What 94 owners told NHTSA about the 2023 Ford Escape Gas

The contact owns a 2023 Ford Escape. The contact stated that on several occasions, while stopped, while the accelerator was depressed, the vehicle hesitated while accelerating. The contact was almost rear-ended several times when the failure occurred. The contact stated that whenever the vehicle idled for longer than five minutes, the vehicle also hesitated while accelerating. The vehicle was taken to a dealer; however, the failure could not be duplicated. The manufacturer was not notified of the failure. The failure mileage was approximately 3,000.

NHTSA ODI 11717795

The transmission failed at 70,000 miles. The research the transmission shop did indicated the main bearing fails in these because they are made of cheap metal. The transmission just stopped pulling with little warning. It started with a jerking and then quit pulling. Within a few feet. There was not any slipping of the transmission before hand.

NHTSA ODI 11715190

Purchased brand new 11/2023, immediately started with electrical problems 01/2024, also would put car in reverse and car would cut off, was dropped off at service but never given a reason for the issue or a repair. 01/2025 car had acceleration issues, dropped off at service and was given a rental and given car back with no explanation. 6/2025 car went into limp mode and was towed to service where they found shards of metal throughout motor, replaced motor and then started having problems with cab filling with exhaust, was told they had no rental available and could continue to drive the car with my baby in it, then told was just a gasket needed to be replaced, car had same issue immediately, returned back to service where the turbo then needed to be replaced as well as catalytic converter gasket, after repair, called numerous times complaining that car would shift very hard and wouldn’t accelerate while driving or pulling out on an intersection or from a stop light, was told valve body needed to be replaced, then check engine light came on immediately after pickup, returned car and purge valve needed to be replaced, after pickup issue of car not accelerating continued, was told no issue found, car acceleration issues has became worse and now have been told soonest available appointment and rental is 02/12/2026.

NHTSA ODI 11714441

Rearview Camera Has turned dark....

NHTSA ODI 11713979

i found the brake pedal too high.i was involved in a very low speed crash. i found my right foot caught between the accelerator and break peddle .unable to stop in time. am checking for a video and police report at this time

NHTSA ODI 11713335

I was driving on a very flat highway (no other cars around me) and it sounded like an explosion and glass rained down the back of the car. When I get to my destination, I looked at my roof and the sun roof glass had exploded.

NHTSA ODI 11711109

The contact owned a 2023 Ford Escape. The contact stated that the infotainment center would display a black screen, and while doing so, the radio would continue to play. The contact stated that while driving at different speeds, the trunk would suddenly open, causing the contact to have to pull over and close the trunk in order to continue to drive. The failure occurred 3 times while the vehicle was parked at home. There would be a burning odor emitting from the vehicle intermittently; however, there would be no smoke or indication of where the smell was coming from. While parked at home and unoccupied, the rear window suddenly shattered, and the vehicle caught on fire. The fire department was called and extinguished the fire. The fire department and the insurance company had determined the vehicle would be totaled; however, an official determination had not been provided. A police report was filed. The dealer was informed of the failure. There were no injuries or medical attention needed. There was no damage done to the property. The manufacturer was informed of the failure. The failure mileage was approximately 37,000.

NHTSA ODI 11709631

HI, Vehicle is under a second recall for the High Voltage Battery potential fire hazard. The first recall lasted 7 months before a potential fix. The second recall was issued in November with no fix available yet. Received second recall identical to first recall indicating a fire risk with no apparent fix. I have requested Ford buyback the vehicle, but it fell outside the 18 month NYS Lemon Law. They have refused. They have no fix and will not provide a loaner until it is fixed. The original vehicle electric range was between 38 and 40 with a window sticker range of 37. It is now down to around a range of 20 on full charge with an actual driveable of about 16. I have asked both Ford and delivering dealership to replace the High Voltage Battery pack as it has seriously deteriorated. Ford refuses to allow dealer to replace the Battery Pack. The vehicle is basically unusable for it's original intended purpose as a partial electric vehicle. I asked Ford, what am I supposed to do if I am transporting my two grandchildren in the vehicle and it starts on fire. How do I choose which child to get first? No response. These vehicles should be removed from use by Ford and loaner vehicles provided or a full buy back should take place. I only have 11,000 miles on this vehicle and it has been in the shop for more than 30 days for various warranty repairs and multiple recalls. These vehicles are not safe. See pictures attached for factual information from vehicle. I have plenty of detail if you need it. Please help. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11708505

Accessory protocol interface module went out screen went dark. No recall on my vin but should be. Problem appeared 12/26/2025 and has been inspected by Peach State Ford.

NHTSA ODI 11708405

The transmission had an internal failure that caused metal fragments to end up in the transmission fluid and caused failure. The vehicle will not drive and required the transmission to be rebuilt

NHTSA ODI 11702397

My 2023 Ford Escape Plug-In Hybrid has experienced repeated high-voltage battery safety issues and prolonged loss of intended function. In February 2025, Ford notified me under recall 24S79 that I must immediately stop charging the vehicle due to the risk of internal battery cell short, potential battery thermal venting, and fire. That “do not charge” instruction lasted approximately six months, eliminating the core plug-in hybrid functionality of the vehicle. Ford originally stated the remedy would be available in Q2 2025, but the repair was not completed until late August 2025. The recall documentation stated that an internal battery cell short could cause the “Stop Safely Now” warning and sudden loss of motive power, which presents a serious safety risk while driving, especially when transporting my family. During the “do not charge” period the vehicle’s plug-in hybrid capability was unusable, and Ford acknowledged the risk of fire and loss of power. In November 2025, I received a new high-voltage battery recall 25SC4 (NHTSA 25V789) for the same general hazard category (internal short, potential fire, loss of motive power). The new recall states that no remedy is available at this time. This means the vehicle is again subject to a serious unresolved safety defect involving the same critical system. The repeated battery failures and the absence of a current fix create an ongoing safety concern, and the vehicle cannot be reliably used or sold during this open recall with no remedy. I am requesting NHTSA review the repeated HV battery defects, extended loss of plug-in hybrid functionality, delayed first recall remedy, and the current “no remedy available” condition, and assess whether further investigation or corrective action is needed for these vehicles.

NHTSA ODI 11702158

Purchased the vehicle approximately 45 days ago. Has driven fine with no problems. Randomly had a hard down shift and when I went to leave my destination put the vehicle in reverse and it would not go. The vehicle would not move in drive and when put in neutral it was still not even able to be pushed. Had it towed to the nearest ford dealership, they diagnosed that there were metal shavings in the transmission, stated the vehicle was no longer drive able and recommend a transmission replacement or rebuild. Vehicle only has 80,000 miles.

NHTSA ODI 11700484

The contact owns a 2023 Ford Escape. The contact stated that the 12-Volt battery had become inoperable. The contact stated that the vehicle lost motive power while attempting to start the vehicle. There was no warning light illuminated. The contact had to charge the battery several times to start the vehicle. The vehicle was taken to the dealer, but was not diagnosed or repaired. The contact was informed that the issue was battery-related and was advised to drive the vehicle differently and to obtain a trickle charger for the battery. The manufacturer was not made aware of the failure. The approximate failure mileage was 8,000.

NHTSA ODI 11700354

During braking the car experienced what seemed to be a glitch and lost all breaking power. Foot went to the floor and had to press and release multiple times for break power assist to come back. This happened three times within 100 mile drive.

NHTSA ODI 11699043

my 2023 ford edge caused burns to the back of my legs. i was unaware until my grandma informed me that something was wrong with my legs. i noticed when i got the car 2 months ago level 3 of the seat warmer was way to hot like i felt it burning. so i only used on setting 1 or 2 and did not feel the burning sensation like when used on 3 but somehow my legs are burned

NHTSA ODI 11692751

Sunroof molding roof drip rail. Ford part #LJ6Z5450036A. This part is held on with double stick tape. When it comes loose, it can interfere with the proper operation of the sunroof sunshade or fall into the passenger compartment. Mine has been replaced several times under warranty. Even though it was nearly detached, it did not fall. However, if it had, it has the potential of either damaging the sunshade or creating a driver distraction while driving.

NHTSA ODI 11679959

Campaign 23B56 Description Inspect front door check-arm reinforcement spot welds Next Steps Contact your dealer for next steps. ---------------------------------------------------------------------------------------------------------------- Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

NHTSA ODI 11674861

Recall Action Soon Issue Since 03-14-2025 Drivers side seat buckle replacement For More Information Telematics Generated Issue Recall Action Soon Issue Since 11-08-2024 Inspect front door check-arm reinforcement spot welds For More Information

NHTSA ODI 11674799

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds with the Adaptive Cruise Control Mode engaged, the vehicle failed to respond as needed after another vehicle pulled in front of the vehicle. The contact stated that the vehicle jerked and decelerated, and then revved up and accelerated unintendedly until the vehicle was within proximity of the other vehicle. Additionally, the contact stated that the Lane Keep Assist failed to keep the vehicle within the intended lane while driving, and the vehicle veered to the left unintendedly while the Lane Keep Assist was engaged. The vehicle was taken to the dealer to be diagnosed, but the cause of the failure could not be determined. Additionally, the dealer informed the contact that the vehicle was previously repaired under NHTSA Campaign Number: 24V440000 (Forward Collision Avoidance), which the contact related to the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000.

NHTSA ODI 11669387

For the last 2 weeks After accelerating my engine coolant overheat warning light goes off and i can't accelerate any further until light goes off. Also ford mechanic states there is metal shavings in the coolant that might be causing engine to overheat on top of the sensor issue.

NHTSA ODI 11669577

The contact owns a 2023 Ford Escape. The contact stated that while her husband was driving at an undisclosed speed, the vehicle experienced a loss of automotive power, and the steering wheel became difficult to turn in either direction. The contact stated that the messages "Electrical Power Saver Active" and "Service Charging System Warning" were displayed on the instrument panel. In addition, the contact's husband stated that the vehicle failed to come to a complete stop as intended, and the brake pedal felt firm while being depressed. The vehicle was towed to a local dealer and remained for further investigation. The manufacturer was not made aware of the failure. The failure mileage was approximately 35,338.

NHTSA ODI 11665986

Sunshade retracted all the way and center roof molding holding it was with double stick tape. Rolled all the back and cannot get it to go back.

NHTSA ODI 11665537

The contact owns a 2023 Ford Escape. The contact state while reversing, the back over prevention camera failed to function as intended. The contact stated that the back over prevention camera failed to display images of pedestrians or vehicles. The contact stated that due to the failure, the contact almost struck a pedestrian. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was then taken to another dealer where a software update was performed. The manufacturer was made aware of the failure. The contact was offered a buyback. The failure mileage was approximately 55,000.

NHTSA ODI 11663459

12v battery system failure to keep 12v battery that boots operating system of car charged. This leads to a vehicle that cannot be started or moved unless jump started. This has happened daily, and sometimes multiple times a day, requiring a jump pack to get the car to turn on. This issue has been reproduced and confirmed via multiple revised manufacturer TSBs. This has likely been inspected by the ford dealership that sold the used vehicle to me. Multiple safety warnings appear when the vehicle determines the 12v battery is not sufficiently charged.

NHTSA ODI 11660957

The contact owns a 2023 Ford Escape. The contact stated while driving 60 MPH, the Adaptive Cruise Control altered the speed after detecting the number on the Minnesota county road sign ending in the number 5. The Adaptive Cruise Control was changed without warning. The vehicle gradually accelerated after the failure. While driving at slow speeds, the speeds spontaneously increased from 30 MPH to 50 MPH. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, who referred the contact to the NHTSA Hotline. The failure mileage was approximately 19,280.

NHTSA ODI 11657822