What 45 owners told NHTSA about the 2022 Mercedes-benz Mercedes-maybach S-class

The factory upgrade 21 inch spoke wheels with Pirelli P-Zero low profile tires are averaging a blow out every 800 miles. 5 flats and 2 sidewall blisters in the last 10,000 miles. Pirelli P-Zero 255/35/R21 Front and 285/30/R21 Rear are all four available for inspection if you tell me to save them before I replace them. There have been thousands of complaints and law suits re this issue just in the last 5 years on mercedes cars with low profile tires; to Mercedes, Pirelli, through legal discovery, to enthusiasts forums, and to NHTSA My first blowout was at 30 mph hitting a 1 1/2" deep pothole full of rain water. That one blew out the front right and blistered the sideall of the right rear at once. Then one of the new replacements blew on hitting a storm drain set 1" into the pavement on the way home from the dealership. I've been driving 60 years, and never had a single pothole blowout before now. Sidewall tears release all or most of the air at once creating an extremely dangerous situation. Somebody will lose control and hurt or kill someone, or behurt while stopped in an unsafe spot. Since the car can't be towed and has no spare, it is exteremely costly and inconvenient to replace a tire. It has cost me thousands so far, and left my disabled wife and me stranded beside the highway. Car is on a flat and one and a blister on a second tire right now in driveway. Best fix is to go to a square wheel/tire fitment using 19" x 8.5" wheels with 35 offset 66.6 mm bore on all four, all season radials. To keep outside diamter the same for the computer, 255/45/R19 /AS/ XL W and with acoustic tuning or dampening to match the quiet factory tires on these cars. 20" wheels is no good, because to maintain diameter would require the same too short 35 sidewall profile on two of the tires. Staggered 19 inch wheels will work, but the square fitment allows for tire rotaion and for the carrying of a spare. Maybe make that optional for replacement recall.

NHTSA ODI 11747686

Vehicle: 2022 Mercedes-Benz S580 The vehicle is experiencing a severe and violent drivetrain "jolt" or "push" during gear transitions, specifically when shifting from 5th to 6th gear at cruising speeds. On multiple occasions, the jolt was so forceful that passengers believed the vehicle had been rear-ended by another car. This behavior is unpredictable and creates a significant safety hazard, as it causes a sudden change in vehicle momentum while driving in traffic. The issue has been reported to the authorized dealer (Fields Mercedes Lakeland) multiple times. The dealer kept the vehicle for over 40 cumulative days and performed motor/transmission mount replacements and "software calibrations," yet the violent shifting persists. Additionally, the engine produces an excessive vibration and loud noise during extended operation in high temperatures, which ceases only when the ECO/Auto-stop mode engages. I am concerned that the transmission or torque converter may fail abruptly while at highway speeds, potentially leading to a loss of propulsion or a rear-end collision due to the unexpected deceleration/jolt behavior. The vehicle is suffering from chronic oil consumption issues. The 'Check Engine Oil Level (Add 1 Quart)' message has appeared twice: once on 10/31/2025 and again on 04/17/2026. This is despite the vehicle being exclusively serviced by Mercedes-Benz Lakeland. This recurring engine issue, combined with the violent drivetrain jolts and shifting failures, significantly compromises the vehicle's safety and reliability."

NHTSA ODI 11732269

While driving a 2022 Mercedes-Maybach S680 at approximately 40 to 65 mph, multiple advanced driver assistance and safety systems suddenly became inoperative at the same time. The vehicle displayed warnings including Active Steering Assist Inoperative, Active Brake Assist Functions Limited, Active Distance Assist Inoperative, Blind Spot Assist Inoperative, Lane Change Assist Unavailable, and Emergency Stop Assist Unavailable. These warnings appeared while the vehicle was in motion and reduced steering support, braking assistance, and collision avoidance functionality. The failures occurred without warning and created a safety concern because critical driver assistance systems were disabled during highway driving. The problem has occurred more than once and affects multiple electronic safety systems simultaneously.

NHTSA ODI 11717209

On multiple occasions, after the vehicle had been parked and not driven for approximately five days or more, the automatic parking brake locked in place and would not release. I attempted standard methods to disengage the brake, including manual release procedures and lightly rocking the vehicle, without success. The only way to release the brake was to apply significant pressure to the accelerator while in reverse, which caused the brake to suddenly unlock. The first incident occurred while the vehicle was parked in my home garage. At the time, my grandson was playing nearby. The sudden release of the brake after applying the accelerator created a dangerous situation and was extremely alarming. A second incident occurred several days later while I was on vacation. In this instance, I made sure no one was near the vehicle before attempting to release the brake. Anticipating the issue, I had my left foot ready to push on the breaks when I accelerated using my right foot which releases the parking. I brought the vehicle to a Mercedes-Benz dealership on January 5, 2026, where the car remained for nearly ten days. The dealership was able to replicate the issue exactly as described. The service advisor also had to apply significant accelerator pressure to release the locked parking brake. A certified Mercedes-Benz technician inspected the vehicle thoroughly, including scanning for fault codes and checking for rust or mechanical issues, but ultimately advised that this behavior was considered “normal operation.” I find this explanation concerning. Having to apply forceful acceleration to release a locked parking brake presents a clear safety risk, particularly in confined spaces such as garages or parking structures, and could easily result in property damage or personal injury

NHTSA ODI 11712692

Was driving the car at 3:00 P.M. and all of a sudden thr dash display when total black out nothing on the display screen. Speed,fuel,turnning singles nothing total black out. Took it to the dealership to fix as this can and would be a life threathing at loss of life could and can happen in a traffic sistiution

NHTSA ODI 11709116

Mercedes-Benz S580 equipped with 21-inch wheels has experienced numerous tire blowouts over the course of ownership — too many to count. The blowouts occurred during normal driving on typical roads. Several blowouts caused rim damage and created a dangerous situation, including moments where I nearly lost control of the vehicle. This appears to be a design defect involving the 21-inch wheel and low-profile tire configuration, which seems structurally inadequate for normal road conditions. The failures are recurring and not due to isolated hazards. Other S580 owners have reported identical issues with repeated blowouts on 21-inch wheels. This presents a serious safety hazard, and a permanent remedy is needed.

NHTSA ODI 11703501

The contact owns a 2022 Mercedes-Benz S 580. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and the engine stalled. The vehicle was taken to the dealer, where it was diagnosed with a failed CAM shaft solenoid. The contact was informed that the CAM shaft solenoid needed to be replaced. In addition, the contact was informed that the engine needed to be dismantled. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact referenced an unknown recall with a similar failure description; however, the VIN was not under recall. The failure mileage was approximately 55,000.

NHTSA ODI 11687434

Subject: Report of Spontaneous Sunroof Explosion - Mercedes S580 2022 Model Dear National Highway Traffic Safety Administration, I am writing to report a concerning incident that occurred on [XXX] at approximately [XXX] while I was driving my 2022 Mercedes S580 to work on [XXX] N. During my drive, I experienced a sudden, loud explosion within the vehicle. Initially, I believed it was either a gunshot or that I had been rear-ended. In a state of confusion, I quickly pulled over to the shoulder to assess the situation. Upon closer inspection, I discovered that my sunroof had shattered spontaneously. I am certain that this was not caused by an external object, such as a falling stone. There were no overpasses, bridges, or surrounding traffic that could have contributed to the damage. This was an extremely frightening experience, and I believe it is important to bring this matter to your attention for safety considerations. I have also reported this incident to my local Mercedes-Benz dealership. Thank you for your attention to this serious safety concern. Sincerely, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11686338

Over ~3 years of ownership, the vehicle has experienced recurrent electrical and engine-management issues, resulting in 15+ service visits and ~100 cumulative days out of service at an authorized dealer. Patterns include: (1) electrical—keyless entry intermittently unresponsive, instrument cluster flickering/rebooting, multiple warning messages including a battery/electrical icon, HVAC/A/C becoming inoperative without cooling; and (2) powertrain/engine—check-engine light (MIL) illuminated, hesitation/limited power on initial acceleration, and rough operation after start. Safety risk: intermittent failure to unlock/start can leave occupants stranded; loss of power/hesitation creates risk when merging or crossing intersections; multiple warning messages/flicker are distracting; and loss of A/C in hot conditions has required operation with windows down to avoid heat stress. Reproduction/confirmation: The concerns have been observed by the dealer on multiple visits with fault codes recorded (codes UNKNOWN to me). Repairs/updates have been attempted, but symptoms recur after service. The vehicle has been inspected repeatedly by the authorized dealer and remains available for inspection upon request. Warnings/symptoms prior to failure: intermittent MIL, battery/electrical warning, cluster glitches/flicker, and A/C blowing warm air; some events followed periods where the vehicle would not unlock or start on the first attempt. Root cause: UNKNOWN.

NHTSA ODI 11686347

mechanical and safety-related failures observed in a Mercedes-Benz vehicle, specifically involving the suspension system, wheels, and braking components. Despite extensive repair efforts—including replacement of all four wheels and tires, complete AWD four-wheel alignment, and diagnostics performed at authorized Mercedes-Benz dealerships—the underlying issues persist. To date, the total cost incurred in attempting to remedy these defects exceeds $15,848. The vehicle and its components have been inspected by two independent Mercedes-Benz dealer service centers and a certified third-party auto inspection firm. All parties have confirmed, through drive testing and diagnostics, that the problems are reproducible and continue to impair vehicle safety and performance. The suspension and associated hardware have been identified as the root cause of instability and braking inconsistencies. These findings align with broader patterns observed in similar vehicles, suggesting a recurring defect that warrants intervention by the manufacturer. Despite clear evidence from multiple independent sources, the manufacturer has failed to initiate a recall or implement corrective measures. This failure poses an ongoing safety risk to operators and the general public. The vehicle remains available for further inspection upon request. Immediate attention to this matter is expected to prevent further liabilities and protect consumer welfare.

NHTSA ODI 11676456

The following pictures will again show the issues that I'm having while driving my 2022 S Class Mercedes, while using the cruise control on the Belt Parkway. It shows me stuck in traffic and, although I can only go 11 miles an hour while I’m stuck in traffic, the cruise control wants to push it to 80 mph, which is indeed VERY VERY DANGEROUS!! as you can well imagine. Also, as you can see in the second picture, I have the cruise control set to 39 MPH. I have been writing for the past two months with no resolve as yet. The repair records speak for themselves and still Mercedes Benz offers no remedy. It would appear that it's going to take a severe accident or fatality to bring some type of action on your part to replace this vehicle, which is definitely a LEMON!!

NHTSA ODI 11651654

Here we go again, while driving on a side road with a 20 mph school speed limit, the cruise control wants to SPEED UP to 60 mph!! WHAT IS IT GOING TO TAKE TO REMEDY THIS BEFORE I’M INVOLVED IN A SERIOUS ACCIDENT!!

NHTSA ODI 11650963

I leased my 2022 S 500, Mercedes Benz. on September 28, 2022 and after about a year, I have had issues with the large screen/radio and cruise control in the vehicle. All events are documented at the Rockville Centre, Long Island service center. I have made numerous complaints beginning in January of this year through emails and was assigned a case number with Mercedes Benz corporate which is 12240831. On numerous occasions, while using the cruise control set to 50 MPH, the vehicle will accelerate to  80 MPH  on a highway with a  50 MPH speed limit. Then on other occasions,  while using the cruise control, the vehicle will accelerate to  80 MPH  on a highway with a  25 MPH speed limit. Then,  at other times, while using the cruise control set to 50 MPH, on a highway which has a 50 MPH speed limit, the car will reduce to 10 MPH .  All of these scenarios are  VERY  DANGEROUS  as you can well imagine. On many other occasions, the screen map will become blurry & distorted causing confusion as to my whereabouts. **The time has come for a replacement/repurchase of this vehicle and,  I believe, at this time, this vehicle should be considered for the  "LEMON LAW"  under all applicable State and Federal laws.   I can send a separate email with all of the pictures of the screen and cruise control issues. 

NHTSA ODI 11649962

as a loyal Mercedes Benz customer for the past 15 years, here I am writing to you for the fourth time since January 28th. of this year. My case number is [XXX]. I leased my 2022 S 500, VIN # [XXX] on [XXX] and after about a year, I have had issues with the large screen/radio in the vehicle. All events are documented with your Rockville Centre, Long Island service facility where the staff has been very helpful. On numerous occasions, while using the cruise control set to 50 MPH, the vehicle will accelerate to 80 MPH on a highway with a 50 MPH speed limit. Then on other occasions, while using the cruise control, the vehicle will accelerate to 80 MPH on a highway with a 25 MPH speed limit. Then, at other times, while using the cruise control set to 50 MPH, on a highway which has a 50 MPH speed limit, the car will reduce to 10 MPH . All of these scenarios are VERY DANGEROUS as you can well imagine. On many other occasions, the screen map will become blurry & distorted causing confusion as to my whereabouts. On a side note, we had an usually warm day [XXX]. here in New York City of about 55° and while riding around NY City, the air conditioner was not cooling properly and was brought in for service shortly afterwards for that issue as well as all of the screen issues. The same problem with the air conditioning occurred last week as the temperatures in New York City were about 55° and, frustrated again, I brought the vehicle in for the air conditioner and screen issues and they kept the vehicle for ten (10) days!!. **The time has come for a replacement/repurchase of this vehicle and, I believe, at this time, this vehicle should be considered for the "LEMON LAW" under all applicable State and Federal laws. I will be sending a separate email with a few pictures of the screen issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11648771

The contact owns a 2022 Mercedes-Benz S580. The contact received notification of NHTSA Campaign Number: 24V704000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ODI 11639174

Check engine light came on few occasions. Took to the dealer and told it’s just a false alarm no problems. On the night of sept 12th 2024, I’m my way home I lost the ac cooling all of a sudden. I was only 5 mts from home. Once inside my garage I saw to my horror some smoke coming from under yhe hood. Upon opening saw some charred wires and some wire smoldering and smoke was coming out of it. Scared for my family I parked my car outside overnite and called the dealer. They had the car towed away the next day. Got my car back on 6 th of November 2024, with a laundry list of problems and issues, that they had supposedly fixed. Three or four various engine wiring harnesses were replaced, due to charring or melting, probably due to the heat. The engine and transmission were lifted off to fix all the wires and what not. I have all the invoices. And video and pictures of some wires and smoke. They don’t have an explanation for this. The recent recall about ecu maybe suggests the overheating of engine and causing the wires to burn out and some wires started burning almost causing fire if not caught in time. Called Mbusa and they didn’t show any concern. But one week after this incident they issued that ecu engine heating warning. Off course there is no repair for that. This is a fire hazard waiting to happen.

NHTSA ODI 11631897

Headunit goes offline blank screen and limits controls back up camera defrost and temperature controls

NHTSA ODI 11627102

Brakes seize when wet. That is, after a car wash or following exposure to rain, the accelerator must be pressed with abnormally greater pressure to get car moving from parked position. Loud, screeching sound emanates when brake releases. This malady continues severally. Resting lightly on brake pedal to dry out turning brake rotors, does not help. Eventually, problem disappears until the next wet episode. -Per Mercedes Authorized Dealer, there is no fix; problem is common to Mercedes 223 series. -Risk of collision exists in both modes, Drive as well as Reverse. This, due to sudden jump forward or rearward under brake-seize conditions. -Issue is ongoing, not a single incident. Remains unresolved. [At age [XXX] , I have over [XXX] driving experience. The above is an abnormal-with-risk, issue.] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11625649

The car slams on the brakes for no reason. phantom braking. i have been tailgated because cars behind me - particularly on tye highway - think i’ve brake checked them (but it was the care slamming on the brakes). the door handles don’t open/deploy reliably. sometimes they work, sometimes they don’t. the touch screens are incredibly dangerous - especially when the system freezes or doesn’t work properly - which is often. there are almost no physical buttons. the system software & touchscreens are VERY glitchy and often doesn’t function properly. touch-sensitive buttons on the steering wheel get activated just from me driving. functions turn on and off just because my hands in on the steering wheel. it’s dangerous. the car had 7 flat tires in 1 year. it’s too heavy for the 21” low profile tires. MBUSA has been made aware of the multitude of problems. The car is constantly at the dealership for warranty repairs. It's a lemon, but MBUSA won’t do anything about it. not until someone gets killed. MBUSA blows me off with every interaction and complaint i make about the quality problems with this car. They don’t care.

NHTSA ODI 11614618

I have the 2022 S 500 with 21 inch mag spoke rims with Pirelli 255/35R21 tires on it which comes stock from Mercedes Benz. I have now been in almost 15 tires repair claims and 3 rim replacements because of how poorly Mercedes designed the rims then put a tire soon the car that cannot handle the weight of the car. I hit a pot hole and my whole tire blew out almost causing a severe crash. this is again the almost 15th time this has happened. I took the car to Mercedes Beverly Hills and the service advisors say that now there is $16,000 dollars in damages on the car fro the constant impact it has taken from the rims being poorly designed on the car. I have asked many times to replace the tire brand to a better and thicker tire. but Mercedes will not allow that and demands I pay over 16k in damages to fix suspensions and the drive unit issues.

NHTSA ODI 11604807

We're on our fifth windshield, and I'm concerned that there is some sort of structural issue. We've lived in the same area for more than 10 years and have never had this problem with any of our other cars, SUVs, or trucks. Sometimes, it sounds like a piece of sand has hit the windshield, and BOOM...another cracked windshield, but it always cracks on the driver's side. This isn't normal. Also, settings don't save to our profiles, and the backup warning signal doesn't work dependably. We've had these things looked at several times by the dealership. They have no answers.

NHTSA ODI 11592292

The contact owns a 2022 Mercedes-Benz S580 equipped with Pirelli Tires, Tire Line: PZero PZ4, Tire Size: 255/35/R21, DOT Number: [XXX] . The contact stated that the vehicle was purchased 6 months prior and while observing the vehicle, both the front original tires had bubbles. The vehicle was taken to the dealer. The tires were replaced with the same brand and tire line. The contact stated that while driving approximately 40 MPH 4-months later, the passenger's side front tire had a blowout. The vehicle was towed to a different dealer. The tire was replaced with the same brand and tire line. The contact stated that 2 months later, the failure recurred with the passenger's side front tire where there were bubbles on the tire. The vehicle was taken to the initial dealer. The tire was replaced with the same tire and tire line. The failure recurred 5 months later. The vehicle was taken to the initial dealer where the tire was replaced with the same tire and tire line. The contact stated that the failure recurred 3 months later. The tire was not replaced. The manufacturer was not made aware of the failure. The vehicle failure mileage was approximately 2,815, and the tire failure mileage was approximately 2,815. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11587281

HIGH VOLTAGE BATTERY ISSUE, WHICH CAUSES THE ALTERNATOR & LOW VOLTAGE BATTERY TO BURN OUT.

NHTSA ODI 11576610

Camera which provides data to key ADAS features repeatedly malfunctions. Car reports “camera view restricted” rendering many safety features inoperable. It does so repeatedly. Dealer service department says camera cover is malfunctioning and part is on back order. This renders the car unsafe since the various safety features are inoperable and the warning message pops up,so often as to be distracting.

NHTSA ODI 11572673

The contact owns a 2022 Mercedes-Benz S580. The contact stated while driving 70 MPH, the vehicle lost motive power. The contact was able to veer to the side of the road. The contact stated that the failure reoccurred several times while driving. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the cam adjuster was replaced; however, the failure persisted. The vehicle was taken back to the dealer. The vehicle was not repaired. Additionally, the contact received notification of NHTSA Campaign Number: 23V445000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The manufacturer was notified of the failure and a case was opened; however, no further assistance was provided. The failure mileage was approximately 5,000.

NHTSA ODI 11559979