA ODI 10956179

I TRADED THIS CAR INTO THE COVERT FORD DEALERSHIP LAST 8-2016. THE DOOR WOULDN'T CLOSE AND I WENT TO TRADE THE CAR IN THIS WAS THE SAME EXACT PROBLEM LISTED IN THE DOOR LATCH RECALL. THEY MADE ME PAY FOR THE PARTS TO FIX THE DOOR, MY VEHICLE WASN'T INCLUDED IN THE RECALL. I WAS UNAWARE OF THE FORD DOOR LATCH PROBLEM AND MY DAD HAD TOLD ME AFTER THE FACT THERE WERE RECALL PROBLEMS AND ARTICLES ALL OVER THE INTERNET. MY VEHICLE WAS MANUFACTURED IN MEXICO, AND THIS WAS A SOURCE OF THE PROBLEM. I HAVE TRIED TO CONTACT FORD TO REPORT THIS AND EXPAND THE RECALL AND I GET ABSOLUTELY NO WHERE. I WANTED TO SEE ABOUT GETTING REFUNDED FOR WHAT THE DEALERSHIP CHARGED ME AT TRADE IN. I WAS AMAZED THAT FORD NEW OF THE PROBLEM AND STILL DID NOTHING, TO TRY AND EXPAND THE RECALL. THIS IS A VERY DANGEROUS ISSUE. I WAS HOPING TO GET SOME HELP OR GETTING SOME FURTHER INFORMATION FROM YOU ALL.

NHTSA ODI 10955653

2013 FORD FUSION WITH 60,000 MILES - WHILE DRIVING ON THE HIGHWAY AT 65 MPH A POWER STEERING WARNING LIGHT CAME ON THAT READ "STEERING LOSS / STOP SAFELY". SUDDENLY THE POWER STEERING WENT COMPLETELY DEAD AND IT WAS NEARLY IMPOSSIBLE TO MOVE THE VEHICLE OR RECOVER THE CAR'S STEERING AT ALL. LUCKILY, I WAS ABLE TO SLOW THE ENGINE DOWN AND MOVE JUST ENOUGH TO THE SIDE OF THE ROAD WHERE I COULD GLIDE TO A STOP. MY FAMILY AND I COULD HAVE BEEN KILLED OR COULD HAVE HURT OR KILLED OTHERS WITH THIS FAILURE. RESEARCH HAS SHOWN THAT THOUSANDS OF OTHERS HAVE HAD SIMILAR ISSUES, AND THAT THERE IS A LAW SUIT AGAINST FORD IN CALIFORNIA SEEKING CLASS ACTION STATUS. MY CALLS TO FORD WERE ESSENTIALLY IGNORED AND I WAS PUSHED BACK ON THE DEALERSHIP, WHO HAD NO POWER TO AUTHORIZE ANY REIMBURSEMENT FOR THE $2000 EXPENSE. IT IS UNFORTUNATE THAT IT WILL TAKE A MAJOR COLLISION WHERE SOMEONE IS SERIOUSLY INJURED OR EVEN KILLED FOR THIS TO BE FIXED. HOPEFULLY THE NHSA AND THE LAWSUIT WILL RECTIFY THIS WITH THESE VEHICLES.

NHTSA ODI 10955131

REAR PASSANGER DOOR LATCH FAILS, DOOR FLYS OPEN WHEN DRIVING AND WILL NOT CLOSE.

NHTSA ODI 10954496

AFTER TURNING ON THE IGNITION AND STARTING TO DRIVE AWAY, THE CAR ENGINE WILL SPUTTER, ACTS LIKE ITS STARVING FOR FUEL, STARTS BUCKING AND THEN SHUTS OFF. NO CODES OR WARNING LIGHTS ARE DISPLAYED. THIS HAS HAPPENED IN PARKING LOTS AND ON STREET PARKING. IT IS VERY DANGEROUS AND I ALMOST GOT IN AN ACCIDENT WHEN ATTEMPTING TO PULL INTO TRAFFIC FROM A PARALLEL PARKING STALL ON THE STREET. PRESSING ON THE ACCELERATOR HAS NO AFFECT. AFTER RESTARTING THE ENGINE, IT RUNS FINE UNTIL I TURN OFF THE CAR. THEN IT IS RANDOM IF IT WILL OCCUR AT THE NEXT ENGINE START. AFTER OWNING THE CAR FOR 3.5 YEARS, THIS JUST STARTED HAPPENING LAST WEEK. IT HAS HAPPENED 8 TIMES OVER THE LAST 7 DAYS. AT FIRST IS ONLY HAPPENED 1 A DAY, BUT RECENTLY IT IS HAPPENING MULTIPLE TIMES A DAY.

NHTSA ODI 10954300