What 650 owners told NHTSA about the 2021 Tesla Model 3 Bev

Car was charging in garage overnight when an interior dash electrical fire started. Fire burnt dash and smoke damaged the interior or car. Fire smoldered itself out, and car was considered a total loss. Collision center that picked up vehicle stated that they believed the fire started from an electrical charging fault at the harness in the dash.

NHTSA ODI 11556904

I was driving home from work on a two-lane highway when my car suddenly (and without any warning) lost all driving power and shut down while there was still battery left on the vehicle (roughly 10%). I could no longer maneuver the vehicle due to lack of propulsion, so my car died in the middle of the road. It was towed directly to Tesla service center where diagnostics were supposedly run. Their conclusion was the car died due to insufficient charge (even though there was about 10% battery left at the time of the incident). About a week later, the same EXACT thing happened! The car lost all power and shut down mid-drive without any warning with about 7% remaining. Both times, I had my home address in the car GPS (so it knew the exact distance I was traveling) and it never indicated once that I needed to stop and charge the battery. Again, I had the car towed to the service center where they reached the same "conclusion" that the car died due to simply running out of battery. When I showed them proof (pictures and videos) that the car died with charge left on the battery, they did not investigate the issue further. They simply stuck to their original conclusion and no longer wanted to help remedy my defective battery. I have video and pictures proving that my car dies without warning (on multiple occasions) while there is still charge left on the battery, but Tesla refuses to fix/warranty my car (let alone try to investigate or replicate the issue). They tell me that my car is "operating as intended" and is safe to drive, all the while knowing it is definitely not safe to drive. I'm especially concerned due to the fact that I drive my two daughters in my car. They both are very young and use car seats. What happens in the event that I am driving on the interstate with them in the backseat and my car randomly dies without warning? There would be no way to safely remove them from the vehicle (let along myself) before being involved in a serious high-speed accident.

NHTSA ODI 11553755

I was driving to work that all of sudden heard warning sound and the monitor displayed the "Shutdown" sign as well. The car lost its power and came to complete stop in the middle of the street. Luckily there was no car near me. I was not able to drive the car and had to tow it to the dealership. According to mechanic “the rear drive unit has failed internally”. This was extremely scary and dangerous and may have caused a fatal accident. The problem has been fixed.

NHTSA ODI 11549464

The contact owns a 2021 Tesla Model 3. The contact stated while driving out of a parking space, the steering wheel seized. The message "Front Motor Disabled. Continue Driving" was displayed. The manufacturer was contacted and provided remote assistance, but the failure persisted. The contact stated that the vehicle regained power steering functionality after an hour. The contact stated that the failure recurred while driving out of a parking space on another occasion. The vehicle was towed to a Tesla Service Center however, the failure could not be duplicated; however, the circuit board was replaced. The contact stated that the failure recurred while pulling out of a parking space on a third occasion. The vehicle was towed to a second Tesla service center, Tesla Sales (750 E El Camino Real, Sunnyvale, CA 94087) who informed the contact that an unknown software update was needed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 17,000.

NHTSA ODI 11545854

While the car was parked in a parking lot, I get two notification stating “Sentry mode has turned off due to a sentry system error.” When I checked out the car, the car has completely failed to do any of the computer related task, leaving only the gear, AC, and Bluetooth was working. None of the cameras, GPS, sensors, brightness mode and many others were completely stuck. This continued until the next day. This happened without prior symptoms or warnings. I would have been in deep trouble if I have been driving at the time of the incident. When I took the car to the shop, tesla didn’t update the status for a week. After a week, Tesla told us that the Turbo A, Autopilot main processor chip failed. This caused the autopilot to go on loop. Therefore the whole motherboard needed to be replaced. This happened to a brand new purchased Tesla 2021 standard range. Which cost me $2404.00.

NHTSA ODI 11538847

Electrical system rebooted in the middle of driving: screen went off couldn't signal i swayed to the side and waited till the screen came back on after 3 minutes.

NHTSA ODI 11532777

This same event has happened to me approximately 3-4 times since owning the vehicle. It occurs randomly without warning. The vehicle screen will randomly and suddenly freeze up and render itself inoperable. Eventually, the screen will reset itself or I will have to manually force a reset. After about 5-10 minutes, the screen will reset and the problem goes away. During the 5-10 minutes of the screen not operating, I cannot see or change any of the vehicles controls; loss of HVAC control, cannot turn on windshield wipers, cannot see vehicle speed, don't know if turn signals are on/off (also lose audible sounds when turn signals are on) are the major safety related losses; you essentially lose all control over the vehicle settings/controls. Vehicle continues to drive as normal, and all functions are restored after reset is complete.

NHTSA ODI 11523177

The contact owns a 2021 Tesla Model 3. The contact stated while driving approximately 25 MPH as he was exiting a highway and slowing for a traffic signal at the bottom of the off-ramp his brakes failed to engage. The contact stated the brake pedal was stiff and he had attempted to use full leg force to depress the brake pedal. The contact's vehicle ran the traffic signal and the contact stated he hit the right front end of a vehicle that was across traffic from him. The contact stated no warning light was illuminated. The contact stated that the crash stopped his vehicle and the other vehicle. The contact said that the air bags had been deployed and that the left front end of his vehicle was crushed into the left wheel well. The contact stated that the other vehicle received only light damage to the right end of the bumper due to it being higher than his vehicle. The contact stated that the police were on the scene and filed a report. The other vehicle was able to drive away, and the contact's vehicle was towed to an impound lot. The contact stated that his insurance provider declared the contact's vehicle a total loss. The vehicle had not been diagnosed or repaired. The contact stated that prior to the crash he had attempted to engage his cruise control while on the highway and it would not work. The contact stated that when he engaged the cruise control the windshield wipers would activate and he stopped attempting to use cruise control. The manufacturer had been informed of the failure. The failure mileage was approximately 18,000.

NHTSA ODI 11522497

While charging Model 3 the amperage went from 32amps and was capped at 16amps. This is a wide spread issue with Tesla’s model 3 Power conversion system (PCS). There is 3 controllers in the PCS system. When all 3 are working correctly it will charge at 48amps. If one stops it will drop to 32 amps or drop to 16 amps if two fail or not even charge if 3 fail. This is a known issue and and costly repair as Tesla refuses to fix these under the battery warranty.

NHTSA ODI 11503723

The supermanifold failed, causing the front defroster to not work properly, resulting in loss of visibility in freezing temperatures. This is a common problem with 2021/2022 model 3/model y with the new heat pump that was supposed to be fixed with a software update, but was not. I now have a $3900 repair bill on a 1 year old car with 56,000 miles. The warranty expired at 50,000 miles. The failure was not a result of negligence.

NHTSA ODI 11499129

The contact owns a 2021 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 22V235000 (Electrical System, Forward Collison Avoidance) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. Parts distribution disconnect.

NHTSA ODI 11498674

The contact owns a 2021 Tesla Model 3. The contact stated while driving 20 MPH, the vehicle inadvertently made a sudden stop and then lost motive power. There was no warning light illuminated. The contact attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer, and the contact was informed that the inverter failed and needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was 9,000.

NHTSA ODI 11497495

The contact leased a 2021 Tesla Model 3. The contact stated upon starting the vehicle, the center display failed to operate as designed. The contact was able to drive the vehicle; however, while driving 25 MPH, the vehicle stopped abruptly in the middle of the road. A message indicating that the trunk was opened was displayed. There was also a question displayed whether the contact wished to continue driving. The contact tapped the option YES however, the touch pad center display failed to respond. The contact exited the vehicle and attempted to close the trunk several times; however, the trunk reopened independently. The contact was able to close the trunk after eight attempts. The contact was able to continue driving to her residence. The contact stated that upon parking the vehicle, the trunk reopened independently. The manufacturer was notified of the failure and assisted the contact with towing the vehicle to the local Tesla Service Center where it was diagnosed that an unknown software had failed. The vehicle was not repaired. The manufacturer declined to provide additional information. The failure mileage was approximately 15,460.

NHTSA ODI 11496152

The cabin heater stopped working. I received an error code "VCFRONT_a447" recommending to take the vehicle in for service. This issue is a problem in sub-zero climates where the windshield will not defrost before and during driving. I have found 67 other cases from reddit and tesla motors club describing the same issue, on new or <2 years old cars. My components have not been inspected. I tried a full hard reboot of the software and no fix. Tesla service estimates $1,792 repair. Replacing a Supermanifold ($450.37) & A/C compressor ($1273.53) +tax =$1792. I am out of warranty by milage, car is 1.5 years old. 60,200 miles.

NHTSA ODI 11495849

I'm getting a notification that says " cabin climate control system requires service cabin heating/cooling limited or unavailable". As a result of this failure the defroster is not working properly. The windshield defroster will only blow cold air very slowly. This causes the windshield to fog up very quickly in cold temperatures. I cannot see out of the windshield properly.

NHTSA ODI 11495717

It has been weeks and Tesla has still not provided a fix for this issue. It was supposed to be resolved over the air but we have called Tesla for weeks and they have no idea when the fix will be available. Do they have a time limit to resolve? Sep 19,2022 Manufacturer Recall NumberTBD NHTSA Recall Number22V702 Recall StatusRecall Incomplete

NHTSA ODI 11494868

Driver side window fails to lock completely upon locking the car manually and/or using auto walk away function. This leaves the car very much unsecure and open to being vandalized. Additionally, the driver sides window fails to close fully when auto close button is pressed. The driver side window button has to be fiddled with few times to get a complete window seel.

NHTSA ODI 11489364

Seat sensor fail and was able to drive in the middle of the intersection to make a left turn. Since the sensor fail if vechicle is driven less the 5 mph the car will go in park- very scary when in the middle trying to turn left

NHTSA ODI 11489213

Since owning this car in January 2022, there have been issues of phantom braking during cruise control or autopilot. However, today 10/6/22 during an hour and a half time frame my car has had phantom braking episodes at least 5 times in the middle of the highway where it's speed suddenly drops by 20mph.

NHTSA ODI 11488278

Tesla Model 3 main computer system failure. Failure was not cause by any negligence by the operator. The vehicle was parked over night and upon attempting to operate the vehicle the following day there was no power to the screen. There were no warnings prior. The screen which displays vehicle speed, vehicle battery level, seatbelt warning indicators was inaccessible. Also as a result of the computer failure the vehicle did not emit the required pedestrian safety sound, the front and rear collision warnings were disabled, charging was not possible, the ability to disable passenger airbags in case of a child needing to be transported in the front was inaccessible, if the vehicle was operated during winter the ability to defrost the windshield would be impossible and all safety and security features were disabled. The screen/computer has been an issue for several owners as easily viewed by a simple google search. The vehicle is only a year and a half old and was purchased new. The issues that occurred from the defective computer could of easily have caused of an accident or a caused disabled pedestrian to have been hit. The computer was deemed the cause by Tesla’s service professionals.

NHTSA ODI 11478922

This "self driving" Model 3, with FL License Plate [XXX], attempted to merge onto I95 south from an on-ramp, and very nearly caused a major accident. The vehicle had a bumper sticker on the back that said something like "please be patient, I am a self driving vehicle." The vehicle was merging from a left side on-ramp, at a VERY LOW SPEED, and crossed two lanes of interstate traffic, very erratically accelerating, then braking, then accelerating again, and then braking. My vehicle was directly in its path, and I had to brake hard, and take to the shoulder to avoid the collision. If this vehicle's trips are logged, it needs to be investigated. If it weren't for the humans paying attention, the actions of the Tesla car/driver would have caused a major accident, and most likely bodily injury or death. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ODI 11472737

The contact owns a 2021 Tesla Model 3. The contact stated while driving approximately 65 MPH with the self-driving feature activated, the vehicle experienced phantom braking. There was no warning light illuminated. The contact stated that there were no other vehicles nearby in the lane. Additionally, the contact was unaware of any shadows or anything else in the lane. The contact stated that the vehicle slowed down and then resumed a higher speed. The contact stated that he disengaged the self-driving feature and manually drove the vehicle. The vehicle was not taken to a dealer or independent mechanic to be diagnosed or repaired. The contact stated that he attempted to notify the manufacturer thru the vehicle App but was unable to leave a full detailed report. The approximate failure mileage was 10,445.

NHTSA ODI 11471563

The contact owns a 2021 Tesla Model 3. The contact stated while driving 70 MPH with the cruise control activated, the vehicle applied the brakes independently. The contact stated no warning light was illuminated. The contact stated he experience the failure three times while using the cruise control feature that same day. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 7,000.

NHTSA ODI 11467739

Vehicle will engage breaks when there is no obstacle or while on a straight road when placed in cruise control.

NHTSA ODI 11467363

While driving with cruise and steering control, car will emergency brake like something is in front of the car. Many call it "phantom" braking. One time on a 2 lane highway the car braked hard for no reason, it happened on the way to Vegas and a large group of bikers were behind us. Very scary at highway speeds. We let the bikers pass.

NHTSA ODI 11467368