What 73 owners told NHTSA about the 2023 Ford Maverick Hev Later Release

Eninge started knocking, flashed warnings to pull over immediately. I did and had the vehicle towed to Westway Ford in Irving. Their investigation showed the engine needs a full rebuild and they are claiming it is not covered under warranty. They shared pictures & a written repair estimate. Doing an analysis of the pictures they took and their description of what happened, combined with what I experienced and observed, this appears to be a textbook case of the behavior and outcome of the mechanical failure described in recall 23S27.

NHTSA ODI 11741298

The contact owns a 2023 Ford Maverick. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was a fuel odor on the exterior and interior of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a fractured fuel seal. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The vehicle was taken to the dealer; however, the vehicle was not diagnosed. The contact was informed that a diagnostic test was needed to determine the cause of the failure. The dealer declined to provide a free diagnostic test. The contact referenced the notification of NHTSA Campaign Number: 23V380000 (Engine); however, the VIN was not associated. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 45,300.

NHTSA ODI 11725203

Per the dealership my vehicle is throwing the same codes P1061 and P032F as the recall that is less than a month from when my vehicle was built. My vehicle knocks and then the speed drops to less than 35 miles and it happened to me in traffic. It is very dangerous and again this is the same issue as the recall for my 2023 that is for other 2023 vehicles. I have called Ford to get help and file a complaint but am getting zero help. Again this is a very dangerous event that is happening and could cause damage not only to my vehicle but to others. I have to work so driving the vehicle is my only option right now and I can't afford the 9,000 to fix something that is a Ford issue. Please review and have Ford pay for the safety issue they already know they have. Thanks

NHTSA ODI 11724855

AUTOMATIC REVVING INCIDENT 1 DATE: November 25, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Slight rain, around 37º F VEHICLE STATUS: In Park, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. ICE engine immediately turned on and revved all the way, as if the accelerator pedal was pressed down all the way. Pedal was NOT under floor mats. Immediately turned key to off position, let sit for a moment. Turned key to on position again and issue seemed to be resolved. No check engine lights or other codes were showing on the dash cluster. AUTOMATIC REVVING INCIDENT 2 & 3 DATE: December 2, 2025 TIME: about 4:05pm LOCATION: [XXX] WEATHER: Clear, around 27º F VEHICLE STATUS: In drive, heat dial turned on. DESCRIPTION OF ISSUE: Turned key to on position while in park. Heat was on. Immediately turned dial to “D,” and engine proceeded to again rev all the way up. However, this time, full power was transferred to wheels, causing vehicle to attempt to lunge forward. Luckily, I was on an icy patch of the road, and the tires spun instead of gaining traction. I immediately slammed the brakes and turned the car off. Waited about 2 minutes and then turned key to on position, and the exact same thing happened again. No check engine lights or other codes were showing on the dash cluster. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11702611

This exact situation has occurred twice in the past 6000 miles driven. Both occurred while driving at highway speeds, once on I85N and once on I75N in GA. Our 2023 Ford Maverick XLT Hybrid suddenly and unexpectedly loss power and shutdown. This forced us to make an emergency stop and attempt to pull over in high speed, heavy traffic in both instances. The vehicle eventually restarted and was drivable with a check engine light illuminated. The DTCs were read with an OBDII scanner and were recorded as P0811, P0E71 and P1920. The first time this occur the vehicle was taken back to Ford under warranty and they said they reprogrammed the PCM and another control module and assured us it was repaired. Obviously that is not the case. The vehicle is currently with Ford being diagnosed. Please follow up on this one. We're not the only Maverick Hybrid owners to have this unfortunate and very unsafe experience. This situation of a vehicle suddenly dying in heavy traffic is going to get someone killed. Thanks in advance for your consideration in this matter. We would like a better explanation from Ford besides "We reprogrammed a computer".

NHTSA ODI 11697663

The car have a Big vibration when speed up over 45 MPH

NHTSA ODI 11696731

The contact owns a 2023 Ford Maverick. The contact stated that while driving approximately 65 MPH, the check engine warning light illuminated, and the "Service Engine Immediately" message was displayed. The contact stated that the vehicle started losing motive power. The accelerator pedal was depressed, but the vehicle decelerated to 5 MPH. The contact stopped and had the vehicle towed to a dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The contact stated that the failure reoccurred. The contact used a handheld scanner and retrieved DTC: P1061 (Faulty Rod Bearing). The vehicle was towed to the same dealer, but the dealer was unable to duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was towed to the same dealer where it was determined that the long block needed to be replaced. The vehicle was not repaired. The contact spoke with a mechanic and was informed that the failure was related to Customer Satisfaction Program: 23N06 (Long Block Replacement). The manufacturer was contacted for confirmation that the vehicle was covered under the CSP; however, the contact was informed that the vehicle was not covered under the CSP. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 80,000.

NHTSA ODI 11681949

While traveling 80 MPH using cruise control, the vehicle speed suddenly reduced and several warning lights illuminated. The three warnings were Pre-Collision Assist Not Available, Service Engine Soon Warning, and Powertrain Malfunction / Reduced Power. The accelerator pedal did not work but I was able to coast to the nearest exit. I stopped, turned the vehicle off and back on a few times but the warning lights would come back on. When I shifted the transmission into Drive the vehicle would take off on its own. I drove the remaining 30 miles just letting the vehicle accelerate on its own because the pedal did not work. It wouldn't accelerate over 35 MPH. The vehicle would still pull when I applied the brakes. Once home, I turned the vehicle off for an hour. When I turned it on the warning lights no longer illuminated and the vehicle drove normal.

NHTSA ODI 11658823

2023 Ford Maverick Hybrid XLT lost all engine power at highway speed in the left lane of [XXX] . Red Warning Triangle with notice to pull over and Check Engine light with codes P0811, P0E71 and P1920. Truck then went completely dead, no electrical indication on the instrument panel and would not start. I towed it to the dealer and they said they reset and reloaded software on the PCM and BCM, but no explanation of what caused the issue to occur. Very unsafe for everyone if these hybrid vehicles can just go dead like this with no warning and no prior issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11658623

On 1028/24, driving at approximately 55 mph in the right lane of a local highway, the front collision braking system engaged almost totally stopping my vehicle. There were no vehicles, animals, nor pedestrians in front of my vehicle. I was able to pull to the shoulder. The collection detection icon appeared on the screen, as well as the check engine light, and the wrench. Then a message saying collision warning system unavailable, then service vehicle immediately. The drive gear dial remained in drive (D) position and was flashing. From there, with my warning light activated, I was able to get the vehicle to go up to 25 mph in order to drive to the Ford dealership nearby. I was told by the service department that they operate on appointments only, I would "try to look at it soon." The Ford Pass App states a powertrain malfunction, pre-collision assist not available, and service engine soon warning. Even if the system resets itself when vehicle turned back on, it is totally unsafe to drive in traffic not knowing if these systems will unexpected fail again, causing an accident and injury. I understand that this problem has occurred with other drivers on this model in the recent past.

NHTSA ODI 11623206

The contact owns a 2023 Ford Maverick. The contact stated that while pressing the fuel pedal the vehicle would not properly accelerate and had stalled. Also, while at a stop light the vehicle had erroneously accelerated forward. During the failures the check engine, power train and collision avoidance warning lights had illuminated. The vehicle was taken to the local dealer who was unable to determine the cause of the failures. The dashboard module was reprogramed but after retrieving the vehicle the failures continued to occur. The manufacturer was not yet contacted. The failure mileage was 9,500.

NHTSA ODI 11580044

Vehicle at Ford dealer on 3/7/24 for two separate recalls, Emission Recall 23E09 and Compliance Recall Notice NHTSA 23V848 where the BCM and PCM were reprogramed and updated. The vehicle operated normally before the dealership service for the recalls. On 3/18/24 after the recall service was performed, while driving along a state route of speed limit 55, the vehicle suddenly lost power and displayed the following indications on dashboard: Service Engine Soon, Pre-Collision Assist not available, and Powertrain Malfunction/Reduced power. The vehicle was able to be pulled over safely to the side of the road. The vehicle was able to be restarted but at a significant loss of power with the same warning lights displayed. Safety was compromised as the vehicle lost power and speed and could only be operated a short distance. Thankfully other vehicles were able to avoid me at my significantly diminished speed and I was able to turn on warning flashers and pull to the side of the road no faster than 10mph. The vehicle was towed to a Ford dealer, who had the vehicle for 3 days, where they confirmed with their scan tools the warning lights had come on and the power had diminished when the incident happened, but were not able to reproduce the symptoms. Technician noted there were no SSMS or TSBS from Ford or otherwise for these concerns and was given back to me at no charge. Incident happened on March 18th, 2024 and is available for inspection.

NHTSA ODI 11579125

I took my ford Maverick to dealer for the recalls for three recalls: 24c01,23c41 & 23e09. About 1 hr later driving on highway the engine lost all power, gearshift knob was flashing; warnings started flashing , hill start assist not available, service soon, pre collision assist not available, service power trac( I think) , check engine light came on & a wrench illuminated on dash. Went from 55-60 mph to a crawl in a few seconds. Fortunately was able to pull off-road. As soon as I touched brake pedal the emergency brake applied automatically & I slammed to a halt. After about 5 minutes & turning ignition on & off a few times everything worked again. Check engine light remained on but turn off the next day. I called dealership and they had no idea. Said to bring in again. This occurred on 3/6/24 and again on 3/10/24, both times identical situation. Both times I was fortunate no one behind me and room to get pull on shoulder. I posted this on the Maverick forum online only to discover it is happening to many people that have had the recalls done. Some their engines stopped on the freeway, going from 70 to a crawl in seconds. One person mentioned they almost got nailed by an 18 wheeler rig. I called the dealership to let them know what I found out online and they had no idea or how to correct. Whatever the recall did ( seems to be the recall associated with emissions - from online discussions) ford needs to correct. This type situation is an accident waiting to happen and putting lives in danger.

NHTSA ODI 11576761