What 119 owners told NHTSA about the 2012 Mini Cooper Countryman

WHILE DRIVING EAST ON INTERSTATE 40, I WAS APPROXIMATELY 50 MILES EAST OF ASHEVILLE, NC WHEN I HEARD A VERY LOUD BOOM THAT SOUNDED LIKE A GUN SHOT. IT THEN SOUNDED AS IF A WINDOW WERE OPEN AND I COULD FEEL OUTSIDE AIR, THEN I SOON DISCOVERED A LARGE HOLE IN MY SUNROOF.

NHTSA ODI 11047705

I PURCHASED THE USED 2012 MINI COOPER COUNTRYMAN, I DROVE IT FOR 84 DAYS, AND WHILE I WAS DRIVING THE CAR THE ENGINE SUDDENLY WENT DEAD ON THE ROAD AND STOPPED WORKING. I TOOK THE CAR TO THE DEALER WHERE I BOUGHT IT FROM AFTER TWO WEEKS THEY SAID THE TIMING CHAIN BROKE AND CAUSED IT TO DESTROY THE ENGINE, NOW I HAVE TO PAY FOR THE NEW ENGINE. I CHECKED ON LINE TO SEE IF THERE WERE ANY PROBLEMS WITH TIMING CHAIN ON THESE CARS, MINI SAID THEY HAD PROBLEMS IN THE PREVIOUS MODEL CARS THAT MADE AND THEY FIXED THE PROBLEM, APPARENTLY THE PROBLEM STILL EXIST IN THE NEWER MODELS.

NHTSA ODI 11046285

TEMPERATURE SENSOR IN RADIATOR HOSE LEAKING. NEEDS UPPER RADIATOR HOSE, AND THERMOSTAT WITH HARNESS TO CORRECT. DISCOVERED DURING A ROUTINE OIL BRAKES ETC INSPECTION BY THE DEALERSHIP. I WAS TOLD THERE WAS A CHANGE IN THE HARNESS AND THE NEW ONE HAS A "COMPUTER" AND WOULD COST $1450 TO FIX. THIS IS AN UPPER HOSE AND I LOOKED ONLINE AND FOUND THE REPLACEMENT HARNESS HAS TOW SEPARATE CONNECTORS, ONE FOR COOLANT TEMP SENSOR AND THE OTHER FOR THE COOLANT THERMOSTAT. I HD CHECKED MY FLUIDS TWO DAYS BEFORE ON A COLD ENGINE AND THEY WERE FINE AND WATER OVERFLOW WAS AT THE PROPER LEVEL. I CHECKED MY COOLANT OVERFLOW TANK THE DAY AFTER VISITING THE DEALERSHIP ON A COLD ENGINE AND THE OVERFLOW TANK WAS LOW... I ADDED WATER... IT HAS NOT GONE DOWN FOR SEVERAL DAYS. I HAVE HEARD THERE IS CORROSION THAT HAPPENS AND THE THERMOSTAT MAY NOT EMPLOY AND YOU CAN HAVE AN OVERHEATED ENGINE.

NHTSA ODI 11044456

THESE 2012 MINI COOPER CLUBMAN ARE HAVING THE TIMING GUIDES BRAKE AND SOMETIMES RUIN THE ENGINE. IN MY CASE I THINK I CAUGHT IT ON TIME, I CALLED MINI HERE LOCALLY AND MY WARRANTY RUNS OUT THIS SEPTEMBER 2017 OR 100,000. BUT MY CAR JUST HIT 105,000, THIS IS AN ISSUE THAT MINI HAVE HAD FOR QUITE A FEW YEARS AND I SAW A RECALL UP TO 2011 BUT HAVEN'T SEEN ANYTHING FOR 2012 MINI CLUBMAN. IT'S HARD TO BELIEVE THAT BMW/MINI WENT WITH PLASTIC GUIDES INSTEAD OF SOME OTHER MATERIAL THAT COULD WITHSTOOD MORE BEATING, SPECIALLY FOR THIS AREA. THANK YOU FOR ANY HELP, BECAUSE I'M HAVING TO FORK OUT ANY WHERES BETWEEN $1500'TO $3000.00!TO GET THIS FIXED. I WAS DRIVING WHEN I HEARD THE NOISE AND NOW IT SITS IN MY DRIVEWAY.

NHTSA ODI 11021337

WHILE DRIVING DOWN THE HIGHWAY ON A WINTER DAY, THE REAR PANEL OF THE PANORAMIC SUNROOF LITERALLY EXPANDED UPWARD AND SHATTERED. THE BULK OF THE GLASS FELL INTO THE CAR. THERE WAS NO IMPACT WITH FOREIGN OBJECTS OR CHIPS IN THE GLASS. THIS WAS A CATASTROPHIC FAILURE. *TR

NHTSA ODI 10945531

PASSENGER SIDE AIRBAG IS RANDOMLY DISABLED (WITH WARNING LIGHT/TONE) WHEN MY 63# DOG IS SITTING IN THE SEAT. CAUSE IS A FAULTY "PASSENGER SEAT OCCUPANT MAT" THAT OTHERS HAVE REPORTED WILL COST OVER $1500 TO REPLACE. THIS HAS HAPPENED NUMEROUS TIMES BUT ONLY WHILE DRIVING SO CAN'T REALLY GET A PICTURE OF THE WARNING LIGHT SAFELY.

NHTSA ODI 10925054

THE PASSENGER AIRBAG SENSOR HAS BEEN ON SINCE THE DATE POSTED. IT WOULD RESOLVE ON ITS OWN SOMETIMES BUT NOT IT NEVER TURNS OFF, HINDERING MY ABILITY TO SEE THE SPEEDOMETER. I HAVE NOT SHELLED OUT THE THOUSANDS TO GET IT FIXED BECAUSE I AM HOPING BMW WILL RECALL FOR THIS APPARENTLY COMMON PROBLEM

NHTSA ODI 10906380

PASSENGER SEATBELT ELEMENT SENSOR MALFUNCTIONED. WE HAD TO REPLACE THE ENTIRE PASSENGER SEAT CUSHION WITH NEW SENSOR FOR A COST OF $1843.00. A 2012 VEHICLE SHOULD NOR REQUIRE A NEW SEAT THROUGH ORDINARY USE. NOTE:MINI SEATBELT SENSOR IS MOLDED INTO THE CUSHION REQUIRING A NEW CUSHION AND NOT JUST REPLACING THE SENSOR RESULTING IN THE HIGH COST TO THE CONSUMER.

NHTSA ODI 10902056

CHECK ENGINE LIGHT-- COOLENT THERMOSTAT STICKING PER ALLDATA SHOWS THERMOSTAT HOUSING W/THERMOSTAT, SENSOR ETC, SHOWS RECALL FOR THESE PARTS UPDATED.

NHTSA ODI 10896947

WATER PUMP FAILURE. BEGAN TO NOTICE SMALL AMOUNT OF LIQUID UNDER CAR IN APRIL 2016, THOUGHT IT WAS CONDENSATION FROM A/C. LEAK WORSENED AND CALLED MINI IN JUNE 2016 TO CHECK IT OUT. WATER PUMP FAILURE ON VEHICLE WITH 45,500 MILES. CLASS ACTION LAWSUIT SETTLEMENT AGREED IN CALIFORNIA IN MARCH WAITING ON FINAL APPROVAL OF TERMS DUE IN NOVEMBER 2016. BMW KNOWS THIS IS A DEFECTIVE PART. WATER PUMP FAILURE FROM DEFECTIVE PART COULD HAVE CATASTROPHIC EFFECTS IF AUTOMOBILE IS IN MOTION AT ANY SPEED.

NHTSA ODI 10885861

CAR KEY STUCK IN SLOT AND WOULD NOT ALLOW THE VEHICLE TO SHIFT. AFTER TAKING IT IN FOR REPAIR TO MINI COOPER, WE WERE INFORMED THAT MOISTURE WAS FOUND IN A COMPUTER WHICH IS LOCATED UNDER THE BEVERAGE HOLDER. YES, YOU READ THAT RIGHT. A COMPUTER UNDER THE BEVERAGE HOLDER AND NO MOISTURE BARRIER, NO PROTECTION OVER THIS COMPONENT.. NOW WHO DOES THAT? THERE IS NOTHING IN THE OWNERS MANUAL TO WARN YOU OF THIS NOR IS THERE ANY INDICATION ON THE BEVERAGE HOLDER ITSELF THAT INDICATES THERE IS A COMPUTER COMPONENT BELOW. HOW WOULD A CONSUMER KNOW? HONESTLY, WHO DESIGNS A CAR LIKE THIS? OF COURSE THERE WILL BE MOISTURE... ITS A BEVERAGE HOLDER FOR PETE SAKE! IT WAS A $1200. FIX. HAD I KNOWN OR BEEN PRE-WARNED SOMEHOW, I WOULD NOT HAVE USED THE DARN THING OR AT LEAST WRAPPED MY DRINKS IN A PAPER TOWEL. OF ALL THE PLACES TO PUT A COMPUTER, WHY WOULD ANYONE PLACE IT UNDER THE BEVERAGE HOLDER. I CAN ONLY GUESS THAT MINI COOPER COUNTS ON THIS REPAIR SOMETIME IN THE LIFE OF THE AUTOMOBILE. I FEEL THEY SHOULD BE RESPONSIBLE FOR THE COST OF THIS REPAIR.

NHTSA ODI 10885732

DRIVING 45 MPH ON BUSY CITY FOUR-LANE ROAD, I BRAKED GRADUALLY IN APPROACH TO RED LIGHT, WHICH IS MY NORMAL BRAKING STYLE. CAR DID NOT COME TO A COMPLETE STOP--BRAKES ONLY WORKED TO A POINT BUT DID NOT COMPLETELY STOP CAR; SIMULTANEOUSLY ENGINE REVVED TO VERY HIGH RPM. I THREW TRANSMISSION INTO PARK AND TURNED OFF IGNITION LEST MY CAR RAM CAR AHEAD OF ME. VERY FRIGHTENING. AT PREVIOUS TWO LIGHTS I HAD NOTICED THAT BRAKES WERE ACTING FUNNY, NOT BRINGING CAR TO A COMPLETE STOP BUT I HAD LEFT PLENTY OF BRAKING DISTANCE AND WAS ABLE TO LET CAR ROLL TO A STOP, IN SPITE OF BRAKES NOT EFFECTING A COMPLETE STOP . AT THOSE TWO LIGHTS THE RUNAWAY ENGINE (HIGH RPM) DID NOT OCCUR OR I WOULD HAVE PULLED OVER RIGHT THEN. HOWEVER, ENGINE REVVING TO HIGH RPM HAS ALSO OCCURRED OCCASIONALLY WHEN PULLING INTO GARAGE BUT I HAD NOT GIVEN THIS A LOT OF THOUGHT BECAUSE I HAVE QUICKLY TURNED OFF IGNITION. NOW I KNOW IT'S VERY DANGEROUS SITUATION. OF COURSE I AM NOT DRIVING IT BUT AM HAVING IT TOWED TO DEALER FOR REPAIR. THE CAR HAS BEEN SERVICED REGULARLY AT DEALER AND HAS 24,239 MILES ON IT. THERE HAS NEVER BEEN A NECESSITY FOR REPAIRS ON THIS MINI COOPER CLUBMAN.

NHTSA ODI 10875740

WHILE TRAVELING AT HIGHWAY SPEEDS THE CAR LOST THE ABILITY TO ACCELERATE AND INSTEAD LURCHED AND CHOKED. THE MECHANIC DETERMINED THAT THE THROTTLE BODY BROKE FREE OF ITS HOUSING. LUCKILY I WAS ABLE TO MOVE THE CAR TO AN OFF-RAMP THAT SLOPED DOWNHILL TO GET TO SAFETY.

NHTSA ODI 10874401

MY 2012 MINI COOPER COUNTRYMAN WITH 30,000 MILES IS REQUIRING REPLACEMENT OF THE THERMOSTAT AND WATER PUMP - BOTH OF WHICH WERE RECALLED AND REPLACED ON THE 2011 MINI COOPER COUNTRYMAN. THERE ARE NOT ANY PARTS IN THE UNITED STATES CURRENTLY TO FIX THE CAR. WE WILL BE WITHOUT OUR CAR FOR NEARLY 3 TO 4 WEEKS WHILE WE WAIT FOR THESE PARTS AND WE HAVE BEEN TOLD NOT TO DRIVE OUR CAR ON THE HIGHWAY. THE DEALER SAID TOUGH LUCK.

NHTSA ODI 10871243

TL* THE CONTACT OWNS A 2012 MINI COOPER. THE CONTACT STATED THAT THE FRONT DRIVER SIDE AIR BAG ABRUPTLY DEPLOYED WHILE DRIVING 40 MPH. THE FAILURE OCCURRED WITHOUT WARNING OR IMPACT. THE CONTACT SUFFERED INJURIES TO THE NECK, BACK, AND ARMS, WHICH REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS NOT FILED. PRIOR TO THE DEPLOYMENT, THE AIR BAG WARNING LIGHT ILLUMINATED. THE DEALER STATED THAT IT WAS SAFE TO DRIVE THE VEHICLE WITH THE AIR BAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE VEHICLE WAS TOWED TO THE DEALER. THE MANUFACTURER INSPECTED THE VEHICLE AND CONCLUDED THAT THE FRONT DRIVER SIDE AIR BAG DEPLOYMENT WAS NOT CAUSED BY A MANUFACTURER DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 43,000.

NHTSA ODI 10863369

TL* THE CONTACT OWNS A 2012 MINI COOPER. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE TECHNICIAN DIAGNOSED THAT THERE WAS A LEAKAGE ON THE OIL CONTROL VALVE. AS A RESULT, THE TECHNICIAN STATED THAT THE OIL CONTROL VALVE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10,800.

NHTSA ODI 10853576

TIMING CHAIN STRETCHED CAUSING TIMING TO BE OFF BY 75MM, THIS RESULTED IN DAMAGE TO THE ECCENTRIC SHAFT AND TIMING CHAIN. ENGINE ENGINE MALFUNCTION LIGHT ILLUMINATED, UPON INSPECTION AT MINI DEALER DETERMINED THE ABOVE CONDITION OF VEHICLE.

NHTSA ODI 10852760

BOTH FRONT WHEEL BEARINGS FAILING AT 23,000 MILES... RIDICULOUS.

NHTSA ODI 10846247

TL* THE CONTACT OWNS A 2012 MINI COOPER COUNTRYMAN. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE ENGINE SPUTTERED AND THERE WAS SMOKE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT OIL WAS LEAKING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE HOSE PIPE AND FREEZE PLUG OVERHEATED AND MELTED WHICH CAUSED THE ENGINE TO REQUIRE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,000.

NHTSA ODI 10845785

TL* THE CONTACT OWNS A 2012 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TURBO CHARGER AND THE WATER PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 10820319

WHEN DRIVING 2 MONTHS AGO,WAS DRIVING WITH MY MOM 9/13/1015,ALL 4 MILESTAR TIRES BUSTED,DEALER REPLACED THEM WITH CHARGING ME 150.00 DEDUCT,NOW SAME PROBLEM OCCURED 11/25/2015,RIGHT PASSAGER SAME BRAND BUSTED,NOW MY CAR IS IN SHOP AGAIN MISSING WORK,STUCK IN FORT MYERS RIGHT NOW,IF IT WASN'T FOR MY FAMILY I WOULD NOT BE HERE WITH THESE TIRES,THE NAME OF THE TIRES MILE-STAR

NHTSA ODI 10807118

UPON ENTERING AN EXIT ONLY LINE ON THE HIGHWAY AT THE END OF A 400 MILE JOURNEY, TRAFFIC BACKED UP AND CAME TO A STOP IN THE EXIT ONLY LANE. WHEN TRAFFIC STARTED MOVING AGAIN, MY CAR WHICH HAS A MANUAL TRANSMISSION WOULD NOT SHIFT FROM NEUTRAL INTO 1ST GEAR (OR ANY GEAR). I WAS STOPPED AND UNABLE TO MOVE WITH TRAFFIC MOVING 50-60 MPH BEHIND ME AND NEXT TO ME. CARS SLAMMED ON BRAKES TO AVOID HITTING ME AND ONE ALMOST HIT ME AFTER SLAMMING ON ITS BREAKS AND TURNING SIDEWAYS. IT WAS ONE OF THE MOST TERRIFYING EXPERIENCES I HAVE EVER ENCOUNTERED. A STATE POLICE OFFICE PULLED UP BEHIND ME AFTER ABOUT 5-10 MINUTES AND WAS ABLE TO PUSH ME TO THE BREAKDOWN LANE. THERE WAS A TERRIBLE BURNING SMELL AND CONSIDERABLE SMOKE FROM UNDER THE CAR WHICH INDICATED A CATASTROPHIC FAILURE OF THE CLUTCH. THE CAR WAS TOWED TO AN AUTO REPAIR SHOP WHERE I LATER LEARNED THE CLUTCH MATERIAL HAD DISINTEGRATED ENTIRELY AND THE FLYWHEEL WAS CRAZED AND BURNED FROM THE EXTREME HEAT. BOTH THE CLUTCH AND FLYWHEEL HAD TO BE REPLACED. THE COST TO REPAIR THE CAR WAS OVER $4000. THE CAR HAD 78,067 MILES ON IT AND PRIOR TO THE CATASTROPHIC FAILURE OF THE CLUTCH THERE WERE ONLY 2 INDICATIONS OF A POTENTIAL CLUTCH PROBLEM WHEN THE TACHOMETER FLUTTERED WHEN SHIFTING INTO HEAR AT ABOUT 300 MILES PRIOR TO THE INCIDENT AND THEN ABOUT 25 MILES PRIOR TO THE INCIDENT, INDICATING TO ME THAT THE CLUTCH WAS STARTING TO SLIP. OTHER THAN THAT, THERE WERE NO WARNING LIGHTS OR OTHER INDICATIONS OF A PROBLEM. THE CAR IS ROUTINELY SERVICED BY THE DEALER AND WHENEVER THERE IS ANY INDICATION OF A PROBLEM. I DO NOT DRIVE CARS HARD. THIS CAR IS STILL ON ITS FIRST SET OF BRAKES AND ONLY ITS SECOND SET OF TIRES. I HAVE DRIVEN MANUAL SHIFT CARS FOR MANY YEARS AND KNOW THE SYMPTOMS OF A FAILING CLUTCH. I CONSIDER THE NEAR CATASTROPHE THAT I EXPERIENCED THE RESULT OF A MAJOR DEFECT IN EITHER THE CLUTCH OR THE WARNING MECHANISM.

NHTSA ODI 10789662

TL* THE CONTACT OWNED A 2012 MINI COOPER. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT CRASHED INTO THE PRECEDING VEHICLE AFTER IT STOPPED WITHOUT WARNING. THE VEHICLE WAS MERGED INTO A PARKING LOT, WHERE THE CONTACT NOTICED SOME MINOR DAMAGE TO THE FRONT OF THE VEHICLE AND SMOKE APPEARED UNDER THE HOOD AS A FIRE STARTED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,000. THE VIN WAS NOT AVAILABLE.

NHTSA ODI 10744546

CHECK ENGINE LIGHT CAME ON. CAUSE: HEATING FAULT CODE IN DIAGNOSIS(THERMOSTAT ACTIVATION). THERMOSTAT, HOUSING , AND ADAPTER REPLACED. REMOVED AND REPLACED COOLANT, CHECKED COOLING SYSTEM FOR LEAKS. 06/17/2015 CHECK ENGINE LIGHT HAS COME ON AGAIN, AND AFTER TAKING TO DEALERSHIP IT APPEARS TO BE THE THERMOSTAT AGAIN.

NHTSA ODI 10735421

TL*THE CONTACT OWNS A 2012 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THERE WAS A HISSING NOISE. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT IT WAS DUE TO SALT AND SHOULD GO AWAY OVER TIME. HOWEVER, THE FAILURE PERSISTED. THE VEHICLE WAS TAKEN TO ANOTHER DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE PADS AND ROTORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN BUT THE CURRENT MILEAGE WAS 18,954.

NHTSA ODI 10692235