What 1,774 owners told NHTSA about the 2013 Ford Fusion Energi

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V875000 (SEAT BELTS) FOR THE PRETENSIONERS. THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 10950331

MY CHECK ENGINE LIGHT CAME ON WHILE I WAS ON MY WAY HOME FROM WORK. WHILE SITTING IDLE AT A STOPLIGHT, THE CAR WARNED THE ENGINE WAS OVERHEATING SO I PULLED OVER AND SHUT IT OFF FOR 20 MINUTES. THE NEXT MORNING WHEN I WENT OUT TO MY CAR, I NOTICED A LARGE AMOUNT OF CLEAR FLUID HAD LEAKED OUT. ON MY WAY TO THE DEALERSHIP, THE CHECK ENGINE LIGHT WENT OFF AND (ACCORDING TO THE DEALERSHIP) STAYED OFF UNTIL I PICKED THE CAR BACK UP AND STARTED DRIVING HOME. AFTER RUNNING DIAGNOSTICS AT THE DEALERSHIP, IT TURNS OUT THAT THE ENGINE BYPASS SOLENOID VALVE SHORTED OUT DUE TO A FAULTY COOLANT TEE ON THE HEATER CORE INLET. AFTER DOING SOME RESEARCH, IT SEEMS THAT THIS WAS A RECALL ON 2013 FORD FUSION SE 1.6L CARS. I CONTACTED MY LOCAL FORD DEALERSHIP AND WAS TOLD THAT MY SPECIFIC 2013 FORD FUSION SE 1.6L WAS NOT PART OF THIS RECALL (ALTHOUGH IT WAS INCLUDED IN THREE OTHER RECALLS FROM FORD). AFTER A SIMPLE SEARCH, I DISCOVERED THAT THIS SEEMS TO BE A WIDESPREAD ISSUE WITH THIS CAR-REGARDLESS OF THE RECALL. APPARENTLY OTHER 2013 FORD FUSION OWNERS NOT INCLUDED IN THE RECALL ARE EXPERIENCING THE EXACT SAME ENGINE COOLANT PROBLEM. IT ALSO SEEMS THE ORIGINAL RECALL HAD TO BE REOPENED TO INCLUDE ADDITIONAL VEHICLES. PERHAPS IT NEEDS TO BE REOPENED AGAIN.

NHTSA ODI 10949962

POWER STEERING ASSIST FAULT LIGHT CAME ON AND REMAINED ON UNTIL I PRESSED "OK" BUTTON. STEERING 'SEIZED UP', MAKING IT IMPOSSIBLE TO STEER, OR TURN THE CAR.THE LIGHT HAD INTERMITTENTLY BLINKED ON, THEN OFF, 2 PREVIOUS TIMES IN THE PAST 4-6 WEEKS, BUT NOT STAYING ON LONG ENOUGH TO READ THE WARNING IN ENTIRETY. THIS TIME THE WARNING STAYED ON UNTIL I MANUALLY TURNED IT OFF. UPON RESEARCHING, I FOUND THE RECALL (#15V250000) FOR HUNDREDS OF THOUSANDS OF 2013 FORD FUSIONS. I ALSO FOUND, TOO NUMEROUS TO COUNT, COMPLAINTS ALL OVER THE INTERNET OF EXACT SAME SCENARIO, AND THESE VEHICLES NOT BEING UNDER THE RECALL EITHER. I CALLED FORD MOTOR COMPANY CUSTOMER SERVICE AND GOT SOMEONE IN A FOREIGN LAND, THAT CONTINUED TO REPEAT, YOUR VEHICLE IS NOT AMONG THOSE IN THE RECALL, YOU MUST TAKE YOUR CAR TO A FORD DEALER FOR INSPECTION OF THIS PROBLEM. NO MATTER WHAT CONCERN OR QUESTION I POSED TO HIM, THAT WAS THE ONLY ANSWER I RECEIVED. I HAVE MADE AN APPOINTMENT WITH A LOCAL FORD DEALER TO HAVE THE CAR INSPECTED. I AM VERY DISAPPOINTED THAT THIS WILL BE AN OUT OF POCKET EXPENSE TO ME.

NHTSA ODI 10948999

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE ATTEMPTING TO ACCELERATE FROM A STOP SIGN, THE ENGINE STALLED WITHOUT WARNING. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC THROTTLE BODY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

NHTSA ODI 10948488

THE PASSENGER SIDE DOOR LATCH WILL NO LONGER LATCH AND SWINGS OPEN FREELY

NHTSA ODI 10948057

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V875000 (SEAT BELTS); HOWEVER THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 05/16/17*LJ *CN

NHTSA ODI 10948016

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V875000 (SEAT BELTS); HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ODI 10948056

MY VEHICLE HAS BEEN DIAGNOSED WITH A COMPLETE POWER STEERING GEAR FAILURE, JUST OUTSIDE BUMPER TO BUMPER WARRANTY. MY CAR HAS 33,000 MILES. I HAVE DONE RESEARCH ONLINE AND NOTICED FORD HAS PENDING LAWSUITS FOR THIS ISSUE AND MANY COMPLAINTS AND DECIDED TO HIDE THE ISSUE THEY KNEW ABOUT AND PUT THE CUSTOMER ON THE HOOK FOR THE $1900 REPAIR COST WHICH IS RIDICULOUS. THIS COULD HAVE HAD DEADLY CONSEQUENCES FOR ME AS THE POWER STEERING FAILURE CAME ON WHILE GOING AT FREEWAY SPEED. LUCKILY IT HAD JUST ENOUGH TO GET ME OFF THE FREEWAY OR I WOULD HAVE MOST LIKELY BEEN INVOLVED IN A CRASH AS I HAD NO STEERING. I HAVE OWNED MULTIPLE FORDS WITH 190,000 MILES AND NEVER HAD ISSUES WITH THE OLD DESIGN. THE NEW ELECTRONIC SYSTEM OBVIOUSLY HAS MAJOR DESIGN FLAWS AND ISSUES BASED ON MANY COMPLAINTS AND LAWSUITS JUST BY SEARCHING THIS ONLINE AND FORD HAS SHRUGGED OF THE ISSUE AS IF IT WAS NON EXISTENT. NOW I AM WORRIED THIS IS GOING TO OCCUR AGAIN AND IS A MAJOR SAFETY CONCERN OF MINE IF I LOSE CONTROL OF THE VEHICLE DUE TO A DESIGN FLAW AND FLAWED OVERALL STEERING GEAR. WHEN FORD IS SUPPOSED TO BE MAKING DESIGN IMPROVEMENTS, THEY ARE BACKTRACKING IN IT AS MY OLD FORD VEHICLES HAVE PERFORMED BETTER THAN THIS NEW ONE.

NHTSA ODI 10947324

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING 30 MPH, THE POWER STEERING WARNING INDICATOR ILLUMINATED AND THE POWER STEERING FAILED TO OPERATE AS INTENDED. THE CONTACT STATED THAT IT BECAME DIFFICULT TO MANEUVER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

NHTSA ODI 10947422

I WAS DRIVING TO WORK AND NOTICED SMOKE COMING THROUGH THE VENT INSIDE THE CAR. I PULLED OVER AND TRIED TO GET OUT THE CAR MY DOOR WOULDN'T OPEN SO I HAD TO PUNCH IT WHEN I GOT OUT THE CAR WAS ON FIRE UNDERNEATH THE FRONT TIRES. AFTER THE FIRE DEPARTMENT INVESTIGATED IT WAS PROVEN THAT THE FIRE STARTED FROM THE ENGINE COMPARTMENT. *TR

NHTSA ODI 10946940

THE ALUMINIUM LUG NUT CAPS SWELL SO THE LUG WRENCH SUPPLIED WITH THE CAR CAN NOT REMOVE THE LUG NUTS. TOW TRUCK COULD NOT REMOVE THEM SO CAR HAD TO BE TOWED TO DEALER, SHORT-REDMOND 1916 JACKSBORO PK. LAFOLLETTE, TN 37766, (800) 810-9088, WWW.SHORT-REDMONDFORD.COM. THE DEALER SAID THIS IS A COMMON PROBLEM WITH THE FUSION LUG NUTS AND OTHER LUG NUTS OF THE SAME TYPE. THE DEALER GOT THE LUG NUTS OFF, BUT THEY HAD TO BE REPLACED AT A COST OF $52/TIRE. MY DEALER IN ASHEVILLE, NC ALSO ADVISED MY TO REPLACE THE LUG NUTS THE NEXT TIME I HAD MY TIRES ROTATED, BUT SAID NOT TO BUY THEM FROM FORD. THERE ARE SOLID STEEL/CHROME AFTER MARKET LUG NUTS THAT ARE BETTER THEN THE ALUMINIUM CAPPED LUG NUTS THAT FORD USES. THIS IS CLEARLY AN ENGINEERING ISSUE. IT DID NOT ALLOW ME TO CHANGE A TIRE ON THE SIDE OF THE ROAD WITH THE EQUIPMNET SUPPLIED WITH THE CAR. I HAD TO WAIT OVER AND HOUR ON THE SIDE OF AN INTERSTATE HIGHWAY FOR A TOW TRUCK WHICH IS ALSO UNSAFE. I DO HAVE THE LUG NUTS AS WELL AS RECIEPT FROM FOR TO REMOVE AND REPLACE THE LUG NUTS. THE ALUMINIUM LUG CAPS ARE VERY DEFORMED SINCE THEY HAD TO HAMMER A SOCKET ONTO THEM TO GET THEM OFF.

NHTSA ODI 10947256

DOOR LATCH RECALL YESTERDAY, IN THE RAIN, I STARTED TO DRIVE ON A CITY STREET AND MY FRONT PASSENGER DOOR OPENED AND MY DASH INDICATED THE DOOR WAS OPEN SO I PULLED OVER, GRABBED THE HANDLE AND TRIED TO CLOSE THE DOOR...WELLL, THE DOOR WOULDN'T LOCK, IT KEPT OPENING, SO I MADE A LOOP THROUGH THE DOOR HANDLE, USING MY BELT AND DROVE WITH ONE HAND ON THE STEERING WHEEL AND ONE HAND ON MY BELT TO TRY AND HOLD THE DOOR CLOSED. I LOOKED ONLINE AND DISCOVERED THERE WAS A DOOR LATCH RECALL LAST YEAR AFFECTING ALMOST 2.4 MILLION CARS, WHICH MY YEAR AND MODEL WERE INVOLVED.I NEVER RECEIVED A RECALL NOTICE. THEN I CHECKED ONLINE FOR ACTIVE RECALLS FOR MY VEHICLE AND THE DOOR LATCH WAS NOT ON THERE. I CALLED THE DEALERSHIP THIS MORNING AND THEY SAID MY VIN NUMBER WAS NOT INCLUDED IN THE RECALL. I WAS NOT HAPPY WITH THEIR RESPONSE SO THE GAVE ME FORD CORPORATE'S PHONE NUMBER. I CONTACTED THEM, THEY GAVE ME THE SAME RESPONSE AS THE DEALERSHIP BUT WAS GOING TO DOCUMENT IT AND TO KEEP MY RECEIPT, FOR THE REPAIRS, IN CASE MY VIN GETS ADDED TO THE RECALL. SO I DON'T KNOW HOW MANY COMPLAINTS IT TAKES FOR YOU TO INVESTIGATE THIS, TO BE INCLUDED IN THE RECALL, BUT THIS SITUATION IS CLEARLY UNSAFE AND LAWSUIT WAITING TO HAPPEN. THIS WAS NOT A RESULT OF ANYBODY TRYING TO BREAK INTO MY CAR OR ANYTHING ELSE...THIS IS CLEARLY A DOOR LATCH ISSUE AND OBVIOUSLY THERE ARE MORE VEHICLES INVOLVED IN THIS RECALL THAT HAVE NOT BEEN ACCOUNT FOR. PLEASE LET ME KNOW WHAT THE NEXT STEPS ARE AND I SHOULD NOT BE RESPONSIBLE FOR PAYING FOR THIS UP FRONT.

NHTSA ODI 10946875

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING BETWEEN 5 TO 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE ON THE FIRST ATTEMPT. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 96,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 10946679

TL* THE CONTACT OWNS A 2013 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING AT 75 MPH, THE VEHICLE BEGAN TO OVER HEAT AND THE ENGINE OVER HEATING WARNING MESSAGE ILLUMINATED. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRING HARNESS AND POWERTRAIN CONTROL MODULE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V551000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 15,000.

NHTSA ODI 10945922

WE WERE DRIVING 70MPH CRUISE CONTROL ON A HIGHWAY, LET OFF CRUISE CONTROL TO DECREASE SPEED ON THE UPCOMING BYPASS AND THE ENGINE IMMEDIATELY POWERED DOWN AND WE COASTED TO A STOP ON THE SIDE OF THE HIGHWAY BYPASS. THE ENGINE LIGHT AND ORANGE WRENCH APPEARED. THE CAR WOULD NOT START THEREAFTER. WE HAD TO CALL FAMILY TO GET OUT 5 AND 7 YEAR OLD AND A TOW TRUCK TO TAKE THE CAR TO A SHOP. *TR

NHTSA ODI 10945440

PASSENGER DOOR WILL NOT LATCH AND SWINGS OPEN.

NHTSA ODI 10944991

FRONT PASSENGER DOOR LATCH BROKE AGAIN, ONE YEAR AND 5 MONTHS AFTER IT WAS REPAIRED PURSUANT TO A RECALL. FORD WILL NOT HONOR ANY WARRANTY ON THE PART OR LABOR AND HAVE ASKED ME TO PAY MORE THAN $500 TO REPAIR IT. THIS IS A SAFETY ISSUE BECAUSE DOOR CAN SWING WIDE OPEN WHILE CAR IS IN MOTION PUTTING ALL PASSENGERS AT RISK OF DEATH OR SERIOUS INJURY. LUCKILY, THE PROBLEM WAS DISCOVERED AFTER VEHICLE WAS PARKED, PASSENGER EXITED AND DOOR WOULD NOT SHUT ANY LONGER.

NHTSA ODI 10945067

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING 30 MPH, THE "HILL ASSIST TRACTION", "TIRE PRESSURE SENSOR FAULT", AND "SERVICE POWER STEERING NOW" INDICATORS ILLUMINATED. THE POWER STEERING SEIZED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000.

NHTSA ODI 10945099

MY VEHICLE HAS 72000 MILES ON IT. I WAS DRIVING ON I90 OUTSIDE OF BUFFALO WHEN THE CAR HAD TROUBLE ACCELERATING, IT WAS UNABLE TO MAINTAIN SPEED AND BY THE TIME I WAS ABLE TO PULL OFF WOLD NOT MOVE ANY FARTHER. THE DEALERSHIP HAS DIAGNOSED THE ISSUE AS NEEDING A NEW TRANSMISSION. A PLASTIC CAP HAD MELTED INTO THE TRANSMISSION LINES, AND FORD IS REFUSING TO COVER THE REPAIR AT 100%, AS THIS WAS A MANUFACTURER DEFECT.

NHTSA ODI 10945101

THERE IS A RECALL FOR SEATBELT, THAT SEATBELTS ARE UNSAFE FOR DRIVER AND PASSENGER BUT THE RECALLED PARTS ARE NOT AVAILABLE YET AND DEALER WON'T PROVIIDE LOANER CAR.

NHTSA ODI 10945137

THE ELECTRONIC THROTTLE CONTROL CAUSES THE CAR IDLE TO DROP AND THE ACCELERATOR TO BECOME UNRESPONSIVE. THIS CAUSES THE CAR TO STALL. THIS HAS HAPPENED TO ME MULTIPLE TIMES IN HEAVY TRAFFIC. THIS HAS BEEN GOING ON FOR A COUPLE MONTHS AND IS BECOMING MORE FREQUENT.

NHTSA ODI 10939658

AFTER THE CAR HAS BEEN DRIVEN FOR AWHILE THEN THE ENGINE IS TURNED OFF FOR 10 TO 20 MINUTES, WHEN I RESTART THE ENGINE IT WILL (WITHIN 30 SECONDS) BEGIN TO RUN ROUGH AND QUIT. IT HAS DONE THIS NOW MORE THAN 50 TIMES. I HAVE TAKEN IT TO THE DEALER 4 TIMES, BUT THEY HAVE NOT FIXED THE PROBLEM. SINCE I HAD TO GIVE A SPECIFIC DATE ON THIS FORM BELOW, I PICKED A DATE THAT IT HAPPENED.

NHTSA ODI 10939675

SHIFTER CABLE WENT BAD AT 78000 MILES. THE CAR WOULD NOT GO DOWN IN GEAR. EVERY TIME YOU GO BACK IT WOULD STAY IN THAT GEAR AND NEVER GO BACK TO PARK. IT GOT STUCK IN THE SPORT GEAR AND NEVER ABLE TO GO TO NEUTRAL, DRIVE NOR PARK. THE DEALERSHIP SAID THAT THE CABLE FROM THE SHIFTER TO THE TRANSMISSION WAS BAD. THIS PART COST $512 TO FIX AT THE DEALERSHIP.

NHTSA ODI 10939194

CAR OVER HEATING ENGINE AND COLLANT SYSTEM AFFECTED

NHTSA ODI 10938733

TL* THE CONTACT OWNS A 2013 FORD FUSION. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED AND WAS COASTED TO A PARKING SPACE. A "FUEL ECONOMY" WARNING MESSAGE APPEARED. THE VEHICLE WAS TURNED OFF. UPON ATTEMPTING TO RESTART THE VEHICLE, THE CONTACT NOTICED SMOKE UNDERNEATH THE HOOD. ONCE THE HOOD WAS OPENED, FLAMES WERE SEEN ON THE REAR PASSENGER SIDE OF THE ENGINE. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE. THE FIRE DEPARTMENT WAS NOT CALLED AND A POLICE REPORT WAS NOT FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE HEAD CRACKED FROM OVERHEATING, WHICH SENT OIL TO THE HOT TURBO. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V551000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 80,000.

NHTSA ODI 10938791