What 94 owners told NHTSA about the 2023 Ford Escape Gas

The contact owns a 2023 Ford Escape. The contact received notification of NHTSA Campaign Number: 24V954000 (Electrical System); however, the part to do the recall repair was unavailable. The dealer was contacted. The dealer confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and informed the contact that a second notice would be mailed whenever parts were available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11653479

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the check engine warning light illuminated. The contact took the vehicle to the dealer where the vehicle was diagnosed, and it was determined that rodents had damaged the coil wiring. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,106.

NHTSA ODI 11652602

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the RPM was not increasing on the gauge on the instrument cluster. There was no warning illuminated. The contact stated that the failure was intermittent but became a recurring failure. Additionally, the contact reported several electrical failures. The contact stated that the instrument cluster was blank, and the windows failed to respond while attempting to raise or lower the windows. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission software needed to be re-flashed, and the 12-Volt battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer replaced the 12-Volt battery; however, the failure recurred. The manufacturer was informed of the failure. The failure mileage was approximately 15,500.

NHTSA ODI 11652300

The contact owns a 2023 Ford Escape. The contact stated that while driving approximately 30 MPH, the transmission overheated warning light illuminated. The contact stated that the vehicle went into LIMP Mode. The contact stopped and had the vehicle towed to the dealer. The dealer diagnosed the vehicle but could not duplicate the failure. The vehicle was not repaired. The contact stated that the failure reoccurred, and the vehicle was taken to another dealer who also was not able to duplicate the failure. The vehicle was not repaired. The contact stated that the transmission failed and was unable to shift into reverse(R) or park(P). The contact had the vehicle towed to an independent mechanic. The vehicle was diagnosed, and it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 150,000.

NHTSA ODI 11651021

The contact owns a 2023 Ford Escape. The contact stated that while driving at various speeds, the transmission unexpectedly downshifted. There was no warning light illuminated. The dealer was notified of the failure, and the contact was instructed to bring the vehicle in for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer had not been notified of the failure. The failure mileage was approximately 41,000.

NHTSA ODI 11650144

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

NHTSA ODI 11650038

I purchased a Ford Escape 2023 in Green Bay, Wisconsin on [XXX] from Dorsch Ford Dealership. On October 7, 2023 I tried to start my vehicle and the battery was drained/dead. This continued through January of 2024, and I received a new battery. I thought the problem was fixed. Not so, and it has continued throughout the past two years. My vehicle will go into Deep Sleep Mode at different times of the day. I have to drive it to regenerate the battery. At times I do not even have lights when I start the Ford Escape. I have taken it to a Ford Dealership in Appleton. I am suppose to go again on March 25, 2025 and it will be my tenth time. The service person stated why should I even come because they can not find the problem. There is a parasitic draw and it needs to be found, or the battery is not operating properly, and needs to be replaced. I am a school teacher, and I thought I was buying a safe and reliable car. This is not the case. I have over 100 pages of documentation. I have filed complaints with Ford and with the State of Wisconsin Lemon Law to no avail. Also, I am close to warranty and then I will have to pay out of pocket. The Ford Motor Company is violating the consumer laws and not following their obligation to make repairs on my car. This is similar to the Bronco/Maverick battery issue. Something more electrical is happening under the hood. The service people I have dealt with even stated that I don't drive the car regularly. I have to now get up at 4am to get the battery charged. I can not access the added features such as remote start. I paid for something I didn't receive! Plus, what happens when I am driving and the vehicle decides to have a major malfunction? This is wrong on all levels. Please look into this matter immediately. I have had one recall concerning the door locks which were repaired last summer. I am worried and nervous to continue driving the Ford Escape 2023 because of its battery. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11648588

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

NHTSA ODI 11648311

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the contact attempted to close the front driver’s side door; however, the door failed to close securely. No warning light was illuminated. The vehicle was taken back to the residence. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 30,000.

NHTSA ODI 11642041

The contact owns a 2023 Ford Escape. The contact stated that the front driver's door window would not completely roll up and close. The vehicle was taken to the local dealer who replaced the front driver's side door window motor, and the vehicle was repaired but failure reoccurred. Additionally, while operating the vehicle, the message "Front Collision Camera Inoperable" was displayed. The vehicle was taken to the local dealer, but failure code could not be retrieved, and the cause of the failure was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The failure mileage was 13,000.

NHTSA ODI 11639692

While driving on an interstate, the Instrument cluster / digital gauge cluster screen behind my steering wheel turned off. I was driving with my adaptive cruise control on when all of a sudden I see the screen go black and I was no longer able to see how fast the car was going, the engine temperature, or how much fuel I had, as well as all of the other metrics on that dashboard. The car never lost power, because the entertainment screen in the middle of my dash remained on and responsive during the short period of time that my instrument cluster screen was off, and I never lost power steering. Instinctively, I pressed on the break pedal and pulled off of the road onto the shoulder, so I’m not sure if the cruise control would have stayed on. After a few minutes on the shoulder, the instrument cluster screen turned back on, not quite like it does when you turn on the car, but it flashed a bunch of the warning lights and slowly came back to normal. I was able to drive my car safely and without another incident back home, however I am very concerned about this happening again. There were no warning lights, signals, or sounds before this happened. Driving on any road, weather it’s a highway or an interstate, it is very important to be able to see how fast you are traveling for the safety of yourself, your children, and the other drivers. There is a popular recall among this same vehicle type, however mine was not included in the previous recall even though it just repeated the same problem the other ford escapes were having. My local dealership is not taking this problem seriously, and I am very concerned.

NHTSA ODI 11638922

The contact owns a 2023 Ford Escape. The contact stated that while driving at undisclosed speeds, the back-over prevention camera screen went to a blue screen. The contact stated that while driving, the camera turned on and the image was shown. The camera was unavailable, and a message to contact the dealer was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the camera needed to be reset and the software updated. The vehicle was test-driven. The vehicle was repaired, but the failure recurred. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 10,668.

NHTSA ODI 11638297

The contact owns a 2023 Ford Escape. The contact stated that upon starting the vehicle, the center console display remained off. The contact was able to continue driving the vehicle however, the center console and the display was independently turning on and off. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 8,000.

NHTSA ODI 11630551

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds, there was an abnormal sound coming from the engine and the front driver’s side tire. In addition, the instrument panel was occasionally turned off independently. Additionally, during rainy weather driving the brakes were making abnormal sounds. The contact stated that several unknown warning lights were occasionally illuminated. The vehicle was taken to a local dealer on several occasions and was diagnosed; however, the failure could not be replicated. The vehicle was taken to another local dealer, Mullinax Ford of Kissimmee (1810 E Irlo Bronson Memorial Hwy, Kissimmee, FL 34744); for a second opinion; however, the failure could not be replicated. The vehicle was also taken to a third local dealer, Tropical Ford (9900 S Orange Blossom Trl, Orlando, FL 32837); but the cause of the failure could not be determined. The vehicle was taken to a local independent mechanic where it was diagnosed and determined that an unknown material might have intruded into the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

NHTSA ODI 11626254

The contact owns a 2023 Ford Escape. The contact stated while driving 70 MPH, the vehicle suddenly decelerated after the engine overheated and shifted into "LIMP Mode". The contact stated that during the failure, the message "Engine Overheated" was displayed. The vehicle was taken to the local dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not contacted regarding the failure. The failure mileage was 4,200.

NHTSA ODI 11610974

At any random time, all sensors fail. Blind spot systems, parking sensors, pre-collision assist, front camera fault, cross traffic system, cruise control, lane assist, auto headlights. Returned to the dealership multiple times, with no resolution. All sensors continue to fail, with no immediate fix available, according to Ford, until the fourth quarter. So, I am left with an unrepairable vehicle to drive in the already dangerous central Texas traffic. The problem has been confirmed at Leif Johnson Ford, 501 E. Koenig, Austin, Tx 78751. Main #512-454-3711, Service #512-454-3767, and reported to Ford Care at 800-392-3673

NHTSA ODI 11610436

I was driving home to Aspen, CO from Denver. I was about 44 miles from my home, on the other side of an 11,000 ft mountain pass. As I was passing another vehicle, the car died. The dashboard light said "engine coolant over temperature". The car died as I was pulling back into the right lane. The person behind me swerved around me. I had to have the car towed to a dealer that is 2 1/2 hours from my home. It's been sitting at the Ford Dealership in Salida, CO for 9 days. They keep telling me they will get it in to diagnose the problem but every day it's the same story and they do nothing. After doing online research, that make, model and year vehicle engine issue has been reported by many owners. There was no warning about this issue. It simply died while driving on the highway.

NHTSA ODI 11609703

I've had this thing less than 6 months, I've already had the engine rebuilt with 34 parts a month and a half in and the drivers side rear door handle replaced during this time because it would not open from the outside and only the inside despite being unlocked. All of this occurred at the beginning of May 2024 and it sat for 3 months due to the engine being basically rebuilt with most parts being on backorder. Today the same door is having the same issue, only this time the same exact door won't open neither from the inside or outside, which is a huge safety hazard in my eyes if I got into an accident and had passengers in the backseat. I do have video proof of this too.

NHTSA ODI 11607852

The contact owns a 2023 Ford Escape. The contact stated on several occasions while driving, or while the vehicle was parked, all four doors locked inadvertently with the keys inside the vehicle. The contact stated the hatch failed to lock securely and there was no other way to get into the vehicle. The emergency brake light had illuminated. In addition, the contact stated that the cruise control was inoperable. The vehicle was taken to a local dealer where it was diagnosed but the vehicle could not be repaired on several occasions. The contact stated that a systems update was performed; however, the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000.

NHTSA ODI 11602771

a 2023 Ford Escape. while driving at approximately 76 MPH, I observed a warning chime dinging, the power train warning light illuminated, and the low engine coolant message was displayed. I received a notification via the Ford Pass APP stating that "There was a failure with the vehicle and to see the dealer'. I contacted the dealer, and they stated they did not see any warnings. Anytime I exceeded a certain rate of speed it still does this. The first time it happened, it had less than 800 miles on it.

NHTSA ODI 11599860

HAD A CHECK ENGINE LIGHT COME ON 2 WEEKS AGO. TOOK IT TO THE DEALER AND THEY REPROGRAMMED THE PCM AND INSPECTED CYLINDER BORES. DEALER ALSO CHANGED THE OIL AT THAT TIME. SHORTLY AFTER THAT THE LIGHT CAME ON AGAIN, TOOK IT BACK TO THE DEALER THEY'VE HAD SINCE LAST FRIDAY AND NOW REPORT THE VEHICLE MAY NEED A REPLACEMENT ENGINE BLOCK. VEHICLE HAS 10,565 MILES AND IS JUST 13 MONTHS OLD. I HAVE RESEARCHED AND FOUND MANY OTHER SIMILAR INSTANCES ON THE INTERNET.

NHTSA ODI 11596365

The contact owns a 2023 Ford Escape. The contact stated while driving at approximately 50 MPH, he observed a warning chime dinging, the power train warning light illuminated, and the 'low engine coolant' message was displayed. The vehicle was taken to the residence. The contact's wife received a notification via the Ford Pass APP stating that “There was a failure with the vehicle and to see the dealer”. The vehicle was taken to a dealer where it was diagnosed that the engine and head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 3,900.

NHTSA ODI 11591508

Quite often, the display screen for the back up camera does not turn on at all. It will also go blank during use at times.

NHTSA ODI 11588863

See attached document for complaint

NHTSA ODI 11585390

Upon reaching 60 mph my vehicle displayed overheating messages and cut power to the motor. Vehicle was towed into Ford service on 4/4/24 and remains in the shop. Been told it needs a new top end of the motor with no eta on parts. I was approximately one mile from my home when the incident occurred.

NHTSA ODI 11585467