What 22 owners told NHTSA about the 2025 Tesla Cybertruck (all Variants)

The contact owns a 2025 Tesla Cybertruck. The contact stated that while pulling into a charging station with the self-driving system activated, the vehicle stopped in front of the payment pole; however, the vehicle inadvertently accelerated through the barrier gate arm, and the arm was fractured. The barrier scratched the passenger’s side bumper. A police report was not filed. There were no injuries sustained. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 13,000.

NHTSA ODI 11745888

PCS2 failure. The PCS2 board manages charging and power conversion. Failures typically start by restricting home AC charging speeds (e.g., dropping from 48A down to 24A) and can eventually result in a complete loss of AC charging and a "Charging Unavailable" alert.

NHTSA ODI 11745238

My 2025 Tesla Cybertruck AWD (VIN: [XXX] ) was returned to me after the first service visit (Invoice XXX Tesla Palo Alto, 8/22/2025) with the Pedestrian Warning System (PWS) speaker disconnected. The disconnection occurred during front-end service work at that visit, which included front fascia inspection and removal. The technician did not reconnect the PWS speaker before returning the vehicle. The disconnection was not discovered until the second service visit (Invoice XXX, Tesla Palo Alto, 9/18/2025), at which point Tesla's own invoice documented: "The issue was caused by a disconnected front pedestrian warning speaker. Technician reconnected the front pedestrian warning speaker to resolve the issue." The [XXX] s therefore operated with a disconnected PWS for approximately 4 weeks — from August 22 to September 18, 2025 — without my knowledge. During this entire period, the vehicle was not emitting the required audible low-speed alert. The PWS emits an audible alert at low speeds to warn pedestrians, cyclists, and visually impaired individuals of the vehicle's approach. This system is required under FMVSS 141 (Minimum Sound Requirements for Hybrid and Electric Vehicles). This is a service-inflicted deactivation of a federally-required pedestrian safety system. The deactivation was caused by Tesla's Palo Alto service center (4180 El Camino Real, Palo Alto, CA 94306) during routine warranty repair work. The vehicle was returned to me without disclosure of the disconnection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11737207

The Power Conversion System (PCS) in the Tesla Cybertruck is experiencing a high rate of hardware-level failure (specifically the PCS2 module) that poses three distinct safety risks beyond the loss of AC charging. Loss of Steer-by-Wire Integrity: The Cybertruck utilizes a full steer-by-wire system and a 48V low-voltage architecture. The PCS is responsible for managing the 48V bus and charging the LV battery. A hardware failure in the PCS (common alerts: PCS2_a094, PCS2_a137) threatens the stability of the 48V system. Any sudden collapse of the 48V bus while in motion could result in a total loss of steering control and vehicle maneuverability, creating an immediate risk of a high-speed collision. Loss of Propulsion and Stranding: PCS failure frequently leads to "limp mode" or a "no-start" condition where the vehicle cannot engage Drive or Reverse. Experiencing a loss of propulsion while in active traffic or being stranded on a highway shoulder without the ability to move the vehicle creates a severe life-safety hazard for occupants and other motorists. Failure of Visibility Systems: Critical safety components, including the primary windshield wiper and exterior lighting, are powered via the 48V system managed by the PCS. Hardware instability has led to reports of these systems failing during inclement weather, severely compromising driver visibility. Tesla has implemented software bypasses (OTA updates) to allow DC Supercharging when the AC hardware fails, but this is a "band-aid" that does not address the underlying hardware defect—likely MOSFET degradation. With replacement parts on backorder for 8+ weeks, owners are forced to operate vehicles with compromised electrical architectures. I am reporting this as a systemic hardware defect that requires an official safety recall.

NHTSA ODI 11734532

Brand-new 2025 Cybertruck developed moisture inside sealed HV battery pack with no submersion, off-roading, or flooding. Service photos show only trace condensation and crystallized residue—no mud, corrosion, or contaminants. Tesla denying warranty and quoting $37k replacement. Suspected manufacturing defect in pack lid gasket (known issue in early VINs). Safety risk if unaddressed.

NHTSA ODI 11704449

The contact owns a 2025 Tesla Cybertruck. The contact stated that while the vehicle was parked, the contact exited the vehicle and the front driver-side door independently closed and slammed his right hand in the door, injuring three of his fingers. The contact sought medical attention and was informed that he had sustained internal bleeding and was prescribed anti-inflammatory medicine and instructed the contact to try not to move his fingers in order to avoid disturbing the healing process. The contact stated he also sustained emotional distress and described the incident as traumatic. The vehicle was taken back to the residence and was not diagnosed. A dealer was not contacted, and the vehicle was not repaired. The manufacturer was notified of the failure, and the contact stated that the manufacturer said they would send an email after the call; however, the manufacturer did not send an email and refused to provide a manufacturer case number. The failure mileage was approximately 7,857.

NHTSA ODI 11704541