What 364 owners told NHTSA about the 2022 Hyundai Tucson Fuel Cell

Fuel injector went out in the middle of highway and vehicle had to be towed after vehicle starting shaking and couldn't drive above 25 miles per hour. This is a known issue by Hyundai in 2022 Hyundai Tucson.

NHTSA ODI 11600264

Fuel injector failure on 02/2024. Fuel injector failure on 06/2024. Both times car lost power and started shaking. Hyundai service center will only replace one at a time. Car only has 28k miles.

NHTSA ODI 11599775

Fuel injector failure on 02/2024. Fuel injector failure on 06/2024. Both times car lost power and started shaking. Hyundai service center will only replace one at a time. Car only has 28k miles.

NHTSA ODI 11599776

We fist noticed a problem with the car having a hard time accelerating and a hard shift at 25-35 mph back at the end of November. We then got a check engine light that came on that said P013A00 Powertrain. We brought it to the dealership the first week of December and were told that the transmission just needed an update. Upon taking the car home it was better for about a week then the issue came back sporadically. Then on March 20th my wife was driving the car and it would not accelerate past 35 mph while getting onto the interstate. Cars were going by her at 70+MPH as she sat there helplessly pressing the accelerator. Eventually she got the car up to 50 mph but it would not go any faster. We brought it into the dealership that day and once again they said the transmission needed an update. I then contacted Hyundai corporate and submitted a complaint and they started a case for the issue. After the second time at the dealership the car was ok for a week and then started with the same issues. After taking it to several other dealerships they all tell me that it’s a transmission issue that they don’t know how to fix but they change what they say once Hyundai corporate talks with them. Presently the car will have very high RPM and jump forward almost colliding with cars in front. It will also not accelerate such as the peddle is on the floor and the RPMs are high but the car will barely move until it shifts gears and jumps forward.

NHTSA ODI 11585828

I was driving on the highway when the engine would not accelerate. I was stuck in a high speed lane and drivers were on my rear bumper. I could not move over and felt helpless. I pulled off at the next exit and the vehicle was sputtering. I made it home at reduced speed. The vehicle would not start the next morning. I had it towed to the nearest dealership. I was contacted days later and informed that the is a bulletin about power loss due to faulty fuel injectors. Many complaint sites are full of the same problems. I now feel unsafe driving the vehicle on trips. I don't want to get stuck in the middle of nowhere. I am a female senior citizen.

NHTSA ODI 11582743

Ignition coil failure while driving. Loss of power, jerking performance, almost to point of stalling. No check engine lights until failure. Confirmed with scanner what computer was registering. I’ve seen other posts online of this happening.

NHTSA ODI 11582790

NHTSA Complaint On Sunday, March 10th 2024 our 2022 Hyundai Tucson with 2.5L engine started missing in one of the cylinders. It did not disable the vehicle and it ran like that for several blocks until we could pullover to safety. At this time there were no warning lights of any kind. It wasn’t until I turned the car off, checked the oil (which was good), started the car again and did a lap around the parking lot that the check engine light came on. So there were no warnings. We dropped the car off at our local Hyundai service center that night so it could be checked first thing the next day. It turned out that it was a bad spark plug and injector. At that point it was no big deal. We chalked it up to a fluke. We received the car back on Thursday, March 14th with the explanation of what happened and that it was replaced under warranty. There were NO RECOMMENDATIONS made upon pick up. Exactly 2 weeks later on Thursday, March 28th, the car lost all power while traveling 60mph in the middle lane of the interstate. Again, there were no warning or diagnostic lights coming on. It was pure luck that there was minimal traffic and other drivers were paying attention as the car came to a complete stop in the middle of the highway in order to be restarted and it refused to accelerate above 20mph in order to limp to the shoulder and get to safety. Over an hour later and stopping and starting the car in a parking lot, the check engine light finally came on. The engine was running worse this time. The car had to be towed this time to the service center. After being checked out it was another spark plug and a fouled fuel injector. Researching online showed that this is a very common issue with Hyundai fuel injectors between 12,000 and 25,000 miles. There are currently no technical service bulletins or recalls warning owners of this common failure and potentially losing power traveling at high speeds. Research showed there have been 3 collisions caused by this exact issue to date.

NHTSA ODI 11582183

In December, while parking in garage, the vehicle suddenly accelerated causing considerable property damage Yesterday, Feb 26,2024 this happened again while parking. The car suddenly accelerated while parking, jumping over the parking curb and into the corner of a building causing major damage to the vehicle. No airbag deployment or forward collision warning in either case

NHTSA ODI 11574169

This is the third time I had issues with my 2022 Hyundai Tucson losing power, being unable to accelerate, and/or completely losing power and stopping. I already created an NHSTA report/complaint when the first incident occurred 11 months ago (NHTSA ID Number: 11507213). Since then, the issue occurred twice (has 33,000 miles & always maintained). I am a professional female in [XXX] . The 2nd time was at night [XXX]; I was on my way to a program for work, car decelerated. I could navigate, with great distress and frustration to a side street where the car shut off completely. I contacted my husband, my supervisor (who delayed the program start for a few minutes, then began without me), Hyundai Blue Link and AAA. My supervisor sent someone to pick me up so I could be present at the program and make my presentation. A colleague returned me to my failed vehicle. I called AAA for an update on the tow, which I was told would not be for another several hours after midnight. My colleague drove me home (16.5 miles one way: my husband was even further away) as I would have again been alone in my vehicle at night (without heat). This third time (Jan 2024), I used the climate start for at least 12 minutes before driving. The car never gained acceleration above 19 mph, occurring immediately. I thought it was just a cold engine that would dissipate as I drove, but it didn't. Since I could not get the engine to accelerate, I could not get heat. It was as though the engine was draining all the functions of the vehicle. There were no cars in front of me, but several drivers behind me were very angry; amazingly, no accident occurred. Finally drove to dealer, called Uber, and was late to work again! Purchased my Tucson after engine issues with my Hyundai Sante Fe. Both purchased new with many extended warranties, assuming I'd have a safe and reliable vehicle. Car still at dealer (10 days). Is Hyundai ignoring safety and significant hazards over sales and profits? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11568825

While driving uphill, the car lost power, beginning to spurt and stalling. Then the car was not able to accelerate while car kept spurting and stopping. It was a dangerous situation as this happened while we were driving, in the middle of the road, while going uphill. Thankfully it was at night and there were no cars behind us but if there was we would have clashed into it. Towed the vehicle to the dealership and was informed that the same year TUCSON came in the night before with similar problems. It appears that there is a pattern to this safety concern. Please take action before someone gets hurt. Car shutting off like this while driving poses safety concerns for drivers and all the people around it. Even with fix, I don't feel safe driving unless I see actions taken by Hyundai to solve this apparent issue with powertrain/engine.

NHTSA ODI 11561088

Spring and Summer 2023: Multiple safety sensor malfunctions during highway rides pose a risk. The official dealership reset the system, but issues have persisted over the last few months. August 9, 2023: Sudden and intense shaking, poor driving performance. The vehicle was serviced at the official dealership (LITHIA Hyundai of New Port Richey #396). Replaced Parts: QQH Injector Assembly Fuel QQH Pipe-High Pressure Combustion Seal Ring K Bolt Gasket-Port Gasket-PCV FKM Washer-Injector Bracket x 2 September 25, 2023: Recurrence of shaking and jerking while driving on the highway. The vehicle was dropped off at the same official dealership. Replaced Parts: Spark Plugs Combustion Seal Ring QQH Pipe-High Pressure QQH Injector Assembly Fuel December 19th, 2023: The same issue appeared yesterday. The vehicle was dropped off for repair at the official dealership (LITHIA Hyundai of New Port Richey #396). Ongoing concerns and recurrent problems warrant further investigation and resolution. Dealership Information: LITHIA Hyundai of New Port Richey #396 Address: 3936 US Hwy 19, New Port Richey, FL 34652 Phone: (727) 203-7300

NHTSA ODI 11561146

My wife was with my Aunt and driving at 70mph on PGBT highway and instant the check engine light come on and the car started smelling of burnt equipment and stalled. The cabin was filled with white smoke and the windows jammed as well. The car was stalled in the middle of the highway with traffic zooming past and severing to save us. This car put my family is a life threatening situation and I want that to be recorded. We use this vehicle for our family trips and it haunts me to think what it can do to my wife and kids. I have started a formal complaint with Hyundai corporate and the complaint number is [XXX]. Also the car is with Hyundai Dealership at Address: 1301 N Central Expy, McKinney, TX 75070 (469) 525-4300) and I am yet to receive a diagnosis from them on what actually happened to the vehicle. Cops were called at the scene but a formal police report was not given. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11560520

System Failed: Shut off in traffic. Vehicle can be inspected upon request. Safety risk: Potential for collision. Input from Dealership: Dealerships error code/diagnostic code was P213800. Reset system and recharge battery. Warning lights came on at the same time as the car shut down. One month prior check engine light came on, but car was operating normally. Dealership ran diagnostic test which did not indicate any issues. The suggestion was to tighten the gas cap.

NHTSA ODI 11558678

This car has 36,000 miles, purchased new and serviced on schedule. The car is at the dealer for the third time since purchase. The first was a fuel injector issue/drivetrain error. The second time was a bad spark plug. The most current issue is another fuel injector. People on the internet have reported similar problems. The dealership has directed us to come get the car, which is unacceptable, because this is an engine error. I spoke to Hyundai Customer Car and they directed me to rent a car at my own cost and to not drive the car.

NHTSA ODI 11557014

For the second time vehicle has lost power and slowly began slowing down. This time it was on the interstate which almost caused a collision with a semi. It is due to faulty fuel injectors which is a known issue with hyundai.

NHTSA ODI 11556172

I am writing to express my deep concerns regarding a series of ongoing safety issues with our HYUNDAI TUCSON 2022 (leased in 2022). We have encountered alarming problems that are affecting the safety and reliability of the vehicle. On July 29, 2023, my husband was driving the vehicle up a sharp incline when the car started shaking/jolting and abruptly shut off. This resulted in a highly dangerous situation as the car began to roll back. He was unable to restart the vehicle, and it had to be towed to the nearest Hyundai dealership. It took over a week for the dealership to address and rectify the issue...so we thought (see below). Also, please note that there was smoke coming out from the exhaust when the tow truck came. It looked like smoke from a flame inside. Fast forward to November 8, 2023, the vehicle was experiencing the same issue as before: continuous shaking/jolting, and the vehicle abruptly shut off once again... stalling in the middle of a highway. A police officer saw what happened and helped my husband relocate the vehicle to the shoulder of the highway to avoid oncoming traffic/collision. He waited with my husband as he kept trying to get the vehicle to turn on. After 30 min, he was able to get it back on. The "check engine" light was illuminated. My husband drove home while the car was still shaking/jolting. We plan to, once again, have it towed to the nearest Hyundai dealership today. We were told the issue had been "resolved" from the last time this happened in July. Clearly, it was not resolved and I feel this vehicle should be recalled. These recurring problems are deeply unsettling for a vehicle that is not even two years old. Given the repeated and unresolved safety issues with this vehicle, I am concerned for the safety of myself, my family, my unborn child as I am expecting and other road users. I would like to request your immediate attention and intervention to address these problems effectively.

NHTSA ODI 11554378

Car lost ability to accelerate and was shuddering for the second time. My personal code reader pulls up codes P0191 and P0303. Engine misfire. Second time since June28,2023. Bought the Hyundai Tucson brand new in December of 2021. First time car lost acceleration and was shuddering on the interstate with my toddler son and pregnant wife stranded. The second time was tonight, October 30th, 2023. I was in the car with my still pregnant wife and toddler son.

NHTSA ODI 11552762

While driving vehicle, car lost power and show down on highway. Car would not start. Eventually started and sputtered white smoke and the smell of fuel. Car would only go 2 miles and hour. Took to dealership and they said it was the fuel injector pump. No recall has been issued even though several other Hyundai and Genesis i models have recalls for same issue.

NHTSA ODI 11549692

While driving the check engine light comes on and the car loses power and starts running very ruff and almost stalls at times. This is the second time this has happen in 3 months, last time they replaced a fuel injector. I look up the problem and it seams to be common problem with the 2022 Hyundai Tucson.

NHTSA ODI 11546812

July.2023: Check Engine Light On ; It came as we were driving on the highway. Acceleration was sluggish due to this issue. Error code indicated that 1 of the 4 engine had issues. Escalated the issue to Hyundai Customer Service. Issue was resolved during first week of Aug.2023. Sept.2023 We were driving on the highway and Check Engine Light came once again. It was late at night. The acceleration was sluggish and managed to drive to a nearby hotel. Contacted Hyundai Customer Service. 2 out of 4 cylinder had issues (replace rotor, wiring etc.,). Dropped the car in a Hyundai dealership (Urbana, IL). Rented a rental car to drive back to MI. Given the recurring cylinder issue, Hyundai Customer Service is NOT willing to accept the issue with Engine. 2 out of 4 cylinders had issue. Remaining 2 cylinders may have similar issue. Given the issue, quality of 2022 Hyundai Tucson Engine design and build quality is a MAJOR issue and RISK for customers. Should you be driving in a freeway, acceleration will be sluggish and can cause major accidents.

NHTSA ODI 11545099

When I’m at a dead stop, and start to drive off, there is a jerking at around 13 miles per hour. I believe it is when it is shifting from first into second gear. It happens often, but not all the time. This happened when I first bought my car, and I was told that the car has to get to know me. I thought this was true, because it seemed to have stopped at some point for a while. Now it is doing it again, but more dramatically. The jerking is very obvious. Also there have been about 5 times when the car revs by itself when I am in the 40’s. I am not pressing heaving on the gas, I am just driving, and it sounds like it slipped out of gear for a second and the car is revving, and then it just goes back to normal.

NHTSA ODI 11544005

Since I received my car, within a few couple of months I have noticed that the car would jump forward when changing the RPMs/gears. When I had brought it in for an oil change, I had mentioned it to the service tech and they told me they would run a diagnostic to see if anything would pop up but the likelihood hood it wouldn't show anything. The second time I mentioned it again while I was driving, the car would accelerate faster than normal as though it was on Sports Mode even though it wasn't, and then the car/engine would jump or make the car lunge forward as it was slowing down. They said they would look into it again but nothing was found. a few months later I was driving home on the freeway when my car jumped again, the engine turned off and I was in the middle of the freeway not being able to accelerate but take the speed I was going to move over to the emergency side in order not to get hit by another car. I got it towed into the dealership, they said they would get back to me after a few days and once they found out what happened, they had my car for about 2 weeks. They also wanted me to pay for a fuel system flush and returned the car to me on empty gas which was full when I brought it in. The back passenger window wasn't working either and I had brought that up to their attention saying if I were to bring it back in I would need to pay for a diagnostic to get it fixed. I was upset and brought it into another dealership to get fixed and mentioned again about the car jumping and afraid that I would be left on the side of the road or the engine would turn off again. They couldn't do anything without an engine light to be turned on. I'm afraid of driving my car but why am I paying for something that the dealership cannot fix or know that whatever they did wasn't fixing the problem? I have brought in my car time and time again to get seen or fixed before the major issue happened and now electrical parts of the car are faulty with things turning off randomly.

NHTSA ODI 11544086

Vehicle would not accelerate leaving driveway. Was bucking as I went down the street. At end of street when I tried to turn off it stopped as I accelerated and I was almost rear ended. I pulled over there were no warning lights on at all. I pulled out as I wanted to turn around and go home and it would not accelerate again. I was able to make it home. I looked up problem on line and it seems like I am not alone. As it is Sunday going to call dealer tomorrow but not expecting them to take it in soon as most appointments take over 1 month to get. I am very scared to drive my car.

NHTSA ODI 11543667

Engine light is on at 6,000 miles,they fixed but on again a month after repair.

NHTSA ODI 11542400

The affected part is the engine and/or power train, the engine light constantly stays on. The acceleration decreases and unable to drive over 40 mph. These parts were inspected by two different car mechanics at Hyundai Car dealerships, Alexandria, VA (April May 2023) and Waldorf, MD, (June -July 2023) which they say was the gas cap. After getting a diagnostic the reading was P0 301. On August 22,2023 at 9:30am took the car to mechanical service at Hyundai In Waldorf, MD they concluded it was the gas cap, again, today the engine is on again.

NHTSA ODI 11540267