Nov 2, 2025Tires
Certified pre-owned 2021 Tesla Model S delivered on October 21, 2025 with worn Michelin Pilot Sport 4S summer tires (255/35ZR21 front, 295/30ZR21 rear). Tread depth measured approximately 2/32" on the outer tread shoulders of all four tires, below Tesla’s published 5/32" delivery standard. Within the first week of ownership, the vehicle hydroplaned multiple times in wet conditions at normal speeds. Tesla service declined to replace the tires, stating measurements were “taken in the wrong location” and that only the inner grooves count, despite Tesla’s public documentation and national tire safety standards defining tread depth across the full width of the tire. Vehicle was returned in same condition without correction, leaving a continued safety risk from inadequate tread and summer tires unsuited for Ohio’s cold and wet seasonal conditions.
NHTSA ODI 11697026
Feb 28, 2025Tires
I have a 2021 Tesla Model S Long Range with rear tire size 295 / 30 ZR 21. Both rear tires are worn so bad on the insides that the cords are showing. These tires were purchased and installed by Tesla along with a wheel alignment under 10,000 miles ago. The tires still look like new on the center and outside of the tire so I had no clue this was happening. The only way I became aware was because the low tire pressure warning kept coming on I started losing air slowly over the last month and thought maybe I had a puncture. The damage to the tire isn’t easily visible when just looking under the vehicle. I urge anyone with these tires to check them as it can easily result in a blow out.
NHTSA ODI 11645675
Oct 28, 2024Tires
295 / 30ZR 21 - My tire failed well before the tread life expired. You can see in the attached images that the tire failed at the meeting point between the tread and the sidewall.
NHTSA ODI 11622354
Aug 17, 2024Tires
Tires wear less than 1k miles. Deflate, side wall wear, separation, tread wear etc. Have purchased around 8 tires from January 2022 - Present FRONT - 265/35/ZR21 101Y Extra Load REAR - 295/30/ZR21 102Y Extra Load Michelin honored tire failure for side wall separation then denied all other claims. And this is the only tire Tesla has on hand since there is no spare.
NHTSA ODI 11609154
Jun 28, 2024Tires
Michelin Pilot Sport 4S 295/30 ZR 21 102Y extra load Purchased Oct 2021, estimated 12,000 miles on vehicle and tire. Tire split along inside corner, nearly all the way around the tire. No warning, instant loss of pressure. No significant wear on the outside corner or the tread. Previously happened earlier in the year on the passenger side rear tire.
NHTSA ODI 11597411
Sep 1, 2023Tires
Tire tread delaminated from the body of the tire, leading to loss of pressure and dangerous loss of vehicle control. Both rear tires had the same issue. 295 /30 R21
NHTSA ODI 11542041
Aug 29, 2023Tires
My rear driver side tire failed on the interstate and lost pressure so quickly I had to pull over immediately. Thankfully the tire remained intact enough for me to safely pull over and no one was injured. After realizing this wasn’t just a puncture, I was shocked. This is either a major defect with the tire or with Teslas installation of the tire. The inner part of the tire was shredded but the rest of the tire has significant tread left. These tires are less than 1 year old and less than 16500 miles of use. The tires offer a 30,000 mile warranty.
NHTSA ODI 11541526
Feb 11, 2023Tires
15,000 miles and 22/32 (70%) tire tread evenly worn available. The tire tread completely separated from the sidewall of the tire. This is a common and known problem with this tire. Many cases are presented on various online forums with photos and documentation.
NHTSA ODI 11506770
Sep 28, 2022Tires
Michelin manufactures this tire specific for the Tesla Model S plaid vehicle. This tire wears pre maturely from the 300 rating most times under 10,000 miles causing tread separation on the inner wall. This specific wear can only be seen once the tire is removed from the vehicle. This is a well know issue on tesla forum boards and Michelin is not only not assisting with the issue, they are on back order for this tire that is specific for the Tesla Model S plaid. Not only did Michelin design a tire for this vehicle that wears well short of the rating, they are also not making enough to replace the worn out\defective tires. The tread separation is on the inside of the tire not visible to the driver that could potentially lead to a catastrophic accident if the tread separates at a high speed. The tire size is 295/30/21.
NHTSA ODI 11486856