What 175 owners told NHTSA about the 2021 Tesla Model S Bev

I engaged Tesla's Autopark to park my car in my usual spot. The car kept going after reaching the back of the parking space, crashing into a pole located around one foot behind the parking spot. The time between when it should have braked and the post was of such short duration that I had no time to apply the brakes and prevent the accident. The car lacks both radar and lidar, either of which would have detected the post. Instead it relies on a single video camera. What made this parking different from previous safe parking attempt in the same space was that the car was perfectly lined up. That meant that the camera could not make use of parallax to enable the AI to notice that the post was moving against the background and must, therefore by close behind instead of 40 feet away. For Tesla Autopark to function safely, it needs to "know" how far back possible obstructions are. It could do so by never backing up with perfect alignment. Instead, the car should move enough from side to side to generate enough parallax effect for it to be able to determine if it is about the crash. The service manager who called to tell me that Tesla decided the accident was my fault absolutely refused to even hear my opinion on what Tesla could do to prevent such accidents in the future. He told me he had be instructed to deliver Tesla's disclaimer and to not listen to anything I might have to say. As an engineer who has patents in the area of both aviation and automotive safety, I have an opinion that might have been worthy of Tesla's hearing. I now suggest you folks warn people that Autopark should not be used to complete the parking procedure unless and until Tesla decides to address this problem. In the meantime, drivers should be cautioned to either not use the feature or to tap the brakes lightly to disengage the feature several feet before reaching the back of a parking space. The driver can then complete the maneuver manually.

NHTSA ODI 11625790

Vehicle constantly overheats and causes charger to overheat. This causes the charging rate to reduce constantly. Home infrastructure has been checked and confirmed to be wired properly by multiple electricians. The suspension makes lots of noises and is a rough ride despite being constantly checked by the service center.

NHTSA ODI 11625612

295 / 30ZR 21 - My tire failed well before the tread life expired. You can see in the attached images that the tire failed at the meeting point between the tread and the sidewall.

NHTSA ODI 11622354

Due to the yoke not having a traditional horn button it is hard to remember to push the tiny capacative touch button... very dangerous. Also the yoke feels more dangerous than a normal wheel.

NHTSA ODI 11621864

See attached document for complaint.

NHTSA ODI 11620387

I received recall notice for 24V-554 on 9/22/2024. The recall notice informs that Tesla will resolve the recall safety defect by over-the-air update via the car's WIFI capabilities. I have informed Tesla that my car's WIFI capabilities are broken and I scheduled service for October 3rd. Tesla informed that parts for my vehicle are not yet ready and rescheduled my service for October 24th. I informed Tesla that I am missing a required safety recall update, and asked if they able to push the update to me via the car's internet or otherwise remedy the issue of my car not having capability to resolve the safety defect. Tesla responded "Due to contraints at the service center we unfortunately had to reschedule you" for October 24th. The Safety Recall notice informed that if the manufacter is unable to remedy the safety defect within a reasonable time, I may notify the NHTSA.

NHTSA ODI 11618371

There is a repeated issue with my vehicle and I looked it up online and it seems all Tesla Model S vehicles have this issue. This is the 2nd time I've had this same issue. As I go over any bumps, accelerate, or decelerate there's a clicking sound coming from the front wheels. While driving there's a whistling sound. Based on websites and videos I've seen all over the internet, it's the result of a loose nut and bolt. It apparently continually occurs because of the very high amount of torque these cars have and the quality of the parts used for this torque doesn't suffice. Tesla needs to fix this on all their Model S vehicles. Instead apparently all they do at service center is apply grease to the affected area to temporarily make the noise go away but that grease melts away annually.

NHTSA ODI 11615339

Front suspension has a popping and creaking sound when driving and turning steering wheel. Safety issue as sounds something is loose but Tesla says no issue it’s the body flexing which is even scarier to hear the panels rattling if this is in fact true. Tesla will not do anything about it. Additionally the brakes and rotors squeal when pressed at slow speeds coming to full hard stop. Both front and back. Both brakes and rotors have 90% life and according to Tesla shouldn’t need replacing until 90k miles due to the regen braking. The braking system does not engage as it should or how it is designed and car has 40k miles. Tesla uses the excuse that that they don’t cover this as it’s a wear and tear component. Which another issue because they don’t know the reason of why it’s doing this. They want customers to pay and replace the brakes and rotors. Many owners with same car experience this issue and is a design defect that can pose safety issues

NHTSA ODI 11615154

Tires wear less than 1k miles. Deflate, side wall wear, separation, tread wear etc. Have purchased around 8 tires from January 2022 - Present FRONT - 265/35/ZR21 101Y Extra Load REAR - 295/30/ZR21 102Y Extra Load Michelin honored tire failure for side wall separation then denied all other claims. And this is the only tire Tesla has on hand since there is no spare.

NHTSA ODI 11609154

To avoid collision on the highway with a deer crossing in front of me, I braked very hard. The left rear brake caliper mount broke as a result. I did not lose brake fluid pressure, thankfully but this could’ve been a catastrophic failure. I contacted Tesla who seemed indifferent and blaming the incident on my driving and the mileage of the car ( 48,000 ). I have never in my life heard of a caliper mount breaking on any car with any number of miles. I’m sure it happens, but it should not happen on a car with 1000 hp.

NHTSA ODI 11605322

Michelin Pilot Sport 4S 295/30 ZR 21 102Y extra load Purchased Oct 2021, estimated 12,000 miles on vehicle and tire. Tire split along inside corner, nearly all the way around the tire. No warning, instant loss of pressure. No significant wear on the outside corner or the tread. Previously happened earlier in the year on the passenger side rear tire.

NHTSA ODI 11597411

Passenger side headlight, daytime running light portion, is flickering, approximately 1-2 times a minute. I only noticed this as I parked in a dark garage with my lights on, seeing the light flickering against the wall. There is no warning from my car telling me this is happening. This is a safety issue because headlights are a safety feature. If my headlight is going on and off, it will affect my visibility, as well as the visibility of my car to other drivers/pedestrians on the road. I notified Tesla, they had mobile technician come to my house, he visually confirmed this issue, and he subsequently replaced the entire headlight. After the replacement, I noticed that this did not resolve the issue. I notified Tesla and they had me bring in my car to service center for inspection. Per tesla tech service summary: "identified customer concern as a known characteristic with no resolution available at this time. Please maintain regular WIFI connection to ensure timely downloads of future firmware updates. No repairs recommended at this time". I need this issue resolved, I do not feel safe driving my car. Tesla is not repairing the issue and has no clear timeframe as to when this issue will be fixed. I attached 2 photos from my video capture showing when the light is on and off.

NHTSA ODI 11580942

I recently encountered a problem with my Tesla where the drivers door opened on its own while operating the vehicle. Tesla reported it was a faulty door handle. I am concerned that the software interlocks related to the door operation have anomalies that create a safety hazard fo car occupants.

NHTSA ODI 11579075

Driving Southeast on [XXX] between Gallup, NM and Albuquerque, NM. I was traveling at 75 MPH on an open road, it was a sunny day. I had the adaptive cruise control engaged (ACC). Literally no traffic in front of me for as far as the eye can see. Nothing that would cause an alert or obstruction in front of the car. The Tesla was on ACC and suddenly braked, hard. I immediately disengaged the ACC and drove manually. It was a frightening incident. If there had been traffic behind me, it would have resulted in a crash, as I would have been rear ended. If the traffic had been a truck behind us, we would probably have sustained extreme injuries. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11579072

The blinkers on the steering wheel inadvertently stop working from time to time causing a dangerous situation for myself and the drivers around me.

NHTSA ODI 11577236

The contact owns a 2021 Tesla Model S. The contact became aware that the VIN was included in NHTSA Campaign Numbers: 24V051000 (Electrical System), 23V838000 (Electrical System), 23V862000 (Latches/Locks/Linkages, Electrical System) and 23V488000 (Seat Belts); however, the part to do the recall repairs were not yet available. The contact stated that the recall remedies were over-the air (OTA) software updates, and OTA updates had not been performed on the vehicle. The vehicle was taken to a Tesla Service Center, who informed the contact that he needed to pay the diagnostic test fee prior to the recall repairs. The contact declined to pay the fee because recall repairs were free of charge. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ODI 11572290

I have never received an audible alert for my blind spot warning. There is no light on the outside mirrors or anywhere else inside the vehicle to catch your attention. If I am looking at my display in front of my steering wheel I will see a car that is in my blindspot change from GRAY to RED when I activate my blinker; however, the car has never beeped or alerted me beyond passively changing the car color to red on my display screen. If I'm changing lanes I am not looking at my screen which is directly in front of me, I'm looking at the road and I'm looking left or right. I have almost hit many other vehicles multiple times because my car will not audibly notify me that theres a car in my blind spot or a car that is speeding up behind me which I might have missed. This is a feature which I paid for and I feel is defective in it's current state. The car is available upon request for inspection. The lack of an audible BSW alert puts myself and others on the road at an increased risk of collision. I have mentioned it to the dealer but after over two years no update has been made. I have not made a big attempt to correct this issue with the dealer since it's difficult to speak to someone at Tesla. No, the issue has not been inspected by anyone. I discussed it with a rep shortly after I purchased the vehicle but it seems like an issue that Tesla knows about if they only programed the vehicle color to change and didn't program an audible alert. No, there have not been any alerts before this issue as it appears to be a simple programing issue.

NHTSA ODI 11572308

The horn is a button. As someone almost steered into me, I looked down to find the horn and almost ran into a child as my car swerved!!! This is incredibly unsafe to hide the horn button in an incredibly small area next to the wiper button and cruise control. How this was approved is beyond me!! Tesla needs to make all current cars correct by having the horn be accesible. Like every other car in the world!

NHTSA ODI 11565388

Left turn signal button randomly stops working, have to click right signal then left again for it to work. Happens about 2-3 times per week

NHTSA ODI 11563661

Went to a Tesla dealership to get my car aligned. 4 days later they told me that my car couldn’t be aligned because my fron lower control arm was bent or broken. I purchased the car from Tesla with 5700 miles. The cad had about 19k miles when it went in for alignment. Seen owning the vehicle I never had an accident or damage to vehicle that would cause such damage. Like always they like to blame the customer to we can cover the defects of there vehicles.

NHTSA ODI 11562326

Driving on divided highway at night, the car slowed dramatically at each exit from the highway.

NHTSA ODI 11562107

The suspension is very stiff and to the point when the smallest of pot holes, road bumps, or going over the road divider marker sends the shock to the body of the passenger. My family complaints of neck pain after a short ride. I live in San Jose, CA. I drive with the comfort mode with the soft ride setting for the suspension. This deep discomfort, pronounced for rear passengers is also increasingly deteriorating. Tesla inspected my car on Sept 8, 2023 - partially fixed the suspension noise. No change to the ride stiffness causing deep discomfort to passengers. Tesla inspected my car on Nov 8, 2023 for the same issue. No resolution. Tesla inspected my car on Dec 17, 2023 for the same issue. No resultion. I was told by Tesla technician who drove with me, that the ride is stiff, however, there are no fixes currently. A change to the setting and / or suspension will happen if there is a volume of complaints. Initially, the suspension had sound issues and frequent cranking. Tesla fixed it partially. However, this did not resolve the stiff suspension. I went to the Tesla dealership three times, each of the times, Tesla toggled with the settings but not avail. Tesla now claims that the suspension is what it is, any relief has to come from NHTSA or I have to sell my car.

NHTSA ODI 11560538

Dear Sir/Madam, I am highly concerned about the safety of the newest versions of Tesla Model S, Model X (without stalks), CyberTruck and Model 3 with the code name Highland. These models pose a significant danger when operated without intuitive direction signals, especially in the following situations: 1) Roundabouts: It is nearly impossible to correctly activate the signal lights. Please refer to the following example: [XXX] 2) Complete distraction of our focus from the road is required to operate signalling (eyes are EVERY TIME off a road), as shown in this example: [XXX] 3) In the event of a slightly dangerous occurrence, it is impossible to effectively and intuitively use the signals (or honk with the "Yoke" steering wheel). Please see: [XXX] Naturally, all of these points contribute to a significantly higher risk of accidents and undoubtedly impact the flow of traffic. Regards Alardo INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ODI 11560406

Have just learned (on routine check) that Front/Rear tire configuration has been backwards since delivery from the FACTORY; 24 mo, 24k miles. Factory specified FRONT REAR 255/45R19 285/40R19 NOTE REVERSAL Actual upon delivery FRONT REAR 285/40R19 255/45R19 ONLY service has been 1 left/right switch at 19k with NO front/back, per tire service recommendation; not detected then. And there’s NO chance it was reversed after delivery. I'm wondering effect on tread life, safety, drive-ability. Tech said this error would vastly affect performance, "Haven't you noticed car 'driving really funny'?" Notified Tesla; no response yet. In photos, Note door decal, fender placement will show front/rear.

NHTSA ODI 11556759

The contact owns a 2021 Tesla Model S. The contact stated that while driving at an undisclosed speed, the driver’s side indicator was inoperable on the yoke steering wheel. The contact stated that the failure had occurred several times. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 24,500.

NHTSA ODI 11555470